Deutsch dropdown-ico

Bedienungsanleitung Lennox Hearth 32FS

36 Seiten 5.34 mb
Download

Zur Seite of 36

Summary
  • Lennox Hearth 32FS - page 1

    INST ALLA TION AND OPERA TION MANUAL Report No. 3105656MID Save These Instructions For Future Reference Fr ee -S ta nd in g Pe ll et S to ve P/N 775 ,196 M, R ev . NC , 06 /200 8 Pe ll et S to ve Mo de l Mo nt ag e™ 3 2F S W ARNINGS • Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will retain heat f ...

  • Lennox Hearth 32FS - page 2

    IM POR T ANT SA F ET Y AND W AR NI IN G IN FOR MA TI ON REA D T HIS MA NUA L I N I TS ENT IRE TY AND UN DER - ST AND THE SE RUL ES TO FOL LOW FO R S AFET Y . 2 W ARNING Do not attempt to alter or modify the construction of the appliance or its components. Any modification or alteration may void the warranty , certification and listings of this un ...

  • Lennox Hearth 32FS - page 3

    3 Please read and carefully follow all of the instructions found in this manual. Please pay special attention to the safety instructions provided in this manual. PRODUCT IS SUBJECT TO CHANGE WITHOUT NOTICE CONGRA TULA TIONS! When you purchased your new pellet stove, you joined the ranks of thousands of individuals whose answer to their home heating ...

  • Lennox Hearth 32FS - page 4

    4 W ARNING Ele ctr ica l gro und ing inst ruc tio ns: This appl ian ce is equ ipp ed wit h a three -pr ong (gr oun din g) plug for you r prot ect ion aga ins t sho ck haz ard and s hou ld be pl ug ge d di r ec tl y i nto a pr op er ly g r ou nd ed t hr ee -p ro ng re cep tac le. Do no t cu t o r re mo ve t he gro und in g pr on g fro m th is plug . ...

  • Lennox Hearth 32FS - page 5

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 5 U p t o * 6 ” ( 1 5 3 mm ) 6 ” ( 1 53 m m ) m i n. 6 ” ( 1 53 m m ) m i n. 6 ” ( 1 5 3 m m) m i n. Fi gur e 1 - F lo or Pro te cti on Re qui rem en ts *Note: When installed at clearances less than 6”, the floor protection is only required to extend to the wall. Rear Front T op View F ...

  • Lennox Hearth 32FS - page 6

    6 INST ALLA TION TIPS GOOD INST ALLA TION: Horizontal Installation (Direct Vent - Outside W all) No natural draft. Wind pressures may affect operation PLEASE REVIEW THIS ENTIRE INST ALLA TION AND OPERA- TION MANUAL FOR ADDITIONAL INSTRUCTIONS. BETTER INST ALLA TION: Vertical & Horizontal Installation (Up and Out) Some natural draft aids venting ...

  • Lennox Hearth 32FS - page 7

    7 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE In addition to the standard installation instructions, the following instruc- tions may be required by local, state or federal building codes: • Installation should be in accordance with the Manufactured Home and Safety Standard (HUD), CFR 3280, Part 24. • Th e sto ve must be per man en tly ...

  • Lennox Hearth 32FS - page 8

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 8 Removing Appliance From Pallet 1. After removing the packaging from the stove, lift the hopper lid, and remove all prepackaged items that were shipped in the hopper . Next, open the stove door and remove all prepackaged items. 2. With the stove door open, remove the ash drawer and set aside. Us ...

  • Lennox Hearth 32FS - page 9

    9 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE IMPOR T ANT NOTE: Install the thermost at per the manufact urers instruc- tions, provided with the thermostat. Failure to follow manufacturers instructions could result in a malfunction. Pay special attention to the thermostat location requirements. If the location requirements are not adhered ...

  • Lennox Hearth 32FS - page 10

    10 VENTING REQUIREMENTS It is recommended that only an Lennox Hearth Products dealer install your pellet stove. The specified installation requirements must be followed to ensure conformity with both the safety listing of the appliance and local building codes. All clearances, installation instructions and precautions specified by the vent manufa ...

  • Lennox Hearth 32FS - page 11

    11 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE Vent T ermination Locations A = Clearance above grade, veranda, por ch, deck, or bal- cony (min. 12”/30cm) B = Clea ranc e to windo w or door tha t may be opene d (m in. 12”/30cm above - 48”/1.2m below and to the side) C = Clearance to permanently closed window *(min. 12”/30cm) D = V e ...

  • Lennox Hearth 32FS - page 12

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 12 Figure 11 - Manufactured Home Chimney Height Requirements Chimney Height Requirements - Site Built Residential Home The vent termination height required is - USA, 1-foot minimum; Canada 3-feet minimum above the roof penetration point as illustrated below (Ref. USA - National Standard, NFP A 21 ...

  • Lennox Hearth 32FS - page 13

    13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE Determining Size Of Pipe T o Install T o determine what diameter pipe to use in an installation (3” or 4”), first find the “equivalent pipe length” using the following guidelines, then plot this number and the altitude on the chart ( Figure 13 ). Fill out the installation chart, and ...

  • Lennox Hearth 32FS - page 14

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 14 Exhaust Port Quick Disconnect Straight “PL -vent” Pipe Combustion Air Inlet Collar Metal Fresh Air Pipe L y therm Gasket W all Thimble 45˚ Elbow Holes through the W all for the Thimble & Fresh Air Pipe 45 o Degree Elbow Joint for Fresh Air Pipe 12” (305 mm) Min. From Outer Wall 12? ...

  • Lennox Hearth 32FS - page 15

    15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE No tes : • It is not rec omm end ed to ter min ate ex hau st ven t on th e pr eva ili ng wind si de of th e h ous e. Wall 3” (75 mm) Minimum clearance between wall and pipe. If you vent to the furthest wall, the vent pipe must maintain a 3” clearance parallel to the other wall. T op View ...

  • Lennox Hearth 32FS - page 16

    16 FPO W al l S tr ap s Re qu ire d Ev ery 4 Fe et Mi ni mu m Standard Vertical Installation Configurations Model: Mont a ge™ 32FS This free-standing model may be connected to an existing flue or by installing listed type “PL” vent pipe. If a liner is run all the way to the top of the existing chimney , the existing flue should be sealed w ...

  • Lennox Hearth 32FS - page 17

    17 CARE AND OPERA TION Simple Operating Instructions 3. Priming the Auger (Optional) a] Fill hopper with pellets Note: use quality grade pellet fuel b] Push the "ST ART" button to turn on the blowers and auger motor e] When pellets begin to drop from feed tube into UltraGrate, push the "STOP" button to stop the auger 1. Start 4. ...

  • Lennox Hearth 32FS - page 18

    18 Control Board Operation ST ART BUTTON The "ST ART" Button turns on the pellet stove. If the exhaust does not reach operati ng temper a- ture within 30 minutes, the stove will automati- cal ly shut down. The pell et sto ve can be resta rted by pushing the "ST ART" Button again. REST ART AUGER ON (green LED) - The auger restart ...

  • Lennox Hearth 32FS - page 19

    19 General Operating Considerations Proper Burn Characteristics: Y our flame should be bright yellow under normal operations. If your flame becomes reddish/orange, your stove probably needs routine maintenance. Excessive amounts of fly-ash build- up in the UltraGrate, clinkers in the UltraGrate, or leakage of air if the UltraGrate is not properl ...

  • Lennox Hearth 32FS - page 20

    20 T urning Off Y our Stove Press the "STOP" button to initiate the shut down cycle (auger LED will be red). The pellets will stop feeding and the blowers will continue to run on a timed cycle. The stove will shut down safely upon completion of the shut down cycle. Shutdown Mode - When the thermostat opens (not calling for heat), or the a ...

  • Lennox Hearth 32FS - page 21

    21 Fuel Specifications - Using the Ultragrate™ burn system, this appliance has been designed to burn wood residue pellets only (with up to 3% ash content). Agricultural pellets (i.e. corn, alfalfa etc.) are not permitted to be burned in the stove. Dirty fuel will adversely affect the per formance of the stove. The pellet fuel should meet P .F .I ...

  • Lennox Hearth 32FS - page 22

    22 Heat Exchange T ubes T ube Scraper - Using the hole in the handle of the Grate Scraper T ool “grab” the scraper rod as shown in Figure 26 . Using the Grate Scraper T ool, pull the rod up and out towards the opening of the firebox. Con - tinue pulling until the T ube Scraper reaches the top of the firebox. Pull the tube scraper out, then re ...

  • Lennox Hearth 32FS - page 23

    23 Ash Clean-out Ports IMPORT ANT NOTES: • ENSURE APPLIANCE IS COLD BEFORE BEGINNING. • FIREBRICK P ANEL MUST BE INST ALLED BEFORE OPERA TING UNIT . • ASH CLEAN-OUT PORTS MUST BE CLEANED OUT AS P ART OF ROUTINE MAINTENANCE. Accessing Ash Clean-Out Ports 1) Open firebox door . 2) Remove Firebrick Panel (see Figure 24A ) : a. Remove the two ? ...

  • Lennox Hearth 32FS - page 24

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 24 Figure 29 - Inspect UltraGrate and Clean if Necessary ( Re c o m m e nd e d F r eq u e n c y o f 1 d a y – 2 w e e ks ) UltraGrate Ash Slide Plate Ash that accumulates around the grate can be “dropped” into the ash pan as follows: 1. Open the firebox door . 2. Pull open the ash release ...

  • Lennox Hearth 32FS - page 25

    25 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE Motor Lubrication The blowers are permanently lubricated by the manufacturer . Do not apply oil to any part of the blower , doing so may cause damage. Blower Cleaning Clean the air holes on the motors of both the exhaust and room air blowers annually . Remove the exhaust blower from the exhaus ...

  • Lennox Hearth 32FS - page 26

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 26 Flue Size 3” (76 mm) Rear Floor Protection Front and Sides: 6”(152 mm) Requirements Back: Up to 6”(152 mm) u Hopper Capacity 55 Lbs. v Burn time 15 - 37 hours v Fuse, Control Board 5 Amp, 250 volt, 3AG w Fuse, Igniter 6 Amp, 125 volt w Heat Input 13,000 - 32,000 BTU/hr v (BTU’ s per ho ...

  • Lennox Hearth 32FS - page 27

    27 • Air Wash A small slot in the door that allows room air to be pulled into the firebox and pours over the inside sur face of the door glass to inhibit the build up of soot. • Auger A motor powered screw device that transfers the fuel from the hopper to the feed chute to deliver pellets to the UltraGrate™. • Auger Motor Drives the Auger ...

  • Lennox Hearth 32FS - page 28

    28 P R OB L E M C A US E ( S ) S O LU T I O N S 1. F i re b u r n s w i t h a l a z y o ra n g e fl am e . P e ll e t s b ui l d u p i n t h e a n d t h e r e i s e x c e ss i v e g la s s s o ot t h a t i s d i f fic u l t t o r e mo v e ( A sh a n d so o t a r e a p r o d uc t o f co m b u s t io n w i t h a n y w o o d pr o d u c t s, s o s o ...

  • Lennox Hearth 32FS - page 29

    29 P R OB L E M C A U SE ( S ) S O LU T I O N S 4 . B l o w e r s w i l l no t o p e r at e w h e n t h e O N/ O F F s ta r t b u tt o n i s d e p r e s se d . A) There is no power to the stove. B) There is no power to the control board. C) The low limit thermal switch has failed in the closed position. A) Check that the stove is plugged in to the ...

  • Lennox Hearth 32FS - page 30

    30 REPLACEMENT P ARTS LIST - MONT AGE™ 32FS Contact an Authorized Lennox Hearth Products dealer to obtain any of these parts. Never use substitute materials. Use of non- approved parts can result in poor performance and safety hazards. DOOR P ARTS Item # Cat. No. Description 1 H7045 Door Assembly 2 H7046 Face Assembly 3 H7047 Door Handle Assembly ...

  • Lennox Hearth 32FS - page 31

    31 REPLACEMENT P ARTS LIST - MONT AGE 32FS 13 46 19 14 33 47 12 49 5 11 15 17 50 9 21 16 18 20 4 10 52 38 ADD WALL THERMOST A T 39 WIRE, THERMOST A T 48 ADD P AINT TOUCH UP 52 ADD CLEANING BRUSH 34 38 Includes 20 feet of thermostat wire 8 6 1 7 3 2 52 ...

  • Lennox Hearth 32FS - page 32

    32 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 35 26 27 28 30 31 32 33 36 37 39 29 38 31 31 ADD IN WIRING HARNESS 24 28 28 37 27 40 56 44 36 30 29 34 41 23 26 45 25 22 43 54 35 55 53 42 32 REPLACEMENT P ARTS DIAGRAMS ...

  • Lennox Hearth 32FS - page 33

    33 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE OPTIONAL ACCESSORIES 1 2 3 Contemporary Accessor y Kit, Montage 32FS, Brushed Nickel Artisan Accessory Kit, Montage 32FS, Matte Black Arch Accessory Kit, Montage 32FS, Matte Black Form # 775,201M Form # 775,201M Form # 775,201M Item # Cat. No. Model Description Optional Accessories 1 H6840 MON ...

  • Lennox Hearth 32FS - page 34

    NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 34 Need Screen Kit drawing. Need clarification, which style trim pieces should match up with which door inserts. I suspect what I have here is wrong. 4 6 P A I N T ACCESSORIES Gothic Accessory Kit, Montage 32FS, Black Paint 5 7 Form # 775,201M Form # 775,077M ...

  • Lennox Hearth 32FS - page 35

    35 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE SAFETY / LISTING LABEL F Combus tible W all Mur Co mbustib le Sto ve Poê le A B E D D B Alcov e Sto ve Poê le Combu stible Wall Mur C ombusti ble Com bus tibl e Wa ll / Mu r C ombu sti ble Com bust ible Wal l/M ur C ombu stib le F C C Sto ve Poê le Cor ner / Pos iti on E n Co in CER TIFIED ...

  • Lennox Hearth 32FS - page 36

    36 Printed in U.S.A. © 2008 Lennox Hearth Products P/N 775,196M REV . NC 06/2008 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. 1110 West T aft Av ...

Produzent Lennox Hearth Kategorie Stove

Dokumente, die wir vom Produzenten des Geräts Lennox Hearth 32FS erhalten, können wir in mehrere Gruppen teilen. Unteranderem in:
- technische Zeichnungen Lennox Hearth
- Bedienungsanleitungen 32FS
- Produktkarten Lennox Hearth
- Informationsbroschüren
- oder Energieetiketten Lennox Hearth 32FS
Jede von ihnen ist wichtig, jedoch finden wir die wichtigsten Informationen für den Nutzer des Geräts in der Bedienungsanleitung Lennox Hearth 32FS.

Die Dokumentengruppe, die als Bedienungsanleitungen bezeichnet wird, wird ebenfalls in detaillierte Arten geteilt, solche wie: Montageanleitungen Lennox Hearth 32FS, Wartungsanleitungen, Kurzanleitungen oder Benutzeranleitungen Lennox Hearth 32FS. Abhängig vom Bedarf, sollten Sie das Dokument finden, das Sie brauchen. In unserem Service können Sie sich die populärste Bedienungsanleitung des Produkts Lennox Hearth 32FS ansehen.

Ähnliche Bedienungsanleitungen

Die komplette Bedienungsanleitung des Geräts Lennox Hearth 32FS, wie sollte sie aussehen?
Die Bedienungsanleitung, auch bezeichnet als Benutzerhandbuch, oder einfach nur „Anleitung”, ist ein technisches Dokument, das dem Benutzer bei der Nutzung von Lennox Hearth 32FS hilfreich sein soll. Die Bedienungsanleitungen werden in der Regel von technischen Schriftstellern geschrieben, aber in einer Sprache, die für alle Nutzer von Lennox Hearth 32FS verständlich ist.

Eine gänzliche Bedienungsanleitung von Lennox Hearth sollte einige Grundelemente enthalten. Ein Teil von ihnen ist nicht so wichtig, wie z.B.: die Titelseite oder Autorenseiten. Die restlichen von ihnen jedoch, sollten Informationen liefern, die für den Nutzer von enormer Wichtigkeit sind.

1. Einführung und Hinweise, wie man sich in einer Bedienungsanleitung von Lennox Hearth 32FS bewegt - Am Anfang jeder Bedienungsanleitung sollten wir Hinweise bezüglich der Nutzungsart eines bestimmten Ratgebers finden. In ihr sollten sich Informationen über die Lokalisierung des Inhaltsverzeichnisses von Lennox Hearth 32FS befinden, FAQ oder über oft auftretende Probleme – also Stellen, die von den Benutzern in jeder Bedienungsanleitung am meisten gesucht werden
2. Inhaltsverzeichnis - Index aller Ratschläge bezüglich Lennox Hearth 32FS, die wir im aktuellen Dokument finden
3. Ratschläge zur Nutzung der Grundfunktionen des Geräts Lennox Hearth 32FS - die uns die ersten Schritte während der Nutzung von Lennox Hearth 32FS erleichtern sollten
4. Troubleshooting - geordneter Tätigkeitslauf, der uns bei der Diagnose und als nächstes bei der Lösung wichtiger Probleme mit Lennox Hearth 32FS hilft
5. FAQ - häufig gestellte Fragen
6. Kontaktdaten Informationen darüber, wo man Kontakt zum Produzenten / Service von Lennox Hearth 32FS im bestimmten Land suchen kann, wenn es nicht gelingt, das Problem selbst zu lösen.

Haben Sie eine Frage bezüglich Lennox Hearth 32FS?

Nutzen Sie das untere Formular

Wenn Sie mit Hilfe der gefundenen Bedienungsanleitung Ihr Problem mit Lennox Hearth 32FS nicht gelöst haben, stellen Sie eine Frage, indem Sie das untere Formular nutzen. Wenn einer der Nutzer ein ähnliches Problem mit Lennox Hearth 32FS hatte, ist es möglich, dass er mit Ihnen die Lösung teilen möchte.

Text vom Bild übertragen

Captcha
Neues Bild

Kommentare (0)