-
Invacare IOC100P - page 1
Dealer: This manual MUST be given to the end user. User: Before using this product, read this manual and save for future ref erence. For more information regarding Invacare products, parts, and services, please visit www.invacare.com User Manual Invacare® Element™ Pneumatic Conserver IOC100P ...
-
Invacare IOC100P - page 2
WARNING Invacare® Element™ 2 Part No 1160840 WARNING DO NOT use this product or any available optional equipment without first completely reading and understanding these instruct ions and any additional instructional material such as owner’s manuals, service manuals or instruction sheets supplied with this product or optional equipment. If ...
-
Invacare IOC100P - page 3
TABLE OF CONTENTS TABLE OF CONTENTS Part No 1160840 3 Invacare® Element™ SPECIAL NOTES ............................................... 4 Receiving Inspection ................... ........................................................ 4 Intended Use .............. ............................................. .................. ........... 4 Dis ...
-
Invacare IOC100P - page 4
SPECIAL NOTES Invacare® Element™ 4 Part No 1160840 SPECIAL NOTES Signal words are use d in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the following table for ...
-
Invacare IOC100P - page 5
SPECIAL NOTES Part No 1160840 5 Invacare® Element™ Principles of Operation The oxygen conserving regulator is designed to be used with high pressure oxygen systems. It consists of a cylinder connection, cylinder contents gaug e (if equipped), high ...
-
Invacare IOC100P - page 6
INTRODUCTION Invacare® Element™ 6 Part No 1160840 INTRODUCTION The oxygen conserving regulator includes a combination of low ‐ pressure regulator and an oxygen conserv er , designed for use with a cylinder as an ambulatory oxygen system. It ...
-
Invacare IOC100P - page 7
SECTION 1—GENERAL GUIDELINES Part No 1160840 7 Invacare® Element™ SECTION 1—GENERAL GUIDELINES When using the oxygen conserving regulator , basic precautions should AL W A YS be followed, including the following: WARNING SECTION 1 ‐ GENERAL GUIDELINES contains ? ...
-
Invacare IOC100P - page 8
SECTION 1—GENERAL GUIDELINES Invacare® Element™ 8 Part No 1160840 Store product in a clean area when not in use. NEVER smoke in an area where oxygen is being administered. NEVER us e aerosol sprays near the equipment. AL W A YS confirm p ...
-
Invacare IOC100P - page 9
SECTION 1—GENERAL GUIDELINES Part No 1160840 9 Invacare® Element™ DO NOT allow oil from yo ur hands or othe r sources to come into contact with the cylinder post val v e . These substances may become flammable in the presence of oxyg ...
-
Invacare IOC100P - page 10
SECTION 2—FEATURES Invacare® Element™ 10 Part No 1160840 SECTION 2—FEATURES DANGER This product is not intended as a life ‐ sustaining or life ‐ supporting device. CAUTION Missing or illegible labels MUST be replaced. Contact customer service at t ...
-
Invacare IOC100P - page 11
SECTION 2—FEATURES Part No 1160840 11 Invacare® Ele ment™ Selector Switch: Enables the user to select the desired setting, as wel l as “OFF” and “CF” (continuous flow). When not in use, the switch should be turned to the ...
-
Invacare IOC100P - page 12
SECTION 3—INSTALLING THE CONSERVING REGULATOR Invacare® Element™ 12 Part No 1160840 SECTION 3—INSTALLING THE CONSERVING REGULATOR WARNING DO NOT allow oil from you r hands or other sources to come into contact with th e regulator gas ket or cylinder post ...
-
Invacare IOC100P - page 13
SECTION 3—INSTALLING THE CONSERVING REGULATOR Part No 1160840 13 Invacare® Ele ment™ NOTE: For information on how to ope rate the cylinder , consult your equipment pr ovider . NOTE: For this pr ocedur e, ref er to FIGURE 3.1. 1. Loosen the cylinder post ...
-
Invacare IOC100P - page 14
SECTION 4—OPERATING INSTRUCTIONS Invacare® Element™ 14 Part No 1160840 SECTION 4—OPERATING INSTRUCTIONS DANGER NEVER smoke in an area where oxygen is being administered. NEVER use near any type of flame or flammable/explosive substances, vapors or atmosph ...
-
Invacare IOC100P - page 15
SECTION 4—OPERATING INSTRUCTIONS Part No 1160840 15 Invacare® Ele ment™ 4. Listen for leaks. If a leak is present, close the cylinder val v e, check the CGA870 seal was h e r, and reinstall. If the leak persists, DO NOT use the equipment ...
-
Invacare IOC100P - page 16
SECTION 4—OPERATING INSTRUCTIONS Invacare® Element™ 16 Part No 1160840 WARNING NO OXYGEN is delivered in between settings. To obtain desired flow , the in dicating pointer MUST align with a specific number on the di al. To av oid injury to ? ...
-
Invacare IOC100P - page 17
SECTION 4—OPERATING INSTRUCTIONS Part No 1160840 17 Invacare® Ele ment™ 12. When finished using the system, close the oxygen supply cylinder va l ve and continue breathing through the nasal cannula until no further oxygen flow is detected. 13. Remov ...
-
Invacare IOC100P - page 18
SECTION 5—REMOVING THE CONSERVING REGULATOR Invacare® Element™ 18 Part No 1160840 SECTION 5—REMOVING THE CONSERVING REGULATOR DANGER NEVER attempt to remove the oxygen conserving regulator from an oxygen cylinder unless the cylinder valve is completely closed . C ...
-
Invacare IOC100P - page 19
SECTION 6—TYPICAL PRODUCT PARAMETERS Part No 1160840 19 Invacare® Ele ment™ SECTION 6—TYPICAL PRODUCT PARAMETERS OXYGEN DELIVERY : SELECTOR SWITCH POSITION LITER FLOW EQUIVALENCY 0O F F 11 22 33 44 55 66 CONTINUOUS FLOW EMERGENCY BYPASS SETTING: Factory Preset at 2 ± .5 L/min. REQUIRED OPERATING PRESSURE: 200 psi to 3000 psi (13.8 bar to 20 ...
-
Invacare IOC100P - page 20
SECTION 6—TYPICAL PRODUCT PARAMETERS Invacare® Element™ 20 Part No 1160840 OXYGEN CYLINDER DURATION The total deliv ery of oxygen via the conserv er is related to the breathing rates, it is user adaptiv e in that the total oxygen delivered per m ...
-
Invacare IOC100P - page 21
SECTION 7—MAINTENANCE Part No 1160840 21 Invacare® Ele ment™ SECTION 7—MAINTENANCE CAUTION DO NOT use cleaning solutions. DO NOT immerse product in any kind of liquid. All repairs MUST be done by Inv acare Corporation. 1. Disconnect all connections be ...
-
Invacare IOC100P - page 22
SECTION 8—TROUBLESHOOTING Invacare® Element™ 22 Part No 1160840 SECTION 8—TROUBLESHOOTING If oxygen conserving regulator fails to function, consult the Tr o u b l e s h o o t i n g guide. If problem cannot be corrected, consult yo ur Dealer/Home Care equipment ? ...
-
Invacare IOC100P - page 23
LIMITED WARRANTY Part No 1160840 23 Invacare® Ele ment™ LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975. This warranty is extended only to the original pu rchaser/user of our products. This warranty gives you spe cific legal ri ghts and you may al ...
-
Invacare IOC100P - page 24
THAN INVACARE OR AN INVACARE SE RVICE CENTER. SUCH EVALUATION SHALL BE SOLELY DETERMINED BY INVACARE. THE FOREGOING EXPRESS WARRANTY IS EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTIES WHATSOEVER, WHETHER EXPRESSED OR IMPLIED, INCLUDING THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FIT NESS FO R A PARTICULAR PURPOSE, AND THE SOLE REMEDY FOR VIOLATIONS ...
