-
Clarke SPS-28 - page 1
Form No. 70466A 11/02 Clarke ® Printed in the U.S.A. READ THIS BOOK This book has important information for the use and safe operation of this machine. Failure to read this book prior to operating or attempting any service or maintenance procedure to your Clarke machine could result in injury to you or to other personnel; damage to the machine or ...
-
Clarke SPS-28 - page 2
Page 2 Clarke ® Model SPS-28 Space Sweeper Operator's Manual Table of Contents Operator Safety Instructions ................................................................................... 3 Operator Safety Instructions Battery Powered Machine .......................................... 4 Introduction & Machine Specifications .......... ...
-
Clarke SPS-28 - page 3
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 3 OPERATOR SAFETY INSTRUCTIONS DANGER means: Severe bodily injury or death can occur to you or other personnel if the DAN- GER statements found on your machine or in your Owner's Manual are ignored or are not adhered to. Read and observe all DANGER statements found in your Owner& ...
-
Clarke SPS-28 - page 4
Page 4 Clarke ® Model SPS-28 Space Sweeper Operator's Manual CAUTION: Connect or disconnect the battery plug only when the charger supply cord is disconnected or arcing and burning may result. CAUTION: D o not expose to rain. Replace defective cords immediately. If the charger is dropped or other- wise damaged, inspect it thoroughly. CAUTION: ...
-
Clarke SPS-28 - page 5
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 5 INTRODUCTION The Model SPS-28 will effectively and efficiently sweep your floors at minimum cost, provided you operate this machine with reasonable care and maintain it in accordance with the intructions contained in this operator's manual. SPECIFICA TIONS Gasoline Engine (Mode ...
-
Clarke SPS-28 - page 6
Page 6 Clarke ® Model SPS-28 Space Sweeper Operator's Manual How to Prepare The Machine for Operation Model 28G (Gasoline Powered) NOTE: Do not attempt to operate the CLARKE Model SPS-28 before reading the instructions in this manual. WARNING: T o prevent injury , always wear protec- tive clothing. Do not wear loose cloth- ing. Before startin ...
-
Clarke SPS-28 - page 7
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 7 How to Prepare The Machine for Operation 1. Before starting the SPS-28B lift the battery box cover and make sure the battery cables are connected. 2. Place all controls in "NEUTRAL". 3. Turn OFF/ON switch to "ON" position. (Switch is located on left side, below h ...
-
Clarke SPS-28 - page 8
Page 8 Clarke ® Model SPS-28 Space Sweeper Operator's Manual HOW TO OPERATE THE MACHINE NOTE: Do not attempt to operate the CLARKE Model SPS-28 before reading the instructions in this manual. WARNING: To prevent injury , always wear protec- tive clothing. Do not wear loose cloth- ing. WARNING: Do not check the engine oil level when the engine ...
-
Clarke SPS-28 - page 9
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 9 HOW TO OPERATE THE MACHINE (cont) How to Operate the Side Broom (Optional): 1. Engage the side broom in "SWEEP" position by grasping the head assembly, pulling forward and rotating downward until the pin in the arm assembly is against the stop on the locating collar. Turn ...
-
Clarke SPS-28 - page 10
Page 10 Clarke ® Model SPS-28 Space Sweeper Operator's Manual HOW TO OPERATE THE MACHINE (cont) How to Empty Debris Hopper: WARNING: T o prevent injury , always stop the en- gine or motor before you empty the hoppers or clean the filter. 1. Grasp the hopper by the handle provided and lift out until clear of frame. 2. Dump debris in appropriat ...
-
Clarke SPS-28 - page 11
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 11 SPS-28 Space Sweeper (INCL UDES 28G & 28B) Section II Part s and Service Manual (70466A) Division of ...
-
Clarke SPS-28 - page 12
Page 12 Clarke ® Model SPS-28 Space Sweeper Operator's Manual SERVICE AND MAINTENANCE WARNING: Maintenance and repairs must be done by authorized personnel only. Keep Adjustments according to specifications. WARNING: T o prevent injury always stop the en- gine or motor before doing any mainte- nance or repairs to this machine. Sepa- rate the ...
-
Clarke SPS-28 - page 13
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 13 Drive Belts WARNING: T o prevent injury always stop the engine or motor before doing any maintenance or repairs to this ma- chine. The drive belts are automatically tensioned by a spring- loaded idler wheel. (See Fig. 9) 1. Remove the idler pulley tension spring. 2. Slip the belt o ...
-
Clarke SPS-28 - page 14
Page 14 Clarke ® Model SPS-28 Space Sweeper Operator's Manual Installation of New Main Brush (cont) Remove the three screws and washers and the bristle strip retained by them. Install the new strip and assemble the retaining screws and washers. Be sure to install the "V" of each strip in the same relation to the core as its companio ...
-
Clarke SPS-28 - page 15
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 15 Cap acitor T est If a commercial capacitor checker is not available, the following test may be made: 1. Briefly short the capacitor terminals together with a screwdriver . 2. Disconnect a wire from either capacitor terminal. 3. Adjust an ohmmeter to a high value such as RX10K or RX ...
-
Clarke SPS-28 - page 16
Page 16 Clarke ® Model SPS-28 Space Sweeper Operator's Manual Clarke ® Model SPS-28 Main Frame, Brush Assembly and Drive System Drawing 1/99 87 86 95 28 42 77 75 76 74 4 5 6 24 25 26 71 96 70 3 96 4 78 22 36 67 37 22 88 49 32 33 62 69 49 60 25 57 56 55 52 54 53 90 34 52 51 82 65 49 82 84 83 82 73 4 4 5 6 25 26 70 31 24 69 68 74 3 81 42 95 94 ...
-
Clarke SPS-28 - page 17
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 17 Clarke ® Model SPS-28 Main Frame, Brush Assembly and Drive System Parts Lists 1/99 Ref # Part No. Description Qty 1 790322 Arm, Lower Clutch, R.H. 1 2 925543 Pin, 1 / 8 x 1¼ Roll 3 3 920349 Nut, ¼-20 3 4 920160 Nut 5 / 16 - 18 Hx Jam 6 5 980652 Washer 5 / 16 Lock 3 6 791323 Bloc ...
-
Clarke SPS-28 - page 18
Page 18 Clarke ® Model SPS-28 Space Sweeper Operator's Manual Clarke ® Model SPS-28 Engine, Dust Control & Handle Assembly Drawing 11/02 34 11 31 41 42 26 11 27 39 37 38 37 36 35 34 33 32 31 30 29 28 43 45 44 43 84 89 86 87 88 85 83 26 13 95 14 16 26 90 18 19 21 20 83 34 1 77 34 7 82 34 6 5 4 96 55 3 17 91 83 92 8 9 94 25 11 10 11 12 68 ...
-
Clarke SPS-28 - page 19
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 19 Clarke ® Model SPS-28 Engine, Dust Control & Handle Assembly 11/02 Ref # Part No. Description Qty 1 60072A F r am e , Main 1 2 792920 Engine, 5 H.P . Br iggs and Stratton 1 3 285161 Label, Gasoline 1 4 722824 Elbow , ¼ x 45° Street Brass 1 5 755721 Nipple, ¼ x 2½" Bra ...
-
Clarke SPS-28 - page 20
Page 20 Clarke ® Model SPS-28 Space Sweeper Operator's Manual Clarke ® Model SPS-28 Hopper and Optional Sidebroom Assembly Drawing 11/02 49 34 BOTTOM TO P 27 28 51 52 50 53 54 55 52 OPTIONAL SIDE BROOM ASSEMBL Y 62 43 43 44 45 46 41 48 13 40 39 38 37 57 58 61 32 33 33 32 35 36 29 30 31 20 42 14 64 65 26 47 7 6 5 2 25 6 7 3 8 3 66 13 14 64 65 ...
-
Clarke SPS-28 - page 21
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 21 Clarke ® Model SPS-28 Hopper and Optional Sidebroom Assembly Parts List 11/02 Ref # Part No. Description Qty 1 30313A Hopper 1 2 798529 Suppor t, Hopper T op 1 3 930090 Rivet, 5 / 32 Dia. 8 5 793921 Handle, Hopper 1 6 798203 Spacer , Carrying Handle 2 7 962568 Screw , 5 / 16 -18 x ...
-
Clarke SPS-28 - page 22
Page 22 Clarke ® Model SPS-28 Space Sweeper Operator's Manual Clarke ® Model SPS-28 Battery P owered Model Dra wing 1/99 7 5 14 14 13 11 12 16 11 12 16 18 17 46 26 45 44 55 37 36 24 3 49 43 12 11 19 19 21 36 20 6 27 26 50 24 22 54 25 2 53 23 51 1 28 29 30 31 32 33 34 35 40 42 36 41 39 38 47 48 36 37 41 52 23 30 30 4 ...
-
Clarke SPS-28 - page 23
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 23 Clarke ® Model SPS-28 Battery P owered Model Dra wing 1/99 Ref # Part No. Description Qty 1 60071A Co v e r Assembly , Batter y Access 1 2 962003 Screw , 6 / 32 x 3 / 8 Rd. Hd. 4 3 930093 R i v et, 1 / 8 x 1 / 4 - 5 / 16 Po p 4 4 871376 Battery , 95 Amp Hr . (W et) 2 871377 Batter ...
-
Clarke SPS-28 - page 24
Page 24 Clarke ® Model SPS-28 Space Sweeper Operator's Manual Clarke ® Model SPS-28 Wiring Diagram & Electrical Schematic 1/99 ...
-
Clarke SPS-28 - page 25
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 25 Clarke ® Model SPS-28 Wiring Diagram 1/99 Ref # Part No. Description Qty 1 871376 Batter y , 95 amp Hr . (W et) 2 871377 Battery , 95 amp Hr . (Dry) 2 2 41207A Cable, Battery 1 3 911470 Connector 1 4 951006 Wire Assembly 1 5 855607 Hour Meter (Optional) 1 6 911440 Circuit Breaker ...
-
Clarke SPS-28 - page 26
Page 26 Clarke ® Model SPS-28 Space Sweeper Operator's Manual NOTE S ...
-
Clarke SPS-28 - page 27
Clarke ® Model SPS-28 Space Sweeper Operator's Manual Page 27 CLARKE PRODUCT SUPPORT BRANCHES PRODUCTION F ACILITIES AL T O Danmark A/S, Aalborg Blytaekkervej 2 DK-9000 Aalborg +45 72 18 21 00 AL T O Danmark A/S, Hadsund Industrikvarteret DK-9560 Hadsund +45 72 18 21 00 SALES SUBSIDIARIES AL T O US - Canada, Ontario (Canada) 4080 B Sladeview ...
-
Clarke SPS-28 - page 28
Clarke ® LIMITED U.S. W ARRANTY This Clarke Industrial/Commercial Product is warranted to be free from defects in materials and workmanship under normal use and service for a period of one year from the date of purchase, when operated and maintained in accordance with Clarke's Maintenance and Operations instructions. This warranty is extended ...
Haben Sie eine Frage bezüglich Clarke SPS-28?
Nutzen Sie das untere Formular
Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Clarke SPS-28 nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Clarke SPS-28 hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.