Bedienungsanleitung Char-Broil 463248208

32 Seiten 5.83 mb
Download

Zur Seite of 32

Summary
  • Char-Broil 463248208 - page 1

    THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your grill online at www.grillregistration.com 1-888-430-7870 463248208 • 80065464 • 04-02-08 CA UTION: Read and follow all safety statements, assembly instructions, and ...

  • Char-Broil 463248208 - page 2

    2 • 463248208 WARNING CALIFORNIA PROPOSITION 65 1. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer, birth de ...

  • Char-Broil 463248208 - page 3

    T ABLE OF CONTENTS WARNING Do not attempt to repair or alter the hose/valve/regulator for any “assumed” defect. Any modification to this assembly will void your warranty and create the risk of a gas leak and fire. Use only authorized replacement parts supplied by manufacturer. To insure your satisfaction and for follow-up service, register your ...

  • Char-Broil 463248208 - page 4

    • NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death. • If you s ...

  • Char-Broil 463248208 - page 5

    WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. T urn all control knobs to the OFF position. 3. T urn LP cylinder OFF by turning hand-wheel clock ...

  • Char-Broil 463248208 - page 6

    6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE: If you cannot complete the connection, discon ...

  • Char-Broil 463248208 - page 7

    WARNING For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly . • Use grill only in well-ventilated space. NEVER use in enclosed space such as carpor ...

  • Char-Broil 463248208 - page 8

    Sideburner Ignitor Lighting s Do not lean over grill while lighting. 1. 2. Open sideburner lid. T urn on gas at LP cylinder . 3. T urn sideburner knob to HIGH , push and hold ELECTRONIC IGNITOR button. 4. If sideburner does NOT light, turn knob to OFF , wait 5 minutes, then repeat lighting procedure. Sideburner Match Lighting 1. 2. Open sideburner ...

  • Char-Broil 463248208 - page 9

    Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting grill. 1. Turn gas off at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove screws and carryover tubes from rear of burners. 4. Remove screw and washers to disengage burner from br ...

  • Char-Broil 463248208 - page 10

    Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry . Separate: Separate raw meats and poultry from ready-to-eat foods to avo ...

  • Char-Broil 463248208 - page 11

    CARE AND CLEANING OF YOUR ST AINLESS STEEL GRILL Routine cleaning is necessary to preserve the appearance and corrosion resistance of Stainless Steel. The perception that many people have is that stainless steel will not rust. That is not the case in certain conditions. Rust marks are regular steel particles that have become attached to the surface ...

  • Char-Broil 463248208 - page 12

    12 • 463248208 This Page Intentionally Blank. ...

  • Char-Broil 463248208 - page 13

    P ARTS LIST – Model No. 463248208 Key Qty Description Part # QQ 4 Flame T amers. . . . . . . . . . . . . . . . . . . . 80016301 R R 1 T a n k W i r e .......................8 0 0 0 8 1 8 8 SS 4 Quantum Infrared Cooking Grates . . . . 80016756 TT 1 W arming Rack . . . . . . . . . . . . . . . . . . . 80006753 UU 1 Sideburner Grate . . . . . . . . . ...

  • Char-Broil 463248208 - page 14

    P ARTS DIAGRAM – Model No. 463248208 MM TT LL KK QQ W N R S M D DD CC AA BB UU BBB X T U Y X Z OO NN O J VV K H P OO F G B C A B C RR PP Q I FF GG E EE HH II JJ 2 JJ 1 JJ 3 YY L ZZ AAA SS YY ZZ WW 14 • 463248208 V XX CCC DDD ...

  • Char-Broil 463248208 - page 15

    ASSEMBL Y – Model No. 463248208 2 1/4-20x1/2” screw 1 Attach side panels to bottom shelf using three 1/4-20x1/2” screws, 7mm lock washers, and 7mm flat washers per panel. IMPORTANT: Panel with large hole must Be on left side of bottom shelf. 7mm lock washer 7mm flat washer Left side panel (with large hole) 80006577 Right side panel Attach the ...

  • Char-Broil 463248208 - page 16

    3 4 This step requires two people to lift and position grill head onto cart. Carefully lower the grill head onto the cart, aligning slots at bottom of grill head with posts on cart side panels. Make sure the regulator hose is hanging outside the cart. Grill head must face open side of cart. Place lower back panel between side panels at rear of bott ...

  • Char-Broil 463248208 - page 17

    6 On back of grill, place upper back panel between side panels and above lower back panel. Secure upper back panel, in lower holes, using one 1/4-20x1½” screw , 7mm lock washer , and 7mm flat washer on each side. Do not fully tighten screws until side shelf installation is complete in later steps. 5 1/4-20x1½” screw 7mm lock washer 7mm flat w ...

  • Char-Broil 463248208 - page 18

    7 1/4-20x1½” screw 7mm flat washer 1/4-20x3/4” screw 7mm lock washer 7mm flat washer 7mm lock washer 1/4-20x3/4” screw 7mm lock washer 7mm flat washer Tabs into holes Right side shelf Fascia, right side shelf Insert tabs on right side shelf into rectangular slots in side of firebox shown ( A) . Attach rear of shelf using one 1/4-20x3/4” sc ...

  • Char-Broil 463248208 - page 19

    8 Insert tabs on left sideburner shelf assembly into rectangular slots in side of firebox shown ( A ). Attach rear of shelf using one 1/4-20x3/4” screw , 7mm lock washer , and 7mm flat washer in upper hole shown ( B ). Use one 1/4-20x1½” screw , 7mm lock washer , and 7mm flat washer in lower hole shown ( B ). Attach front of shelf and fascia u ...

  • Char-Broil 463248208 - page 20

    #8-32x3/8” screw 4mm lock washer Control knob Control knob bezel Sideburner valve bracket Screws and Washers removed from valve bracket Sideburner fascia Valve stem 8a A) Insert the Electronic Ignition module into the hole of B) Insert AA battery into ignitor module, negative (—) end first, screw on the ignition button. C) Connect main burner i ...

  • Char-Broil 463248208 - page 21

    11 Insert sideburner burner into left shelf, making sure burner tube engages sideburner valve (A) . Center stud on bottom of burner fits into center hole in burner pan on shelf. See illustration C for proper burner-to-valve engagement. Secure burner to pan using two #10-24x3/8” screws, 5mm lock washers, and 5mm flat washers (B) . A Burner tube Va ...

  • Char-Broil 463248208 - page 22

    13 Burner cap Sideburner cooking grate Sideburner griddle Place burner cap onto sideburner . Attach sideburner cap clip and sideburner cooking grate into holes in drip pan. Next, place griddle onto shelf. B Sideburner cap clip 14 Inside of cart, insert rear shield tabs into two left slots between upper and lower back panels. Attach left and center ...

  • Char-Broil 463248208 - page 23

    Tank Wire A B 15 Insert end of tank wire (without hole) into back of lower back panel. Attach other end to bottom of front brace with a #8x3/8” self-tapping screw . 16 C Door Brace A B Tank Exclusion Wire Frame Insert wire ends into lower back panel (A) . Attach front right side of wire shelf to the right side panel with one #8-32x3/8” screw , ...

  • Char-Broil 463248208 - page 24

    17 Attach both doors using four #8-32x3/8” flat head screws and one #8x3/8” self-tapping screw . Right door 18 Install flame tamers by sliding one end of each flame tamer into slots at front of firebox and resting opposite end on pins in back of firebox. Back of firebox Front of firebox Flame tamer Note: Some parts not shown for illustration pu ...

  • Char-Broil 463248208 - page 25

    Assembled warming rack Warming rack Cooking grate 19 Place cooking grates onto the firebox as shown. Insert the three wire ends at rear of warming rack into holes in back of firebox. Front wires of warming rack rest on sides of firebox. Note: Some parts not shown for illustration purpose 20 LP CYLINDER IS SOLD SEPARATELY. Fill and leak check the cy ...

  • Char-Broil 463248208 - page 26

    21 On back of grill, slide grease tray into opening in upper back panel. Grease tray CA UTION Failure to install grease tray will cause hot grease to drip from bottom of grill with risk of fire or property damage. 26 • 463248208 ...

  • Char-Broil 463248208 - page 27

    + – EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire coming through control panel. Grease fire o ...

  • Char-Broil 463248208 - page 28

    Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor . (See Electronic Ignition T roubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s)). Unable to fill LP cylinder . One burner does not light from oth ...

  • Char-Broil 463248208 - page 29

    Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when ignition button is pushed; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when ignition switch is pushed; noise can be heard from spark module. SECTION III Sparks are present but not at all electrodes an ...

  • Char-Broil 463248208 - page 30

    LIMITED W ARRANTY Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require that defective par ...

  • Char-Broil 463248208 - page 31

    Mail to: / Envíelo a: Consumer W arranty Service P . O. Box 1240 Columbus, GA 31902-1240 Thank you for completing this questionnaire. Y our answers will help us and other companies reach you with of fers that may interest you. If you prefer not to receive these offers, please check here . Gracias por completar este cuestionario. Sus respuestas nos ...

  • Char-Broil 463248208 - page 32

    ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-888-430-7870 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Grilling Safety Checklist Read and understand owners manual. Never overfill LP cylinder . Overfilled cylinders ma ...

Produzent Char-Broil Kategorie Outdoor Cart

Dokumente, die wir vom Produzenten des Geräts Char-Broil 463248208 erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Char-Broil
- Bedienungsanleitungen 463248208
- Produktkarten Char-Broil
- Informationsbroschüren
- oder Energieetiketten Char-Broil 463248208
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Char-Broil 463248208.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Char-Broil 463248208, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Char-Broil 463248208. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Char-Broil 463248208 ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Char-Broil 463248208, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Char-Broil 463248208 hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Char-Broil 463248208 verständlich ist.

Eine gänzliche Bedienungsanleitung von Char-Broil sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Char-Broil 463248208 bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Char-Broil 463248208 befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Char-Broil 463248208, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Char-Broil 463248208 - die uns die ersten Schritte während der Nutzung von Char-Broil 463248208 erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Char-Broil 463248208 hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Char-Broil 463248208 im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Char-Broil 463248208?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Char-Broil 463248208 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Char-Broil 463248208 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Kommentare (0)