English dropdown-ico

Manual Karcher SHD-R 3000

37 pages 1.25 mb
Download

Go to site of 37

Summary
  • Karcher SHD-R 3000 - page 1

    5.956-486 A2005937 (06/03) SHD-R 3000 Betriebsanleitung ! www.karcher.com ...

  • Karcher SHD-R 3000 - page 2

    Operating Instructions T o be handed to the operator Read these instructions carefully before star ting up the unit Retain f or future ref erence Notes about these operating instructions Before starting up the interior cleaner for the first time, please carefully read through these instructions. In particular, you should note all the safety informa ...

  • Karcher SHD-R 3000 - page 3

    English SHD-R 3000 5.956-486 A2005937 (06/03) A. For your safety 1 . Safety information and instructions 2 . Noise protection 3 . Authorized operators 4 . Personal protective equipment 5 . Emergency drill 6 . Safety devices 7 . Applicable regulations 8 . Using the system for its intended purpose 9 . Special conditions in hazardous area 10. Schemati ...

  • Karcher SHD-R 3000 - page 4

    SHD-R 3000 English 5.956-486 A2005937 (06/03) 1 . Safety information and instructions The following symbols are used throughout these Operating Instructions: ! Danger! Denotes an immediate and present danger. Failure to observe this notice could lead to severe injury or death. Caution! Denotes a potentially hazardous situation. Failure to observe t ...

  • Karcher SHD-R 3000 - page 5

    English SHD-R 3000 5.956-486 A2005937 (06/03) A2 A. For your safety 5 . Emergency drill  Turn mains supply voltage off at system master switch.  Turn off supply of cleaning liquid.  If a handgun is being used, release any remaining pressure in the system by pressing the lever on the handgun. 6 . Safety devices Safety valve ! Danger! Injury ...

  • Karcher SHD-R 3000 - page 6

    SHD-R 3000 English 5.956-486 A2005937 (06/03) A3 8 . Using the system for its intended purpose This system is used for pumping a cleaning liquid at high-pressure, for the purpose of:  with the handgun attached – cleaning containers, boxes, cases and equipment parts, etc.  with the interior cleaner attached – cleaning enclosed containers, ...

  • Karcher SHD-R 3000 - page 7

    English SHD-R 3000 5.956-486 A2005937 (06/03) A4 A. For your safety 1 0 . Schematic diagram of area classification ...

  • Karcher SHD-R 3000 - page 8

    SHD-R 3000 English 5.956-486 A2005937 (06/03) A5 A. For your safety 11. Area Classification In the BetrSichV and EN 1127-1, hazardous (potentially explosive) areas are classified into zones according to the frequency and duration of the occurrence of hazardous, potentially explosive atmospheres. It is the responsibility of the owner/ operator to de ...

  • Karcher SHD-R 3000 - page 9

    English SHD-R 3000 5.956-486 A2005937 (06/03) 1 . T ypes of system Static or mobile systems The static system  is intended to be installed on a base,  has been mounted onto a rigid steel frame,  is most suitable for use in conjunction with fixed-installation high-pressure lines. B. T ypes of system, and operating information The mobile sys ...

  • Karcher SHD-R 3000 - page 10

    SHD-R 3000 English 5.956-486 A2005937 (06/03) B2 B. T ypes of system, and operating information Cleaning liquids T ype of system (see rating plate) Cleaning liquid W orking pressure/ Pressure setting for safety v alve [bar] Comments SHD-R 3000 (F) - W ater - VE -water * - W ater with Kärcher-RM 50/65 Standard version SHD-R 3000 (F) S - W ater - VE ...

  • Karcher SHD-R 3000 - page 11

    English SHD-R 3000 5.956-486 A2005937 (06/03) B3 B. T ypes of system, and operating information Cleaning liquids T ype of system (see rating plate) Cleaning liquid W orking pressure/ Pressure setting for safety v alve [bar] Comments SHD-R 3000 (F) SSR - W ater - VE -water - W ater with Kärcher-RM - Acids 1) - Alkali solutions 2) 85/100 - The pisto ...

  • Karcher SHD-R 3000 - page 12

    SHD-R 3000 English 5.956-486 A2005937 (06/03) B. T ypes of system, and operating information B4 Cleaning liquids T ype of system (see rating plate) Cleaning liquid W orking pressure/ Pressure setting for safety v alve [bar] Comments SHD-R 3000 (F) SLA – W ater – VE water* – W ater with Kärcher-RM – Alkali s ol u ti on s 2) 85/100 – – ? ...

  • Karcher SHD-R 3000 - page 13

    English SHD-R 3000 5.956-486 A2005937 (06/03) B5 B. T ypes of system, and operating information 2 . System start-up Emergency drill  Turn mains supply voltage of at system master switch.  Turn off supply of cleaning liquid.  If a handgun is being used, release any remaining pressure in the system by pressing the lever on the handgun. Worki ...

  • Karcher SHD-R 3000 - page 14

    SHD-R 3000 English 5.956-486 A2005937 (06/03) C1 C. System functions 1 Transmission casing 2 Crankshaft with drive 3 Seal (oil compartment) 4 Gland 5 Seal (grease compartment) 6 Lubrication nipple or leakage pipe 7 Sealing pack (high-pressure) 8 Piston 9 Suction valve 10 Pressure valve ...

  • Karcher SHD-R 3000 - page 15

    English SHD-R 3000 5.956-486 A2005937 (06/03) C2 C. System functions Operational sequence of the high- pressure pump  Cleaning liquid is taken in by the piston.  Suction valves (9) prevent cleaning liquid from flowing backwards.  Action of piston pumps cleaning liquid onwards.  Pressure valves (10) prevent cleaning liquid from flowing b ...

  • Karcher SHD-R 3000 - page 16

    SHD-R 3000 English 5.956-486 A2005937 (06/03) D1 D . T echnical specifications Unit SHD-R 3000 (F) SHD-R 3000 (F) S SHD-R 3000 (F) SSR 1) SHD-R 3000 (F) SLA 1) SHD-R 3000 (F) SV A SHD-R 3000 (F) LM Electrical connection T ype of current F r equency Hz 3~ 50* 3~ 50* 3~ 50* V oltage V 400** 400** 400** Motor rating with Class of protection IP55 Class ...

  • Karcher SHD-R 3000 - page 17

    English SHD-R 3000 5.956-486 A2005937 (06/03) E1 E. Care and maintenance 1 . General information It is a fundamental requirement for ensuring that this system functions safely and reliably that maintenance is carried out regularly in accordance with the following schedule. Use only original spare parts supplied by the manufacturer or recommended al ...

  • Karcher SHD-R 3000 - page 18

    SHD-R 3000 English 5.956-486 A2005937 (06/03) E2 E. Care and maintenance 2 . Maintenance schedule Frequency T ype of pump SHD-R 3000 (F) Action Pr ocedure By whom? 1, 2, 4, 10 hours after initial star t- up . LM SLA SSR Regulate tension in compression glands See Maintenance Tasks Operator Once only after first 100 operating hours all Check tension ...

  • Karcher SHD-R 3000 - page 19

    English SHD-R 3000 5.956-486 A2005937 (06/03) E3 E. Care and maintenance 2 . Maintenance schedule Frequency T ype of pump SHD-R 3000 (F) Action Procedure By whom? Monthly or after e very 160 operating hours Standard S / SV A Check pump f or leaks If during operation more than 5 droplets per minute leak from the pump , tighten piston seal Operator S ...

  • Karcher SHD-R 3000 - page 20

    SHD-R 3000 English 5.956-486 A2005937 (06/03) E4 E. Care and maintenance 3 . Maintenance tasks Changing the oil ! Danger! Burns hazard due to hot oil and hot system components. Allow pump to cool down for 15 minutes before changing oil. i Important! Waste oil may only be disposed of by the operators of special collection points. Please deposit your ...

  • Karcher SHD-R 3000 - page 21

    English SHD-R 3000 5.956-486 A2005937 (06/03) E5 E. Care and maintenance V-belt Test tension of V-belt and adjust as follows:  Switch off system, and ensure that it cannot be switched back on again unintentionally.  Remove guard over V-belt.  Test belt tension. Press down on belt which should not move by more than 1 cm. If necessary, adjus ...

  • Karcher SHD-R 3000 - page 22

    SHD-R 3000 English 5.956-486 A2005937 (06/03) F1 F . T r oubleshooting Who is permitted to repair faults on the system?  Operator Tasks that are marked “Operator” may only be carried out by persons who have been instructed in the safe operation and maintenance of high-pressure systems.  Qualified electrician Persons who have a professiona ...

  • Karcher SHD-R 3000 - page 23

    English SHD-R 3000 5.956-486 A2005937 (06/03) F . T r oubleshooting F2 1 . Fault-finding Prob lem Component P ossible cause Remedy By whom? System does not star t up Control circuitr y No v oltage supply to system or control circuitr y Check mains v oltage Electrician Control circuitr y F ault on – motor contactor – fuses Check Electrician Cont ...

  • Karcher SHD-R 3000 - page 24

    SHD-R 3000 English 5.956-486 A2005937 (06/03) F3 F . T r oubleshooting 1 . Fault-finding Prob lem Component P ossible cause Remedy By whom? Knocking noise V -belt V -belt has snapped Replace V -belt (see Maintenance T asks) Operator Detergent metering on suction side of pump (Accessor y kit) Pump is taking in air – – Fill up with cleaning liqui ...

  • Karcher SHD-R 3000 - page 25

    English SHD-R 3000 5.956-486 A2005937 (06/03) ! Hazard! The following mounting and accessory kits must not be used for operation with solvents or in a hazardous (potentially explosive atmosphere) area. 1 . Mounting kits (non-hazardous area) Float tank with float valve Function  The float valve fitted inside the float tank controls the level of l ...

  • Karcher SHD-R 3000 - page 26

    SHD-R 3000 English 5.956-486 A2005937 (06/03) G2 Pressure-relief valve Function  The pressure-relief valve is an integrated solenoid valve.  The pressure-relief valve is only active during the start-up phase when the system is configured for star-delta starting.  When the pressure-relief valve is opened, the liquid delivered by the pump fl ...

  • Karcher SHD-R 3000 - page 27

    English SHD-R 3000 5.956-486 A2005937 (06/03) G3 G. Mounting kits and accessories Figure A 170/1 ...

  • Karcher SHD-R 3000 - page 28

    SHD-R 3000 English 5.956-486 A2005937 (06/03) G4 G. Mounting kits and accessories Figure A 172 ...

  • Karcher SHD-R 3000 - page 29

    English SHD-R 3000 5.956-486 A2005937 (06/03) G5 G. Mounting kits and accessories Figure A 173 ...

  • Karcher SHD-R 3000 - page 30

    SHD-R 3000 English 5.956-486 A2005937 (06/03) G6 G. Mounting kits and accessories Figure A 161 ...

  • Karcher SHD-R 3000 - page 31

    English SHD-R 3000 5.956-486 A2005937 (06/03) G7 G. Mounting kits and accessories Figure A 154 ...

  • Karcher SHD-R 3000 - page 32

    SHD-R 3000 English 5.956-486 A2005937 (06/03) H1 H. W arranty The applicable warranty conditions in different countries are issued by the respective national distributor of KÄRCHER products. In the event of a warranty claim, please contact your original dealer or the nearest authorized customer service centre. ...

  • Karcher SHD-R 3000 - page 33

    English SHD-R 3000 5.956-486 A2005937 (06/03) I1 I. System installation This system should only be installed by  Kärcher Customer Service engineers,  persons who have been specially authorized by Kärcher. Unpacking the system Unpack the system and deliver the packag- ing materials to an appropriate collection point for recycling. For static ...

  • Karcher SHD-R 3000 - page 34

    SHD-R 3000 English 5.956-486 A2005937 (06/03) I. System installation I2 Dimensional diagram: Static system Mobile system approx. 1100 ...

  • Karcher SHD-R 3000 - page 35

    English SHD-R 3000 5.956-486 A2005937 (06/03) J1 J. Declaration of Conformity EC Declaration of Conformity We herewith declare that the design and type of machine named in the following as well as the model marketed by us complies with the relevant fundamental health and safety requirements of the EC Directives. This declaration becomes invalid if ...

  • Karcher SHD-R 3000 - page 36

    SHD-R 3000 English 5.956-486 A2005937 (06/03) J2 J. Declaration of Conformity EC Declaration of Conformity We herewith declare that the design and type of machine named in the following as well as the model marketed by us complies with the relevant fundamental health and safety requirements of the EC Directives. This declaration becomes invalid if ...

  • Karcher SHD-R 3000 - page 37

    English SHD-R 3000 5.956-486 A2005937 (06/03) K1 K. T est recor d T ype no.: Factory no.: Commissioned on: T ests carr ied out on: .............................................................................................................. Results ....................................... Signature T ests carr ied out on: .......................... ...

Manufacturer Karcher Category Water Pump

Documents that we receive from a manufacturer of a Karcher SHD-R 3000 can be divided into several groups. They are, among others:
- Karcher technical drawings
- SHD-R 3000 manuals
- Karcher product data sheets
- information booklets
- or energy labels Karcher SHD-R 3000
All of them are important, but the most important information from the point of view of use of the device are in the user manual Karcher SHD-R 3000.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Karcher SHD-R 3000, service manual, brief instructions and user manuals Karcher SHD-R 3000. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Karcher SHD-R 3000.

Similar manuals

A complete manual for the device Karcher SHD-R 3000, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Karcher SHD-R 3000 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Karcher SHD-R 3000.

A complete Karcher manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Karcher SHD-R 3000 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Karcher SHD-R 3000, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Karcher SHD-R 3000, that we can find in the current document
3. Tips how to use the basic functions of the device Karcher SHD-R 3000 - which should help us in our first steps of using Karcher SHD-R 3000
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Karcher SHD-R 3000
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Karcher SHD-R 3000 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Karcher SHD-R 3000?

Use the form below

If you did not solve your problem by using a manual Karcher SHD-R 3000, ask a question using the form below. If a user had a similar problem with Karcher SHD-R 3000 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)