Manual Sears 580.75151

28 pages 2.72 mb
Download

Go to site of 28

Summary
  • Sears 580.75151 - page 1

    OWNER'S MANUAL MODEL NO. 580.751510 HOURS: Mort. - Fri. 8 a.m. to 5 p.m (CST) CAUTION: Read and Follow all Safety Rules and Instructions Before Operating This Equipment 5 HORSEPOWER 1800 PSi 2.5 GPM HiGH PRESSURE WASHER o Assembly o Operation ° Customer Responsibilities o Service and Adjustment ° Repair Parts ® SEARS, ROEBUCK and CO., Hoffm ...

  • Sears 580.75151 - page 2

    SAFETY RULES _ AUTION: ALWAYS DISCONNECT SPARK PLUG WIRE AND PLACE WIRE WHERE IT CANNOT CON_ _, TACT SPARK PLUG, TO PREVENT ACCIDENTAL STARTING WHEN SETTING UP, TRANSPORTING, ADJUSTING OR MAKING REPAIRS TO YOUR HIGH PRESSURE WASHER. TRAINING: e Engine exhaust gases contain DEADLY carbon monox- Ide gas_ This dangerous gas, if breathed in sufficient ...

  • Sears 580.75151 - page 3

    CONGRATULATIONS on your purchase of a Sears Crafts- man high pressure washer, it has been designed, engi- neered and manufactured to give you the best possible dependability and performance. Should you experience any problem you cannot easily remedy, please contact your nearest Sears Service Cen- ter/Department or call the 1-800 number listed on th ...

  • Sears 580.75151 - page 4

    TABLE OF CONTENTS SAFETY RULES ............................................................. 2 PRODUCT SPECIFICATIONS ....................................... 3 ACCESSORIES AND ATTACHMENTS ......................... 5 CONTENTS OF HARDWARE PACK ............................. 6 ASSEMBLY .................................................................. ...

  • Sears 580.75151 - page 5

    ACCESSORIES AND ATTACHMENTS These accessories and attachments were available when the high pressure washer was purchased. They are also available at most Sears retail outlets and service centers, Most Sears stores can order these items for you when you provide the model number of your high pressure washer, Some of these accessories may not apply to ...

  • Sears 580.75151 - page 6

    CONTENTS OF HARDWARE PACK Parts packed separately in carton Parts Carton l Owners Manual Main Unit ,_r.__f Gun and Wand Assembly (packed in flat carton) Guide Handle Assembly (packed in flat carton High Pressure Hose Parts packed in Parts Carton (2) Wheels Motor Oil (3)Parts Bags Parts Bag contents shown full size (fasteners) (2) Axle Pins (2) Hex ...

  • Sears 580.75151 - page 7

    ASSEMBLY Read these instructions and Operator's Manual in its en- tirety before you attempt to assemble or operate your new high pressure washer. Your high pressure washer has, for the most part, been assembled at the factory, except those parts left unassembled. Before you can operate your new high pressure washer, you must assemble the wheel ...

  • Sears 580.75151 - page 8

    ASSEMBLY = Using a 5/16" (8mm) wrench, attach wire support to top two holes of guide handle with #10 self-drilling screws and #10 flat washers (Fig. 3), The hose minder should Q be to the left and _unholder to the right° Be sure loop of support is pointing upward. Place vinyl cap onto gun holder. VINYL CAP WIRE SUPPORT J FIG. 3 FASTENERS TO A ...

  • Sears 580.75151 - page 9

    OPERATION KNOW YOLIR HIGH PRESSURE WASHER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR HIGH PRESSURE WASHER. Compare the illustrations with your high pressure washer to familiarize yourself with the locations of various controls and adjustment& Save this manual for future reference. GUIDE HANDLE SPARK PLUG PRESSURE REGUL ...

  • Sears 580.75151 - page 10

    OPERATION HOW TO USE YOUR WASHER IF YOU HAVE ANY PROBLEMS OPERATING YOUR PRESSURE WASHER. PLEASE CALL THE PRESSURE WASHER HELPLINE AT 1-800-222-3136. STOPPING YOUR PRESSURE WASHER o First, move engine throttle lever to"OFF" position (Fig. 9). I OFF, IDLE FAST l FIG. 9 o Simply shutting OFF engine will not release pres- sure In the system. ...

  • Sears 580.75151 - page 11

    OPERATION DETERGENT APPUCATION WITH ADJUSTABLE NOZZLE IMPORTANT: USE SOAPS DESIGNED SPECIFICALLY FOR PRESSURE WASHERS. HOUSEHOLD DETER- GENTS COULD DAMAGE THE PUMP. IMPORTANT: YOU MUST ATTACH ALL HOSES BE- FORE YOU START THE ENGINE. STARTING THE EN_ GINE WITHOUT ALL THE HOSES CONNECTED WILL DAMAGE THE PUMP_ Pressure washers are useful cleaning tool ...

  • Sears 580.75151 - page 12

    OPERATION NOTE: When adding oil to the engine crankcase in the future, use only high quality detergent oil rated with API service classification SF, SG or SH rated SAE 30 weight° Use no special additives. Select the oil's viscosity grade according to your expected operating temperature. f colder 32°F warmer 5W30 _ SAE30 Although multi-viscos ...

  • Sears 580.75151 - page 13

    OPERATION TO START ENGINE iMPORTANT: DO NOT RUN PUMP WITHOUT THE WATER SUPPLY CONNECTED AND TURNED ON, YOU MUST FOLLOW THIS CAUTION OR THE PUMP WILL BE DAMAGED. = Press trigger on pressure washer wand to relieve high pressure and/or purge the inlet hose of air. • Move throttle control to FAST position (Fig. 19). FIG. 19 o For a cold engine, move ...

  • Sears 580.75151 - page 14

    CUSTOMER RESPONSIBJLITIIES iii MAINTENANCE SCHEDULE FiLL IN DATES AS YOU COMPLETE REGULAR SERVICE MAINTENANCE TASK PRESSURE WASHER Chock/clean inlet filter and screen Chock high pressure hose. Check detergent hose. Check gun and wand for leaks. Chock pump oil. ENGINE Chock oil level. Change engine oil. _, Service air' cleaner. Replace/clean sp ...

  • Sears 580.75151 - page 15

    CUSTOMER RESPONSIBILITY PUMP MAINTENANCE Pump OI1: Change pump oil after first 50 hours of opera- tion, then every 500 hours thereafter° To change pump oil, follows these steps: = Place a proper container beneath the pump. You will only need a small one because capacity is only 5 ounces, = Remove the Oil Drain Plug on bottom of pump and drain oil ...

  • Sears 580.75151 - page 16

    CUSTOMER RESPONSiBILITiES CLEAN COOUNG SYSTEM • Clean dirt or chaff from finger 0uard or rotating screen even] 8 hours to prevent engine damage caused by ovedleating (Fig. 25), = Keep dirt and combustible debris off of muffler area. REPLACE SPARK PLUG Change the spark plug every 100 hou rs of operation or' once each year, whichever comes fir ...

  • Sears 580.75151 - page 17

    STORAGE AFTER EACH USE Water should not remain in the unit for long periods of time. Sediments of minerals can deposit on pump parts and "freeze" pump action. Follow these procedures after every use: Flush detergent hose by placing the injector filter into a pail of clear water while running Pressure Washer with no771e in low pressure mod ...

  • Sears 580.75151 - page 18

    TROUBLESHOOTING CAUSE Nozzle in low pressure mode. PROBLEM Pump has following problems: t. failure to produce pressure, erratic pressure, chattering, loss of pressure, 2. low water volume. 3 4o 5. 6. 7o 8. 9. 10. 11. 12, Detergent fails to mix with spray_ 1_ 2 3o Engine runs good at no-load but "bogs Enginewill not start; or starts and runs ro ...

  • Sears 580.75151 - page 19

    CRAFTSMAN 1800 PSI HIGH PRESSURE WASHER 580.751510 REPAIR PARTS 40 °G" 6 3F z j Gu, BARREL I I° i, 34 ITEM 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 PART NO. 95998 87628 89647 96016 95456 92479 22336 95567 92661 65852 22471 91842A 23365 88977 91841 32713 89314 39414 95902 75402 91094 DESCRIPTION ITEM PART NO, 5 hp Briggs & St ...

  • Sears 580.75151 - page 20

    CRAFTSMAN 1800 PSi HIGH PRESSURE WASHER 580.751510 BRIGGS & STRATTON 4-CYCLE ENGINE 133212-0159-01 REPAIR PARTS 346 357 17 22 36 35 40 41 9 220 8 10 ! 615 616 33 7 34 26 27 45 592 ,f' 0 X_ _"( _ _ J'-&_ 1_o_9 LABEL K_TI %. __, wu _ REQUIRES SPECIAL TOOLS -- TO INSTALL. SEE REPAIR 219 INSTRUCTION MANUAL° 20 ...

  • Sears 580.75151 - page 21

    CRAFTSMAN 1800 PSI HIGH PRESSURE WASHER 580.751510 BRIGGS & STRATTON 4-CYCLE ENGINE 133212-0159-01 REPAIR PARTS 634 97 202 987 _' 152 154 L90 ' 394 ,4 127 / 127A 149 / 257 217 118 203 205 256 124 153 II_°/F/_ 1012 _ "__ 542 779 414 153 _ _)3 _78 163 524 7 191 392 187 432 611 ! 435 433 9 358 GASKET SET _ 414A 206A 201 232 ! 2] 12 ...

  • Sears 580.75151 - page 22

    CRAFTSMAN 1800 PSi HIGH PRESSURE WASHER 580.751510 REPAIR PARTS BRIGGS & STRATTON 4-CYCLE ENGINE 133212-0159-01 209 267 526 265 190 190A 208 280 181 _ 224 204 223 916_ _;_62! 269 969 971 535 l 271 268 270 985 353 _ 520 (_ 354 967 966 22 ...

  • Sears 580.75151 - page 23

    CRAFTSMAN 1800 PSI HIGH PRESSURE WASHER 580.751510 BRIGGS & STRATTON 4-CYCLE ENGINE 133212-0159-01 REPAIR PARTS 55 373 85 ® ® 1016 57 461 69A 515 58 59 69 456 w %o_=o, 613A _81 346A i i 3_ 304 346 455 305 23 73 _305 335 23 670 O 334 356 ...

  • Sears 580.75151 - page 24

    CRAFTSMAN 1800 PSi HIGH PRESSURE WASHER 580.751510 BRIGGS & STRATTON 4-CYCLE ENGINE 133212-0159-01 REPAIR PARTS Ref. NO. 1 3 5 7 8 9 10 11 12 13 13A 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 32 33 34 35 36 37 40 41 45 45 52 55 56 57 56 59 60 65 69 69A 73 75 8I 9O 95 95 97 106 116 121 124 127 127A 149 152 153 154 Part No. Part Name 4951 ...

  • Sears 580.75151 - page 25

    CRAFTSMAN 1800 PSI HIGH PRESSURE WASHER 580.751510 BRIGGS & STRATTON 4-CYCLE ENGINE 133212-0159-01 REPAIR PARTS Ref, NO. 432 433 434 435 455 456 459 461 467 515 520 626 527 528 529 535 535 542 552 562 592 608 613A 614 615 Part NO. 220082 221198 221377 93265 214021 93141 494770 224321 492883 262626 280715 262625 93722 94659 223786 231550 67838 4 ...

  • Sears 580.75151 - page 26

    CRAFTSMAN 1800 PSI HIGH PRESSURE WASHER 580.751510 REPAIR PARTS 3_ 4_ 5-- 7_ 8_ 5_ 9_ 11-- 12-- 18-- i 25 23 24 57 22 t,. "l,:'j 2_ 64 63 54 55 ITEM KIT PART NO. DESCRIPTION ITEM KIT PART NO. DESCRIPTION 1 96737 Pressure Reglulator Knob 29 89361 3/8" Fitting 2 96738 Ring Nut 32 89361 O-ring 3 96739 Spring Guide 33 Washer 4 Spring 34 ...

  • Sears 580.75151 - page 27

    CRAFTSM AN 1800 PSI HIGH PRESS U R E WASHER 580.751510 REPAIR PARTS , KIT 89360 KIT 89358 I -_'-"'_ IL('ll! .:ll //f P'_ _3 22 23 24 P5 26 27 28 29 30 _ 62 _- , ............... - ITEM 1 2 7 8 9 10 ll 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 KIT PART NO. 96742 89360 89360 89360 89360 89360 89358 B935B 96743 945O ...

  • Sears 580.75151 - page 28

    OWNER'S MANUAL MODEL NO. 580.751510 IF YOU NEED REPAIR SERVICE OR PARTS FOR REPAIR SERVICE CALL THIS TOLL FREE NUMBER 1-800-4,4:IEPAIR (1-800-473-7247) FOR REPLACEMENT PARTS INFORMATION AND ORDERING, CALL THIS TOLL FREE NUMBER: 1-800-FON-PART (1-8O0-366-7278) CRRFTSMRN ° 5 HORSEPOWER 1800 PSI 2,5 GPM HIGH PRESSURE WASHER Each High Pressure Wa ...

Manufacturer Sears Category Pressure Washer

Documents that we receive from a manufacturer of a Sears 580.75151 can be divided into several groups. They are, among others:
- Sears technical drawings
- 580.75151 manuals
- Sears product data sheets
- information booklets
- or energy labels Sears 580.75151
All of them are important, but the most important information from the point of view of use of the device are in the user manual Sears 580.75151.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Sears 580.75151, service manual, brief instructions and user manuals Sears 580.75151. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Sears 580.75151.

Similar manuals

A complete manual for the device Sears 580.75151, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Sears 580.75151 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Sears 580.75151.

A complete Sears manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Sears 580.75151 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Sears 580.75151, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Sears 580.75151, that we can find in the current document
3. Tips how to use the basic functions of the device Sears 580.75151 - which should help us in our first steps of using Sears 580.75151
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Sears 580.75151
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Sears 580.75151 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Sears 580.75151?

Use the form below

If you did not solve your problem by using a manual Sears 580.75151, ask a question using the form below. If a user had a similar problem with Sears 580.75151 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)