Manual HP Clemco 60 HP

14 pages 0.2 mb
Download

Go to site of 14

Summary
  • HP Clemco 60 HP - page 1

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR CLEMCO SUPPLIED AIR RESPIRA T OR MODEL 60 HP O.M. 10533 690-0985 09/85 K, 05/15/98 MC FILE NUMBER: DATE OF ISSUE: REVISION: WARNING Do not proceed with these instructions until you have READ the orange cover of this MANU AL and Y OU UNDERST AND its content.* These W ARNINGS are included for the health and safety ...

  • HP Clemco 60 HP - page 2

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR x 04440 Flow Regulator x 04410 Flow Regulator x 04411 Flow Regulator x 21422 Cont. Flow Conn. x 04397 Hose 25 Ft. x 04415 Hose 50 Ft. x 04398 Hose 100 Ft. Page 1 Clemco Industries Corp. W ashington, Missouri USA (314) 239-0300 TYPE C AND CE CONTINUOUS FLO W SUPPLIED-AIR RESPIRA TOR IS APPRO VED ONL Y IN THE FOLL ...

  • HP Clemco 60 HP - page 3

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 2 ! W ARNING “Warning” is used to indicate a potentially haz- ardous situation which, if not avoided, could result in death or serious injury. ! DANGER “Danger” is used to indicate an imminently haz- ardous situation which, if not avoided, will result in death or serious injury. 1.3 Respiratory and ...

  • HP Clemco 60 HP - page 4

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 3 This manual does not contain all the health and safety requirements regarding toxic and hazard- ous dust exposure. Obtain copies of the OSHA regulations and consult a safety professional and/or industrial hygienist for complete require- ments. Within this manual we refer to hazardous or con- taminated env ...

  • HP Clemco 60 HP - page 5

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 4 bels. (42 CFR part 84.140) When any exterior noise causes the internal noise level to exceed 80 decibels, the user must wear additional hearing protection. A variety of hearing protectors can be worn with the respirator. 1.7 Description 1.7.1 The Clemco Apollo 60 Supplied-Air Respirator is approved by the ...

  • HP Clemco 60 HP - page 6

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 5 2.0 INSPECTION ! NOTICE A Clemco respirator hose must be used with the Apollo Respirator. If one is not available, it must be ordered from an authorized distributor of Clemco products. Hoses are not included with respirators, because blast operators often are assigned personal respirators, while using com ...

  • HP Clemco 60 HP - page 7

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 6 connect the other end of the respirator hose to a respirable air source. If longer hose is required, it must be a NIOSH- approved Clemco respirator hose extension. Any 25 foot, 50 foot and 100 foot respirator hoses can be added in any combination to produce the maximum total length as noted in the table i ...

  • HP Clemco 60 HP - page 8

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 7 monoxide removal or conversion system may also be used to ensure breathing air quality. The maximum allowable presence of carbon monoxide in Grade D breathing air is 10 parts per million (ppm). 4.2 Air Volume and Pressure 4.2.1 A pressure regulator and gauge must be installed at the point where the respir ...

  • HP Clemco 60 HP - page 9

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 8 5.1 Prior to operation, thoroughly inspect and clean the helmet, breathing tube, respirator hose, air entry ports, and fittings of all dust and debris. Inspect the helmet suspension and adjust if necessary per Section 6.2. 5.2 Start the compressor and open the service valve to pressurize the air supply li ...

  • HP Clemco 60 HP - page 10

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 9 6.2 Helmet Suspension Adjustment and Replacement, Figure 3 ! W ARNING The suspension maintains a fixed distance be- tween the head and the helmet. It is critical that the suspension is properly installed, and ad- justed as described, to provide maximum head protection and comfort. 6.2.1 Remove the cape fr ...

  • HP Clemco 60 HP - page 11

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 10 7.2.4 Periodically inspect and clean the foam filter and screen in the alternate air control valve. Replace the foam filter at first sign of blockage or deterioration. (See Section 9.8) 7.2.5 The inner collar is a very important factor in controlling air escape from the helmet and preventing ingress of d ...

  • HP Clemco 60 HP - page 12

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Page 11 8.4.3 If the acoustical foam on the inside of the helmet becomes soiled, it can be wiped with a damp cloth or pulled off and replaced. 8.5 Inner Lens 8.5.1 Inner lenses should be replaced when dirty or scratched; however mild detergent and water can be used to clean the inner lens. Volatile solutions suc ...

  • HP Clemco 60 HP - page 13

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR 9.4.2 Separate the Velcro tabs on the back of the cape. See Figure 5. 9.4.3 Slide the ends of the cape to the notch. Continue sliding one end of the cape out of the groove until the entire cape is detached from the helmet. 9.4.4 To install the cape, separate the Velcro tabs on the cape and slide one end into the ...

  • HP Clemco 60 HP - page 14

    APOLLO 60 HP SUPPLIED-AIR RESPIRATOR Figure 6. (2) (1) (3, 4, 5) (6) (7) (9) (8) (10) (11) (12) (14) (13) (15) (16) (17) (18) (24) (19) (20) (22) (23) (21) Page 13 10.2 Supplied-Air Respirator, Figure 6 Item Description Stock No. 1. Constant-flow connector, HP (alternate), without belt ........................................ 21415 2. Belt assembly ...

Manufacturer HP Category Respiratory Product

Documents that we receive from a manufacturer of a HP Clemco 60 HP can be divided into several groups. They are, among others:
- HP technical drawings
- Clemco 60 manuals
- HP product data sheets
- information booklets
- or energy labels HP Clemco 60 HP
All of them are important, but the most important information from the point of view of use of the device are in the user manual HP Clemco 60 HP.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals HP Clemco 60 HP, service manual, brief instructions and user manuals HP Clemco 60 HP. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product HP Clemco 60 HP.

Similar manuals

A complete manual for the device HP Clemco 60 HP, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use HP Clemco 60 HP by users. Manuals are usually written by a technical writer, but in a language understandable to all users of HP Clemco 60 HP.

A complete HP manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual HP Clemco 60 HP - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the HP Clemco 60 HP, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the HP Clemco 60 HP, that we can find in the current document
3. Tips how to use the basic functions of the device HP Clemco 60 HP - which should help us in our first steps of using HP Clemco 60 HP
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with HP Clemco 60 HP
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of HP Clemco 60 HP in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning HP Clemco 60 HP?

Use the form below

If you did not solve your problem by using a manual HP Clemco 60 HP, ask a question using the form below. If a user had a similar problem with HP Clemco 60 HP it is likely that he will want to share the way to solve it.

Copy the text from the picture

Comments (0)