Manual Raypak RHP100

19 pages 1.47 mb
Download

Go to site of 19

Summary
  • Raypak RHP100 - page 1

    Raypak ® RHP Series Swimming Pool and Spa Heat Pump OWNER and INST ALLA TION MANUAL This manual should be maint ained in legible condition and kept adjacent to the heat pump or in a safe place for future use. For additional information call: ( 800) 260-2758 Manual Effective Date: 3/1/20 03 Replaces: All Previous V ersions De ve lo pe d a nd pr in ...

  • Raypak RHP100 - page 2

    i PRODUCT SAFETY SIGNS AND LABE LS This manual, as well as the pool/spa heat pum p itself, contains ANSI-approved product safety signs and labels. Please read these signs and labe ls, as they convey important safety information about hazards that may be potentially present in and around the heat pump. They are classified according to relative serio ...

  • Raypak RHP100 - page 3

    ii RHP Series Swimming Pool and Spa Heat Pump OWNER and INST ALLA TION MANUAL CONTENTS Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 I. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...

  • Raypak RHP100 - page 4

    1 Intr oduction This pool/sp a heat pump is an electromechanical m achine that incorporates a pressurized refrigerant gas in a sealed system. ONL Y trained and qualified service personnel should attem pt to install or servic e this equipment. Without proper training a nd knowledge of such equipment, any attempt to inst all or service the unit could ...

  • Raypak RHP100 - page 5

    2 • Each side of the unit must be lo cated at least 1 ft fr om walls, pipes, or other obstructions for unrestricted air intake and service access. Do not inst all the unit within 3 f t of fossil fuel burning heaters. Air int ake along the sides of this heat pump co uld disturb the combustion process of the unit, and could cause damage or personal ...

  • Raypak RHP100 - page 6

    3 III. W ater Connections The heat pump inlet and outlet connection s are NOT interchangeable. They must be connected as inst ructed below . 1. Connect the heat pump in the return water li ne between the pool filt er and the pool. See page 10, Plumbing Diagrams. 2. Connect the filter outlet to the fitting marked WA T E R I N at the bottom front of ...

  • Raypak RHP100 - page 7

    4 Indicator Lamps : There are 6 indicator lamps located on the unit control panel: • Power (amber lamp): When lit, indicates power is applied to the unit. NOTE: The heat pump will not run whe n the Remote position is selected and there is no remote control system attached. • W ater Flow (green lamp): When lit, indicates normal water flow . • ...

  • Raypak RHP100 - page 8

    5 NOTE: The heat pump wi ll be OFF when the Remote position is selected on th e Pool/Sp a selector switch and there is no remote con trol system att ached. 4.Allow the heat pump to op erate for a few minutes to stabilize operating pressure s and to allow various component temperatures to normalize. 5. V erify that the discharge air temperature is a ...

  • Raypak RHP100 - page 9

    6 VIII. Summer Shutdown If you do not plan to use the pool heat pump duri ng the summer months, secure and protect it as follows: 1. From the control panel, tu rn the contr ol switch to Remote (OFF). 2. T urn the heat pump circuit break er or disconnect switch to OFF . 3. Leave the valves set the way they are unless additional circulation is requir ...

  • Raypak RHP100 - page 10

    7 2. B. Cabinet Care (optional) - The cabinet is designed for outdoor use and require s little care. However , you can clean it if you wish. 1. 2. W ash the cabinet with soap and water . C. Condensate Drainage - The heat pump extracts humidity from the air as it passes through the coil, similar to the way a cold drink outside “swe ats” on a hot ...

  • Raypak RHP100 - page 11

    8 operation. After the desired temper ature is reached, return the system to normal operation of 8-10 hours per day . • Is airflow through the unit being obstructed? Restri ctions such as shrubbe ry , tall grass, dirty coils, or any other obstruction to airflow will reduce performance. • Is the pool blanket/cover bei ng used? Unblanketed pools ...

  • Raypak RHP100 - page 12

    9 POWER SUPPL Y • V erify that all circ uit breakers are reset and working properly . •I f t h e Power lamp on the control pane l still does not light, cont act the installing dealer , since it may be a power probl em requiring an electrician. WAT E R F L O W • V erify that the filter is clean to provide good flow . • V erify that the valve ...

  • Raypak RHP100 - page 13

    10 Plumbing Diagrams For systems with p umps of less than 2 HP (under 80 gpm) , no external bypass is required. Connections are 2 -inch pipe slip. Plumb the heat pump after the filter and before any chlorinators. Wa t er I n (from pool or S pa) Wa t er O u t (to pool or S pa) Filter For systems with pum p s of 2 HP or greate r (over 80 gpm), an ext ...

  • Raypak RHP100 - page 14

    11 Heat Pump Schematic 12 34 A B C D 4 3 2 1 D C B A Title Number Revision Size A Date: 27-Jan-2003 Sheet of File: C:Pool FactPoofactPoofact.ddb Drawn By: 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 TB1 Control Panel Interface D4 Delay Active D5 Active D6 Pressure D1 Power D2 Wat er Fl ow D3 Heat Demand R1 Spa R2 Pool K1 Conta ...

  • Raypak RHP100 - page 15

    12 Contr ol Panel Assembly Replacement Parts List 12 4 7 13 11 10 16 11 9 15 2 5 8 14 3 6 1 ITEM QTY DESCRIPTION PART No. 1 1 Control Panel 83-10002 2 1 Contactor Compressor 54-10002 3 1 Fan Relay 50-10010 4 1 Control Board 24Volt 50-10007 5 1 Thermostat 50-10003 6 1 Transformer 50-10014 7 1 Timer IMC 203 55-10011 8 1 Capacitor 55-10003 9 1 Pressur ...

  • Raypak RHP100 - page 16

    13 Contr ol Panel Cover Assemb ly Replacement Parts List 1 4 4 4 7 6 7 6 8 8 5 Front ITEM QTY DESCRIPTION PART No. 1 1 Control Panel Cover 81-30152 2 2 POT 50-10004 3 1 Switch Type A403 50-10005 4 3 Knob 56-10001 5 1 Label Control Panel 84-10017 6 2 Lamp Green 53-10001 7 2 Lamp Red 53-10003 8 2 Lamp Amber 53-10002 2 3 2 RHP Control Panel Cover 1 Ba ...

  • Raypak RHP100 - page 17

    14 Heat Pump Assembly Re placement Parts List - RHP 100 11 15 13 12 5 9 18 2 7 7 7 6 8 1 4 10 3 17 14 9 19 RHP 100 16 0207 *See assembly drawing in this manual ITE M QT Y DESCRIPTION PART No. 1 1 Assembly Base 8 1- 20140 2 1 E vaporator Coil 40-10002 3 1 Access Panel 81 - 50141 4 1 Power Input Panel 81-40151 5 1 Co ver, Top 81-10140 6 1 Compressor, ...

  • Raypak RHP100 - page 18

    15 Heat Pump Assembly Re placement Parts List - RHP 1 15 11 15 13 12 5 9 2 9 16 7 7 18 14 6 7 3 17 19 4 10 1 8 RHP 115 *See assembly drawing in this manual ITEM QTY DESCRIPTION PART No. 1 1 Assembly Base 8 1- 20 14 0 2 1 E v aporator Coil 40-10002 3 1 Ac ce ss P an el 81-50141 4 1 Power Input Panel 81-40151 5 1 Cover, Top 81 -10 140 6 1 Compressor, ...

  • Raypak RHP100 - page 19

    16 11 12 15 13 18 9 2 16 9 7 7 7 6 8 1 4 3 17 14 10 19 5 *See assembly drawing in this manual RHP 160 ITE M QTY DESCRIPTION PART No. 1 1 Assembly Base 8 1- 20 14 0 2 1 E vaporator Coil 40-10003 3 1 Access Panel 81- 50 14 2 4 1 Power Input Panel 81-4015 2 5 1 Cover, Top 81-1 0140 6 1 Compressor, Scroll 30- 1000 3 7 3 Corner Support 81-60152 8 1 Heat ...

Manufacturer Raypak Category Swimming Pool Pump

Documents that we receive from a manufacturer of a Raypak RHP100 can be divided into several groups. They are, among others:
- Raypak technical drawings
- RHP100 manuals
- Raypak product data sheets
- information booklets
- or energy labels Raypak RHP100
All of them are important, but the most important information from the point of view of use of the device are in the user manual Raypak RHP100.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals Raypak RHP100, service manual, brief instructions and user manuals Raypak RHP100. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product Raypak RHP100.

Similar manuals

A complete manual for the device Raypak RHP100, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use Raypak RHP100 by users. Manuals are usually written by a technical writer, but in a language understandable to all users of Raypak RHP100.

A complete Raypak manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual Raypak RHP100 - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the Raypak RHP100, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the Raypak RHP100, that we can find in the current document
3. Tips how to use the basic functions of the device Raypak RHP100 - which should help us in our first steps of using Raypak RHP100
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with Raypak RHP100
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of Raypak RHP100 in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning Raypak RHP100?

Use the form below

If you did not solve your problem by using a manual Raypak RHP100, ask a question using the form below. If a user had a similar problem with Raypak RHP100 it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)