Manual Lennox Hearth SHGL-18MP-R

20 pages 0.82 mb
Download

Go to site of 20

Summary
  • Lennox Hearth SHGL-18MP-R - page 1

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 1 FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance. FOR YOUR SAFETY: What to do if you smell gas: • DO NOT light any appliance. • DO NOT touch any electrical switches. • DO NOT use any phone in your building. • Im ...

  • Lennox Hearth SHGL-18MP-R - page 2

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 2 GENERAL INFORMATION These Dual-Listed Gas Log Appliances incor- porate unitized ceramic fiber logs which glow realistically when the appliance is operating. The gas log sets covered in this document are heater rated units. These units are equipped with either a standard manual gas valve or a millivo ...

  • Lennox Hearth SHGL-18MP-R - page 3

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 3 • Do not install the appliance in a bedroom or bathroom. • The installation must conform with local codes or, in the absence of local codes with the National Fuel Gas Code, ANSI Z223.1. • The appliance and its individual shut-off valve must be disconnected from the gas supply piping system whi ...

  • Lennox Hearth SHGL-18MP-R - page 4

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 4 Figure 2 Figure 1 Step 2. Ceiling Clearance: The ceiling must be at least 42" from the top of the appliance open- ing ( Figure 1 ). Step 3. Noncombustible materials (minimum requirements): To install the appliance with- out wood mantels, shelves or other combus- tible projections directly above ...

  • Lennox Hearth SHGL-18MP-R - page 5

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 5 Example: The bottom of the mantel may project from the wall a maximum of 2 ¹₂ " at a minimum of 8" above the opening. The top shelf of the mantel may project a maximum of 6" at a minimum of 14 ¹₂ " above the opening. Noncombustible Material Requirements with No Mantel ...

  • Lennox Hearth SHGL-18MP-R - page 6

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 6 Gas Pressure Check The appliance regulator controls the burner pressure which should be checked at the pres- sure test point ( ¹⁄₈ " NPT plugged tap) located on the manual control valve body (on Manual models) or on the control valve itself (on Milli- volt models), identified OUT for the m ...

  • Lennox Hearth SHGL-18MP-R - page 7

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 7 Figure 10 WARNING: FAILURE TO POSITION THE PARTS IN ACCORDANCE WITH FIGURE 10 OR FAILURE TO USE ONLY PARTS SPECIFICALLY APPROVED WITH THIS AP- PLIANCE MAY RESULT IN PROPERTY DAMAGE OR PERSONAL INJURY. WARNING: DO NOT PLACE ANY LAVA ROCK ON LOGS OR BURNERS. THIS MAY CAUSE SOOTING. ONLY PLACE LAVA ROC ...

  • Lennox Hearth SHGL-18MP-R - page 8

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 8 Remove the log set, gently handling at each end. Use a vacuum cleaner to remove loose particles from the base and from around the burners. Gloves are recommended to prevent the fibers from pricking your skin. If the skin is pricked, wash gently with soap and water. Replace the log set. If, after a p ...

  • Lennox Hearth SHGL-18MP-R - page 9

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 9 If you encounter any problems or have any questions concerning the installation of this dual-listed gas appliance, please contact your distributor. For the name of your nearest distributor contact: LENNOX HEARTH PRODUCTS 1110 West Taft Avenue Orange, CA 92865 ACCESSORY COMPONENTS (Millivolt Models O ...

  • Lennox Hearth SHGL-18MP-R - page 10

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 10 MILLIVOLT WIRING DIAGRAM VENTED/UNVENTED GAS LOG APPLIANCE TECHNICAL CHART FOR MILLIVOLT LOG SET BTU/HR Regulator Gas Inlet Valve Model No. Input Gas Type Ignition Pres. Setting Pressure* Operation Orifice Size * For the purpose of input adjustment. SHGL - 18VN-R 36,000 Natural Piezo 1.6 – 3.5&qu ...

  • Lennox Hearth SHGL-18MP-R - page 11

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 11 VENTED/UNVENTED GAS LOG APPLIANCE TECHNICAL CHART FOR MANUAL LOG SET BTU/HR Regulator Gas Inlet Valve Model No. Input Gas Type Ignition Pres. Setting Pressure* Operation Orifice Size * For the purpose of input adjustment. SHGL - 18MN-R 36,000 Natural Piezo 3.5" w.c. Max. 10.5" w.c. Manual ...

  • Lennox Hearth SHGL-18MP-R - page 12

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 12 OPERATING INSTRUCTIONS — MANUAL CONTROL MODELS FOR YOUR SAFETY READ BEFORE LIGHTING LIGHTING INSTRUCTIONS 1. Stop! Read the safety information above. 2. Make sure manual shut-off valve is fully open. 3. Refer to Figure 14 to locate gas control knob and piezo. 4. Depress control knob in and turn c ...

  • Lennox Hearth SHGL-18MP-R - page 13

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 13 Figure 15 Figure 14 Gas Control Knob Location Pilot Location Turn Control Knob to “ OFF ” Position (Manual) Turn Control Knob to “ IGN ” Position (Manual) Figure 17 Figure 16 Pilot O F F I G N L O W H I O F F I G N L O W H I ...

  • Lennox Hearth SHGL-18MP-R - page 14

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 14 LIGHTING INSTRUCTIONS – MILLIVOLT WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. FOR YOUR SAFETY READ BEFORE LIGHTING • Do not use any phone in your building. • Immediately call your gas suppli ...

  • Lennox Hearth SHGL-18MP-R - page 15

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 15 1. When igniter button is pressed, there is no spark at ODS/pilot. 2. Heater produces unwanted odors. 3. Heater shuts off in use (ODS operates). 4. Gas odor even when control knob is in “OFF” position. 5. When igniter button is pressed, there is spark at ODS/pilot, but no ignition. 6. ODS/pilot ...

  • Lennox Hearth SHGL-18MP-R - page 16

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 16 REPLACEMENT PARTS LIST (MILLIVOLT) 18N/18P 24N/24P No. Description Part No. Part No. 1. Valve, Millivolt (Natural) H1203 H1203 Valve, Millivolt (Propane, L.P.G.) 901917 901917 2. Base Log Assembly H1679 H1682 3. Front Log (Separate) H1680 H1683 4. Twig H1681 H1684 5. Burner H1196 H1196 6. Piezo Ign ...

  • Lennox Hearth SHGL-18MP-R - page 17

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 17 REPLACEMENT PARTS (MILLIVOLT) 7 1 13 8 5 2 10 6 11 12 3 9 4 (Propane Pilot Shown) ...

  • Lennox Hearth SHGL-18MP-R - page 18

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 18 REPLACEMENT PARTS LIST (MANUAL) 18N/18P 24N/24P No. Description Part No. Part No. 1. Valve, Manual (Natural) H1214 H1214 Valve, Manual (Propane, L.P.G.) H1319 H1319 2. Base Log Assembly H1679 H1682 3. Front Log (Separate) H1680 H1683 4. Twig H1681 H1684 5. Burner H1196 H1196 6. Piezo Ignitor 10K86 ...

  • Lennox Hearth SHGL-18MP-R - page 19

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 19 REPLACEMENT PARTS (MANUAL) 7 2 5 1 9 8 12 11 6 10 3 4 (Propane Pilot Shown) ...

  • Lennox Hearth SHGL-18MP-R - page 20

    NOTE: DIAGRAMS & ILLUSTRATION NOT TO SCALE. 20 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.S.A. © 2004 by Lennox Hearth Products ...

Manufacturer Lennox Hearth Category Electric Heater

Documents that we receive from a manufacturer of a Lennox Hearth SHGL-18MP-R can be divided into several groups. They are, among others:
- Lennox Hearth technical drawings
- SHGL-18MP-R manuals
- Lennox Hearth product data sheets
- information booklets
- or energy labels Lennox Hearth SHGL-18MP-R
All of them are important, but the most important information from the point of view of use of the device are in the user manual Lennox Hearth SHGL-18MP-R.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Lennox Hearth SHGL-18MP-R, service manual, brief instructions and user manuals Lennox Hearth SHGL-18MP-R. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Lennox Hearth SHGL-18MP-R.

A complete manual for the device Lennox Hearth SHGL-18MP-R, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Lennox Hearth SHGL-18MP-R by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Lennox Hearth SHGL-18MP-R.

A complete Lennox Hearth manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Lennox Hearth SHGL-18MP-R - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Lennox Hearth SHGL-18MP-R, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Lennox Hearth SHGL-18MP-R, that we can find in the current document
3. Tips how to use the basic functions of the device Lennox Hearth SHGL-18MP-R - which should help us in our first steps of using Lennox Hearth SHGL-18MP-R
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Lennox Hearth SHGL-18MP-R
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Lennox Hearth SHGL-18MP-R in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Lennox Hearth SHGL-18MP-R?

Use the form below

If you did not solve your problem by using a manual Lennox Hearth SHGL-18MP-R, ask a question using the form below. If a user had a similar problem with Lennox Hearth SHGL-18MP-R it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)