Manual Ford AM/FM stereo

248 pages 2.19 mb
Download

Go to site of 248

Summary
  • Ford AM/FM stereo - page 1

    Introduction 4 Instrument Cluster 12 W arning and control lights 12 Gauges 15 Entertainment Systems 17 AM/FM stereo 17 AM/FM stereo cassette 19 AM/FM stereo with CD 21 AM/FM stereo with in-dash six CD 24 Rear seat entertainment system 28 Climate Controls 49 Heater only 49 Manual heating and air conditioning 50 Lights 52 Headlamps 52 T urn signal co ...

  • Ford AM/FM stereo - page 2

    Seating and Safety Restraints 75 Seating 75 Safety restraints 81 Air bags 91 Child restraints 95 Driving 1 1 1 Starting 111 Brakes 114 T ransmission operation 118 V ehicle loading 125 T railer towing 128 Recreational towing 139 Roadside Emergencies 140 Getting roadside assistance 140 Hazard flasher switch 141 Fuel pump shut-off switch 141 Fuses and ...

  • Ford AM/FM stereo - page 3

    Maintenance and Specifications 181 Engine compartment 182 Engine oil 184 Battery 187 Fuel information 195 Air filter(s) 210 T ire Information 212 Part numbers 225 Refill capacities 226 Lubricant specifications 231 Accessories 240 Index 243 All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or ...

  • Ford AM/FM stereo - page 4

    CALIFORNIA Proposition 65 W arning W ARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. In addition, certain fluids contained in vehicles and certain products of component wear contain or emit chemic ...

  • Ford AM/FM stereo - page 5

    SAFETY AND ENVIRONMENT PROTECTION W arning symbols in this guide How can you reduce the risk of personal injury and prevent possible damage to others, your vehicle and its equipment? In this guide, answers to such questions are contained in comments highlighted by the warning triangle symbol. These comments should be read and observed. W arning sym ...

  • Ford AM/FM stereo - page 6

    SPECIAL NOTICES Emission warranty The New V ehicle Limited W arranty includes Bumper -to-Bumper Coverage, Safety Restraint Coverage, Corrosion Coverage, and 6.0L Power Stroke Diesel Engine Coverage. In addition, your vehicle is eligible for Emissions Defect and Emissions Performance W arranties. For a detailed description of what is covered and wha ...

  • Ford AM/FM stereo - page 7

    T o access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent, unless pursuant to court order or where required by law enforcement, other government authorities or other third parties acting with lawful ...

  • Ford AM/FM stereo - page 8

    Using your vehicle as an ambulance If your light truck is equipped with the Ford Ambulance Preparation Package, it may be utilized as an ambulance. Ford urges ambulance manufacturers to follow the recommendations of the Ford Incomplete V ehicle Manual, Ford T ruck Body Builder ’ s Layout Book and the Qualified V ehicle Modifiers (QVM) Guidelines ...

  • Ford AM/FM stereo - page 9

    Notice to owners of natural gas fueled vehicles Before you drive your vehicle, be sure to read the Dedicated Natural Gas V ehicle supplement. This book contains important operation and maintenance information. Middle East/North Africa vehicle specific information For your particular global region, your vehicle may be equipped with features and opti ...

  • Ford AM/FM stereo - page 10

    These are some of the symbols you may see on your vehicle. V ehicle Symbol Glossary Safety Alert See Owner ’ s Guide Fasten Safety Belt Air Bag-Front Air Bag-Side Child Seat Child Seat Installation W arning Child Seat Lower Anchor Child Seat T ether Anchor Brake System Anti-Lock Brake System Brake Fluid - Non-Petroleum Based T raction Control Adv ...

  • Ford AM/FM stereo - page 11

    V ehicle Symbol Glossary Power W indows Front/Rear Power W indow Lockout Child Safety Door Lock/Unlock Interior Luggage Compartment Release Symbol Panic Alarm Engine Oil Engine Coolant Engine Coolant T emperature Do Not Open When Hot Battery A void Smoking, Flames, or Sparks Battery Acid Explosive Gas Fan W arning Power Steering Fluid Maintain Corr ...

  • Ford AM/FM stereo - page 12

    W ARNING LIGHTS AND CHIMES W arning lights and gauges can alert you to a vehicle condition that may become serious enough to cause expensive repairs. A warning light may illuminate when a problem exists with one of your vehicle ’ s functions. Many lights will illuminate when you start your vehicle to make sure the bulb works. If any light remains ...

  • Ford AM/FM stereo - page 13

    Brake system warning light: To confirm the brake system warning light is functional, it will momentarily illuminate when the ignition is turned to the ON position when the engine is not running, or in a position between ON and ST ART , or by applying the parking brake when the ignition is turned to the ON position. If the brake system warning light ...

  • Ford AM/FM stereo - page 14

    Low fuel: Illuminates when the fuel level in the fuel tank is at or near empty (refer to Fuel gauge in this chapter). Check gage: Illuminates when any of the following conditions has occurred: • The engine coolant temperature is high. • The engine oil pressure is low . • Fuel gauge is at or near empty . T urn signal: Illuminates when the left ...

  • Ford AM/FM stereo - page 15

    GAUGES Speedometer: Indicates the current vehicle speed. Engine coolant temperature gauge: Indicates engine coolant temperature. At normal operating temperature, the needle will be in the normal range (between “ H ” and “ C ” ). If it enters the red section, the engine is overheating. Stop the vehicle as soon as safely possible, switch off ...

  • Ford AM/FM stereo - page 16

    T rip odometer: Registers the kilometers (miles) of individual journeys. Press the SELECT/RESET control once to switch from the odometer to the trip odometer . Press the control again to select T rip A and T rip B features. T o reset the trip, press and hold the control again until the trip reading is 0.0 miles. T achometer: Indicates the engine sp ...

  • Ford AM/FM stereo - page 17

    AM/FM STEREO (IF EQUIPPED) 1. Seek: Press / to find the next listenable station down/up the frequency band. 2. T une: Press / to manually adjust the radio frequency down/up. 3. AM/FM: Press to choose a frequency band in radio mode. 4. Memory preset buttons: T o set a station: Select frequency band AM/FM1/FM2; tune to a station, press and hold a pre ...

  • Ford AM/FM stereo - page 18

    5. Power/volume: Press to turn ON/OFF; turn to increase or decrease volume levels. 6. T one: Press TONE until the desired level — Bass, T reble, Fade appears on the display . T urn the volume control to raise/lower the levels, or to move the audio sound from the right to left or the front to back (if equipped). 7. CLK (Clock): T o set the hour , ...

  • Ford AM/FM stereo - page 19

    AM/FM STEREO CASSETTE (IF EQUIPPED) 1. Balance: Press to shift sound to the left/right speakers. 2. Fade: Press to shift sound to the rear/front speakers. 3. CLK: T o set the hour , press and hold CLK. Then press SEEK to decrease or increase the hours. T o set the minute, press and hold CLK and press TUNE to decrease or increase the minutes. SCAN B ...

  • Ford AM/FM stereo - page 20

    4. T ape AMS: In tape mode, press and hold to activate Automatic Music Search (allows you to quickly locate the beginning of the tape selection being played or to skip to the next selection). Then, press REW (for the beginning of the current selection) or FF (to advance to the next selection). The tape MUST have a blank section of at least four sec ...

  • Ford AM/FM stereo - page 21

    13. AM/FM: Press to choose a frequency band in radio mode. 14. Bass: Press / to decrease/increase the bass output. 15. T reble: Press / to decrease/increase the treble output. 16. EJ (Eject): Press to eject a tape. 17. Cassette door: Insert a cassette into the cassette door . AM/FM STEREO / SINGLE CD RADIO (IF EQUIPPED) EJ BASS CD TREB BAL FADE SCN ...

  • Ford AM/FM stereo - page 22

    1. Balance: Press / to shift sound to the left/right speakers. 2. Fade: Press / to shift sound to the front/rear speakers. 3. SCN (Scan): Press to hear a brief sampling of all listenable stations or CD tracks. Press again to stop. 4. CLK: T o set the hour , press and hold CLK and press SEEK to decrease or increase the hours. T o set the minute, pre ...

  • Ford AM/FM stereo - page 23

    11. T une : In radio mode, press to move up or down the frequency band in individual increments. 12. Seek: Press and release SEEK / for previous/next strong station, selection or track. 13. Power/volume: Press to turn ON/OFF; turn to increase or decrease volume levels. 14. CD : Press to enter CD mode or to play a CD already loaded into the system. ...

  • Ford AM/FM stereo - page 24

    PREMIUM IN-DASH SIX CD SOUND SYSTEM (IF EQUIPPED) 1. Seek: Press and release SEEK / for previous/next strong station, or track of the current disc. 2. Rewind: Press and hold until the desired selection is reached. Fast forward: Press and hold until the desired selection is reached. 3. Comp (Compression): The compression feature operates in CD mode ...

  • Ford AM/FM stereo - page 25

    6. Bass: Press BASS; then press SEL / to decrease/increase the bass output. T reble: Press TREB; then press SEL / to decrease/increase the treble output. 7. Select: Use with Bass, T reble, Balance and Fade controls to adjust levels. Use with MENU to set the clock and RDS function on/off. 8. Balance: Press BAL; then press SEL / to shift sound to the ...

  • Ford AM/FM stereo - page 26

    10. Memory presets: T o set a station: Select frequency band AM/FM; tune to a station, press and hold a preset button until sound returns. 11. CD: Press to select CD mode. 12. AM/FM: Press to select AM/FM1/FM2 frequency band. In CD mode, press to begin radio play . Autostet: Stores the six strongest stations without erasing your current presets. T ...

  • Ford AM/FM stereo - page 27

    RADIO FREQUENCIES AM and FM frequencies are established by the Federal Communications Commission (FCC) and the Canadian Radio and T elecommunications Commission (CRTC). Those frequencies are: AM - 530, 540 – 1700, 1710 kHz FM- 87.7, 87.9 – 107.7, 107.9 MHz RADIO RECEPTION FACTORS There are three factors that can affect radio reception: • Dist ...

  • Ford AM/FM stereo - page 28

    Don ’ t: • Expose discs to direct sunlight or heat sources for extended periods of time. • Insert more than one disc into each slot of the CD changer magazine. • Clean using a circular motion. CD units are designed to play commercially pressed 12 cm (4.75 in) audio compact discs only . Due to technical incompatibility , certain recordable a ...

  • Ford AM/FM stereo - page 29

    T o operate the system: 1. Y our AutoVision 威 system is automatically activated when the vehicle ignition and the audio system are ON. Note: The VCP will not generate sound if the vehicle ’ s audio system isn ’ t turned on. 2. If a movie is desired, insert a VHS cassette into the VCP and the video should start playing. 3. Press the MEDIA cont ...

  • Ford AM/FM stereo - page 30

    Should you have any questions regarding your AutoVision 威 System, please feel free to call the toll free assistance hotline at 1 (877) 848 – 6434. Safety information Read all of the safety and operating instructions before operating the system and retain for future reference. Do not attempt to service, repair or modify the AutoVision 威 System ...

  • Ford AM/FM stereo - page 31

    tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with ...

  • Ford AM/FM stereo - page 32

    Humidity and moisture condensation Moisture in the air will condense in the VCP under extremely humid conditions or when moving from a cold place to a warm one. Moisture condensation on the tape playback head drum may damage the videocassette and/or drum. If moisture condensation occurs, do not insert a videocassette into the player . If a videocas ...

  • Ford AM/FM stereo - page 33

    AutoVision 姞 system Features • 2 – head hi-fi playback • AutoPlay feature • Digital auto tracking • Dual stereo headphone with electric volume control • Self docking connection for easy mobile installation • Latching system for secure safety • Carrying handle for portability • W ater resistant tape door • On screen display • ...

  • Ford AM/FM stereo - page 34

    VCP controls 1. LED display The display lamp will light up in green when power is supplied to the videocassette player . 2. POWER key Press to toggle between ON/OFF . When the power is ON, other keys (PLA Y , FF , REW , STOP) will illuminate. 3. PLA Y key Press to playback a videocassette tape. 4. REWIND/REVIEW button Press to enter the reverse pic ...

  • Ford AM/FM stereo - page 35

    Remote control 1. POWER button Press to turn the videocassette player (VCP) ON or OFF . 2. ENCORE button Press to reverse the casssette for 5 seconds. Normal playback will then resume when in PLA YBACK mode. 3. STILL/ADV ANCE (frame advance button) Press to temporarily suspend playback. Press again to make the tape advance one frame at a time. 4. R ...

  • Ford AM/FM stereo - page 36

    7. PLA Y button Press to play the tape. 8. REW button Press to rewind the tape. 9. FF button Press to fast forward the tape. 10. STOP button Press to stop the tape. Battery replacement Batteries are supplied with the remote control unit. However , they are simply for operation check and will only work for a short time. Slide battery cover off as sh ...

  • Ford AM/FM stereo - page 37

    If you will not be using the remote control for a considerably long time, remove the batteries. AutoVision 姞 controls The AutoVision 威 controls allow the rear seat passengers to operate the radio, tape, CD or CD DJ(if equipped). Parental control Y our AutoVision 威 system allows you to have control over the rear seat controls. The system is au ...

  • Ford AM/FM stereo - page 38

    Adjusting the volume This control allows the rear seat passengers to adjust the volume level of the audio system. Press the + control to increase the volume. Press the — control to decrease the volume. From the AutoVision 威 controls, the speaker volume cannot be set higher than the current volume radio setting. When in headphone mode, the AutoV ...

  • Ford AM/FM stereo - page 39

    Speakers ON/OFF mode W ith the speakers ON, you can adjust the audio output to all system speakers — front and rear together (headphones are disabled in this mode). The rear seat passengers can not raise the volume of the system above the level on the front radio bezel. W ith the speakers OFF , the headphones are enabled. The rear seat passengers ...

  • Ford AM/FM stereo - page 40

    Memory preset control In radio mode, press the MEM (Memory) control successively to scroll through the memory presets in AM, FM1 or FM2. In CDDJ mode, press the MEM (Memory) control to select the next disc in the compact disc changer . Play will begin with the first track. Seek function The SEEK control has varying functions depending on which mode ...

  • Ford AM/FM stereo - page 41

    Flip-down screens The screens rotate down to view and up into the housing to store when not in use. Ensure that the screens are latched into the housing when being stored. 1. 6.4 ” (diagonal) color liquid crystal display (LCD) screen. 2. Screen housing. 3. Dimmer switch. Rotate to increase/decrease the brightness of the screen. General operation ...

  • Ford AM/FM stereo - page 42

    Inserting/removing cassette Inserting cassette • Open the AutoVision 威 console cover . • Insert the videocassette into the cassette compartment. Inserting a videocassette into the VCP automatically turns the power ON (the indicator lamp will illuminate) and the tape will begin playback. If the vehicle is traveling over rough terrain, it may b ...

  • Ford AM/FM stereo - page 43

    On-screen indicators Playback operation 1. Press the POWER control on the VCP . 2. Insert a videocassette into the VCP . 3. The videocassette should automatically begin playback, and the picture will appear within approximately nine seconds. 4. Press the STOP control to stop playback or press EJECT to remove the cassette. Fast-forward or rewind (no ...

  • Ford AM/FM stereo - page 44

    Encore (on remote control) • Press the ENCORE control while in playback mode. The VCP will reverse to the previous five seconds of the selection and then operate at normal playback mode. Auxiliary input jacks The auxiliary input jacks on the AutoVision 威 control panel accepts video and audio connectors for all standard video games (Nintendo 威 ...

  • Ford AM/FM stereo - page 45

    V ideo source selection The MEDIA control determines which video (VCP or Auxiliary input) is seen on the AutoVision 威 screen. When the vehicle ignition is ON and the system is not in VCP mode, the AutoVision 威 selects the Auxiliary input as the video source. (If there is not a video source connected to the Auxiliary input jack, the screen will ...

  • Ford AM/FM stereo - page 46

    The following are some possible messages that may illuminate on your LED display and their meanings. Illuminates when there is a videocassette in the system during power off. Illuminates when there is a videocassette in the system during power on. Illuminates when a videocassette is ejected from the system. Flashes during emergency mode. Illuminate ...

  • Ford AM/FM stereo - page 47

    Illuminates when the videocassette is in PLA Y mode. Illuminates when the videocassette is in REV (review) mode. Illuminates when the videocassette is in CUE mode. Flashes separately when the videocassette is in ENCORE mode. Displays when: • the thermostat detects an extremely high or low temperature, or • the dew sensor is activated for high h ...

  • Ford AM/FM stereo - page 48

    • Patch cords with RCA style connectors These parts are available in your local electronics store or call toll free 1 (877) 848 – 6434 for assistance. Auxiliary jacks for home use 1. VIDEO OUT Connect this terminal to the VIDEO IN terminal of your display (LCD, TV). 2. DC jack in Connect this jack to the DC source (DC 12V). 3. AUDIO OUT LR Conn ...

  • Ford AM/FM stereo - page 49

    HEATER ONLY SYSTEM (IF EQUIPPED) 1. Fan speed adjustment: Controls the volume of air circulated in the vehicle. 2. T emperature selection: Controls the temperature of the airflow in the vehicle. 3. Air flow selections: Controls the direction of the airflow in the vehicle. See the following for a brief description on each control. VENT : Distributes ...

  • Ford AM/FM stereo - page 50

    MANUAL HEATING AND AIR CONDITIONING SYSTEM (IF EQUIPPED) 1. Fan speed adjustment: Controls the volume of air circulated in the vehicle. 2. T emperature selection: Controls the temperature of the airflow in the vehicle. 3. Air flow selections: Controls the direction of the airflow in the vehicle. See the following for a brief description on each con ...

  • Ford AM/FM stereo - page 51

    • Remove any snow , ice or leaves from the air intake area at the base of the windshield. T o aid in side window defogging/demisting in cold weather: 1. Select MIX. 2. Set the temperature control to maintain comfort. 3. Set the fan speed to HI Do not place objects on top of the instrument panel as these objects may become projectiles in a collisi ...

  • Ford AM/FM stereo - page 52

    HEADLAMP CONTROL • The first position turns on the parking, tail, license plate and side marker lamps. • The outer position turns on the headlamps. Battery saver The battery saver will turn off the courtesy lamps in 10 minutes if a door is left open and the key is not in the ignition. The battery saver will also shut off the demand interior lam ...

  • Ford AM/FM stereo - page 53

    Always remember to turn on your headlamps at dusk or during inclement weather . The Daytime Running Lamp (DRL) system does not activate with your tail lamps and generally may not provide adequate lighting during these conditions. Failure to activate your headlamps under these conditions may result in a collision. High beams Push the lever toward th ...

  • Ford AM/FM stereo - page 54

    AIMING THE HEADLAMPS The headlamps on your vehicle are properly aimed at the assembly plant. If your vehicle has been in an accident the alignment of your headlamps should be checked by a qualified service technician. TURN SIGNAL CONTROL • Push down to activate the left turn signal. • Push up to activate the right turn signal. INTERIOR LAMPS Ca ...

  • Ford AM/FM stereo - page 55

    Front and rear courtesy/reading lamps The dome portion of the lamp, the center light, can be turned on when the headlamp control is rotated fully counterclockwise or when any door is opened. The reading lamp portion, the two outer lights, can only be toggled on and off at the lamp. BULBS Replacing exterior bulbs Check the operation of all the bulbs ...

  • Ford AM/FM stereo - page 56

    Replacing headlamp bulbs (aerodynamic) 1. Make sure headlamp switch is in the OFF position and open the hood. 2. Push each clip tab toward the engine compartment and lift upward to the stop position, then remove the headlamp assembly . 3. Disconnect the electrical connector from the bulb by pulling rearward. 4. Remove the bulb retaining ring by rot ...

  • Ford AM/FM stereo - page 57

    Replacing headlamp bulbs (low series) 1. Make sure headlamp switch is in the OFF position and open the hood. 2. Remove the two headlamp screws and bezel from the headlamp housing. 3. Remove the four headlamp bulb retaining screws and the retaining ring. 4. Remove the headlamp. 5. Disconnect the electrical connector from the bulb and remove the bulb ...

  • Ford AM/FM stereo - page 58

    Replacing high-mount brakelamp bulbs The interior cargo lamp (if equipped), on vehicles without a rear headliner , will have to be removed from under the high-mount brakelamp assembly located inside the vehicle. Then: 1. Remove the two screws from the high-mount brakelamp assembly and lift the lamp from the vehicle. 2. Remove the bulb socket from t ...

  • Ford AM/FM stereo - page 59

    Replacing tail lamp/turn/backup lamp bulbs 1. T urn the headlamp switch to the OFF position and then remove the four screws and the lamp assembly from vehicle. 2. Rotate bulb socket counterclockwise and remove from lamp assembly . 3. Carefully pull the bulb straight out of the socket and push in the new bulb. T o install the lamp, follow the remova ...

  • Ford AM/FM stereo - page 60

    MULTI-FUNCTION LEVER W indshield wiper: Rotate the end of the control away from you to increase the speed of the wipers; rotate towards you to decrease the speed of the wipers. W indshield washer: Push the end of the stalk: • briefly: causes a single swipe of the wipers without washer fluid. • a quick push and hold: the wipers will swipe three ...

  • Ford AM/FM stereo - page 61

    TILT STEERING WHEEL T o adjust the steering wheel: 1. Pull and hold the steering wheel release control toward you. 2. Move the steering wheel up or down until you find the desired location. 3. Release the steering wheel release control. This will lock the steering wheel in position. Never adjust the steering wheel when the vehicle is moving. OVERHE ...

  • Ford AM/FM stereo - page 62

    1. Place V elcro hook onto side of aftermarket transmitter opposite of actuator control. 2. Place the transmitter into storage compartment, control down. 3. Place the provided height adaptors onto the back of the GARAGE control as needed. 4. Press the GARAGE control to activate the transmitter . Electronic compass/temperature display (if equipped) ...

  • Ford AM/FM stereo - page 63

    The compass reading may be affected when you drive near large buildings, bridges, power lines and powerful broadcast antenna. Magnetic or metallic objects placed in or on the vehicle may also affect compass accuracy . Adjustments may need to be made to the zone and calibration of the compass. Compass zone adjustment 1. Determine which magnetic zone ...

  • Ford AM/FM stereo - page 64

    CELL PHONE USE The use of Mobile Communications Equipment has become increasingly important in the conduct of business and personal affairs. However , drivers must not compromise their own or others ’ safety when using such equipment. Mobile Communications can enhance personal safety and security when appropriately used, particularly in emergency ...

  • Ford AM/FM stereo - page 65

    POWER WINDOWS (IF EQUIPPED) When closing the power windows, you should verify they are free of obstructions and ensure that children and/or pets are not in the proximity of the window openings. Press and hold the bottom part of the rocker switch to open the window . Press and hold the top part of the rocker switch to close the window . ACCESSORY DE ...

  • Ford AM/FM stereo - page 66

    T elescoping mirror The spotter mirror has a swivel that allows it to tilt up and down, and also to tilt left and right to increase side and rear visibility . Fold-away mirrors The mirrors can be manually folded forward or backwards for narrow spaces like driving through an automatic car wash or backing out of a garage with the trailer tow mirror . ...

  • Ford AM/FM stereo - page 67

    SPEED CONTROL (IF EQUIPPED) W ith speed control set, you can maintain a speed of 48 km/h (30 mph) or more without keeping your foot on the accelerator pedal. Speed control does not work at speeds below 48 km/h (30 mph). Do not use the speed control in heavy traffic or on roads that are winding, slippery or unpaved. Setting speed control The control ...

  • Ford AM/FM stereo - page 68

    Increasing speed while using speed control There are two ways to set a higher speed: • Press and hold the SET ACCEL control until you get to the desired speed, then release the control. Y ou can also use the SET ACCEL control to operate the T ap-Up function. Press and release this control to increase the vehicle set speed in increments by 1.6 km/ ...

  • Ford AM/FM stereo - page 69

    Turning of f speed control There are two ways to turn off the speed control: • Depress the brake pedal. This will not erase your vehicle ’ s previously set speed. • Press the speed control OFF control. Note: When you turn off the speed control or the ignition, your speed control set speed memory is erased. 2004 Econoline (eco) Owners Guide (p ...

  • Ford AM/FM stereo - page 70

    KEYS The key operates all locks on your vehicle. In case of loss, replacement keys are available from your dealer . Y ou should always carry a second key with you in a safe place in case you require it in an emergency . POWER DOOR LOCKS (IF EQUIPPED) Press U to unlock all doors and L to lock all doors. Memory lock If you lock your doors with the po ...

  • Ford AM/FM stereo - page 71

    Changes or modifications not expressly approved by the party responsible for compliance could void the user ’ s authority to operate the equipment. The typical operating range for your remote entry transmitter is approximately 10 meters (33 feet). A decrease in operating range could be caused by: • weather conditions, • nearby radio towers, ? ...

  • Ford AM/FM stereo - page 72

    Sounding a panic alarm Press to activate the alarm. Press the control again, or turn the ignition to the 1 (ACCESSORY) or 4 (ON) position to deactivate the alarm. Note: The panic alarm will only operate when the ignition is in the 2 (LOCK) or 3 (OFF) position. Replacing the battery The remote entry transmitter uses one coin type three-volt lithium ...

  • Ford AM/FM stereo - page 73

    Replacing lost remote entry transmitters If you would like to have your remote entry transmitter reprogrammed because you lost one, or would like to buy additional remote entry transmitters, you can either reprogram them yourself, or take all remote entry transmitters to your authorized dealer for reprogramming. How to reprogram your remote entry t ...

  • Ford AM/FM stereo - page 74

    Illuminated entry The interior lamps illuminate when the remote entry system is used to unlock the door(s) or sound the personal alarm. The illuminated entry system will turn off the interior lights if: • the ignition switch is turned to the 4 (ON) or 1 (ACCESSORY) position, or • the remote transmitter lock control is pressed, or • after 25 s ...

  • Ford AM/FM stereo - page 75

    SEATING Notes: Reclining the seatback can cause an occupant to slide under the seat ’ s safety belt, resulting in severe personal injuries in the event of a collision. Do not pile cargo higher than the seatbacks to reduce the risk of injury in a collision or sudden stop. Adjusting the front manual seat (if equipped) Never adjust the driver ’ s ...

  • Ford AM/FM stereo - page 76

    Pull lever up to adjust seatback. Using the manual lumbar support The lumbar support control is located on the inboard side of the driver ’ s seat. T urn the lumbar support control clockwise to increase firmness. T urn the lumbar support control counterclockwise to increase softness. Adjusting the front power seat (if equipped) The control is loc ...

  • Ford AM/FM stereo - page 77

    Press to raise or lower the rear portion of the seat cushion. Press the control to move the seat forward, backward, up or down. Quick release captains chair (7 passenger second row only) T o remove the seat: 1. Disengage the lap/shoulder belt from the seat by inserting a key or small screwdriver into the slot in the detachable anchor and lifting up ...

  • Ford AM/FM stereo - page 78

    Stow the tongue end of the detachable anchor . 2. Pull the seat latch handle, then pull the seat toward the right side of the vehicle to disengage four pins from the floor mount. 3. Remove the seat. T o install the seat: Check to see that the seat and seatback is latched securely in position. Keep floor area free of objects that would prevent prope ...

  • Ford AM/FM stereo - page 79

    REAR SEATS Accessing the 3rd, 4th and 5th row seats (if equipped) T o make access to the 4th and 5th row seats easier , attach the 3rd and 4th row passenger side seat belts to the trim panel by using the snaps attached to the seat belt webbing and the trim panel. Rear bench seat T o remove the seats: 1. Disengage the lap/shoulder belt from the seat ...

  • Ford AM/FM stereo - page 80

    2. Pull the LH/RH seat latch handles, located under the seat, rearward to release the latch hook ends from the front strikers. 3. Move the seat rearward and lift the seats rear hooks away from the rear strikers prior to lifting the front hooks out from the front strikers. 4. W ith assistance, remove the seat assembly . • T o remove the 3rd, 4th, ...

  • Ford AM/FM stereo - page 81

    SAFETY RESTRAINTS Safety restraints precautions Always drive and ride with your seatback upright and the lap belt snug and low across the hips. T o reduce the risk of injury , make sure children sit in the back seat where they can be properly restrained. Never let a passenger hold a child on his or her lap while the vehicle is moving. The passenger ...

  • Ford AM/FM stereo - page 82

    Safety belts and seats can become hot in a vehicle that has been closed up in sunny weather; they could burn a small child. Check seat covers and buckles before you place a child anywhere near them. Combination lap and shoulder belts 1. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) unt ...

  • Ford AM/FM stereo - page 83

    When to use the automatic locking mode In this mode, the shoulder belt is automatically pre-locked. The belt will still retract to remove any slack in the shoulder belt. The automatic locking mode is not available on the driver safety belt. This mode should be used any time a child safety seat is installed in a passenger front or outboard rear seat ...

  • Ford AM/FM stereo - page 84

    After any vehicle collision, the safety belt systems at all outboard seating positions (except the driver position, which does not have this feature) must be checked by a qualified technician to verify that the automatic locking retractor feature for child seats is still functioning properly . In addition, all seat belts should be checked for prope ...

  • Ford AM/FM stereo - page 85

    Front safety belt height adjustment Adjust the height of the shoulder belt so the belt rests across the middle of your shoulder . T o adjust the shoulder belt height, push the button and slide the height adjuster up or down. Release the button and pull down on the height adjuster to make sure it is locked in place. Position the safety belt height a ...

  • Ford AM/FM stereo - page 86

    Shorten and fasten the belt when not in use. Safety belt warning light and indicator chime The safety belt warning light illuminates in the instrument cluster and a chime sounds to remind the occupants to fasten their safety belts. Conditions of operation If... Then... The driver ’ s safety belt is not buckled before the ignition switch is turned ...

  • Ford AM/FM stereo - page 87

    If... Then... The driver ’ s safety belt is not buckled approximately 5 seconds after the safety belt warning light has turned off... The BeltMinder feature is activated - the safety belt warning light illuminates and the warning chime sounds for 6 seconds every 30 seconds, repeating for approximately 5 minutes or until safety belt is buckled. Th ...

  • Ford AM/FM stereo - page 88

    Reasons given... Consider ... “ I was in a hurry ” Prime time for an accident. BeltMinder reminds us to take a few seconds to buckle up. “ Seat belts don ’ t work ” Safety belts, when used properly , reduce risk of death to front seat occupants by 45% in cars, and by 60% in light trucks. “ T raffic is light ” Nearly 1 of 2 deaths occu ...

  • Ford AM/FM stereo - page 89

    Deactivating/activating the BeltMinder feature Read step s1-5 thoroughly before proceeding with the deactivation/activation programming procedure. The BeltMinder feature can be deactivated/activated by performing the following procedure: Before following the procedure, make sure that: • the parking brake is set • the gearshift is in P (Park) (a ...

  • Ford AM/FM stereo - page 90

    will flash 4 times per second for 3 seconds, followed by 3 seconds with the light off, then followed by the airbag warning light flashing 4 times per second for 3 seconds again. 5. After receiving confirmation, the deactivation/activation procedure is complete. Safety belt extension assembly If the safety belt is too short when fully extended, ther ...

  • Ford AM/FM stereo - page 91

    AIR BAG SUPPLEMENT AL RESTRAINT SYSTEM (SRS) Important SRS precautions The SRS is designed to work with the safety belt to help protect the driver and right front passenger from certain upper body injuries. Air bags DO NOT inflate slowly; there is a risk of injury from a deploying air bag. All occupants of the vehicle, including the driver , should ...

  • Ford AM/FM stereo - page 92

    The National Highway T raffic Safety Administration (NHTSA) recommends a minimum distance of at least 25 cm (10 inches) between an occupant ’ s chest and the driver air bag module. Never place your arm over the air bag module as a deploying air bag can result in serious arm fractures or other injuries. T o properly position yourself away from the ...

  • Ford AM/FM stereo - page 93

    Children and air bags Children must always be properly restrained. Accident statistics suggest that children are safer when properly restrained in the rear seating positions than in the front seating position. Failure to follow these instructions may increase the risk of injury in a collision. Air bags can kill or injure a child in a child seat. NE ...

  • Ford AM/FM stereo - page 94

    The air bags inflate and deflate rapidly upon activation. After air bag deployment, it is normal to notice a smoke-like, powdery residue or smell the burnt propellant. This may consist of cornstarch, talcum powder or sodium compounds which may irritate the skin and eyes, but none of the residue is toxic. While the SRS is designed to help reduce ser ...

  • Ford AM/FM stereo - page 95

    Determining if the system is operational The SRS uses a readiness light in the instrument cluster or a tone to indicate the condition of the system. Refer to Air bag readiness section in the Instrument Cluster chapter . Routine maintenance of the air bag is not required. A difficulty with the system is indicated by one or more of the following: • ...

  • Ford AM/FM stereo - page 96

    Important SRS precautions The SRS is designed to work with the safety belt to help protect the driver and right front passenger from certain upper body injuries. Air bags DO NOT inflate slowly; there is a risk of injury from a deploying air bag. All occupants of the vehicle, including the driver , should always properly wear their safety belts, eve ...

  • Ford AM/FM stereo - page 97

    Do not attempt to service, repair , or modify the air bag supplemental restraint systems or its fuses. See your Ford or Lincoln Mercury dealer . Children and safety belts If the child is the proper size, restrain the child in a safety seat. Children who are too large for child safety seats (as specified by your child safety seat manufacturer) shoul ...

  • Ford AM/FM stereo - page 98

    Booster seats should be used until you can answer YES to ALL of these questions: • Can the child sit all the way back against the vehicle seat back with knees bent comfortably at the edge of the seat without slouching? • Does the lap belt rest low across the hips? • Is the shoulder belt centered on the shoulder and chest? • Can the child st ...

  • Ford AM/FM stereo - page 99

    Both can be used in any vehicle in a seating position equipped with lap/shoulder belts if your child is over 40 lbs. The shoulder belt should cross the chest, resting snugly on the center of the shoulder . The lap belt should rest low and snug across the hips, never up high across the stomach. If the booster seat slides on the vehicle seat, placing ...

  • Ford AM/FM stereo - page 100

    When installing a child safety seat: • Review and follow the information presented in the Air Bag Supplemental Restraint System section in this chapter . • Use the correct safety belt buckle for that seating position (the buckle closest to the direction the tongue is coming from). • Insert the belt tongue into the proper buckle until you hear ...

  • Ford AM/FM stereo - page 101

    Installing child safety seats with combination lap and shoulder belts 1. Position the child safety seat in a seat with a combination lap and shoulder belt. An air bag can kill or injure a child in a child seat. Never place a rear -facing child seat in front of an active air bag. If you must use a forward-facing child seat in the front seat, move th ...

  • Ford AM/FM stereo - page 102

    3. While holding the shoulder and lap belt portions together , route the tongue through the child seat according to the child seat manufacturer ’ s instructions. Be sure the belt webbing is not twisted. 4. Insert the belt tongue into the proper buckle (the buckle closest to the direction the tongue is coming from) for that seating position until ...

  • Ford AM/FM stereo - page 103

    7. Pull the lap belt portion across the child seat toward the buckle and pull up on the shoulder belt while pushing down with your knee on the child seat. 8. Allow the safety belt to retract to remove any slack in the belt. 9. Before placing the child in the seat, forcibly tilt the seat forward and back to make sure the seat is securely held in pla ...

  • Ford AM/FM stereo - page 104

    Because the last row of seats is not equipped with either child tether or LA TCH anchors and is spaced closer to the row of seats in front, Do not use forward-facing or rear -facing child seats (other than belt-positioning boosters) in the last row . Air bags can kill or injure a child in a child seat. NEVER place a rear -facing child seat in front ...

  • Ford AM/FM stereo - page 105

    3. Route the child safety seat tether strap over the back of the front right-hand passenger seat as shown. 4. Clip the tether strap hook to the seat pedestal to the location shown. 5. Adjust the front right hand passenger seat to the full rearward position. 2004 Econoline (eco) Owners Guide (post-2002-fmt) USA English (fus) Seating and Safety Restr ...

  • Ford AM/FM stereo - page 106

    6. Install the child safety seat tightly using the LA TCH anchors or safety belts. Follow the instructions in this chapter . 7. T ighten the child safety seat tether strap according to the manufacturer ’ s instructions. Second row bucket seats (Chateau Quads) The tether strap can be attached directly to the tether bracket under the back edge of t ...

  • Ford AM/FM stereo - page 107

    3. Clip the tether strap hook to the seat pedestal at the location shown. 4. Install the child safety seat tightly using the LA TCH anchors or safety belts. Follow the instructions in this chapter . 5. T ighten the child safety seat tether strap according to the manufacturer ’ s instructions. Second, Third and Fourth row three passenger bench sea ...

  • Ford AM/FM stereo - page 108

    3. Clip the tether strap hook to the tether bracket mounted under rear rail of seat cushion frame. 4. Install the child safety seat tightly using the LA TCH anchors or safety belts. Follow the instructions in this chapter . 5. T ighten the child safety seat tether strap according to the manufacturer ’ s instructions. For additional important safe ...

  • Ford AM/FM stereo - page 109

    • Seven passenger wagon • Eight passenger wagon • T welve passenger wagon • Fifteen passenger wagon represents LA TCH anchors. represents tether strap anchors. 2004 Econoline (eco) Owners Guide (post-2002-fmt) USA English (fus) Seating and Safety Restraints 109 ...

  • Ford AM/FM stereo - page 110

    Never attach two LA TCH child safety seats to the same anchor . In a crash, one anchor may not be strong enough to hold two child safety seat attachments and may break, causing serious injury or death. The lower anchors for child seat installation are located at the rear section of the seat between the cushion and seat back. Follow the child seat m ...

  • Ford AM/FM stereo - page 111

    STARTING Positions of the ignition 1. ACCESSORY , allows the electrical accessories such as the radio to operate while the engine is not running. 2. LOCK, locks the automatic transmission gearshift lever and allows key removal. 3. OFF , shuts off the engine and all accessories without locking the steering wheel. This position also allows the automa ...

  • Ford AM/FM stereo - page 112

    Do not park, idle, or drive your vehicle in dry grass or other dry ground cover . The emission system heats up the engine compartment and exhaust system, which can start a fire. Do not start your vehicle in a closed garage or in other enclosed areas. Exhaust fumes can be toxic. Always open the garage door before you start the engine. See Guarding a ...

  • Ford AM/FM stereo - page 113

    • Make sure the gearshift is in P (Park). • T urn the key to 4 (ON) without turning the key to 5 (ST ART). Make sure the corresponding lights illuminate or illuminate briefly . If a light fails to illuminate, have the vehicle serviced. • If the driver ’ s safety belt is fastened, the light may not illuminate. Starting the engine 1. T urn th ...

  • Ford AM/FM stereo - page 114

    Note: If the engine does not start within five seconds on the first try , turn the key to 3 (OFF), wait 10 seconds and try again. If the engine still fails to start, press the accelerator to the floor and try again; this will allow the engine to crank with the fuel shut off in case the engine is flooded with fuel. Using the engine block heater (if ...

  • Ford AM/FM stereo - page 115

    keeping the brakes from locking. Noise from the ABS pump motor and brake pedal pulsation may be observed during ABS braking; this is normal and should be no reason for concern. ABS warning lamp The ABS lamp in the instrument cluster momentarily illuminates when the ignition is turned on. If the light does not illuminate during start up, remains on ...

  • Ford AM/FM stereo - page 116

    The parking brake is not recommended to stop a moving vehicle. However , if the normal brakes fail, the parking brake can be used to stop your vehicle in an emergency . Since the parking brake applies only the rear brakes, the vehicle ’ s stopping distance will increase greatly and the handling of your vehicle will be adversely affected. STEERING ...

  • Ford AM/FM stereo - page 117

    V ehicles with a higher center of gravity such as utility and four -wheel drive vehicles handle differently than vehicles with a lower center of gravity . Utility and four -wheel drive vehicles are not designed for cornering at speeds as high as passenger cars any more than low-slung sports cars are designed to perform satisfactorily under off-road ...

  • Ford AM/FM stereo - page 118

    AUTOMATIC TRANSMISSION OPERATION Brake-shift interlock This vehicle is equipped with a brake-shift interlock feature that prevents the gearshift lever from being moved from P (Park) when the ignition is in the ON position unless brake pedal is depressed. If you cannot move the gearshift lever out of P (Park) with ignition in the ON position and the ...

  • Ford AM/FM stereo - page 119

    Understanding the gearshift positions of the 4 – speed automatic transmission This vehicle is equipped with an adaptive T ransmission Shift Strategy . Adaptive Shift strategy offers the optimal transmission operation and shift quality . When the vehicle ’ s battery has been disconnected for any type of service or repair , the transmission will ...

  • Ford AM/FM stereo - page 120

    N (Neutral) W ith the gearshift lever in N (Neutral), the vehicle can be started and is free to roll. Hold the brake pedal down while in this position. (Overdrive) The normal driving position for the best fuel economy . T ransmission operates in gears one through four . Overdrive can be deactivated by pressing the transmission control switch on the ...

  • Ford AM/FM stereo - page 121

    • Selecting 2 (Second) at higher speeds will cause the transmission to downshift to second gear at the appropriate vehicle speed. 1 (First) • Provides maximum engine braking. • Allows upshifts by moving gearshift lever . • W ill not downshift into 1 (First) at high speeds; allows for 1 (First) when vehicle reaches slower speeds. Forced down ...

  • Ford AM/FM stereo - page 122

    Do not rock the vehicle if the engine is not at normal operating temperature or damage to the transmission may occur . Do not rock the vehicle for more than a minute or damage to the transmission and tires may occur , or the engine may overheat. Understanding the shift positions of the 5 – speed automatic transmission (if equipped - diesel engine ...

  • Ford AM/FM stereo - page 123

    D (Drive) without Overdrive D (Drive) without Overdrive can be activated by pressing the transmission control switch (TCS) on the end of the gearshift lever . • This position allows for all forward gears except overdrive. • The OFF lamp on the gearshift lever is illuminated. • Provides engine braking. • Use when driving conditions cause exc ...

  • Ford AM/FM stereo - page 124

    DRIVING THROUGH WATER If driving through deep or standing water is unavoidable, proceed very slowly especially if the depth is not known. Never drive through water that is higher than the bottom of the hubs (for trucks) or the bottom of the wheel rims (for cars). T raction or brake capability may be limited and your vehicle may stall. W ater may al ...

  • Ford AM/FM stereo - page 125

    V EHICLE LOADING – WITH AND WITHOUT A TRAILER This section will guide you in the proper loading of your vehicle and/or trailer , to keep your loaded vehicle weight within its design rating capability , with or without a trailer . Properly loading your vehicle will provide maximum return of vehicle design performance. Before loading your vehicle, ...

  • Ford AM/FM stereo - page 126

    Exceeding the Safety Certification Label axle weight rating limits could result in substandard vehicle handling, performance, engine, transmission and/or structural damage, serious damage to the vehicle, loss of control and personal injury . Note: For trailer towing information refer to T railer towing found in this chapter or the RV and T railer T ...

  • Ford AM/FM stereo - page 127

    GCW (Gross Combined W eight) – is the weight of the loaded vehicle (GVW) plus the weight of the fully loaded trailer . GCWR (Gross Combined W eight Rating) – is the maximum allowable weight of the vehicle and the loaded trailer – including all cargo and passengers – that the vehicle can handle without risking damage. (Important: The towing ...

  • Ford AM/FM stereo - page 128

    Exceeding any vehicle weight rating limitation could result in serious damage to the vehicle and/or personal injury . Special loading instructions for owners of pickup trucks and utility-type vehicles For important information regarding safe operation of this type of vehicle, see the Preparing to drive your vehicle section in this chapter . Loaded ...

  • Ford AM/FM stereo - page 129

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) E-150 Regular V an (6700 GVWR) 4.6L 3.55 5216 (11500) 2903 (6400) 5.52 (60) 5.4L 3.55 5443 (12000) 3084 (6800) 5.52 (60) E-150 Regular V an (Crew) (6700 GVWR ...

  • Ford AM/FM stereo - page 130

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) E-250 Regular V an (Crew) (8600 GVWR) 4.6L 4.10 4990 (11000) 2404 (5300) 5.52 (60) 5.4L 3.73 5897 (13000) 3266 (7200) 5.52 (60) E-250 Extended V an (7300 GVW ...

  • Ford AM/FM stereo - page 131

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) E-350 Regular V an (Crew) (9500 GVWR) 5.4L 3.55 5443 (12000) 2767 (6100) 5.52 (60) 5.4L 4.10 5897 (13000) 3221 (7100) 5.52 (60) 6.8L 3.73 6804 (15000) 4082 ( ...

  • Ford AM/FM stereo - page 132

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) E-350 Regular W agon (8 – passenger) (8600 GVWR) 5.4L 3.73 5897 (13000) 3130 (6900) 5.52 (60) E-350 Regular W agon (8 – passenger) (8700 GVWR) 6.8L 3.73 ...

  • Ford AM/FM stereo - page 133

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) E-350 Extended W agon (15 – passenger) (9300 GVWR) 6.8L 3.73 6804 (15000) 3810 (8400) 5.52 (60) 6.8L 4.10 8391 (18500) 4536 (10000) 5.52 (60) E-350 Cutaway ...

  • Ford AM/FM stereo - page 134

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) E-350 Chassis Cab (138 ” wheelbase, dual rear wheel) (10700 GVWR) 5.4L 4.10 5897 (13000) 3493 (7700) 5.52 (60) 6.8L 4.10 8391 (18500) 4536 (10000) 5.52 (60 ...

  • Ford AM/FM stereo - page 135

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) E-350 Stripped Chassis (138 ” wheelbase) (10000 GVWR) 5.4L 4.10 5897 (13000) 3856 (8500) 5.52 (60) 6.8L 4.10 8391 (18500) 4536 (10000) 5.52 (60) E-350 Stri ...

  • Ford AM/FM stereo - page 136

    GCWR (Gross Combined W eight Rating)/T railer W eights Engine Rear axle ratio Maximum GCWR - kg (lbs.) Maximum Loaded T railer W eight - kg (lbs.) Maximum frontal area of trailer - m 2 (ft 2 ) Maximum trailer weight for all cutaway (E-350 and E-450) vehicles must be calculated by subtracting the weight of the vehicle (including incomplete vehicle w ...

  • Ford AM/FM stereo - page 137

    Safety chains Always connect the trailer ’ s safety chains to the frame or hook retainers of the vehicle hitch. T o connect the trailer ’ s safety chains, cross the chains under the trailer tongue and allow slack for turning corners. If you use a rental trailer , follow the instructions that the rental agency gives to you. Do not attach safety ...

  • Ford AM/FM stereo - page 138

    • T o eliminate excessive shifting, use a lower gear . This will also assist in transmission cooling. • Anticipate stops and brake gradually . When descending long, steep downhill grades, always use a lower gear to provide engine braking to save wear on brakes. Use Drive (Overdrive OFF) on moderately steep hills, Second (2) on steep hills, and ...

  • Ford AM/FM stereo - page 139

    Launching or retrieving a boat Disconnect the wiring to the trailer before backing the trailer into the water . Reconnect the wiring to the trailer after the trailer is removed from the water . When backing down a ramp during boat launching or retrieval: • do not allow the static water level to rise above the bottom edge of the rear bumper . • ...

  • Ford AM/FM stereo - page 140

    GETTING ROADSIDE ASSISTANCE T o fully assist you should you have a vehicle concern, Ford Motor Company offers a complimentary roadside assistance program. This program is separate from the New V ehicle Limited W arranty . The service is available: • 24 – hours, seven days a week • for the New V ehicle Limited W arranty period of three years o ...

  • Ford AM/FM stereo - page 141

    Canadian customers who require roadside assistance, call 1 – 800 – 665 – 2006. If you need to arrange roadside assistance for yourself, Ford Motor Company will reimburse a reasonable amount. T o obtain reimbursement information, U.S. Ford or Mercury vehicles customers call 1-800-241-3673; Lincoln vehicle customers call 1 – 800 – 521 – 4 ...

  • Ford AM/FM stereo - page 142

    Except for commercial stripped chassis vehicles, this switch is located in the front passenger ’ s footwell, by the kick panel. On commercial stripped chassis vehicles, this switch is located on a bracket above the brake pedal. T o reset the switch: 1. T urn the ignition OFF . 2. Check the fuel system for leaks. 3. If no leaks are apparent, reset ...

  • Ford AM/FM stereo - page 143

    FUSES AND RELAYS Fuses If electrical components in the vehicle are not working, a fuse may have blown. Blown fuses are identified by a broken wire within the fuse. Check the appropriate fuses before replacing any electrical components. Note: Always replace a fuse with one that has the specified amperage rating. Using a fuse with a higher amperage r ...

  • Ford AM/FM stereo - page 144

    T o remove a fuse use the fuse puller tool provided on the fuse panel cover . The fuses are coded as follows. Fuse/Relay Location Fuse Amp Rating Passenger Compartment Fuse Panel Description 15 A 4 – Wheel Anti – lock Brake System (4W ABS) module 2 10A Remote Keyless Entry (RKE), O/D cancel, Low vacuum (Diesel engine only) 3 15A T rip computer ...

  • Ford AM/FM stereo - page 145

    Fuse/Relay Location Fuse Amp Rating Passenger Compartment Fuse Panel Description 6 10A Brake-shift interlock, Speed control (gasoline engine only) 7 10A Multi-function switch, T urn signals 8 30A Radio capacitor(s), Ignition coil, Powertrain Control Module (PCM) diode, PCM power relay , Auxiliary PCM (APCM) (Diesel engine only) 9 30A W iper control ...

  • Ford AM/FM stereo - page 146

    Fuse/Relay Location Fuse Amp Rating Passenger Compartment Fuse Panel Description 24 — Not used 25 10A Left headlamp (low beam) 26 20A Cigar lighter , Diagnostics 27 5A Radio 28 — Not used 29 20A Power point #4 (console) 30 15A Headlamps (high beam indicator) 31 10A Right headlamp (low beam) 32 20A Power point #1 (instrument panel) 33 10A Starte ...

  • Ford AM/FM stereo - page 147

    Power distribution box The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that protect your vehicle ’ s main electrical systems from overloads. Always disconnect the battery before servicing high current fuses. Always replace the cover to the power distribution box before reconn ...

  • Ford AM/FM stereo - page 148

    Fuse/Relay Location Fuse Amp Rating Power Distribution Box Description 3 10A* Daytime Running Lamps (DRL) module, A/C clutch 4 20A* Natural Gas V ehicle (NGV) tank solenoids (natural gas vehicle only) 5 15A* Horn relay 6 2A* Brake pressure switch 7 60A** Ignition switch, Fuse panel, Accessory delay 8 40A** T railer battery charge relay 9 50A** Modi ...

  • Ford AM/FM stereo - page 149

    Fuse/Relay Location Fuse Amp Rating Power Distribution Box Description 23 10A* Alternator 24 20A* T railer tow running lamps and back-up lamp relays 25 — Not used 26 20A* T railer tow turn signals 27 10A* PCM 28 — Not used A — Fuel pump relay B — Horn relay C — T railer back-up lamps relay D — T railer running lamps relay E — T railer ...

  • Ford AM/FM stereo - page 150

    The relays are coded as follows: Relay location Description 1 Interior lamps 2 Open 3 Roof marker lamps 4 Battery saver Engine compartment relay module The engine compartment relay module is located in one of two places depending on which type of engine your vehicle is equipped with: • Gasoline engine: driver side of the engine compartment above ...

  • Ford AM/FM stereo - page 151

    CHANGING A FLAT TIRE If you get a flat tire while driving: • do not brake heavily . • gradually decrease the vehicle ’ s speed. • hold the steering wheel firmly . • slowly move to a safe place on the side of the road. The use of tire sealants may damage your tires. Dissimilar spare tire/wheel information Failure to follow these guidelines ...

  • Ford AM/FM stereo - page 152

    • W et weather driving capability • All-Wheel Driving Capability (if applicable) • Load Leveling Adjustment (if applicable) When driving with the dissimilar spare tire/wheel additional caution should be given to: • T owing a trailer • Driving vehicles equipped with a camper body • Driving vehicles with a load on the cargo rack Drive cau ...

  • Ford AM/FM stereo - page 153

    Tire change procedure Preparing to change the tire T o help prevent the vehicle from moving when you change a tire, be sure the parking brake is set, then block (in both directions) the wheel that is diagonally opposite (other side and end of the vehicle) to the tire being changed. 1. Park on a level surface. 2. Activate the warning flashers. 3. Pl ...

  • Ford AM/FM stereo - page 154

    • non-chassis cab vehicles: jack is located in the rear right-hand side of the cargo area. • E-350 chassis cab vehicles(if equipped): jack is strapped to a bracket behind the driver ’ s seat. 2004 Econoline (eco) Owners Guide (post-2002-fmt) USA English (fus) Roadside Emergencies 154 ...

  • Ford AM/FM stereo - page 155

    7. Use the tapered end of the lug nut wrench to unscrew wheel ornaments attached by retaining screws. Remove any wheel trim. Insert the tapered end of the lug nut wrench behind wheel covers or hubcaps and twist off. 8. Loosen the wheel nut by pulling up on the handle of the lug nut wrench about one-half turn (counterclockwise). Do not remove the wh ...

  • Ford AM/FM stereo - page 156

    Rear axle jacking points - All models except E-350 Dual Rear Wheel (DR W) and E-450: Rear axle jacking points - E-350 Dual Rear Wheel (DR W) and E-450: Front axle jacking points: Place the jack under the pin on the front surface of the front axle. Do not place the jack under or on the steering linkage. • Raise the jack until the wheel is complete ...

  • Ford AM/FM stereo - page 157

    If your vehicle has single rear wheels, thread the lug nuts on the studs with the beveled face toward the wheel. If your vehicle has dual rear wheels, thread the two element swiveling lug nuts on the studs with the flange facing toward the wheel. 3. Use the lug nut wrench to screw the lug nut snugly against the wheel. 4. Lower the vehicle by turnin ...

  • Ford AM/FM stereo - page 158

    2. Slide the wheel partially under the vehicle and install the retainer through the wheel center . Pull on the cable to align the components at the end of the cable. 3. T urn the jack handle clockwise until the tire is raised to its stowed position underneath the vehicle. The effort to turn the jack handle increases significantly and the spare tire ...

  • Ford AM/FM stereo - page 159

    On all two-piece flat wheel nuts, apply one drop of motor oil between the flat washer and the nut. Do not apply motor oil to the wheel nut threads or the wheel stud threads. When a wheel is installed, always remove any corrosion, dirt or foreign materials present on the mounting surfaces of the wheel or the surface of the front disc brake hub and r ...

  • Ford AM/FM stereo - page 160

    Preparing your vehicle When the battery is disconnected or a new battery is installed, the transmission must relearn its shift strategy . As a result, the transmission may have firm and/or soft shifts. This operation is considered normal and will not affect function or durability of the transmission. Over time, the adaptive learning process will fu ...

  • Ford AM/FM stereo - page 161

    2. Connect the other end of the positive (+) cable to the positive (+) terminal of the assisting battery . 3. Connect the negative (-) cable to the negative (-) terminal of the assisting battery . + – + – + – + – 2004 Econoline (eco) Owners Guide (post-2002-fmt) USA English (fus) Roadside Emergencies 161 ...

  • Ford AM/FM stereo - page 162

    4. Make the final connection of the negative (-) cable to an exposed metal part of the stalled vehicle ’ s engine, away from the battery and the carburetor/fuel injection system. Do not use fuel lines, engine rocker covers or the intake manifold as grounding points. Do not connect the end of the second cable to the negative (-) terminal of the ba ...

  • Ford AM/FM stereo - page 163

    Removing the jumper cables Remove the jumper cables in the reverse order that they were connected. 1. Remove the jumper cable from the ground metal surface. Note: In the illustrations, lightning bolts are used to designate the assisting (boosting) battery . 2. Remove the jumper cable on the negative (-) connection of the booster vehicle ’ s batte ...

  • Ford AM/FM stereo - page 164

    3. Remove the jumper cable from the positive (+) terminal of the booster vehicle ’ s battery . 4. Remove the jumper cable from the positive (+) terminal of the disabled vehicle ’ s battery . After the disabled vehicle has been started and the jumper cables removed, allow it to idle for several minutes so the engine computer can relearn its idle ...

  • Ford AM/FM stereo - page 165

    WRECKER TOWING If you need to have your vehicle towed, contact a professional towing service or , if you are a member of a roadside assistance program, your roadside assistance service provider . Ford recommends your vehicle be towed with a wheel lift or flatbed. Do not tow with a slingbelt. Ford Motor Company has not approved a slingbelt towing pr ...

  • Ford AM/FM stereo - page 166

    GETTING THE SERVICES YOU NEED At home Y ou must take your Ford vehicle to an authorized Ford dealer for warranty repairs. While any Ford dealership handling your vehicle line will provide warranty service, we recommend you return to your selling dealer who wants to ensure your continued satisfaction. Please note that certain warranty repairs requir ...

  • Ford AM/FM stereo - page 167

    Ford Motor Company of Canada, Limited P .O. Box 2000 Oakville, Ontario L6J 5E4 1-800-565-3673 (FORD) www .ford.ca If you own a Lincoln vehicle and are away from home when your vehicle needs service, or if you need more help than the dealership could provide, after following the steps described above, contact the Ford Customer Relationship Center to ...

  • Ford AM/FM stereo - page 168

    In the United States, a warranty dispute must be submitted to the Dispute Settlement Board before taking action under the Magnuson-Moss W arranty Act, or to the extent allowed by state law , before pursuing replacement or repurchase remedies provided by certain state laws. This dispute handling procedure is not required prior to enforcing state cre ...

  • Ford AM/FM stereo - page 169

    The Dispute Settlement Board may not be available in all states. Ford Motor Company reserves the right to change eligibility limitations, modify procedures and/or to discontinue this service without notice and without incurring obligations per applicable state law . What kinds of cases does the Board review? Unresolved warranty repair concerns or v ...

  • Ford AM/FM stereo - page 170

    from Ford and Lincoln Mercury dealership management, recognized for their business leadership qualities. What the Board needs T o have your case reviewed you must complete the application in the DSB brochure and mail it to the address provided on the application form. Some states will require you to use certified mail, with return receipt requested ...

  • Ford AM/FM stereo - page 171

    Making a decision Board members review all available information related to each complaint, including oral presentations, and arrive at a fair and impartial decision. Board review may be terminated at any time by either party . Every effort is made to decide the case within 40 days of the date that all requested information is received by the Board ...

  • Ford AM/FM stereo - page 172

    In the CAMV AP program, impartial third-party arbitrators conduct hearings at mutually convenient times and places in an informal environment. These impartial arbitrators review the positions of the parties, make decisions and, when appropriate, render awards to resolve disputes. CAMV AP decisions are fast, fair , and final; the arbitrator ’ s aw ...

  • Ford AM/FM stereo - page 173

    ORDERING ADDITIONAL OWNER ’ S LITERA TURE T o order the publications in this portfolio, contact Helm, Incorporated at: HELM, INCORPORA TED P .O. Box 07150 Detroit, Michigan 48207 Or call: For a free publication catalog, order toll free: 1-800-782-4356 Monday-Friday 8:00 a.m. - 6:00 p.m. EST Helm, Incorporated can also be reached by their website: ...

  • Ford AM/FM stereo - page 174

    3. The vehicle is out of service for repair of nonconformities for a total of more than 30 calendar days (not necessarily all at one time) In the case of 1 or 2 above, the consumer must also notify the manufacturer of the need for the repair of the nonconformity at the following address: Ford Motor Company 16800 Executive Plaza Drive Mail Drop 3NE- ...

  • Ford AM/FM stereo - page 175

    W ASHING THE EXTERIOR W ash your vehicle regularly with cool or lukewarm water and a neutral Ph shampoo, such as Motorcraft Detail W ash (ZC-3 – A), which is available from your dealer . • Never use strong household detergents or soap, such as dish washing or laundry liquid. These products can discolor and spot painted surfaces. • Never wash ...

  • Ford AM/FM stereo - page 176

    • Do not allow paint sealant to come in contact with the sliding door electrical contact switches. Paint sealant or other contaminants could interfere with the proper operation of the power locks or radio speakers. If necessary , clean the contacts with Motorcraft Bug and T ar Remover (ZC-42) to remove any sealant. Do not use any abrasives on the ...

  • Ford AM/FM stereo - page 177

    • Do not spray a hot engine with cold water to avoid cracking the engine block or other engine components. • Spray Motorcraft Engine Shampoo and Degreaser (ZC-20) on all parts that require cleaning and pressure rinse clean. • Cover the highlighted areas to prevent water damage when cleaning the engine. • Never wash or rinse the engine while ...

  • Ford AM/FM stereo - page 178

    • Do not use abrasives, as they may cause scratches. • Do not use fuel, kerosene, or paint thinner to clean any parts. • W iper blades can be cleaned with isopropyl (rubbing) alcohol or windshield washer solution. Be sure to replace wiper blades when they appear worn or do not function properly . INSTRUMENT PANEL AND CLUSTER LENS Clean the in ...

  • Ford AM/FM stereo - page 179

    Do not use cleaning solvents, bleach or dye on the vehicle ’ s seatbelts, as these actions may weaken the belt webbing. LEATHER SEATS (IF EQUIPPED) Y our leather seating surfaces have a clear , protective coating over the leather . • T o clean, use a soft cloth with Motorcraft Deluxe Leather and Vinyl Cleaner (ZC-11 – A). Dry the area with a ...

  • Ford AM/FM stereo - page 180

    Motorcraft Extra Strength Upholstery Cleaner (not available in Canada) (ZC-41) Motorcraft Custom Bright Metal Cleaner (ZC-15) Motorcraft Wheel and T ire Cleaner (ZC-37 – A) Motorcraft Dash and Vinyl Cleaner (ZC-38 – A) Motorcraft Car Care Kit (ZC-26) Ford Premium Car W ash Concentrate (F2SZ-19523 – WC) Motorcraft Carlite Glass Cleaner (Canada ...

  • Ford AM/FM stereo - page 181

    SERVICE RECOMMENDATIONS T o help you service your vehicle: • W e highlight do-it-yourself items in the engine compartment for easy location. • W e provide a scheduled maintenance guide which makes tracking routine service easy . If your vehicle requires professional service, your dealership can provide the necessary parts and service. Check you ...

  • Ford AM/FM stereo - page 182

    OPENING THE HOOD 1. Inside the vehicle, pull the hood release handle located under the bottom left corner of the instrument panel. 2. Go to the front of the vehicle and release the auxiliary latch that is located in the center top of the grill. 3. Lift the hood and secure it with the prop rod. IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT Engine ...

  • Ford AM/FM stereo - page 183

    1. W indshield washer fluid reservoir 2. Engine oil filler cap 3. Automatic transmission fluid dipstick 4. Air filter assembly 5. Engine oil dipstick 6. Power steering fluid reservoir 7. Brake fluid reservoir 8. Engine coolant reservoir 9. Battery WINDSHIELD WASHER FLUID Add fluid to fill the reservoir if the level is low . In very cold weather , d ...

  • Ford AM/FM stereo - page 184

    W asher fluids containing non-methanol antifreeze agents should be used only if they provide cold weather protection without damaging the vehicle ’ s paint finish, wiper blades or washer system. If you operate your vehicle in temperatures below 4.5 ° C (40 ° F), use washer fluid with antifreeze protection. Failure to use washer fluid with antif ...

  • Ford AM/FM stereo - page 185

    • If the oil level is between the MIN and MAX marks, the oil level is acceptable. DO NOT ADD OIL. • If the oil level is below the MIN mark, add enough oil to raise the level within the MIN-MAX range. • Oil levels above the MAX mark may cause engine damage. Some oil must be removed from the engine by a service technician. 7. Put the indicator ...

  • Ford AM/FM stereo - page 186

    Engine oil and filter recommendations Look for this certification trademark. Use SAE 5W -20 engine oil. Only use oils “ Certified For Gasoline Engines ” by the American Petroleum Institute (API). T o protect your engine ’ s warranty use Motorcraft SAE 5W -20 or an equivalent 5W -20 oil meeting Ford specification WSS-M2C153 – H. SAE 5W -20 o ...

  • Ford AM/FM stereo - page 187

    BATTERY Y our vehicle is equipped with a Motorcraft maintenance-free battery which normally does not require additional water during its life of service. However , for severe usage or in high temperature climates and only for frame mounted deep cycle auxiliary batteries, check the battery electrolyte level. Note: This does not apply to production f ...

  • Ford AM/FM stereo - page 188

    When lifting a plastic-cased battery , excessive pressure on the end walls could cause acid to flow through the vent caps, resulting in personal injury and/or damage to the vehicle or battery . Lift the battery with a battery carrier or with your hands on opposite corners. Keep batteries out of reach of children. Batteries contain sulfuric acid. A ...

  • Ford AM/FM stereo - page 189

    If the battery has been disconnected or a new battery has been installed, the clock and radio settings must be reset once the battery is reconnected. • Always dispose of automotive batteries in a responsible manner . Follow your local authorized standards for disposal. Call your local authorized recycling center to find out more about recycling a ...

  • Ford AM/FM stereo - page 190

    When the engine is cold, check the level of the engine coolant in the reservoir . • The engine coolant should be at the “ cold fill level ” or within the “ cold fill range ” as listed on the engine coolant reservoir (depending upon application). • Refer to the Scheduled Maintenance Guide for service interval schedules. • Be sure to re ...

  • Ford AM/FM stereo - page 191

    Do not add engine coolant when the engine is hot. Steam and scalding liquids released from a hot cooling system can burn you badly . Also, you can be burned if you spill coolant on hot engine parts. Do not put engine coolant in the windshield washer fluid container . If sprayed on the windshield, engine coolant could make it difficult to see throug ...

  • Ford AM/FM stereo - page 192

    coolant pressure relief cap on the radiator of a vehicle with an overflow system, follow these steps to add engine coolant. T o reduce the risk of personal injury , make sure the engine is cool before unscrewing the coolant pressure relief cap. The cooling system is under pressure; steam and hot liquid can come out forcefully when the cap is loosen ...

  • Ford AM/FM stereo - page 193

    Used engine coolant should be disposed of in an appropriate manner . Follow your community ’ s regulations and standards for recycling and disposing of automotive fluids. Coolant refill capacity T o find out how much fluid your vehicle ’ s cooling system can hold, refer to Refill capacities in this section. Fill your engine coolant reservoir as ...

  • Ford AM/FM stereo - page 194

    What you should know about fail-safe cooling (if equipped) If the engine coolant supply is depleted, this feature allows the vehicle to be driven temporarily before incremental component damage is incurred. The “ fail-safe ” distance depends on ambient temperatures, vehicle load and terrain. How fail-safe cooling works If the engine begins to o ...

  • Ford AM/FM stereo - page 195

    Never remove the coolant reservoir cap while the engine is running or hot. 5. Re-start the engine and take your vehicle to a service facility . Driving the vehicle without repairing the engine problem increases the chance of engine damage. T ake your vehicle to a service facility as soon as possible. WHAT YOU SHOULD KNOW ABOUT AUTOMOTIVE FUELS Impo ...

  • Ford AM/FM stereo - page 196

    • Extinguish all smoking materials and any open flames before fueling your vehicle. • Always turn off the vehicle before fueling. • Automotive fuels can be harmful or fatal if swallowed. Fuel such as gasoline is highly toxic and if swallowed can cause death or permanent injury . If fuel is swallowed, call a physician immediately , even if no ...

  • Ford AM/FM stereo - page 197

    • Place approved fuel container on the ground. • DO NOT fill a fuel container while it is in the vehicle (including the cargo area). • Keep the fuel pump nozzle in contact with the fuel container while filling. • DO NOT use a device that would hold the fuel pump handle in the fill position. Fuel Filler Cap Y our fuel tank filler cap has an ...

  • Ford AM/FM stereo - page 198

    Choosing the right fuel Use only UNLEADED FUEL. The use of leaded fuel is prohibited by law and could damage your vehicle. Do not use fuel containing methanol. It can damage critical fuel system components. Y our vehicle was not designed to use fuel or fuel additives with metallic compounds, including manganese-based additives. Repairs to correct t ...

  • Ford AM/FM stereo - page 199

    Cleaner air Ford endorses the use of reformulated “ cleaner -burning ” gasolines to improve air quality . Running out of fuel A void running out of fuel because this situation may have an adverse affect on powertrain components. If you have run out of fuel: • Y ou may need to cycle the ignition from OFF to ON several times after refueling, to ...

  • Ford AM/FM stereo - page 200

    amount of fuel in a full tank and a tank when the fuel gauge indicates empty . Empty reserve is the small amount of fuel remaining in the fuel tank after the fuel gauge indicates empty . The amount of usable fuel in the empty reserve varies and should not be relied upon to increase driving range. When refueling your vehicle after the fuel gauge ind ...

  • Ford AM/FM stereo - page 201

    economy under current driving conditions. Additionally , keeping records during summer and winter will show how temperature impacts fuel economy . In general, lower temperatures give lower fuel economy . Driving style — good driving and fuel economy habits Give consideration to the lists that follow and you may be able to change a number of varia ...

  • Ford AM/FM stereo - page 202

    • Perform all regularly scheduled maintenance items. Follow the recommended maintenance schedule and owner maintenance checks found in your vehicle scheduled maintenance guide. Conditions • Heavily loading a vehicle or towing a trailer may reduce fuel economy at any speed. • Carrying unnecessary weight may reduce fuel economy (approximately 0 ...

  • Ford AM/FM stereo - page 203

    • Use only the specified fuel listed. • A void running out of fuel. • Do not turn off the ignition while your vehicle is moving, especially at high speeds. • Have the items listed in your Scheduled Maintenance Guide performed according to the specified schedule. The scheduled maintenance items listed in the Scheduled Maintenance Guide are e ...

  • Ford AM/FM stereo - page 204

    environment by ensuring that your vehicle continues to meet government emission standards. The OBD-II system also assists the service technician in properly servicing your vehicle. When the Check engine/Service engine soon light illuminates, the OBD-II system has detected a malfunction. T emporary malfunctions may cause your Check engine/Service en ...

  • Ford AM/FM stereo - page 205

    CHECKING AND ADDING POWER STEERING FLUID Check the power steering fluid. Refer to the scheduled maintenance guide for the service interval schedules. If adding fluid is necessary , use only MERCON 威 AT F. Check the fluid level when it is at ambient temperature, 20 °– 80 ° F (-7 ° – 25 ° C): 1. Check the fluid level on the dipstick. It sho ...

  • Ford AM/FM stereo - page 206

    BRAKE FLUID RESERVOIR The fluid level will drop slowly as the brakes wear , and will rise when the brake components are replaced. Fluid levels below the “ MAX ” line that do not trigger the brake system warning lamp are within the normal operating range, there is no need to add fluid. If the fluid levels are outside of the normal operating rang ...

  • Ford AM/FM stereo - page 207

    5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If necessary , refer to Identifying components in the engine compartment in this chapter for the location of the dipstick. 6. Install the dipstick making sure it is fully seated in the filler tube. 7. Remove the dipstick and inspect the fluid level. The fluid should be in the ...

  • Ford AM/FM stereo - page 208

    Adjusting automatic transmission fluid levels Before adding any fluid, make sure the correct type is used. The type of fluid used is normally indicated on the dipstick and also in the Lubricant specifications section in this chapter . Use of a non-approved automatic transmission fluid may cause internal transmission component damage. If necessary , ...

  • Ford AM/FM stereo - page 209

    Automatic transmission fluid filter (if equipped) The T orqShift automatic transmission is equipped with a serviceable external fluid filter mounted on the driver ’ s side of the transmission. Refer to the Scheduled Maintenance Guide for service intervals. T o replace the transmission filter: 1. Shut off the engine. 2. Unscrew remote filter housi ...

  • Ford AM/FM stereo - page 210

    Changing the air filter element 1. Disconnect the fresh air inlet tube from the radiator support. 2. Loosen the clamp that secures the two halves of the air filter housing together . 3. Carefully separate the two halves of the air filter housing. 4. Remove the air filter element from the housing. 5. Install a new air filter element. Be careful not ...

  • Ford AM/FM stereo - page 211

    These T ire Quality Grades are determined by standards that the United States Department of T ransportation has set. T ire Quality Grades apply to new pneumatic tires for use on passenger cars. They do not apply to deep tread, winter -type snow tires, space-saver or temporary use spare tires, tires with nominal rim diameters of 10 to 12 inches or l ...

  • Ford AM/FM stereo - page 212

    Safety Standard No. 109. Grades B and A represent higher levels of performance on the laboratory test wheel than the minimum required by law . The temperature grade for this tire is established for a tire that is properly inflated and not overloaded. Excessive speed, underinflation, or excessive loading, either separately or in combination, can cau ...

  • Ford AM/FM stereo - page 213

    INFORMATION CONTAINED ON THE TIRE SIDEWALL Federal law requires tire manufacturers to place standardized information on the sidewall of all tires. This information identifies and describes the fundamental characteristics of the tire and also provides a U.S. DOT T ire Identification Number for safety standard certification and in case of a recall. I ...

  • Ford AM/FM stereo - page 214

    7. H: Indicates the tire ’ s speed rating. The speed rating denotes the speed at which a tire is designed to be driven for extended periods of time under a standard condition of load and inflation pressure. The tires on your vehicle may operate at different conditions for load and inflation pressure. These speed ratings may need to be adjusted fo ...

  • Ford AM/FM stereo - page 215

    sidewall. T ire manufacturers also must indicate the ply materials in the tire and the sidewall, which include steel, nylon, polyester , and others. 11. Maximum Load: Indicates the maximum load in kilograms and pounds that can be carried by the tire. Refer to the tire label or the safety certification label, located on the B-Pillar or the driver ? ...

  • Ford AM/FM stereo - page 216

    Additional information contained on the tire sidewall for “ LT ” type tires “ LT ” type tires have some additional information than those of “ P ” type tires; these differences are described below: 1. LT: Indicates a tire, designated by the T ire and Rim Association (T&RA), that is intended for service on light trucks. 2. Load Range ...

  • Ford AM/FM stereo - page 217

    Information on “ T ” type tires T145/80D16 is an example of a tire size. Note: The temporary tire size for your vehicle may be different than this example. 1. T: Indicates a type of tire, designated by the T ire and Rim Association (T&RA), that is intended for temporary service on cars, SUVs, minivans and light trucks. 2. 145: Indicates the ...

  • Ford AM/FM stereo - page 218

    Use the recommended cold inflation pressure for optimum tire performance and wear . Under -inflation or over -inflation may cause uneven treadwear patterns. Under -inflation is the most common cause of tire failures and may result in severe tire cracking, tread separation or ⬙ blowout ⬙ , with unexpected loss of vehicle control and increased ri ...

  • Ford AM/FM stereo - page 219

    6. Visually inspect the tires to make sure there are no nails or other objects embedded that could poke a hole in the tire and cause an air leak. 7. Check the sidewalls to make sure there are no gouges, cuts, bulges or other irregularities. Tire inflation information All tires with Steel Carcass Plies (if equipped): This type of tire utilizes steel ...

  • Ford AM/FM stereo - page 220

    Tire and wheel alignment A bad jolt from hitting a curb or pothole can cause the front end of your vehicle to become misaligned or damage to your tires. If your vehicle seems to pull to one side when you ’ re driving, the wheels may be out of alignment. Have a qualified technician at a Ford or Lincoln/Mercury dealer check the wheel alignment peri ...

  • Ford AM/FM stereo - page 221

    • Front Wheel Drive (FWD) vehicles (front tires at top of diagram) • Rear Wheel Drive (RWD) vehicles/Four Wheel Drive (4WD) vehicles (front tires at top of diagram) 2004 Econoline (eco) Owners Guide (post-2002-fmt) USA English (fus) Maintenance and Specifications 221 ...

  • Ford AM/FM stereo - page 222

    Sometimes irregular tire wear can be corrected by rotating the tires. Note: If your tires show uneven wear ask a qualified technician at a Ford or Lincoln/Mercury dealership to check for and correct any wheel misalignment, tire imbalance or mechanical problem involved before tire rotation. Note: Y our vehicle may be equipped with a dissimilar spare ...

  • Ford AM/FM stereo - page 223

    • Severe abrasion on the sidewall If your vehicle has a leak in the exhaust system, a road tire or the spare tire may be exposed to hot exhaust temperatures requiring the tire to be replaced. Tire Replacement Requirements Y our vehicle is equipped with tires designed to provide safe ride and handling capability . Only use replacement tires and wh ...

  • Ford AM/FM stereo - page 224

    T ire explosions can cause death, personal injury or property damage. Do not allow anyone to stand near , directly ahead or behind the spinning tire. Never spin the tires in excess of the 55 km/h (35 mph) point indicated on the speedometer . Highway hazards No matter how carefully you drive there ’ s always the possibility that you may eventually ...

  • Ford AM/FM stereo - page 225

    • Remove the tire chains when they are no longer needed. Do not use tire chains on dry roads. • The suspension insulation and bumpers will help prevent vehicle damage. Do not remove these components from your vehicle when using snow tires and chains. MOTORCRAFT PART NUMBERS Component 1 4.6L V8 engine 5.4L V8 engine 6.8L V10 engine Air filter el ...

  • Ford AM/FM stereo - page 226

    Replace the spark plugs with ones that meet Ford material and design specifications for your vehicle, such as Motorcraft or equivalent replacement parts. The customer warranty may be void for any damage to the engine if such spark plugs are not used. Refer to V ehicle Emissions Control Information (VECI) decal for spark plug gap information. 4 Only ...

  • Ford AM/FM stereo - page 227

    Fluid Ford Part Name Application Capacity Engine coolant-gasoline engine 1 Motorcraft Premium Gold Engine Coolant (yellow-colored) 4.6L V8 engine 23.7L (25.0 quarts) 1 row – 22.6L (23.8 quarts) 8 4.6L V8 engine with aux rear heat 25.7L (27.2 quarts) 1 row – 24.6L (26.0 quarts) 8 5.4L V8 engine 27.4L (29.0 quarts) 1 row – 26.3L (27.8 quarts) 8 ...

  • Ford AM/FM stereo - page 228

    Fluid Ford Part Name Application Capacity Rear axle 4 Motorcraft SAE 75W -90 Fuel Efficient High Performance Synthetic rear axle lubricant 2 Visteon 8.8/9.75 inch conventional and T raction-Lok 2.6 (5.5 pints) 3 SAE 75W -140 Synthetic Rear Axle Lubricant 2 Dana M70HD (M273HD) E-350 DSO 3.5L (7.4 pints) 3 Dana M60 (M248) E-250/350 DSO limited slip 4 ...

  • Ford AM/FM stereo - page 229

    Fluid Ford Part Name Application Capacity Fuel tank N/A All regular and extended length vans and wagons 132.4L (35.0 gallons) 138 inch wheelbase (except E-Super Duty) 140.0L (37.0 gallons) 158 inch wheelbase (except E-Super Duty) 140.0L (37.0 gallons) 5 176 inch wheelbase (except E-Super Duty) 140.0L (37.0 gallons) 158 inch and 176 inch wheelbase ( ...

  • Ford AM/FM stereo - page 230

    1 Add the coolant type originally equipped in your vehicle. 2 If your vehicle ’ s rear axle is filled with a synthetic rear axle lubricant it is considered lubricated for life. These lubricants do not need to be checked or changed unless a leak is suspected, service is required or the axle assembly has been submerged in water . The axle lubricant ...

  • Ford AM/FM stereo - page 231

    8 If your vehicle is equipped with a single row radiator , there will be a label on the top side of the radiator indicating “ 1 Row Radiator ” . 9 Use of synthetic or synthetic blend motor oil is not mandatory . Engine oil need only meet the requirements of Ford specification WSS-M2C153 – H and the API Certification mark. LUBRICANT SPECIFICAT ...

  • Ford AM/FM stereo - page 232

    Item Ford part name Ford part number Ford specification Lock cylinders Motorcraft Penetrating and Lock Lubricant Motorcraft XL-1 none Power steering fluid Motorcraft MERCON 威 AT F XT -2-QDX MERCON 威 Automatic transmission (4R100) 1 Motorcraft MERCON 威 AT F XT -2-QDX MERCON 威 Automatic transmission (4R70/75 E-W) 1 Motorcraft MERCON 威 V AT ...

  • Ford AM/FM stereo - page 233

    Item Ford part name Ford part number Ford specification Dana M70HD (M273HD) E-350 DSO Dana M60 (M248) E-250/350 DSO limited slip 3 SAE 75W -140 Synthetic Rear Axle Lubricant XY -75W140 – QL WSL-M2C192 – A Dana Limited Slip Axles 3 M60 (M248) E-250/350 M70FF (M267FF) E-350 M70HD (M273HD) E-450 SAE 90 Hypoid Gear Oil C6AZ-19580 – E ESW -M2C105 ...

  • Ford AM/FM stereo - page 234

    1 Ensure the correct automatic transmission fluid is used. T ransmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being added is of the correct type. Refer to your Scheduled Maintenance Guide to determine the correct service interval. Some transmission fluids may be labeled ...

  • Ford AM/FM stereo - page 235

    V EHICLE DIMENSIONS V an/wagon models E-150 E-250 E-350 (1) Overall height 2050 mm (80.7 in) 2118 mm (83.4 in) 2136 mm (84.1 in) (2) T rack front/rear 1763 (69.4)/1707 mm (67.2 in) 1763 (69.4)/1692 mm (66.6 in) 1763 (69.4)/1687 mm (66.4 in) (3) Overall width (excluding mirrors) 2014 mm (79.3 in) (4) Wheelbase 3505 mm (138 in) (5) Overall length Reg ...

  • Ford AM/FM stereo - page 236

    Cutaway/commercial stripped chassis models Body style Dimension E-250 E-350 E-450 Super Duty (1) Overall height Refer to Body Builder for specifications. (2) T rack (Front / Rear) 1763 mm (69.4 in)/ 1 692 mm (66.6 in) Cutaway 1763 mm (69.4 in)/SRW 1831 mm (72.1 in) — DRW 1859 mm (73.2 in) Stripped Chassis 1763 mm (69.4 in)/SRW 1687 mm (66.4 in) ? ...

  • Ford AM/FM stereo - page 237

    Body style (3) Overall width Refer to Body Builder for specifications. (4) Wheelbase 3150 mm (124 in) 3505 mm (138 in) 4013 mm (158 in) 4470 mm (176 in) 4013 mm (158 in) 4470 mm (176 in) (5) Overall length Refer to Body Builder for specifications. V EHICLE IDENTIFICATION NUMBER Complete Ford built vehicles The vehicle identification number is attac ...

  • Ford AM/FM stereo - page 238

    Certification label for incomplete vehicles On completed derivations of incomplete vehicles, the certification label is affixed at a location determined by a subsequent stage manufacturer of the completed vehicle. In these cases the completed vehicle is manufactured in two or more stages by two or more separate manufacturers. T RANSMISSION/T RANSAX ...

  • Ford AM/FM stereo - page 239

    Code T ransmission Description U Automatic 4 – speed overdrive (4R70W) T Automatic 4 – speed overdrive (4R44E) E Automatic 4 – speed overdrive (4R100) J Automatic 5 – speed overdrive (5R55E) Electric H One speed electric D Automatic 5 – speed overdrive (5R44E) R Automatic 5 – speed overdrive (5R55S) PASSENGER CAR APPLICATION: Code T ran ...

  • Ford AM/FM stereo - page 240

    GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local authorized Ford or Ford of Canada dealer . These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance ...

  • Ford AM/FM stereo - page 241

    Splash guards Step bars T onneau covers T ruck caps Wheels Interior style Cell phone holders Consoles Electrochromatic compass/temperature interior mirrors Floor mats Interior trim kits Leather wrapped steering wheels Scuff plates Speed control Lifestyle Bedliners and bedmats Bed tents Bike racks Cargo organization and management Diamond plate acce ...

  • Ford AM/FM stereo - page 242

    Peace of mind Airbag anti-theft locks First aid and safety kits Full vehicle covers Locking gas cap Navigation systems Remote start V ehicle security systems For maximum vehicle performance, keep the following information in mind when adding accessories or equipment to your vehicle: • When adding accessories, equipment, passengers and luggage to ...

  • Ford AM/FM stereo - page 243

    A Accessory delay ..........................65 Air bag supplemental restraint system ....................................91, 96 and child safety seats .............. 93 description .......................... 91, 96 disposal ...................................... 95 driver air bag ............................ 93 indicator light ..................... ...

  • Ford AM/FM stereo - page 244

    wheels ...................................... 176 wiper blades ............................ 177 Climate control (see Air conditioning or Heating) ......49, 51 Clock adjust 6-CD in dash .............................25 AM/FM ....................................... 18 AM/FM/CD ................................. 22 AM/FM/T ape .......................... ...

  • Ford AM/FM stereo - page 245

    specifications .................. 231, 234 Exhaust fumes .......................... 114 F Fail safe cooling ........................ 194 Fluid capacities .........................226 Four -Wheel Drive vehicles preparing to drive your vehicle ..................................... 116 Fuel ............................................ 195 calculating ...

  • Ford AM/FM stereo - page 246

    J Jump-starting your vehicle ......159 K Keys positions of the ignition ......... 111 L Lamps bulb replacement specifications chart .................. 55 daytime running light ...............52 headlamps ................................. 52 headlamps, flash to pass .......... 53 instrument panel, dimming ..... 53 interior lamps .................... ...

  • Ford AM/FM stereo - page 247

    for adults ............................. 82 – 83 for children .........................95, 97 lap belt ...................................... 85 safety belt maintenance ........... 90 warning light and chime .......... 86 Safety seats for children ............ 99 Seat belts (see Safety restraints) .................................... 81 Seats ... ...

  • Ford AM/FM stereo - page 248

    W ater , Driving through ............. 124 W indows power ......................................... 65 W indshield washer fluid and wipers .......................................... 60 checking and adding fluid ..... 183 replacing wiper blades .............60 W recker towing ......................... 165 2004 Econoline (eco) Owners Guide (post-2002 ...

Manufacturer Ford Category Stereo System

Documents that we receive from a manufacturer of a Ford AM/FM stereo can be divided into several groups. They are, among others:
- Ford technical drawings
- AM/FM stereo manuals
- Ford product data sheets
- information booklets
- or energy labels Ford AM/FM stereo
All of them are important, but the most important information from the point of view of use of the device are in the user manual Ford AM/FM stereo.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Ford AM/FM stereo, service manual, brief instructions and user manuals Ford AM/FM stereo. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Ford AM/FM stereo.

Similar manuals

A complete manual for the device Ford AM/FM stereo, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Ford AM/FM stereo by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Ford AM/FM stereo.

A complete Ford manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Ford AM/FM stereo - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Ford AM/FM stereo, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Ford AM/FM stereo, that we can find in the current document
3. Tips how to use the basic functions of the device Ford AM/FM stereo - which should help us in our first steps of using Ford AM/FM stereo
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Ford AM/FM stereo
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Ford AM/FM stereo in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Ford AM/FM stereo?

Use the form below

If you did not solve your problem by using a manual Ford AM/FM stereo, ask a question using the form below. If a user had a similar problem with Ford AM/FM stereo it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)