-
CMA Dishmachines EAH/EC - page 1
Owner’s Manual Keep with machine for reference MODEL EAH/EC MODEL EAH / EC Installation and Operations Manual Revision 1.01 A 800-854-6417 FAX 714-895-2141 CMA DISHMACHINES 12700 KNOTT AVENUE GARDEN GROVE, CALIFORNIA 92841 ...
-
CMA Dishmachines EAH/EC - page 2
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 2 TABLE OF CONTENTS SPECIFICATIONS .................................................................................................................................. 3 EAH / EC Dishmachine ............................................................................ ...
-
CMA Dishmachines EAH/EC - page 3
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 3 SPECIFICATIONS EAH / EC Dishmachine WATER CONSUMPTI ON PER RACK 1.7 GAL. 6.45 L PER HOUR 68 GAL. 212 L OPERATING CYCLE WASH TIME- SEC 45 45 RINSE TIM E-SEC 30 30 DWELL TIME-SEC 15 15 TOTAL CYCLE 90 Sec 90 Sec OPERATING CAPACIT Y RACKS PER HOUR 40 40 WASH TANK CAP ...
-
CMA Dishmachines EAH/EC - page 4
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 4 GETTING STARTED Introduction to EAH and EC CMA dishwash ers have been use d world wide for m any years. This manual has bee n written to help you, the operator, i n your job. Your job is one of the “most important” i n this restaur ant. Why? Your product, the ...
-
CMA Dishmachines EAH/EC - page 5
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 5 WARNING: Electrical and plumbing connections need to be made by a qualified service person who will comply with all available Federal, State, an d local Health, Electrical, Plumbing Safety Codes. SCRAP TRAP ACCUMULATOR CONNECTION: N ot suppl ied wi th Machine ...
-
CMA Dishmachines EAH/EC - page 6
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 6 6. Water Line The model EAH & EC should plumbed wit h ½” hot water line. The tim e necessary to deliver water to the machine is controlled by the number four cam. This c am provides the serviceman with the opportunity to fin e-tune the machine to deliver t ...
-
CMA Dishmachines EAH/EC - page 7
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 7 OPERATION CMA dishwashers have be en used worldwide for many years. This manua l has been written to help you, the oper ator, in your jo b. The manual is divided int o three sections . Sections A and B cover star t-up and di sh handling, and section C covers trou ...
-
CMA Dishmachines EAH/EC - page 8
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 8 Operating Instructions 1. Scraping and Pre-rinse Remove remaini ng food fr om utensils. Sc rape by h and or by usi ng a clean ing tool suc h as a sp onge or rubber spatula . For protect i o n of the hands , w e ar gl oves . Use a pre-rinse hose f or wet scraping ...
-
CMA Dishmachines EAH/EC - page 9
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 9 4. Racking glas ses Glasses, cups, bowl s a nd ot he r deep dishes must be racke d faced dow n. This is so as not to carry out wash water and so the sprays can work on the inte rnal surfaces. Rack gl asses and cu ps in a properly sized compart mentalized gl ass r ...
-
CMA Dishmachines EAH/EC - page 10
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 10 SORTING AND STORING FLA TWARE Stacking and storage o f dish es being washed and sanitized is very important. A dish may be perfectly washed but be completely contam inated from the handling after washing. Avoid storing dishes where they may be soi led. Handling ...
-
CMA Dishmachines EAH/EC - page 11
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 11 Cleaning and Maintenance Certain times of the day s hould be all otted to clea ning the CM A dishwashing machine. F ollow the clean ing and inspection procedures listed below: 1. Cleaning the drain screen Remove the drain screen and thorough ly clean all foreign ...
-
CMA Dishmachines EAH/EC - page 12
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 12 3. Check Operations Operate the machine for one cycle. Wa tch detergent, sanitizer and rinse additive “delivery tubes” at the point where t hey inject chemi cal into the machine. Re member: red t ube – deterge nt; blue tube-rinse; a nd clear white tube-san ...
-
CMA Dishmachines EAH/EC - page 13
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 13 Quick service guide TECHNICAL ISSUE CAUSE SOLUTION Starts with doors open Faulty #1 micro switch (start/stop ) Replace micro switch, P/N 00411 .00 Faulty door switch Replace switch, P/N 00557.55 Faulty #1 micro switch (start/stop) Replace micro switch, P/N 00411 ...
-
CMA Dishmachines EAH/EC - page 14
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 14 Troubleshooting the EAH & EC Will Not Start 1. Check master switch on the control box to make sure that it is “ON”. 2. Check circuit breaker that services the dishw asher. Make sure it is “ON”. 3. After (ONLY after) checking steps 1 and 2, call t ...
-
CMA Dishmachines EAH/EC - page 15
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 15 Machine Will Not Fill Check gate valve on the top of the ma chine. Make sure “handle” has been opened. If it is, call y our CMA service technician. ...
-
CMA Dishmachines EAH/EC - page 16
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 16 EAH/EC Options Door Handle Conversion EAH To EC #00617.30 INSTRUCTIONS: Before handle conversion, place templa te with the upper edge against two upper left fron t pan el holes. Mark the four holes position using a cen ter punch. Drill a 1/8” hole through each ...
-
CMA Dishmachines EAH/EC - page 17
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 17 Door Handle Conversion EC to EAH #00617.20 ITEM NO. NO. REQ’D P/N DESCRIPTION 1 2 00603. 20 Door Sprin g Extensi on Rod 2 1 00613.0 9 Door Ha ndle 3 1 00926. 00 5/16” SS Washer 4 1 01555. 50 L.H. D oor H andle Supp ort 5 1 01556. 50 R.H. Door Han dle Suppor ...
-
CMA Dishmachines EAH/EC - page 18
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 18 ADDENDUM FOR MACHINES INSTAL LED IN THE CITY OF CHICAGO All food dispensing establishmen ts using chlorine or other approved ch emical sanitizers shall at all times maintain an adequate testing device. Dishes and other eating and drin king utensils to be washed ...
-
CMA Dishmachines EAH/EC - page 19
Title Rev 1.00A Installation & Operation Model EAH / EC Dishwasher 01/26/04 Page 19 ELECTRICAL DIAGRAM ...
Haben Sie eine Frage bezüglich CMA Dishmachines EAH/EC?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit CMA Dishmachines EAH/EC nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit CMA Dishmachines EAH/EC hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.