-
Dayton 3VG80 - page 1
Dayton Pr opane Construction Heater Description Dayton Model 3VG80 heater is a variable 65,000, 85,000, and 100,000 Btu/Hr construc- tion heater . This heater uses propane gas for combustion. It is primarily intended for temporary heating of well-ventilated buildings under construction, alteration, or r epair . This heater should only be used indoo ...
-
Dayton 3VG80 - page 2
Dayton Operating Instructions and Parts Manual 3VG80 2 Dayton Pr opane Construction Heater ® General Safety Information Make certain you read and understand a ll warnings. Keep these instructions for refer ence. They are your guide to safe and proper operation of this heater . Safety information appears throughout these instructions. Pay close att ...
-
Dayton 3VG80 - page 3
Version B - For Reduction G016.J ® Dayton Operating Instructions and Parts Manual 3 Model 3VG80 • Locate heater on stable and level surface if heater is hot or operating. • Never block air inlet (rear) or air outlet (front) of heater . • Keep heater away from str ong drafts, wind, water spray , rain, or dripping water . • Never operate hea ...
-
Dayton 3VG80 - page 4
Dayton Operating Instructions and Parts Manual 3VG80 4 Dayton Pr opane Construction Heater ® Figure 2 - Pr oduct Identification Handle Power Cord Hose /Regulator Assembly Hot Air Outlet (Front) Inlet Connector Control Knob Motor Mount Fan Guard Product Identification ...
-
Dayton 3VG80 - page 5
Version B - For Reduction G016.J ® Dayton Operating Instructions and Parts Manual 5 Model 3VG80 Air For Combustion And Heating Fuel Combustion Chamber Figure 3 - Cross Section Operational V iew Clean Heated Air Out (Front) Hose/Regulator Assembly Nozzle Fan Cool Air In (Back) Power Cord THE FUEL SYSTEM The hose/regulator assembly attaches to the p ...
-
Dayton 3VG80 - page 6
Dayton Operating Instructions and Parts Manual 3VG80 6 Dayton Pr opane Construction Heater ® Installation Review and understand the warnings in the General Safety Infor - mation section, pages 2 and 3. They ar e needed to safely operate this heater . Follow all local codes when using this heater . T est all gas piping and connections for leaks aft ...
-
Dayton 3VG80 - page 7
Version B - For Reduction G016.J ® Dayton Operating Instructions and Parts Manual 7 Model 3VG80 5. Plug extension cord into a 120 V olt/60 Hertz, 3-hole, grounded outlet. Motor will start. Fan will turn, forcing air out front of heater . 6. Open propane supply valve on pr opane tank(s) slowly . NOTE: If not opened slowly , excess-flow check valve ...
-
Dayton 3VG80 - page 8
Dayton Operating Instructions and Parts Manual 3VG80 8 Dayton Pr opane Construction Heater ® Maintenance (Continued) Ground Screw T er minal Board Motor Green Lead T ransfor mer Green Lead Power Cord Green Lead Figure 6 - Location of Gr ound Screw Hole in Shell for Wires Motor Mount Screw Fan Guard Motor Mount Figure 7- Removing Motor , Motor Moun ...
-
Dayton 3VG80 - page 9
Version B - For Reduction G016.J ® Dayton Operating Instructions and Parts Manual 9 Model 3VG80 5. Place setscrew on flat of shaft. Tighten setscrew firmly (40-50 inch-pounds). 6. Place motor , motor mount, and fan guard into r ear of heater shell (See Motor , page 8, steps 14 through 18). Maintenance (Continued) Fan Hub Setscrew Motor Shaft Figur ...
-
Dayton 3VG80 - page 10
Dayton Operating Instructions and Parts Manual 3VG80 10 Dayton Pr opane Construction Heater ® Wiring Diagram 100,000 BUT/HR MODEL Black Green White Motor Ignitor Orange Blue Blue Auto Control V alve Thermocouple 12 34 56 8 7 Thermal Switch T erminal Board Blue Black Ignition Control White Relay Green Green Black Black White White Green Power Cord ...
-
Dayton 3VG80 - page 11
Version B - For Reduction G016.J ® Dayton Operating Instructions and Parts Manual 11 Model 3VG80 T roubleshooting Chart Never attempt to service heater while it is plugged in, connected to pr opane supply , operating, or hot. Severe burns and electrical shock can occur . Symptom Possible Cause(s) Corrective Action 1. No electrical power to heater ...
-
Dayton 3VG80 - page 12
Dayton Operating Instructions and Parts Manual 3VG80 12 Dayton Pr opane Construction Heater ® For Repair Parts, call 1-800-323-0620 24 hours a day - 365 days a year Figure 15 - Repair Parts Illustration Please provide following information: -Model number -Serial number (if any) -Part description and number as shown in parts list Address parts corr ...
-
Dayton 3VG80 - page 13
Version B - For Reduction G016.J ® Dayton Operating Instructions and Parts Manual 13 Model 3VG80 Repair Parts List ( ) Not shown. (*) Standard har dware item, available locally . 1 Base T ray 102362-01 1 2 *Hex TPG Screw , 10-16 X 38 M11084-26 15 3 Base 103917-01AA 1 4 Nozzle 099138-02 1 5 Shell Kit 098511-216 1 6 *Hex TPG Screw ,10-16 X .75 M1108 ...
-
Dayton 3VG80 - page 14
Dayton Operating Instructions and Parts Manual 3VG80 103029-01 Rev . E 10/02 Version B - For Reduction G016.J ® Dayton Pr opane Construction Heater LIMITED WARRANTY DAYTON ONE-YEAR LIMITED WARRANTY. Dayton propane construction heater, Models covered in this manual, are warranted by Dayton Electric Mfg. Co. (Dayton) to the original user against def ...
¿Tienes una pregunta acerca de Dayton 3VG80?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Dayton 3VG80, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Dayton 3VG80 probablemente compartirá una forma de solucionarlo.