-
United States Stove 5500 - page 1
USSC 1 King/Ashley Pellet Stove Please read this entire manual before installation and use of this appliance. Failure to follow these instructions could result in property damage, bodily injury, or even death. Contact your local building or re ofcials about restrictions and installation inspection requirements in your area. Save these instruc ...
-
United States Stove 5500 - page 2
2 USSC T ABLE OF CONTENTS .............................................................................................. 2 SAFETY PRECAUTIONS ........................................................................................... 3 SPECIFICA TIONS .................................................................................................. ...
-
United States Stove 5500 - page 3
USSC 3 Safety Precautions IMP OR T ANT : Read this ent ire manu al before ins tal ling an d op er at ing th is p ro du ct. Fa ilu re to d o s o m ay result in property damage, bodily injury , or even death. Properinstallationofthis stoveis? ...
-
United States Stove 5500 - page 4
4 USSC Specications HeatOutput 1 48,000BTU/hr . Heating Capacity 2 800-2,000sq.ft. Fuel Burn Rate 3 2.0-6.0lbs./hr . BurnT ime(lowestsetting) 5500/5500M -60hrs. 5500XL -160hrs. HopperCapacity 5500/5500M -150lbs. 5500XL -320lbs. ? ...
-
United States Stove 5500 - page 5
USSC 5 INST ALLA TION OPTIONS King/Ashley ? ...
-
United States Stove 5500 - page 6
6 USSC Installation CLEARANCES Y ourKing/Ashley stove has beentested and listed for installationin residential, mobile home,and alcove applications inaccordancewiththeclearancesgiveninFIGURES3-5andT ABLE1. NOTE: Distance “C” on the left -hand side of your King/A ...
-
United States Stove 5500 - page 7
USSC 7 Installation VENTING REQUIREMENTS ? ...
-
United States Stove 5500 - page 8
8 USSC Installation VENT TERMINA TION CLEARANCES: A) Minimum4-footclearancebeloworbesideanydoororwindowthatopens. B) Minimum1-footclearanceaboveanydoororwindowthatopens. C) Minimum3-footclearancefromanyadjacentbuilding. D) Minimum7-footclearancefrom? ...
-
United States Stove 5500 - page 9
USSC 9 Installation THROUGH THE W ALL INST ALLA TION (RECOMMENDEDINST ALLA TION) T o vent the unit through the wall, connect the pipe adapter tothe exhaustmotoradapter . Iftheexhaust adapteris at least 18-inches above ground level, a straight section of ...
-
United States Stove 5500 - page 10
10 USSC Installation OUTSIDE AIR SUPPL Y (optional) Dependingonyourlocationandhomeconstruction,outsideairmaybenecessaryforoptimalperformance. Metal pipe (solid or exible) must be used for the outside air installation. PVC pipe is NOT approved? ...
-
United States Stove 5500 - page 11
USSC 1 1 How your stove works Y our King/Ashley stove utilizes a inclined auger fuel feed system that is operated by a microprocessor controlled digital circuit board. The digitalcircuit board allows the inclinedauger fuel feed system torun in ...
-
United States Stove 5500 - page 12
12 USSC Control Panel Overview ON/OFF Pressing the “ON” button on the control panel will begin the start-up sequence for the heater . Fuel will begin to feed through the auger feed system after 3 minutes. Pressing and holding the “ON”? ...
-
United States Stove 5500 - page 13
USSC 13 UNIT PREP ARA TION After care fully unpac king and readi ng the instruc tions for inst alling your stove, you will need to perform the followin g steps: Attachtheincludedspringhandletothedoorhandlebyscrewingitoninarespectivelocation. Attac ...
-
United States Stove 5500 - page 14
14 USSC SHUT DOWN PROCEDURE Pressthe “OFF” buttononthecontrolpad toputthestovein shutdownmode. Atthistime,the redlightabove thepad willilluminate.Oncethis isdone,theaugerwillstop feedingpellets,butthedistribution blowerande ...
-
United States Stove 5500 - page 15
USSC 15 Maintenance Operation DAIL Y OPERA TION ? ...
-
United States Stove 5500 - page 16
16 USSC INTERIOR CHAMBERS Periodicallyremove andclean theburnpot andthe area insidethe burnpothousing. In particularit is advisableto clean out the holes in the burnpot to remove any build up that may prevent air from moving through ...
-
United States Stove 5500 - page 17
USSC 17 Trouble Shooting ? ...
-
United States Stove 5500 - page 18
18 USSC Error Code Err1 Err2 Err3 Err4 Err5 Err6 Err7 Err8 Error Descrption Thehighlimittemperaturesensor hastripped. Stoveranoutoffuelduringnormal operation. The stove was unable to reach the RoomFan Ontemperature withinthe startuptime. The power failed while? ...
-
United States Stove 5500 - page 19
USSC 19 13 5 11 10 1 10 12 10 6 12 7 8 2 4 3 9 9 9 Parts Diagram/List models 5500, 5500M & 5500XL 11 3 2 1 5 6 4 7 9 8 10 12 1 25490 DoorWeldment 1 2 891 166 CeramicGlass 1 3 891 188 GlassRetainer ,T op 1 4 891 186 GlassR ...
-
United States Stove 5500 - page 20
20 USSC Parts Diagram model 5500, 5500M and 5500XL Note: All repair parts (other than Cabinet Sides, Hopper Assy., and Door Assy.) are same for models 5500, 5500M and 5500XL. ...
-
United States Stove 5500 - page 21
USSC 21 Parts List model 5500/5500M/5500XL 1 86624 Burnpot Assembly 1 2 86625 Housing Assy ,Burnpot 1 3 86628 Weldment,ExhaustDuct 1 4 86633 Weldment,Igniter Tube 1 5 80481 IgniterCartridge 1 6 25506? ...
-
United States Stove 5500 - page 22
22 USSC Wiring Diagram GRAY BLACK ...
-
United States Stove 5500 - page 23
USSC 23 Notes ...
-
United States Stove 5500 - page 24
24 USSC THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPENDABLE SER- VICE FROM YOUR KING OR ASHLEY, AND ENABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFERENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOW ...
Do you have a question concerning United States Stove 5500?
Use the form below
If you did not solve your problem by using a manual United States Stove 5500, ask a question using the form below. If a user had a similar problem with United States Stove 5500 it is likely that he will want to share the way to solve it.