-
Weber S-640 - page 1
YOU MUST READ THIS O WNER’S GUIDE BEF ORE OPERA TING YOUR G A S GRILL DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open fl ames. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fi re department. Leaking gas may cause a fi re or explosion which ca ...
-
Weber S-640 - page 2
2 WWW . WEBER.COM ® DANGERS AND W ARNINGS DANGER Failure to follow the Dangers, W arnings and Cautions contained in this Owner ’ s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property . W ARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this b ...
-
Weber S-640 - page 3
3 WWW . WEBER.COM ® 3 W ARRANTY W ARRANTY Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this W eber ® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum castings -2 year on paint excludes fading, 25-years Stainless steel Shroud, 25-years Porcelain- ...
-
Weber S-640 - page 4
4 WWW . WEBER.COM ® + , $$ $% &* &, '# '$ '% '& * &$ &% && &' &( &) % & ' ( ) $ $# &+ S640_LP_US $& $' $( $) $* $+ '' $, %# %$ %% '( %& %' %( %) %* %+ %, &# ') '* '+ ', (( (' () (* (# ($ (% (& EXPL ODED VI ...
-
Weber S-640 - page 5
5 WWW . WEBER.COM ® 5 Shroud Hardware Shroud Thermometer Thermometer Bezel Handle Qrill Out TM Handle Light Rotisserie Motor Rotisserie Bracket W arming Rack Cooking Grates Flavorizer ® Bars Burner T ubes Manifold Control Panel Small Knob Bezel Small Knob Large Knob Large Knob Bezel W ater Baffl e / Heat Shield 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. ...
-
Weber S-640 - page 6
6 WWW . WEBER.COM ® OPERA TING Liquid Propane (LP) gas supply is easy to use and gives you more cooking control than charcoal fuel. • These instructions will give you the minimum requirements for assembling your Weber ® gas barbecue. Please read the instructions carefully before using your Weber ® gas barbecue. Improper assembly can be dangero ...
-
Weber S-640 - page 7
7 WWW . WEBER.COM ® 7 GENERAL INSTRUC TIONS IMPORT ANT LP CYLINDER INF ORMA TION Failure to follow these DANGER statements exactly may result in a fi re causing death or serious injury . DANGER NEVER store a spare LP Cylinder under or near this barbecue. NEVER fi ll the tank beyond 80% full. The proper fi lling methods for the fi l ...
-
Weber S-640 - page 8
8 WWW . WEBER.COM ® GAS INSTRUC TIONS Some LP tanks have dif fering top collar assembles. (The top collar is the metal protective ring around the valve.) One series of tanks mount with the valve facing front (a) . The other tanks mount with the valve facing away from the fuel scale (b) . W eber recommends the use of cylinder manufacturer ’s Manc ...
-
Weber S-640 - page 9
9 WWW . WEBER.COM ® 9 CHECK F OR GAS LEAKS W ARNING: The gas connections of your Summit ® gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your Summit ® gas grill. REMOVE CONTROL P ANEL Part required: Phillips Screwdriver . 1) Remove the burner control knobs. 2) Remove the t ...
-
Weber S-640 - page 10
10 WWW . WEBER.COM ® 2 7 1 5 6 A A * The grill illustrated may have slight differences than the model purchased. Check: 1) Main gas line to manifold connection. 2) Rotisserie (I.R. Burner) gas line connection. 3) Bulkhead and gas supply hose connection. 4) Corregated gas line to bulkhead connection. W ARNING: If there is a leak at connection ( ...
-
Weber S-640 - page 11
11 WWW . WEBER.COM ® 11 GAS INSTRUC TIONS REFILLING THE LIQUID PROP ANE CYLINDER We recommend that you refi ll the LP cylinder before it is completely empty . Removal of the LP cylinder 1) Close cylinder valve (turn clockwise). 2) Unscrew regulator coupling by turning counterclockwise, by hand only . 3) Loosen cylinder lock wing nut and turn cyli ...
-
Weber S-640 - page 12
12 WWW . WEBER.COM ® GAS INSTRUC TIONS GRILLING METHODS Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. Y ou can adjust the individual burners as desired. The control settings are ST ART/HI , MEDIUM , LOW , or OFF . If burners go out during cooking, turn off all burners and wait 5 minutes before religh ...
-
Weber S-640 - page 13
13 WWW . WEBER.COM ® 13 GAS INSTRUC TIONS GRILLING TIPS & HELPFUL HINTS • Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C). • Sear meats and cook with the lid down for perfectly grilled food every time. • Grilling times ...
-
Weber S-640 - page 14
14 WWW . WEBER.COM ® 1 3 2 4 5 LIGHTING Summary lighting instructions are inside the left hand cabinet door . DANGER Failure to open the lid while igniting the barbecue’ s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive fl ame-up which can cause serious bodily injury or ...
-
Weber S-640 - page 15
15 WWW . WEBER.COM ® 15 OPERA TING INSTRUC TIONS MAIN BU RNER MANU AL LIGHTING DANGER Failure to open the lid while igniting the barbecue’ s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive fl ame-up which can cause serious bodily injury or death. 1) Open the lid. 2) Make ...
-
Weber S-640 - page 16
16 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS LIGHTING THE SMOKER BURNER DANGER Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive fl are-up which can cause serious bodily injury or death. SMOKER BURNER SNAP IGNITION Note: The control kno ...
-
Weber S-640 - page 17
17 WWW . WEBER.COM ® 17 9 2 3 10 1 5 8 4 7 MANU ALL Y LIGHTING THE SMOKER BURNER W ARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way , do not use the grill. Replace using only Weber ® authorized replacement hose. Contact the Customer Service Representative in your ...
-
Weber S-640 - page 18
18 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS USING THE ROTISSERIE Note: Before using your rotisserie, measure your food at the widest point. If it exceeds 9½” (241.8mm), it is too large to fi t the rotisserie. If it is too large, food can be prepared using a roast holder and the Indirect Cooking Method. IMPORT ANT SAFEGU ARDS W ARNINGS ? ...
-
Weber S-640 - page 19
19 WWW . WEBER.COM ® 19 OPERA TING INSTRUC TIONS LIGHTING THE ROTISSERIE BURNER ROTISSERIE BURNER SNAP IGNITION Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. Y ou generate the energy for the spark by pushing in the control knob and turning to “ST ART/HI”. This will ignite each indi ...
-
Weber S-640 - page 20
20 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS MANUALL Y LIGHTING THE ROTISSERIE BURNER A TTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner , a few seconds must pass for the gas supply line to fi ll. When holding a match to the rotisserie burner you will see a fl ash of fl ames ...
-
Weber S-640 - page 21
21 WWW . WEBER.COM ® 21 TROUBLESHOO TING OPERA TING THE HANDLE LIGHT The Weber Grill Out™ Handle Light has a built-in “T ilt Sensor .” With the power button (a) activated, the light will come on when the grill lid is open. The light will turn off when the lid is closed. For daytime use, deactivate the sensor by pressing power button (a) . HA ...
-
Weber S-640 - page 22
22 WWW . WEBER.COM ® PROBLEM CHECK CURE Rotisserie burner does not light. Did you hold the burner control knob in and hold in for 20 seconds until after burner ignited? T ry to relight burner by holding burner control knob in and continue holding in until 20 seconds after burner has ignited. Did you wait to see the entire ceramic surface become al ...
-
Weber S-640 - page 23
23 WWW . WEBER.COM ® 23 MAINTENANCE MAIN BURNER CLEANING PROCEDURE T urn off the gas supply . Remove the manifold (See “Replace Main Burners”). Look inside each burner with a fl ashlight. Clean the inside of the burners with a wire (a straightened-out coat hanger will work). Check and clean the air shutter opening at the ends of the burners. ...
-
Weber S-640 - page 24
24 WWW . WEBER.COM ® AnnnNNUAL MAINTENANCE Inspection and cleaning of the Spider/Insect screens T o inspect the Spider/Insect screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens. Brush the Spider/Insect screens lightly with a soft bristle brush (i.e. an old toothbrush). CAUTIO ...
-
Weber S-640 - page 25
25 WWW . WEBER.COM ® 25 ...
-
Weber S-640 - page 26
©2007 The following trademarks are registered in the name of W eber-Stephen Products Co., an Illinois corporation, located at 200 East Daniels Road, Palatine, Illinois 60067 U.S.A. Australia; Smokey Joe, Weber , Kettle Silhouette ® , Genesis, Austria; Kettle Silhouette ® , Smokey Joe, Weber , Benelux; Kettle Silhouette ® , Smokey Joe, Weber , C ...
-
Weber S-640 - page 27
Spring. Summer . Fall. Winter . Four FREE issues of W eber Nation™ , our ho t e-mail newsle tter all about grilling, will be coming y our wa y . Each issue is packed with grilling tips an d advice, triple-tested recipes, an d everything you need to kn ow to become a bo na fide W eber Grilling Guru. All y ou hav e to do to activa te yo ur subscrip ...
-
Weber S-640 - page 28
Knowing more about wh o buys our grills helps the crew back i n R&D come up with new cutting edge Weber products. Please fill i n the answers you feel comfortable shari ng with us, and pass by any question you prefer to leave bl ank. Thank you for being so generous. Saber más sobre quién compra nuestros asadores ayud a al equipo de Investiga ...
¿Tienes una pregunta acerca de Weber S-640?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Weber S-640, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Weber S-640 probablemente compartirá una forma de solucionarlo.