Manual RedMax BC250

52 pages 0.92 mb
Download

Go to site of 52

Summary
  • RedMax BC250 - page 1

    OWNER / OPERA T OR MANUAL MODE D’EMPLOI MANUAL DE INSTRUCCIONES BR USHCUTTERS DEBR OUSSAILLEUSE DESBR OZADOR 848-JAC-93A1 (805) APPLICABLE SERIAL NUMBERS : DRIVE UNIT 40400101 and up ENGINE UNIT KU40001 and up NUMEROS DE SERIE APPLICABLES : BOITE DE COMMANDES 40400101 et au-delà MOTEUR KU40001 et au-delà NÚMEROS DE SERIE APLICABLES: UNIDAD DE ...

  • RedMax BC250 - page 2

    2 SAFETY FIRST Instructions contained in warnings within this manual marked with a symbol concern critical points which must be taken into consideration to prevent possible serious bodily injury, and for this reason you are requested to read all such instructions carefully and follow them without fail. ■ WARNINGS IN THE MANUAL This mark indicates ...

  • RedMax BC250 - page 3

    3 SECURITE Les instructions contenues dans les mises en garde de ce mode d’emploi portant le symbole concernent les points critiques qui doivent être pris en considération pour éviter les blessures corporelles graves, c’est pourquoi ces précautions doivent être rigoureusement suivies. ■ DIFFERENTS TYPES D’AVERTISSEMENT DE CE MODE D’E ...

  • RedMax BC250 - page 4

    4 1. Parts location English English ■ BC250 Overall size(LxWxH) ······················································································· 72.0(1830)x9.0(228)x9 .5(241) in(mm) Dry weight ······························? ...

  • RedMax BC250 - page 5

    5 1. Emplacement des pieces 1. Situación de las piezas Français Español 1. Poignée 2. Interrupteur d’arrêt 3. Câble d’accélérateur 4. Gâchette de la commande de vitesse 5. Manette des gaz 6. Tube d’arbre 7. Protection d’accessoire de coupe 8. Tête de coupe a fil 9. Boîtier du renvoi d’angle 10. Grille d’arrêt d’étincelles ...

  • RedMax BC250 - page 6

    6 3. W arning labels on the machine English For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to take a mistake. (a) The port to refuel the "MIX GASOLINE" Position: FUEL TANK CAP (b) The direction A to close the choke The direction B to open the choke Pos ...

  • RedMax BC250 - page 7

    7 3. Etiqueta de advertencia en la máquina 3. Etiquettes d’avertissement sur la machine 7 Français Español (1) Lire le mode d’emploi avant d’utiliser cette machine. (2) Porter un casque de sécurité, des lunettes de sécurité et un casque antibruit. (3) Avertissement! Phénomène de rebond dangereux. (4) Attention aux objets qui volent o ...

  • RedMax BC250 - page 8

    8 1. Read this manual carefully until you completely understand and follow all safety and operating instructions. 2. Keep this manual handy so that you may refer to it later whenever any questions arise. Also note, if you have any questions which cannot be answered herein, contact the dealer from whom you purchased the product. 3. Always be sure to ...

  • RedMax BC250 - page 9

    9 1. Lea detenidamente este manual hasta comprender cabalmente todas las instrucciones de seguridad y uso. 2. Mantenga este manual a mano para que pueda consultarlo cuando tenga alguna duda. Si tiene cualquier duda que no esté cubierta en este manual, consulte en la tienda donde adquirió el producto. 3. Asegúrese de incluir siempre este manual a ...

  • RedMax BC250 - page 10

    10 other times when weather conditions might make it unsafe to use the product. ■ WORKING PLAN 1. You should never use the product when under the influence of alcohol, when suffering from exhaustion or lack of sleep, when suffering from drowsiness as a result of having taken cold medicine or at any other time when a possibility exists that your j ...

  • RedMax BC250 - page 11

    c. Pendant les averses, les orages avec éclairs, par grands vents ou toute autre condition climatique rendant l’utilisation de la machine dangereuse. ■ PLAN DE TRAVAIL 1. Ne jamais utiliser la machine sous l’influence de l’alcool ou en état de faiblesse due à la fatigue, au manque de sommeil, à la prise de médicament ou à tout autre m ...

  • RedMax BC250 - page 12

    12 Remove any obstacle before beginning work. 3. Inspect the entire unit for loose fasteners and fuel leakage. Make sure that the cutting attachment is properly installed and securely fastened. 4. Be sure the debris guard is firmly attached in place. ■ STARTING THE ENGINE 1. Keep bystanders and animals at least 50feet (15m) away from the operatin ...

  • RedMax BC250 - page 13

    13 Retirer tout obstacle avant de commencer le travail. 3. Vérifier que la machine ne comporte aucun élément desserré ou de fuite de carburant. S’assurer que l’outil de coupe est monté correctement et bien serré. 4. S'assurer que le cache de protection anti-débris est fermement attaché. ■ DEMARRAGE DU MOTEUR 1. Empêcher toute pe ...

  • RedMax BC250 - page 14

    14 1. Grip the handles firmly with both hands using your whole hand. Place your feet slightly apart (slightly further apart than the width of your shoulders) so that your weight is distributed evenly across both legs, and always be sure to maintain a steady, even posture while working. 2. Keep cutting attachment below waist level. 3. Maintain the s ...

  • RedMax BC250 - page 15

    15 deux mains. Ecarter légèrement les jambes (pour que les pieds reposent sur une largeur un peu plus importante que celle des épaules) et avoir une posture de travail stable et répartir le poids du corps également sur chaque jambe. 2. Maintenir l’outil de coupe toujours plus bas que le niveau de la taille. 3. Faire tourner le moteur à la v ...

  • RedMax BC250 - page 16

    16 maintenance or repair work not described in this manual must be performed, please contact a representative from the store nearest RedMax/ ZENOAH authorized servicing dealer for assistance. 5. Do not use any accessory or attachment other than those bearing the RedMax/ZENOAH mark and recommended for the unit. 6. Under no circumstances should you e ...

  • RedMax BC250 - page 17

    17 5. Ne pas utiliser d’accessoires ou d’outils de marque autres que RedMax/ZENOAH ou non agréés. 6. Ne jamais démonter ou modifier la machine, quelles que soient les circonstances. Dans le cas contraire, la machine risque d’être endommagée en cours d’utilisation ou de ne pas fonctionner correctement. ■ MANIPULATION DU CARBURANT 1. L ...

  • RedMax BC250 - page 18

    18 6. Set up English ■ INSTALLING HANDLE • Mount the handle to the shaft tube and clamp it at a location that is comfortable to you. (SE1) (1) About 19 inches (48cm) ■ INSTALLING DEBRIS GUARD • Put the debris guard on the gear box, attach it with the screws and hardware provided. (SE2) ■ INSTALLING CUTTING HEAD (SE3) 1. While locking the ...

  • RedMax BC250 - page 19

    19 6. Assemblage 6. Montaje Français Español ■ MISE EN PLACE DE LA POIGNEE • Monter la poignée sur le bras de l'appareil et la positionner pour avoir une prise confortable et sûre (SE1). (1) Environ 48cm ■ MISE EN PLACE DU CACHE ANTI-PROJECTION • Mettre en place le cache anti-projection sur le carter du renvoi d’angle et le fixer ...

  • RedMax BC250 - page 20

    20 7. Fuel English • Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 3m (10ft) away from the fueling point before starting the engine. • The RedMax/ZENOAH engines are lubricated ...

  • RedMax BC250 - page 21

    • La gasolina es muy inflamable. Evite fumar o producir cualquier llama o chispa cerca del combustible. Asegúrese de detener el motor y dejar que se enfríe antes de repostar la unidad. Seleccione un terreno al aire libre para el reabastecimiento y aleje la unidad una distancia de por lo menos 3 metros (10 pies) del punto de abastecimiento antes ...

  • RedMax BC250 - page 22

    22 ■ HOW TO MIX FUEL Agitate carefully. 1. Measure out the quantities of gasoline and oil to be mixed. 2. Put some of the gasoline into a clean, approved fuel container. 3. Pour in all of the oil and agitate well. 4. Pour In the rest of gasoline and agitate again for at least one minute. As some oils may be difficult to agitate depending on oil i ...

  • RedMax BC250 - page 23

    23 participer ainsi à la protection de l’environnement et de votre santé. • De l’essence ou de l’huile de basse qualité risque d’endommager les joints, les conduites d’essence ou le réservoir d’essence du moteur. ■ COMMENT OBTENIR UN BON MELANGE Agiter avec précautions. 1. Mesurez les volumes d’essence et d’huile à mélang ...

  • RedMax BC250 - page 24

    24 cause severe damage to the internal engine parts very quickly. 2. GASOHOL – It can cause deterioration of rubber and/or plastic parts and disruption of engine lubrication. 3. OIL FOR 4-CYCLE ENGINE USE – It can cause spark plug fouling, exhaust port blocking, or piston ring sticking. 4. Mixed fuels which have been left unused for a period of ...

  • RedMax BC250 - page 25

    25 1. ESSENCE SANS HUILE (ESSENCE PURE) – L’essence pure est capable d’endommager très rapidement les pièces du moteur. 2. ESSENCE-ALCOOL – Ce mélange risque de très rapidement détruire les pièces en caoutchouc et/ou en plastique et d’empêcher la lubrification du moteur. 3. HUILE POUR MOTEURS 4 TEMPS – Elles risquent d’encrasse ...

  • RedMax BC250 - page 26

    26 8. Operation English ■ STARTING ENGINE The cutting head will start rotating upon the engine starts. 1. Rest the unit on a flat, firm place. Keep the cutting head off the ground and clear of surrounding objects as it will start rotating upon starting of the engine. 2. Push the primer pump several times until overflown fuel flows out in the retu ...

  • RedMax BC250 - page 27

    27 8. Fonctionnement 8. Uso Français Español ■ DEMARRAGE DU MOTEUR La tête de coupe commencera à tourner au démarrage du moteur. 1. Poser la machine dans un endroit plat et ferme. Ne pas poser la tête de coupe sur le sol et dégager tout objet pouvant être projeté par la lame qui se met à tourner dès que le moteur démarre. 2. Appuyer p ...

  • RedMax BC250 - page 28

    28 8. Operation English ■ STOPPING ENGINE 1. Release the throttle lever and run the engine for a half minute. 2. Shift the ignition switch to the STOP position. • Except for an emergency, avoid stopping the engine while pulling the throttle lever. ■ ADJUSTING IDLING SPEED (OP5) 1. When the engine tends stop frequently at idling mode, turn the ...

  • RedMax BC250 - page 29

    29 8. Fonctionnement 8. Uso Français Español ■ ARRET DU MOTEUR 1. Relâcher le levier d’accélération et laisser tourner le moteur pendant encore 30 secondes. 2. Placer le bouton de contact en position STOP. • Sauf en cas d’urgence, ne jamais couper le contact lorsqu’on accélère. ■ REGLAGE DU RALENTI (OP5) 1. Lorsque le moteur a te ...

  • RedMax BC250 - page 30

    30 8. Operation English than placing the full workload on the arm and hands. 6. Take precautions to avoid wire, grass and dead, dry, long-stem weeds from wrapping around the head shaft. Such materials can stall the head and cause the clutch to slip, resulting in damage to the clutch system if repeated frequently. ADJUSTING THE LINE LENGTH • Your ...

  • RedMax BC250 - page 31

    31 8. Fonctionnement 8. Uso Français Español punto de perder el equilibrio o el control de la misma. 5. Intente controlar el movimiento de corte con la cadera en lugar de hacer que toda la carga del trabajo descanse sobre el brazo y las manos. 6. Tome precauciones para evitar que alambres, vidrio y hierbajos muertos, secos y largos se enrosquen e ...

  • RedMax BC250 - page 32

    32 every every every 25 50 100 system/compornent procedure before hours hours hours note use after after after fuel leaks, fuel spillage wipe out ✔ fuel tank, air filter, fuel filter inspect/clean ✔✔ replace, if necessary see ■ ADJUSTING replace carburetor idle adjusting screw ✔ IDLING SPEED (p.28) if necessary clean and readjust GAP: .02 ...

  • RedMax BC250 - page 33

    33 L’entretien, le remplacement ou la réparation du dispositif et des systèmes de lutte contre les émissions peuvent être effectués par toute société ou individu spécialisé dans la réparation des moteurs hors-route. El mantenimiento, recambio o reparación del dispositivo de control de emisiones y del equipo pueden realizarse en cualqui ...

  • RedMax BC250 - page 34

    34 9. Maintenance English MA1 ■ REFILLING TRIMMING LINE (MA1) 1. For replacement line, use a diameter of .095in (2.4mm). The spool is capable for a line upto 20ft (6m) on the 4” head. Avoid using a larger line as it may cut down the trimming performance. For safety reasons, do not use metalreinforced line. 2. Pinch the slotted area on the both ...

  • RedMax BC250 - page 35

    35 9. Entretien 9. Mantenimiento Français Español ■ REMPLACEMENT DU FIL DE COUPE (MA1) 1. Pour le renouvellement, utiliser du fil de 2.4 mm de diamètre. La tête de 4’’ de diamètre peut contenir jusqu'à 6m de fil. Eviter d’utiliser un fil plus gros car cela risque de diminuer les performances de coupe. Pour des raisons de sécurit ...

  • RedMax BC250 - page 36

    36 9. Maintenance English ■ FUEL FILTER • When the engine runs short of fuel supply, check the fuel cap and the fuel filter for blockage. (MA3) (1) Fuel filter ■ SPARK PLUG • Starting failure and mis-firing are often caused by a fouled spark plug. Periodically clean the spark plug and check that the spark gap is in the correct range. For a ...

  • RedMax BC250 - page 37

    37 9. Entretien 9. Mantenimiento Français Español ■ FILTRE A CARBURANT • Si l’essence n’arrive plus au carburateur, vérifier que l’évent du bouchon de réservoir et le filtre à carburant ne sont pas bouchés. (MA3) (1) Filtre à carburant ■ BOUGIE D’ALLUMAGE • Les démarrages sans succès et les ratés d’allumage du moteur so ...

  • RedMax BC250 - page 38

    38 9. Maintenance English ■ SPARK ARRESTER • The muffler is equipped with a spark arrester to prevent red hot carbon from flying out of the exhaust outlet. Periodically inspect and clean as necessary with a wire brush. In the State of California it is required by law (Section 4442 of the California Public Resources Code) to equip a spark arrest ...

  • RedMax BC250 - page 39

    39 9. Entretien 9. Mantenimiento Français Español ■ GRILLE D’ARRET D’ETINCELLES • Le moteur est équipé d’un écran pare-étincelles sur l’échappement. La vérifier régulièrement et la maintenir en bon état. Dans l’état de Californie, la loi (section 4442 du Code des Ressources Public de la Californie) oblige d’équiper un o ...

  • RedMax BC250 - page 40

    40 9. Maintenance English • If waste gets stuck and causes blockage around the intake air cooling vent or between the cylinder fins, it may cause the engine to overheat, and that in turn may cause mechanical failure on the part of the brushcutter. (MA8) (1) Cylinder fin (2) Intake air cooling vent (back) ■ PROCEDURES TO BE PERFORMED AFTER EVERY ...

  • RedMax BC250 - page 41

    41 9. Entretien 9. Mantenimiento Français Español • Si des détritus se coincent et bouchent la zone aux alentours de l’ouïe d’entrée d’air de refroidissement ou des ailettes de cylindres, le moteur risque de chauffer et provoquer une grave panne mécanique. (MA8) (1) Cylindre (2) Ouïe d’entrée d’air de refroidissement ■ PROCEDU ...

  • RedMax BC250 - page 42

    42 Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clogged ➞ clean carburetor adjustment screw ➞ out of normal range ➞ adjust to normal range sparking (no spark) ➞ spark plug is fouled/wet ➞ clean/dry ➞ plug gap is incorrect ➞ correct ...

  • RedMax BC250 - page 43

    43 13. Parts list 13. Liste des pièces 13. Lista de piezas NOTE : 1. Use RedMax/ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. RedMax/ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company. 3. When placing parts orders for repair and/or ...

  • RedMax BC250 - page 44

    44 13. Parts list Fig.1 DRIVE UNIT BC250 (S/N 40400101 and up) ...

  • RedMax BC250 - page 45

    45 Key# Part Number Description Q'ty 1 848-JAC-58A0 PIPE 1 2 848-JA3-58B0 BUSH 2 3 848-JAC-58C0 LINER 1 4 848-JA3-58D0 • SEAL 1 5 848-JA3-58E0 SHAFT 1 6 848-JAC-6100 GEARCASE ASSY 1 7 848-B20-62A0 • GEARCASE 1 8 06004-06000 • BEARING 1 9 06000-00626 • BEARING 1 10 04065-02612 • RING 1 11 T3195-13210 • SHAFT 1 12 T3300-93250 • GEA ...

  • RedMax BC250 - page 46

    46 Fig.2 ENGINE UNIT BC250 (S/N KU40001 and up) 13. Parts list ...

  • RedMax BC250 - page 47

    47 Key# Part Number Description Q'ty 1 6634401 SCREW 4 2 3075406 FRONT HOUSING 1 3 6635301 SCREW CLUTCH 2 4 6969601 WASHER CURVED 2 5 3075603 CLUTCH ASSY 1 6 6969501 WASHER PLAIN 2 7 6968901 NUT 1 8 6457403 ROTOR 1 9 4309501 CRANKCASE&SHAFT ASSY 1 10 6968501 • BEARING 2 11 5987501 • SEAL 1 12 9071301 GASKET CASE 1 13 6968401 • RING 1 ...

  • RedMax BC250 - page 48

    EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE UNIT, RedMax/ZENOAH AMERICA INC. (THE COMPANY), THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART OR PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP. EMISSION-RELATED PARTS ARE: THE ...

  • RedMax BC250 - page 49

    Pièces en rapport avec les émissions de gaz d'échappement : RedMax/ZENOAH AMERICA INC., par l'intermédiaire de n'importe quel revendeur RedMax, réparera gratuitement ou remplacera gratuitement pour l'acheteur initial et chaque acheteur successif toute(s) pièce(s) se révélant de constitution et/ou de montage défectueux p ...

  • RedMax BC250 - page 50

    PIEZAS REALACIONADAS CON LAS EMISIONES, POR DOS (2) AÑOS A CONTAR DE LA FECHA DE ENTREGA ORIGINAL DEL UNIDAD, RedMax /ZENOAH AMERICA, INC., A TRAVÉS DE CUALQUIER DISTRIBUIDOR RedMax, REPARARÁ O REEMPLAZARÁ, GRATUITAMENTE, PARA EL COMPRADOR ORIGINAL Y CUALQUIER COMPRADOR POSTERIOR, CUALQUIER PIEZA O PIEZAS QUE PRESENTEN DEFECTOS EN SUS MATERIALE ...

  • RedMax BC250 - page 51

    ...

  • RedMax BC250 - page 52

    Printed in U.S.A. ZENOAH AMERICA, INC. 1100 Laval Blvd. Suite 110 Lawrenceville, Georgia 30043 ...

Manufacturer RedMax Category Brush Cutter

Documents that we receive from a manufacturer of a RedMax BC250 can be divided into several groups. They are, among others:
- RedMax technical drawings
- BC250 manuals
- RedMax product data sheets
- information booklets
- or energy labels RedMax BC250
All of them are important, but the most important information from the point of view of use of the device are in the user manual RedMax BC250.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals RedMax BC250, service manual, brief instructions and user manuals RedMax BC250. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product RedMax BC250.

Similar manuals

A complete manual for the device RedMax BC250, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use RedMax BC250 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of RedMax BC250.

A complete RedMax manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual RedMax BC250 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the RedMax BC250, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the RedMax BC250, that we can find in the current document
3. Tips how to use the basic functions of the device RedMax BC250 - which should help us in our first steps of using RedMax BC250
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with RedMax BC250
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of RedMax BC250 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning RedMax BC250?

Use the form below

If you did not solve your problem by using a manual RedMax BC250, ask a question using the form below. If a user had a similar problem with RedMax BC250 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)