-
American Water Heater GTS-705-NI - page 1
Tankless W ater Heater System Design Manual Plumbing schematics for single and multiple tankless water heaters in use with domestic systems, recirculation, and storage tanks. PRINTED 0708 186965-000 ...
-
American Water Heater GTS-705-NI - page 2
2 Certifications .................................................................................. 3 Water Quality and Scale ................................................................ 4 Pump Sizing for Circulation .......................................................... 5 T able of Contents Tank Water Heaters in a Circulation Loop Addition ...
-
American Water Heater GTS-705-NI - page 3
3 Approvals Certified to applicable U.S. standards for appliances using gas or other petroleum fuel. Certified to applicable Canadian standards for appliances using gas or other petroleum fuel. Certified by the Uniform Plumbing Code (UPC) Certified by National Sanitation Foundation (NSF), www.nsf.org (indoor models must use the NSF approved top gua ...
-
American Water Heater GTS-705-NI - page 4
4 W ater Quality and Scale A complete water analysis and an unde rstanding of system requirements are needed to prote ct the tankless water heaters and water heating systems from scale. Water analysis shows whether water is hard or soft. Hard water, unless treated, will cause scaling or liming of the heat exchanger. The rate of scaling increases wi ...
-
American Water Heater GTS-705-NI - page 5
5 Pump Sizing for Circulation 1. Use the chart below or one appropriate for your co nditions to determine the heat loss in the length of the hot water supply and return piping. For example, 100 ft of 1-1/2 in bare copper tubing results in a heat loss of 5300 Btu/h. 2. Determine the acceptable temperature drop at the last fixture in the loop. For ex ...
-
American Water Heater GTS-705-NI - page 6
6 T ank W ater Heaters in a Circulation Loop The following applies when using a tank water heater (gas or electric) to provide heat for a circulation loop. Drawing WH-1-RGE is an example. The heat output of the tank must be equal to or greater than the calculated circulation loop heat loss. (Reference page 6, Step 1 on calculating heat loss). Elect ...
-
American Water Heater GTS-705-NI - page 7
The following applies when using tankless water heaters to recover a storage tank. Drawing WH-1-B is an example. Tankless water heaters have a pressure loss which must be considered in the system design. Reference the pressure loss curve for the heater m odel being used to determine the pump size for the desired recovery rate. For recommended pump ...
-
American Water Heater GTS-705-NI - page 8
8 Pressure Loss Curves Pressure Loss (psi) Water Flow (gpm) 0. 0 5. 0 10. 0 15. 0 20. 0 25. 0 30. 0 35. 0 40. 0 45. 0 01 234 56 789 1 0 1 1 0. 0 10. 0 20. 0 30. 0 40. 0 50. 0 60. 0 Pressure Loss (ft head) 705 305 i 505 305 e ...
-
American Water Heater GTS-705-NI - page 9
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-1 Domestic Hot W ater - S tandard Installation 1 Tankless Water Heater Preferred Piping Installation G a s S u p p ly 3 / 4 " C o l d W a t e r ...
-
American Water Heater GTS-705-NI - page 10
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-2 Domestic Hot W ater - S tandard Installation 2 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an engineering ...
-
American Water Heater GTS-705-NI - page 11
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion Ch e c k V a l ve Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-3 Domestic Hot W ater - S tandard Installation 3 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an engineeri ...
-
American Water Heater GTS-705-NI - page 12
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-4 Domestic Hot W ater - S tandard Installation 4 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an engineering ...
-
American Water Heater GTS-705-NI - page 13
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion Ch e c k V a l ve Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-5 Domestic Hot W ater - S tandard Installation 5 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an engineeri ...
-
American Water Heater GTS-705-NI - page 14
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion Ch e c k V a l ve Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-6 Domestic Hot W ater - S tandard Installation 6 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an engineeri ...
-
American Water Heater GTS-705-NI - page 15
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-1-D Domestic Hot W ater - O p t i o n a l F r eeze Protection 1 Outdoor Tankless W ater Heater Preferred Piping Installation June 11, 2007 This is n ...
-
American Water Heater GTS-705-NI - page 16
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-2-D Domestic Hot W ater - O p t i o n a l F r eeze Protection 2 Outdoor Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This ...
-
American Water Heater GTS-705-NI - page 17
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-3-D Domestic Hot W ater - O p t i o n a l F r eeze Protection 3 Outdoor Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This ...
-
American Water Heater GTS-705-NI - page 18
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-6-D Domestic Hot W ater - O p t i o n a l F r eeze Protection 6 Outdoor Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This ...
-
American Water Heater GTS-705-NI - page 19
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-1-RGE Domestic Hot W ater - C i r c u l a t i o n S y s t e m s 1 Tankless W ater Heater with Gas or Electric Tank Preferred Piping Installation Feb ...
-
American Water Heater GTS-705-NI - page 20
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion Ch e c k V a l ve Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-1-R Domestic Hot W ater - C irculation Systems 1 Tankless W ater Heater Optional Piping Installation June 11, 2007 This is not an engineering dra ...
-
American Water Heater GTS-705-NI - page 21
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-2-RGE Domestic Hot W ater - C i r c u l a t i o n S y s t e m s 2 Tankless W ater Heaters with Gas or Electric Tank Preferred Piping Installation Fe ...
-
American Water Heater GTS-705-NI - page 22
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-2-R Domestic Hot W ater - Circulation Systems 2 Tankless W ater Heaters Optional Piping Installation February 27, 2008 This is not an engineering dr ...
-
American Water Heater GTS-705-NI - page 23
23 Domestic Hot Water - Circulation Systems 3 Tankless Water Heaters with Gas or Electric Tank Preferred Piping Installation Tankless Water Heater Tankless Water Heater Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boi ...
-
American Water Heater GTS-705-NI - page 24
24 Tankless Tankless Tankless Tankless Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion Ch e c k V a l ve Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-6-RGE Domestic Hot W ater - C i r c u l a t i o n S y s t e m s 6 Tankless W ater Heaters with Gas or Elec ...
-
American Water Heater GTS-705-NI - page 25
25 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-1-B Domestic Hot W ater - Backup Storage 1 Tankless W ater Heater Preferred Piping Installation February 27, 2008 This is not an engineering draw ...
-
American Water Heater GTS-705-NI - page 26
26 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-1-B-R Domestic Hot W ater - Backup Storage / Circulation 1 Tankless W ater Heater Preferred Piping Installation February 27, 2008 This is not an ...
-
American Water Heater GTS-705-NI - page 27
27 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-2-B Domestic Hot W ater - Backup Storage 2 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an engineering dra ...
-
American Water Heater GTS-705-NI - page 28
28 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion Ch e c k V a l ve Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-2-B-R Domestic Hot W ater - Backup Storage / Circulation 2 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not ...
-
American Water Heater GTS-705-NI - page 29
29 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion Ch e c k V a l ve Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-3-B Domestic Hot W ater - B a c k u p S t o r a g e 3 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an e ...
-
American Water Heater GTS-705-NI - page 30
30 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-3-B-R Domestic Hot W ater - Backup Storage / Circulation 3 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an ...
-
American Water Heater GTS-705-NI - page 31
31 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-6-B Domestic Hot W ater - Backup Storage 6 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an engineering dra ...
-
American Water Heater GTS-705-NI - page 32
32 Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e WH-6-B-R Domestic Hot W ater - Backup Storage / Circulation 6 Tankless W ater Heaters Preferred Piping Installation February 27, 2008 This is not an ...
-
American Water Heater GTS-705-NI - page 33
Drawing Number: Drawing Date: Pres s ure R elief Valv e 3/ 4" Ball Valv e 3/ 4" U nion C hec k Valv e Ke y S Pres s ure R egulat or C irc ulating Pum p Solenoid Valv e Boiler D rain Valv e M-1-F 1 Tankless W ater Heater Maintenance - Scale Flush Procedure June 11, 2007 This is not an engineering drawing; it is intended only as a guide and ...
-
American Water Heater GTS-705-NI - page 34
34 Notes ...
-
American Water Heater GTS-705-NI - page 35
35 Notes ...
-
American Water Heater GTS-705-NI - page 36
• 500 T ennessee Waltz Parkway • Ashland, TN 37015 • ...
Haben Sie eine Frage bezüglich American Water Heater GTS-705-NI?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit American Water Heater GTS-705-NI nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit American Water Heater GTS-705-NI hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.