-
Sears 486.245332 - page 1
Owner's Manual 25 GALLON SPRA YER Model No. 486.245332 • Saf ety • Assemb ly • Operation • Maintenance • P ar ts PRINTED IN U .S.A. Sears, Roeb uck and Co ., Hoffman Estates , IL 60179 U .S.A. www .sears .com/craftsman ® FORM NO . 40171 (REV . 3/06) CA UTION: Bef ore using this product, read this manual and f ollow all Saf ety Rules ...
-
Sears 486.245332 - page 2
2 T ABLE OF CONTENTS SAFETY R ULES .............................................................. 2 FULL SIZE HARD W ARE CHART .................................... 3 CAR TON CONTENTS ..................................................... 4 ASSEMBL Y ...................................................................... 4 OPERA TION ................. ...
-
Sears 486.245332 - page 3
3 SHOWN FULL SIZE HARDW ARE P ACKAGE CONTENTS O P 20 40 60 80 100 0 NO T SHO WN FULL SIZE Q R T U S N A H J K L B C D G F E I M KEY QTY . DESCRIPTION KEY QTY . DESCRIPTION KEY QTY . DESCRIPTION KEY QTY . DESCRIPTION A 8 He x Bolt, 5/16" x 2" A 8 He x Bolt, 5/16" x 2" A 8 He x Bolt, 5/16" x 2" A 8 He x Bolt, 5/16" ...
-
Sears 486.245332 - page 4
4 ASSEMBL Y TOOLS REQUIRED FOR ASSEMBL Y (2) 1/2" Wrenches (1) Screwdriv er (1) Pliers (1) Hammer FIGURE 1 STEP 1: (SEE FIGURE 1) • Remov e all items from car ton and la y out as shown on pages 3 and 4. • Assemble the axle clamps (U) and f our 5/16" hex nuts (SEMS) (E) to the f actor y installed bolts in the frame tubes. Do not tighte ...
-
Sears 486.245332 - page 5
5 STEP 3: (SEE FIGURE 3) • Assemble a hitch arm to the inside of a frame tube under neath the tank. Use two 5/16" x 2" hex bolts (A) and 5/16" nyloc k nuts (F). Do not tighten yet. Repeat f or other side. FIGURE 3 STEP 4: (SEE FIGURE 4) • F asten the ends of the hitch ar ms together using two 5/16" x 1-1/4" he x bolts ( ...
-
Sears 486.245332 - page 6
6 FIGURE 8 STEP 7: (SEE FIGURE 7) • Assemble the large (P) and small (O) spr ay gun clips to the side of the tank using two #10 x 1/2" scre ws (D) and #10 lock w ashers (I). SPRA Y GUN CLIP (P) (LARGE) SPRA Y GUN CLIP (O) (SMALL) #10 x 3/8" SCREW (D) #10 LOCK W ASHER (I) FIGURE 7 STEP 8: (SEE FIGURE 8) • Inser t a garden hose gask et ...
-
Sears 486.245332 - page 7
7 NEVER allow negativ e pin on plug to come in contact with positive "Hot" post on batter y . Fire or explosion ma y result. IMPORT ANT : Connect to 12 volt batteries only! FIGURE 9 FIGURE 10 STEP 9: (SEE FIGURE 9 AND 10) • Attach the spra yer to the tractor hitch and connect the wiring to the tractor batter y . The red wire must be con ...
-
Sears 486.245332 - page 8
8 OPERA TION KNOW YOUR SPRA YER Read this owner's manual and safety rules before operating your sprayer . Compare the illustration below with y our spra yer to f amiliarize yourself with the v ar ious controls and their locations . ON-OFF PUMP SWITCH T ur ns the pump motor on or off . ADJUST ABLE SPRA Y GUN NOZZLE Adjusts the spra y from a con ...
-
Sears 486.245332 - page 9
9 HOW TO USE YOUR SPRA YER BEFORE ST ARTING It is important to test the boom and spra y gun with plain water bef ore using chemicals. This will enable y ou to check the spr ay er for leaks and to set the spra y patter n and nozzle pressure. If a leak should occur , thread tape ma y be used to better seal the fi tting. ON-OFF SWITCH This s witch is ...
-
Sears 486.245332 - page 10
10 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .25 36.8 18.4 12.3 9.2 7.4 4.9 3.7 10 .2 ...
-
Sears 486.245332 - page 11
11 Ser vice Dates Check f or loose fasteners X Check f or loose fasteners X Flush the tank X Flush the tank X Flush the tank X Flush the tank X Cleaning the strainers X Cleaning the strainers X Cleaning the strainers X Cleaning the strainers X Cleaning the strainers X Lubrication X Lubrication X Lubrication X Lubrication X Lubrication X MAINTENANCE ...
-
Sears 486.245332 - page 12
12 CAUSE System pressure is reaching max i mum setting of pump's pressure s witch. 1. Bypass valv e open too far . 2. T ank strainer dir ty . Nozzles strainers dir ty . 1. Nozzles set too low . 2. Nozzles don't point straight down. PROBLEM Pump motor cycles on and off rapidly . (OK f or shor t per iods of time) Pressure too low Pressure O ...
-
Sears 486.245332 - page 13
13 NOTES ...
-
Sears 486.245332 - page 14
14 P ARTS REP AIR P ARTS FOR 25 GALLON SPRA YER MODEL 486.245332 28 25 38 40 43 46 27 23 24 25 42 49 56 C 40 23 40 38 28 45 44 44 52 39 19 62 62 20 31 21 37 30 36 33 35 34 51 63 21 21 32 21 30 37 36 21 33 35 34 63 21 57 58 59 B C 38 40 29 1 A 7 53 6 55 54 18 17 2 14 3 8 15 4 9 10 55 B 16 61 5 13 7 50 48 47 60 50 48 15 22 55 7 21 B 63 26 11 26 41 A ...
-
Sears 486.245332 - page 15
15 REP AIR P ARTS FOR 25 GALLON SPRA YER MODEL 486.245332 REF . P ART QTY . DESCRIPTION REF . P ART QTY . DESCRIPTION REF . P ART QTY . DESCRIPTION REF . P ART QTY . DESCRIPTION NO . NO . NO . NO . 34 45029 2 Strainer , Screen T ype 34 45029 2 Strainer , Screen T ype 34 45029 2 Strainer , Screen T ype 35 45037 2 Nut, Screen Body 35 45037 2 Nut, Scr ...
-
Sears 486.245332 - page 16
® Registered Trademark / TM Tra demark / SM Ser vice Mark of Sear s Brands, L LC ® Marca Re gistrada / TM Mar c a de Fábrica / SM M arca de Servicio de Sears Brands, LLC MC Marque de commerce / MD Marque déposée d e Sears Brand s, LLC © Sears Brand s , LLC G e t it fix e d , a t y o u r h o m e o r o u r s ! Your Home For repair – in you r ...
¿Tienes una pregunta acerca de Sears 486.245332?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Sears 486.245332, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Sears 486.245332 probablemente compartirá una forma de solucionarlo.