Manual Alto-Shaam 1010

41 pages 3.2 mb
Download

Go to site of 41

Summary
  • Alto-Shaam 1010 - page 1

    MN-29245 • 05/12 printed i n u . s . a . Combitherm ® Combination Oven / Steamer ES ELECTRIC COMBITOUCH® SERIES 6•10 10•10 7•14 10•18 12•20 20•20 VHes-5 VHes -10   • InstallatIon W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 u s a / c a N a d a ...

  • Alto-Shaam 1010 - page 2

    i Delivery .................................. 1 Unpacking ................................ 1 Safety Procedures and Precautions ............. 2 Installation Site Requirements ........................ 3 Ventilation Requirements ................... 3 Positioning on Site ........................ 4 Lifting Instructions ........................ 5 Levelin ...

  • Alto-Shaam 1010 - page 3

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 1. DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims section located in ...

  • Alto-Shaam 1010 - page 4

    CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard that can or will cause minor or moderate personal injury or property damage if the warning included wit ...

  • Alto-Shaam 1010 - page 5

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 3. SITE INSTALLATION INSTALLATION DANGER IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIP ...

  • Alto-Shaam 1010 - page 6

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 4. NOTE: Note dimensions required for doorways and aisles for access of the oven and pallet to the installation site. Transport the oven in an upright and level position only. Do not tilt the oven. ® SITE INSTALLATION INSTALLATION POSITIONING ON SITE Stand the oven in a level position. Us ...

  • Alto-Shaam 1010 - page 7

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 5. SITE INSTALLATION INSTALLATION Lifting Ins tructions Do not lift in this area! Damage t o the components will r esult. Cent er of Gra vity Front View T op View (Fron t) Leg 24” Spacer Board Remov e banding befor e lifting. Place a spacer board(s ) 24” in length, with a minimum h eig ...

  • Alto-Shaam 1010 - page 8

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 6. SITE INSTALLATION INSTALLATION POSITIONING REQUIREMENTS q In order to ensure proper ventilation, a minimum distance of at least 6-inches (152mm) must be kept from the control panels side (left) of the oven and any adjoining surfaces. NOTE: Additional clearance is needed for service acce ...

  • Alto-Shaam 1010 - page 9

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 7. COMMON SPECIFICATIONS CombiGuard™ BWS Blended Water System ( iNcludEs 50 gallON taNk , 1 MEMbraNE & 3 FiltErs ) FI-28727 CombiGuard™ BWS Replacement Filter Cartridge AMS-QT FI-29316 CombiGuard™ BWS Replacement Filter Cartridge SCLX2-Q FI-29317 CombiGuard™ BWS Replacement Pre ...

  • Alto-Shaam 1010 - page 10

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 8. 6•10 es 31-3/8" (796mm) 34-1/16" (864mm) 17-15/16" (456mm) 7-9/16" (191mm) WA TER DRAIN 33-1/8" (840mm) 4-15/16" (125mm) Steam Ve nt (Top) 60-9/16" (1538mm) Water Drain (Back) Tr eated Wa ter Intake (Bottom) Untreated Water Intake (Bottom) Electrical ...

  • Alto-Shaam 1010 - page 11

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 9. 6•10 es i 31-3/8" (796mm) 34-1/16" (864mm) 17-15/16" (456mm) 7-9/16" (191mm) WA TER DRAIN 33-1/8" (840mm) 4-15/16" (125mm) Steam Ve nt (Top) 60-9/16" (1538mm) Water Drain (Back) Tr eated Wa ter Intake (Bottom) Untreated Water Intake (Bottom) Electric ...

  • Alto-Shaam 1010 - page 12

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 10. 6•10 es iN 32-15/16" (835mm) 35-9/16" (903mm) 21-11/16" (550mm) 5-3/8" (137mm) 6-3/8" (161mm) WA TER DRAIN 33-7/8" (859mm) 35-13/16" (909mm) 2" (50mm) 41-1/16" (1042mm) Water Drain (Side Back) Steam Vent (T op) Electrical Connection (Botto ...

  • Alto-Shaam 1010 - page 13

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 11. 10•10 es 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31-3/8" (796mm) 34-1/16" (865mm) 17-1 ...

  • Alto-Shaam 1010 - page 14

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 12. 10•10 es i 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31-3/8" (796mm) 34-1/16" (865mm) 17 ...

  • Alto-Shaam 1010 - page 15

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 13. 19-1/2" (495mm) 12-5/16" (312mm) 9-9/16" ( 242m m) 35-7/8" (910mm) 33-7/8" (860mm) 33" (837mm) 2" (50mm) 35-11/16" (905mm) 25" (635mm) 7-9/16" (191mm) 5" (126mm) Water Drain (Rear) Steam Vent (T op) 21-15/16" (557mm) 41-1/16&q ...

  • Alto-Shaam 1010 - page 16

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 14. 7•14 es TO P VIEW FRONT VIEW SIDE VIEW A rial MT Condensed Light 8 pt 43-3/4" (1111mm) 8-1/2" (216mm) 26-1/2" (672mm) 6-1/4" (159mm) 35-7/16" (899mm) Grease Collection Pump (option) Grease Collection Pump (option) Wa ter Drain 44-7/16 " (1128mm) 70-15/16 ...

  • Alto-Shaam 1010 - page 17

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 15. 7•14 es i TO P VIEW FRONT VIEW SIDE VIEW A rial MT Condensed Light 8 pt 43-3/4" (1111mm) 8-1/2" (216mm) 26-1/2" (672mm) 6-1/4" (159mm) 35-7/16" (899mm) Grease Collection Pump (option) Grease Collection Pump (option) Wa ter Drain 44-7/16 " (1128mm) 70-15/ ...

  • Alto-Shaam 1010 - page 18

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 16. 30" (760mm) 22-3/8" (568mm) 15-1/2" (393mm) 12-3/4" (323mm) Electrical Connection (Bottom) 2" (50mm) 46-7/8" (1190mm) 43-7/8" (1114mm) 41-15/16" (1064mm) 40-1/8" (1019mm) 25-5/8" (650mm) 8-11/16" (219mm) 6-1/4" (158mm) Water D ...

  • Alto-Shaam 1010 - page 19

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 17. 10•18 es i WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS TWO (2) COLD W A TER INLETS - DRINKING QUALITY ONE (1) TREA TED W A TER INLET : 3/4" NPT* ONE (1) UNTREA TED W A TER INLET : 3/4" NPT* LI NE PR ES SU RE : 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" CO ...

  • Alto-Shaam 1010 - page 20

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 18. 46-3/4" (1186mm) 44-3/4" (1136mm) 40-15/16" (1039mm) 1-13/16" (46mm) 48" (1218mm) 45-5/16" (1151mm) 33-1/2" (851mm) 2-1/16" (52mm) Water Drain (Bottom) 51-15/16" (1319mm) 2" (50mm) 76-15/16" (1954mm) 8-15/16" (226mm) 7-11/16&q ...

  • Alto-Shaam 1010 - page 21

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 19. 12•20 es i WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS TWO (2) COLD W A TER INLETS - DRINKING QUALITY ONE (1) TREA TED W A TER INLET : 3/4" NPT* ONE (1) UNTREA TED W A TER INLET : 3/4" NPT* LI NE PR ES SU RE : 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" CO ...

  • Alto-Shaam 1010 - page 22

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 20. 40-15/16" (1039mm) 1-13/16" (46mm) 46-3/4" (1186mm) 44-3/4" (1136mm) 4-3/4" (120mm) 2" (50mm) 51-15/16" (1319mm) Water Drain (Back) Steam Vents (T op) 76-15/16" (1954mm) 8-15/16" (226mm) 67-3/8" (1710mm) 76-1/4" (1936mm) 12-15/16&q ...

  • Alto-Shaam 1010 - page 23

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 21. 20•20 es i WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS TWO (2) COLD W A TER INLETS - DRINKING QUALITY ONE (1) TREA TED W A TER INLET : 3/4" NPT* ONE (1) UNTREA TED W A TER INLET : 3/4" NPT* LI NE PR ES SU RE : 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" CO ...

  • Alto-Shaam 1010 - page 24

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 22. ELECTRICAL CONNECTION INSTALLATION DANGER ENSURE POWER SOURCE MATCHES VOLTAGE IDENTIFIED ON APPLIANCE RATING TAG. DANGER To avoid electrical shock, this appliance MUST be adequately grounded in accordance with local electrical codes or, in the absence of local codes, with the current e ...

  • Alto-Shaam 1010 - page 25

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 23. ELECTRICAL CONNECTION INSTALLATION DANGER ELECTRICAL CONNECTIONS MUST BE MADE BY A QUALIFIED SERVICE TECHNICIAN IN ACCORDANCE WITH APPLICABLE ELECTRICAL CODES. FINAL ASM, TOUCH SCREEN COMBICLEAN 5011685 Terminal Block Ground Electrical Connection DANGER To avoid electrical shock, this ...

  • Alto-Shaam 1010 - page 26

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 24. MOBILE EQUIPMENT RESTRAINT INSTALLATION Any appliance that is not furnished with a power supply cord but includes a set of casters must be installed with a tether. Adequate means must be provided to limit the movement of this appliance without depending on or transmitting stress to the ...

  • Alto-Shaam 1010 - page 27

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 25. INSTALLATION WATER QUALITY REQUIREMENT WARNING TO PREVENT WATER PIPES OR HOSES FROM BURSTING, INCOMING WATER SUPPLY SHOULD BE TURNED OFF WHEN THE APPLIANCE IS NOT IN USE. WARNING WATER SUPPLY MUST BE OPEN WHEN CLEANING PROGRAM IS ACTIVATED. VERIFY WATER SUPPLY BEFORE STARTING CLEANING ...

  • Alto-Shaam 1010 - page 28

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 26. INSTALLATION WATER CONNECTIONS WATER SUPPLY & INSTALLATION WATER REQUIREMENTS TWO (2) COLD WATER INLETS - DRINKING QUALITY ONE (1) TREATED WATER INLET: 3/4" NPT* ONE (1) UNTREATED WATER INLET: 3/4" NPT* LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar * Can manifold off of one ...

  • Alto-Shaam 1010 - page 29

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 27. INSTALLATION WATER VALVE WATER DRAINAGE shut - off valve shown i n the off position NOTE: THE SHUT-OFF VALVE MUST BE IN THE OPEN POSITION WHEN THE OVEN IS BEING USED. The oven must discharge through an indirect waste pipe by means of an air gap. The drain fitting is supplied with a 1-1 ...

  • Alto-Shaam 1010 - page 30

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 28. GREASE COLLECTION HOOK-UP ( I F EQUIPPED WITH THIS FEATURE ) • Grease Collection Hose Assembly is attached to the oven in the back. • Place Grease Collection Containers inside the tray of the Mobile Grease Collection Cart. Roll into place next to the oven. • Remove cap from conta ...

  • Alto-Shaam 1010 - page 31

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 29. INSTALLATION COMBITOUCH® CHECKLIST Use this list as a nal check of oven installation conformance. Damage directly attributed to improper set up, installation, or cleaning can invalidate warranty claims. CLEARANCES: Left: 6" (152mm) — Service access of 18" (457mm) recomm ...

  • Alto-Shaam 1010 - page 32

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 30. INSTALLATION cONTINUed ON NexT pAge ERROR CODES This section is provided for the assistance of qualified technicians only and is not intended for use by untrained or unauthorized service personnel. If your Alto-Shaam ® unit is not operating properly , check the following before callin ...

  • Alto-Shaam 1010 - page 33

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 31. INSTALLATION cONTINUed ON NexT pAge ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E13 Boiler Temperature High Boiler temperature overheats — Scale build up inside steam generator. — Scale build up on water level probe. — B4 Probe connection ...

  • Alto-Shaam 1010 - page 34

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 32. INSTALLATION ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E34 Steam Generator Drain Pump Fault Water level in steam generator does not drop during cleaning program — Scale build up inside the steam generator drain pump. — Scale build up insid ...

  • Alto-Shaam 1010 - page 35

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 33. INSTALLATION ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E57 No Rinse Water During rinse no water fl ow is detected through solenoid valve — Water supply is shut off. — Low water pressure. — Check wiring to all components mentioned below. ...

  • Alto-Shaam 1010 - page 36

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 34. INSTALLATION Type of Error Indication Release of Error Undervoltage LED fl ashing sequence, with 1 fl ash per period. Voltage of intermediate circuit is less than 250V Overvoltage LED fl ashing sequence, with 2 fl ashes per period. Voltage of intermediate circuit exceeds 445V Exces ...

  • Alto-Shaam 1010 - page 37

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 35. INSTALLATION ERROR CODES When the oven malfunctions, an error code will appear in the display . PRESS THE ST AR T ICON TO ACKNOWLEDGE THE ERROR. The icons that begin to flash repr esent operational modes that are still usable. When the oven fault is corrected, the Combitherm will r etu ...

  • Alto-Shaam 1010 - page 38

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 36. INSTALLATION VENTLESS HOOD OPTION The Ventless Hood option is factory installed directly on the top of the Alto-Shaam Combitherm oven. The hood is designed to vent clean air back into the kitchen, filtering vapors and grease. A high-power fan draws steam and fumes into the hood intake ...

  • Alto-Shaam 1010 - page 39

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 37. INSTALLATION VENTLESS HOOD OPTION TOP LEVEL ASSY, VHES-5 HOOD FOR COMBI 5010692 TOP EXHAUST VENT 2 6 1 4 3 5 7 1 Ventless Hood Power Knob 2 Emergency Latch Release: This release is to be used ONLY if the timed latch mechanism is not working or in the event of a power outage. Repeated u ...

  • Alto-Shaam 1010 - page 40

    COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 38. ORIGINAL EQUIPMENT LIMITED WARRANTY Alto-Shaam, Inc. warrants to the original purchaser that any original part that is found to be defective in material or workmanship will, at Alto-Shaam’s option, subject to provisions hereinafter stated, be replaced with a new or rebuilt part. The ...

  • Alto-Shaam 1010 - page 41

    TRANSPORTATION DAMAGE AND CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me ...

Manufacturer Alto-Shaam Category Double Oven

Documents that we receive from a manufacturer of a Alto-Shaam 1010 can be divided into several groups. They are, among others:
- Alto-Shaam technical drawings
- 1010 manuals
- Alto-Shaam product data sheets
- information booklets
- or energy labels Alto-Shaam 1010
All of them are important, but the most important information from the point of view of use of the device are in the user manual Alto-Shaam 1010.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Alto-Shaam 1010, service manual, brief instructions and user manuals Alto-Shaam 1010. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Alto-Shaam 1010.

Similar manuals

A complete manual for the device Alto-Shaam 1010, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Alto-Shaam 1010 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Alto-Shaam 1010.

A complete Alto-Shaam manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Alto-Shaam 1010 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Alto-Shaam 1010, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Alto-Shaam 1010, that we can find in the current document
3. Tips how to use the basic functions of the device Alto-Shaam 1010 - which should help us in our first steps of using Alto-Shaam 1010
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Alto-Shaam 1010
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Alto-Shaam 1010 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Alto-Shaam 1010?

Use the form below

If you did not solve your problem by using a manual Alto-Shaam 1010, ask a question using the form below. If a user had a similar problem with Alto-Shaam 1010 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)