Manual Lennox International Inc. MPB3328CNE-B

28 pages 2.32 mb
Download

Go to site of 28

Summary
  • Lennox International Inc. MPB3328CNE-B - page 1

    OTL Report No. 116-F-36-5 US Portland MODELS This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases unless a c ...

  • Lennox International Inc. MPB3328CNE-B - page 2

    2 T ABLE OF CONTENTS Packaging ......................................... Page 2 Introduction ...................................... Page 2 General Information .......................... Page 2 Massachusetts and New Y ork Requirements ................................ Page 4 Cold Climate Insulation ..................... Page 5 Manufactured Home Requi ...

  • Lennox International Inc. MPB3328CNE-B - page 3

    3 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W ARNING I mproper installation, adjust - ment, alteration, service or maintenance can cause injury or property damage. Refer to this manual. For assistance or additional information consult a qualified installer , service agency or the gas supplier . W ARNING Failure to comply with these i n ...

  • Lennox International Inc. MPB3328CNE-B - page 4

    4 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Manifold Gas Supply Pressure (all models) Fuel # Lo w (millivolt only) High Na tu ra l Gas (Lo) 2.2" WC (0.55 kPa) (Hi) 3.5" WC (0.87 kPa) Propane (Lo) 6.3" WC (1.57 kPa) (Hi) 10.0" WC (2.49 kPa) T able 4 Inlet Gas Supply Pressure (all models) Fuel # Minimum Maximum Natural ...

  • Lennox International Inc. MPB3328CNE-B - page 5

    5 Figure 3 - T ypical Installations Note: When the unit is installed with one side flush with a wall, the wall on the other side of the unit must not extend beyond the front edge of the unit. COLD CLIMA TE INSULA TION For cold climate installations, seal all cracks around your appliance with noncombustible material and wherever cold air could ente ...

  • Lennox International Inc. MPB3328CNE-B - page 6

    6 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. VENT TERMINA TION CLEARANCES Gas Vent Rule - Gas vent caps are not per - mitted within 8 feet (2.4 mm) of a vertical wall or similar obstruction. Gas vent caps that are located 8' or more from a portion of a building which extends at an angle greater than 45° upward from the horizontal m ...

  • Lennox International Inc. MPB3328CNE-B - page 7

    7 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Hearth Extension - A hearth extension is not required with this appliance. If a hearth extension is used, do not block the control compartment access panel. Any hearth extension used is for appearance only and does not have to conform to standard hearth extension installation requirements. Wal ...

  • Lennox International Inc. MPB3328CNE-B - page 8

    8 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Step 7. ( Page 15 ) Outside Air Kit Installa- tion. Step 8 . ( Page 16 ) Verify appliance opera- tion. Step 9 . ( Page 16 ) Install grate, vermiculite, embers and logs. Step 10 . ( Page 21 ) Installation/Removal of glass enclosure panels. Step 11. ( Page 22 ) Adjust burner primar y air shutter ...

  • Lennox International Inc. MPB3328CNE-B - page 9

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 9 FRAMING SPECIFICA TIONS Note: All framing dimensions calculated for 1/2" dr y wall at the appliance face. If sheathing the chase or finishing with other thickness materials, calculations will need to be made. * Outside air kit - FOAK (without adapter). See Figure 22 on Page 16. *Optional ...

  • Lennox International Inc. MPB3328CNE-B - page 10

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 10 F E B D C G T op View FRAMING SP ACERS (T op and Sides and Rear) Front View 3 (76) A J H Flue Outlet For B-Vent Connection OPTIONAL ELECTRICAL INLET KNOCKOUT REQUIRING A FIELD PROVIDED JUNCTION BOX (Either Side) GAS INLET (Either Side and bottom) NOTE - Hood shown as positioned in louvered fr ...

  • Lennox International Inc. MPB3328CNE-B - page 11

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 11 Step 2. ROUTE GAS SUPPL Y LINE Route a 1/2" (13 mm) gas line as shown in Figure 11. Gas lines must be routed, con- structed and made of materials that are in strict accordance with local codes and regulations. The appliance, as set up at the factory , is best suited for use with a gas li ...

  • Lennox International Inc. MPB3328CNE-B - page 12

    12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 13 Figure 12 T yp e B-V ent - 4 in . (10 2 mm ) f or M PB 33 28 Mo de ls , 5 in. ( 12 7 m m) f or MP B 35 30 / 40 35 Mo de ls or 6 in . (153 mm) for MPB 4540 Models Se cur in g Screws Fl ue Ou tl et Collar USE ONL Y APPROVED B-VENT DIAMETER MPB-3328, MPB-3530, MPB-4035 and MPB- 4540 se ...

  • Lennox International Inc. MPB3328CNE-B - page 13

    13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A. SIT Millivolt Wiring (See Figure 14) – 1 . Select any of the following optional controls: appliance-mounted (rocker switch) or wall- mounted switch, thermostat, or one of the optional remote control kits. If appliance- mounted ON/OFF control is selected mount it in the gas valve mounting ...

  • Lennox International Inc. MPB3328CNE-B - page 14

    14 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 17 Figure 18 1. If any of the original wire as supplied must be replaced , 1. it must be replaced with T ype A WM 105 ° C – 18 GA. wire. 2. 120V , 60Hz – Less than 3 amps. BK Junction Box Tr ansf. 120 V. 24 V Facto ry Wired Field Wired BL Electronic Wiring Diagram (Honeywell) Show ...

  • Lennox International Inc. MPB3328CNE-B - page 15

    15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Using pipe-dressing materials appropriate for the gas type, securely affix the shut-off valve to this determined pipe length at a convenient location outside of the appliance lower control compartment. TEST ALL CONNECTIONS FOR GAS LEAKS (F ACTORY AND FIELD): Figure 21 Operate the actuator th ...

  • Lennox International Inc. MPB3328CNE-B - page 16

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 16 Step 9. INST ALLING LOGS, DECORA- TIVE VOLCANIC STONE AND GLOW- ING EMBERS Step 8. VERIFYING APPLIANCE OPERA- TION With gas line installed run initial system check- out before clos ing up the front of the unit. Foll ow the pilot lighting instructions provided in the Care and Operation Instruc ...

  • Lennox International Inc. MPB3328CNE-B - page 17

    17 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Proper twig placement is critical to prevent sooting. T wigs should be placed in the gaps between the flame peaks and should be positioned so that at no time they impinge the flames. 1. Remove the appliance front door . 2. Remove the log set from the interior of the fireplace. 3. Remove th ...

  • Lennox International Inc. MPB3328CNE-B - page 18

    18 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. MPB-3328 LOG PLACEMENT 1 Position the individual logs as shown below . Logs should be placed in the order shown. Position the rear log on the brackets at the rear of the firebox with the log's notches directly over the brackets. Position the right log (log no. 3) by inserting the pin fr ...

  • Lennox International Inc. MPB3328CNE-B - page 19

    19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. MPB-3530 LOG PLACEMENT 1 Position the individual logs as shown below . Logs should be placed in the order shown. Position the rear log on the brackets at the rear of the firebox with the log's notches directly over the brackets. Position the right log (log no. 3) by inserting the pin fr ...

  • Lennox International Inc. MPB3328CNE-B - page 20

    20 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. MPB-4035 & MPB-4540 LOG PLACEMENT 1 Position the individual logs as shown below . Logs should be placed in the order shown. Position the center log on the burner first, then place the glowing embers as shown in Fig- ure 28. Place the rear log, both the right and left, and then the smalle ...

  • Lennox International Inc. MPB3328CNE-B - page 21

    21 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Only doors certied with the appliance shall be used. Seules des portes certiées pour cet appareil doivent être utilisées. CAUTION: DO NOT abuse glass door by striking or slamming shut. These appliances are designed to operate only with the front glass enclosure panel properly install ...

  • Lennox International Inc. MPB3328CNE-B - page 22

    22 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 33 Main Burner Factory Air Shutter Opening Setting - Inches (millimeter) Model Natural Gas Propane Gas MPB-3328 Fully Closed 3/16" (4.76 mm) MPB-3530 Fully Closed 3/16" (4.76 mm) MPB-4035 Fully Closed 3/16" (4.76 mm) MPB-4540 Fully Closed 3/16" (4.76 mm) Note - The ...

  • Lennox International Inc. MPB3328CNE-B - page 23

    23 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 36 Burner Flame Appearance - Model MPB-4035 & MPB-4540 Figure 34 Figure 35 Burner Flame Appearance - Model MPB-3328 Burner Flame Appearance - Model MPB-3530 Step 12. VENT OPERA TION TEST After appliance installation, perform this vent operation test to verify that proper venting co ...

  • Lennox International Inc. MPB3328CNE-B - page 24

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 24 Scoop Scoop Securing Screws Fire Box To p Lintel Securing Screw Hole in Cabinet To p Figure 37 Blocked Flue Safety Limit Location, Inside View of Firebox, T op/Right Side Intersection Detail A Detail C Fire Box To p Limit Limit/Bracket Securing Screws Lintel Securing-Screw Hole in Cabinet To ...

  • Lennox International Inc. MPB3328CNE-B - page 25

    25 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Step 14. A TT ACHING SAFETY IN OPERA TION WARNINGS It is the installer ' s responsibility to ensure these warnings are properly affixed during installation. These warning labels are a critical step in informing consumers of safe operation of this appliance. A PP OS IT IO N D ES M IS ES ...

  • Lennox International Inc. MPB3328CNE-B - page 26

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 26 GAS CONVERSION KITS In Canada: THE CONVERSION SHALL BE CAR - RIED OUT IN ACCORDANCE WITH THE REQUIREMENTS OF THE PROVINCIAL AUTHORITIES HA VING JURISDICTION AND IN ACCORDANCE WITH THE RE- QUIREMENTS OF THE CAN/CSA-B149.1 INST ALLA TION CODE. LA CONVERSION DEVRA ÊTRE EF - FECTUÉE CONFORMÉME ...

  • Lennox International Inc. MPB3328CNE-B - page 27

    27 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 40 b. Refer to Figure 40 and remove the pilot hood assembly to access the hexed pilot orifice. Remove and replace the orifice with the one provided with the kit. Pilot for SIT Millivolt Gas Valve Pilot Orifice Figure 42 All Models Step 8. VERIFY THE PROPER ORIFICE SIZE BEFORE INST A ...

  • Lennox International Inc. MPB3328CNE-B - page 28

    Printed in U.S.A. © 2005 Lennox Hearth Products P/N 850033M Rev . G 01/2011 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. 1508 Elm Hill Pike, Sui ...

Manufacturer Lennox International Inc. Category Indoor Fireplace

Documents that we receive from a manufacturer of a Lennox International Inc. MPB3328CNE-B can be divided into several groups. They are, among others:
- Lennox International Inc. technical drawings
- MPB3328CNE-B manuals
- Lennox International Inc. product data sheets
- information booklets
- or energy labels Lennox International Inc. MPB3328CNE-B
All of them are important, but the most important information from the point of view of use of the device are in the user manual Lennox International Inc. MPB3328CNE-B.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Lennox International Inc. MPB3328CNE-B, service manual, brief instructions and user manuals Lennox International Inc. MPB3328CNE-B. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Lennox International Inc. MPB3328CNE-B.

A complete manual for the device Lennox International Inc. MPB3328CNE-B, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Lennox International Inc. MPB3328CNE-B by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Lennox International Inc. MPB3328CNE-B.

A complete Lennox International Inc. manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Lennox International Inc. MPB3328CNE-B - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Lennox International Inc. MPB3328CNE-B, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Lennox International Inc. MPB3328CNE-B, that we can find in the current document
3. Tips how to use the basic functions of the device Lennox International Inc. MPB3328CNE-B - which should help us in our first steps of using Lennox International Inc. MPB3328CNE-B
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Lennox International Inc. MPB3328CNE-B
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Lennox International Inc. MPB3328CNE-B in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Lennox International Inc. MPB3328CNE-B?

Use the form below

If you did not solve your problem by using a manual Lennox International Inc. MPB3328CNE-B, ask a question using the form below. If a user had a similar problem with Lennox International Inc. MPB3328CNE-B it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)