Bedienungsanleitung HP QuarterHorse Series 0.25 hp Portable Chiller PS-025

28 Seiten 0.6 mb
Download

Zur Seite of 28

Summary
  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 1

    PS-025 QuarterHorse Series 0.25 hp Portable Chiller Operation and Installation Manual ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 2

    Page 2 PS QuarterHorse Series Chillers AEC, Inc./Application Engineering is commi tted to a continuing program of product improvement. Specifications, appearance, and dimensions described in this manual are subject to change without notice. © Copyright AEC/Application Engineering and AEC, Inc. 2002 All rights reserved. Effective 9/24/02 ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 3

    PS QuarterHorse Series Chillers Page 3 Safety Considerations PS Series Chillers are designed to provide safe and reliable operation when installed and operated within design specifications, following national and local safety codes. To avoid possible personnel injury or equipment damage when installing, operating or maintaining this equipment, use ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 4

    Page 4 PS QuarterHorse Series Chillers Table of Contents 1 General Information ................................................. 7 1-1 Introduction 1-2 Necessary Documents 1-3 Models Covered 1-4 Available Options 1-5 Uncrating Your New Chiller 1-6 In the Event of Shipping Damages 1-7 If the Shipment is Not Complete 1-8 If the Shipment is Incorrect ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 5

    PS QuarterHorse Series Chillers Page 5 Table of Contents 4 Startup Checklists .................................................. 17 4-1 Introduction 4-2 PS Pre-Startup Checklist 4-3 PS Startup Checklist 5 Microprocessor Control ......................................... 19 5-1 Introduction 5-2 Setting the Process Water Temperature 5-3 Power Switch 6 ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 6

    Page 6 PS QuarterHorse Series Chillers Charts and Figures 1 PS050A Process Pump Curves 10 2 PS Series Chiller Specifications 10 3 Ethylene Glycol Curve 13 4 Overhead Piping 14 ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 7

    PS QuarterHorse Series Chillers Page 7 1 General Information 1-1 Introduction PS Series Water Chillers are reliable, accurate, and easy-to-use air cooled chillers designed for use with water/glycol. Standard range of operation is 50 ° F to 70 ° F (10°C to 21°C). This PS chiller is a ¼ hp (187 W) model and has an internal one gallon (3.8 liter) ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 8

    Page 8 PS QuarterHorse Series Chillers 1-4 Available Options PS Series chillers are available with options that tailor the unit to your requirements. Some are factory installed, some can be retrofitted in the field. Consult your local Application Engineering Sales Representative. Some of these options are: Power Cord A 6 foot (1.8 m) power cord is ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 9

    PS QuarterHorse Series Chillers Page 9 1-6 In the Event of Shipping Damages Important! According to the contract terms and conditions of the Carrier, the responsibility of the Shipper ends at the time and place of shipment. ; Notify the transportation company’s local agent. ; Hold the damaged goods and packing material for the exam ining agent’ ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 10

    Page 10 PS QuarterHorse Series Chillers 1-9 Returns Important! Do not return any damaged or incorrect items until you receive shipping instructions from Application Engineering. Figure 1 PS025 Process Pump Curve 6 0 HE RTZ P UMP CURV E C U R VES R EPR ESEN T PUMP DI SC H A RG E A D JU STE D F OR I N TERN A L B Y -P ASS PS 0 25 - P R O C E S S P U M ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 11

    PS QuarterHorse Series Chillers Page 11 2 Chiller Installation 2-1 Electrical Connections Check serial tag voltage and amperage requirements and m ake sure your electrical service conforms. See Figure 2 on Page 10 for total running amps. ; Electrical connections must comp ly with all applicable electrical codes. ; The chiller must be grounded in ac ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 12

    Page 12 PS QuarterHorse Series Chillers Process Water Bypass All PS chillers have an internal bypass device. If the process flow becomes blocked during chiller operation, this component allows water to flow through the chiller. This protects the chiller from freeze-up, excessive pressures, and pump dam age, and allows other safety features to remai ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 13

    PS QuarterHorse Series Chillers Page 13 ; If you want to use straight water, contact Application Engineering’s, Engineering Department. ; The 1 gallon (3.8 liter) reservoir is not designed to withstand water pressure above 5 psi (34 kPa). ; The fill opening and vent line must be vented to the atm osphere for proper operation. Properly Venting and ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 14

    Page 14 PS QuarterHorse Series Chillers 2-5 Overhead Process Considerations If your application has chilled water or process piping above the reservoir fill and vent level, install a standpipe to a point 1’ (30 cm) above the highest point in the system. In applications where the process or its piping is 15 feet (4.6 m) or more above the reservoir ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 15

    PS QuarterHorse Series Chillers Page 15 3 Sequence of Operation Important! The PS unit has a leaving water temperature range of 50°F to 70°F (10°C to 18°C). Do not attempt to run the PS unit outside this temperature range or damage to the unit may occur . 3-1 Chilled Water Circuit ; Process cooling water supply and return connections are made a ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 16

    Page 16 PS QuarterHorse Series Chillers - Notes - ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 17

    PS-025 QuarterHorse Series 0.25 hp Portable Chiller Operation and Installation Manual ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 18

    Page 18 PS QuarterHorse Series Chillers - Notes - ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 19

    PS QuarterHorse Series Chillers Page 19 5 Microprocessor Control 5-1 Introduction Standard PS Series chillers use a microprocessor based controller. The controller is a modular, self-contained unit that can slide from its m ounting housing. It is factory set and adjusted; no field adjustment to the internal controls is necessary. 5-2 Setting the Pr ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 20

    Page 20 PS QuarterHorse Series Chillers - Notes - ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 21

    PS QuarterHorse Series Chillers Page 21 6 Routine Maintenance 6-1 Lubrication Every three months, grease all fan motors and pum p motors that do not have permanently sealed bearings. Remove grease relief plug (m otors only) before adding grease. Failure to do so may result in dislodging the bearing grease retainer, eventually causing bearing failur ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 22

    Page 22 PS QuarterHorse Series Chillers - Notes - ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 23

    PS QuarterHorse Series Chillers Page 23 7 Troubleshooting Guide Problem Possible cause Solution No power. Check main disconnect fuses, wiring, and power lead to the unit. Wrong voltage supplied to the chiller. Voltage must be within plus or minus 10% of the nameplate rating. Defective on/off switch. Replace. Control circuit fuse blown. Replace, che ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 24

    Page 24 PS QuarterHorse Series Chillers Service Notes ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 25

    PS QuarterHorse Series Chillers Page 25 Service Notes ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 26

    Page 26 PS QuarterHorse Series Chillers Parts Department Call toll-free 7am–6pm CST [ 800 ] 423-3183 or call [ 847 ] 273 - 7700 The AEC/Application Engineering Parts Depar tment at AEC, Inc. is ready to prov ide the parts to keep your systems up and running. AEC/Application Engineeri ng replacement parts ens ure operation at design specifications ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 27

    Warranty AEC, Inc. warrants all equipment manufactured by it to be free from defects in workmanship and material when used under recomme nded conditions. The Company’s obligation i s limited to repair or replace FOB the factory any parts that ar e returned prepa id within one year of equipment shipment to the original purcha ser, and whic h, in t ...

  • HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - page 28

    801 AEC Drive • Wood Dale, IL 60191-1198 USA (630) 595-1060 • Fax (630) 595-6641 http://www.aecinternet.com ...

Produzent HP Kategorie Refrigerator

Dokumente, die wir vom Produzenten des Geräts HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen HP
- Bedienungsanleitungen QuarterHorse Series 0.25 hp Portable Chiller PS-025
- Produktkarten HP
- Informationsbroschüren
- oder Energieetiketten HP QuarterHorse Series 0.25 hp Portable Chiller PS-025
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung HP QuarterHorse Series 0.25 hp Portable Chiller PS-025.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen HP QuarterHorse Series 0.25 hp Portable Chiller PS-025, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen HP QuarterHorse Series 0.25 hp Portable Chiller PS-025. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 ansehen.

Die komplette Bedienungsanleitung des Geräts HP QuarterHorse Series 0.25 hp Portable Chiller PS-025, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 verständlich ist.

Eine gänzliche Bedienungsanleitung von HP sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich HP QuarterHorse Series 0.25 hp Portable Chiller PS-025, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 - die uns die ersten Schritte während der Nutzung von HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich HP QuarterHorse Series 0.25 hp Portable Chiller PS-025?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit HP QuarterHorse Series 0.25 hp Portable Chiller PS-025 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)