-
Quadra-Fire CB1200M-MBK - page 1
R www .quadrare.com 7014-179D December 16, 201 1 CLASSIC BA Y 1200 PELLET ST OVE O-T L T ested and Listed by Portland Oregon USA OMNI-T est Laboratories, Inc. C US Owner ’ s Manual Installation and Operation CB1200M-MBK Model: DO NOT DISCARD THIS MANUAL NOTICE • Important operating and maintenance instruc - tionsincluded. ? ...
-
Quadra-Fire CB1200M-MBK - page 2
Page2 7014-179D December 16, 201 1 R CB 1200 Pellet Stove and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradition of excellence! In choosing a Quadra-Fire appliance, you have our assurance of commitment to quality , durabi ...
-
Quadra-Fire CB1200M-MBK - page 3
R December 16, 201 1 7014-179D Page3 CB 1200 Pellet Stove Section 1: Listing and Code Approvals A. ApplianceCertications...................... 4 B. MobileHomeApproved...................... 4 C. GlassSpecications ............................ 4 D. ElectricalRating .................... ...
-
Quadra-Fire CB1200M-MBK - page 4
Page4 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 1 Listing and Code Approvals A. Appliance Certication C. Glass Specications E. BTU & Efciency Specications This appliance is equipped with 5mm ceramic glass. Replace glass only with 5mm ceramic glass. Please contac ...
-
Quadra-Fire CB1200M-MBK - page 5
R December 16, 201 1 7014-179D Page5 CB 1200 Pellet Stove A . Design, Installation & Location Consider- ations Warning! Risk of Fire Damaged parts could impair safe operation. Do NOT install damaged, incomplete or substitute components. 1. Appliance Location NOTICE: Checkbuildingcodespri ...
-
Quadra-Fire CB1200M-MBK - page 6
Page6 7014-179D December 16, 201 1 R CB 1200 Pellet Stove C. Thermostat Location The thermostat’s location will have some effect on the appliance’s operation. When the thermostat is located close to the appliance, it may require a slightly higher temperatur ...
-
Quadra-Fire CB1200M-MBK - page 7
R December 16, 201 1 7014-179D Page7 CB 1200 Pellet Stove H. Inspect Appliance & Components and Pre-Burn Check List ReciprocatingSaw ChannelLocks Hammer PhillipsScrewdriver T apeMeausre PlumbLine Level FramingMaterial Hi-tempCaulkingMaterial Gloves SafetyGlasses FramingSquare ElectricDrill&Bits? ...
-
Quadra-Fire CB1200M-MBK - page 8
Page8 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 3 Dimensions and Clearances A. A ppliance Dimensions 5.0 in (127mm) 4-5/8 in (1 18mm) 12-3/8 in (314mm) 14-1/4 in (362mm) 2-1/2 in (64mm) C L 8-1/6 in. (205mm) 20- 7/ 16 in. (51 9 mm) 28-1/ 2 in. (724m m) 27-5/ 8 in. (69 2 mm) 25-3/ 4 in. (65 4 mm) C L 10-3/4 in. (273mm) 24-3/4 in. (62 ...
-
Quadra-Fire CB1200M-MBK - page 9
R December 16, 201 1 7014-179D Page9 CB 1200 Pellet Stove Straight Back Against W all Inches Millimeters A BackW allto Appliance 2 51 B SideW allto Appliance 6 152 Corner Installation Inches Millimeters C W allsto Appliance 2 51 V ertical Installation Inches Millimeters D BackW alltoFluePipe 3 76 E SideW ...
-
Quadra-Fire CB1200M-MBK - page 10
Page10 7014-179D December 16, 201 1 R CB 1200 Pellet Stove *L Exception for Horizontal Installations: USA INSTALLATIONS : A non-combustible oor protec - tion is recommended extending beneath the ue pipe when installed with horizontal venting or under the top ventadapter? ...
-
Quadra-Fire CB1200M-MBK - page 11
R December 16, 201 1 7014-179D Page1 1 CB 1200 Pellet Stove Do not terminate vent inanyenclosedorsemi-enclosed areasuchasacarport,garage,attic,crawlspace,undera sundeckorporch,narrowwalkwayorcloselyfencedarea, oranylocationthatcanbuildupac ...
-
Quadra-Fire CB1200M-MBK - page 12
Page12 7014-179D December 16, 201 1 R CB 1200 Pellet Stove Improperinstallation,adjustment,alteration,serviceor maintenancecancauseinjuryorpropertydamage.Refer totheowner ’sinformationmanualprovidedwiththisap pli - ance.Forassistanceoradditionalinformationco ...
-
Quadra-Fire CB1200M-MBK - page 13
R December 16, 201 1 7014-179D Page13 CB 1200 Pellet Stove 5 V enting Systems NOTE: • IllustrationsreecttypicalinstallationsandareFOR DESIGNPURPOSESONL Y . • I llustrations/diagramsarenotdrawntoscale. • Actualinstallationmayvaryduetoindividualdesign preferen ...
-
Quadra-Fire CB1200M-MBK - page 14
Page14 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 6 in. (152mm) Min imu m Non-combustible Hearth Pad W all Thimble Horizontal T ermination Cap 2 in. (51mm) Minimum 6 in. (152mm) Minimum From Glass Straight Out B. Through The W all Horizontal termination cap must be a minimumof 12 inches. (305mm) from? ...
-
Quadra-Fire CB1200M-MBK - page 15
R December 16, 201 1 7014-179D Page15 CB 1200 Pellet Stove We recommend a minimum of 60 in. (1.5m) vertical, howeverabovetheeaveispreferred. Both installations areapproved formobile home instal - lations. Must use 3 or 4 inch (76 to 102mm) “L ...
-
Quadra-Fire CB1200M-MBK - page 16
Page16 7014-179D December 16, 201 1 R CB 1200 Pellet Stove FireHazard InspectionofChimney: • Masonrychimneymustbeingoodcondition. • MeetsminimumstandardofNFP A 21 1 • Factory-builtchimneymustbeminimum6in.(152mm) UL103HT . W ARNING E. Masonry F. Alternate Masonry ...
-
Quadra-Fire CB1200M-MBK - page 17
R December 16, 201 1 7014-179D Page17 CB 1200 Pellet Stove 6 Mobile Home 1. An outside air inlet must be provided for the combustion air andmust remainclear of leaves,debris, iceand/or snow . It must be unrestricted while the appliance is in use? ...
-
Quadra-Fire CB1200M-MBK - page 18
Page18 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 7 Appliance Set-Up A. Outside Air Kit Instructions Flex Hose Hose Clamp Collar Assembly T rim Rin g T erminatio n Cap Assembly Hose Clamp Included in Kit: 1pieceof2inchx3footexhose,2hose clamps,1collarassembly ,terminationcap ...
-
Quadra-Fire CB1200M-MBK - page 19
R December 16, 201 1 7014-179D Page19 CB 1200 Pellet Stove 3 to 3 inch T op V ent Adapter 3 to 6 inch T op V ent Offset Adapter 1. Put a layer of high temperature silicone on the 3 inch (76mm)exhaustoutlet. 2. Slidethetopventadapterontotherearexhaustoutlet andadjust ...
-
Quadra-Fire CB1200M-MBK - page 20
Page20 7014-179D December 16, 201 1 R CB 1200 Pellet Stove D. Optional Brick Set Installation 1. Removethebaferst,followinstructionson page 34 . 2. Slide bottom of left rear brick in rst; rotate top edge toward rear of appliance and then rotate outer ...
-
Quadra-Fire CB1200M-MBK - page 21
R December 16, 201 1 7014-179D Page21 CB 1200 Pellet Stove G. Optional Gold or Nickel Grille Assembly 1. Place the front log in rst as shown in Figure 21.1 . Place logbetweenrepotand faceofappliancewith charred areasurroundingrepot. 2. Set the left ...
-
Quadra-Fire CB1200M-MBK - page 22
Page22 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 1 . A 12 volt AC thermostat is required to operate this pellet appliance. Y ou may use the included wall mount thermo - stator purchase an optional programmable thermostat or remote control. ...
-
Quadra-Fire CB1200M-MBK - page 23
R December 16, 201 1 7014-179D Page23 CB 1200 Pellet Stove 8 Operating Instructions A. Fuel Size And Material 1. Wood Pellets Fuelpellets are made from sawdustor wood by-products. Ifthe source material is hardwood, they can have a higher mine ral content,creatingmorea ...
-
Quadra-Fire CB1200M-MBK - page 24
Page24 7014-179D December 16, 201 1 R CB 1200 Pellet Stove E. Fire Characteristics A properly adjusted re with the heat o utput control switch set on“high” hasa shortactiveame patternthat extendsoutof the repot approximately 4 to 6 inches ...
-
Quadra-Fire CB1200M-MBK - page 25
R December 16, 201 1 7014-179D Page25 CB 1200 Pellet Stove G. Ignition Cycles 1. During each ignition cycle, it is normal to see some smoke in the rebox. The smoke will stop once the restarts. 2. The convection blowerwill automaticallyturn on a ...
-
Quadra-Fire CB1200M-MBK - page 26
Page26 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 9 T roubleshooting With proper installation,operation, andmaintenance yourappliance willprovide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist aqual i? ...
-
Quadra-Fire CB1200M-MBK - page 27
R December 16, 201 1 7014-179D Page27 CB 1200 Pellet Stove Symptom Possible Cause Corrective Action Sloworsmokystart-up (Cont’d ) Dirtyexhaustand/orventingsystem. Checkforashbuildupinunit,includ - ingbehindrearpanels,rebox,heat exchanger ,exhaustblowerandventing. ...
-
Quadra-Fire CB1200M-MBK - page 28
Page28 7014-179D December 16, 201 1 R CB 1200 Pellet Stove Symptoms Possible Cause Corrective Action Convectionblowerfailsto start. #1snapdiscdefective. Blowernotpluggedin. Blowerisdefective. Controlboxisdefective. Replacesnapdisc. Checkthatblowerispluggedintowirehar - ne ...
-
Quadra-Fire CB1200M-MBK - page 29
R December 16, 201 1 7014-179D Page29 CB 1200 Pellet Stove 10 Maintaining & Servicing Y our Appliance C. General Maintenance 1. T ypes of Fuel Dependingonthe typeoffuelyouare burningwilldictate howoftenyouhavetocleanyourrepot. If the fuel you are burning has? ...
-
Quadra-Fire CB1200M-MBK - page 30
Page30 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 5. Disposal of Ashes • Frequency: Asneeded • By: Homeowner Ashes should be placed in a metal container with a tight-tting lid. The closed container of ashes should be placedon anon-combustible ...
-
Quadra-Fire CB1200M-MBK - page 31
R December 16, 201 1 7014-179D Page31 CB 1200 Pellet Stove 7. Cleaning Beneath Heat Exchanger • Frequency: Monthlyorafterburning1tonoffuel • By: Homeowner a. Be sure the appliance is allowed to cool, has been unpluggedandtheexhaustblowerisoff .? ...
-
Quadra-Fire CB1200M-MBK - page 32
Page32 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 15. Soot and Fly Ash: Formation & Need for Removal in Exhaust V enting System. • Frequency: Y earlyormorefrequentlydependingon ashbuild-up. • By: QualiedServiceT echnician/Homeowner Be sure the appliance is allowed to ...
-
Quadra-Fire CB1200M-MBK - page 33
R December 16, 201 1 7014-179D Page33 CB 1200 Pellet Stove Correct Flame Size, Y ellow/White in Color Correct Figure 33.3 Ash Build Up in Firebox Pellets Back Up In Feed T ube Firepot Overfills T all, Lazy Flame, Orange in Color Incorrect Figure 33.1 Figure 33.2 D. High Ash Fuel Content Maintenance • Frequency: Whentheashbuil ...
-
Quadra-Fire CB1200M-MBK - page 34
Page34 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 2. Exhaust Blower Replacement G. Igniter Replacement F . Bafe Removal 1. Use proper shut down procedures to shut down the appliance and let it completely cool down and then unplugitandremovetheashdrawer . 2. ...
-
Quadra-Fire CB1200M-MBK - page 35
R December 16, 201 1 7014-179D Page35 CB 1200 Pellet Stove H. Glass Replacement • Glassis5mmthickhightemperatureheat- resistantceramicglass. • DONOTREPLACEwithanyothermaterial. • Alternatematerialmayshatterandcause injury . W ARNING Figure 35.1 T op & Bottom Frame ...
-
Quadra-Fire CB1200M-MBK - page 36
Page36 7014-179D December 16, 201 1 R CB 1200 Pellet Stove 11 Reference Materials 7. Heat Exchangers The heat exchangers transfer hot air from the exhaust system into convection air . Lift the stove top to access the heat exchangers. There are 2clean out rods ...
-
Quadra-Fire CB1200M-MBK - page 37
R December 16, 201 1 7014-179D Page37 CB 1200 Pellet Stove 16. Thermostat The applianceis designedto runon a12 volt ACthermostat. The heat anticipator should be set on the lowest setting available. 17. Snap Disc #1 (Convection Blower) 145°F Snapdisc#1is located? ...
-
Quadra-Fire CB1200M-MBK - page 38
Page38 7014-179D December 16, 201 1 R CB 1200 Pellet Stove B. Component Locations Heat Output Fan Speed Reset Button Call Light HIGH HIGH MED LOW LOW Power Outlet T erminal Block. Center 2 screws for Thermostat Wires Outside Air Flex Hose Convection Blower Cleaning Rods Heat Exchanger T ubes Figure 38.1 Figure 38.3 Figure 38.4 Figure 38.2 ...
-
Quadra-Fire CB1200M-MBK - page 39
R December 16, 201 1 7014-179D Page39 CB 1200 Pellet Stove C. Exploded Views Figure 39.1 Service Parts 12/1 1 R Classic Bay Freestanding Pellet Stove CB1200M-MBK Beginning Manufacturing Date: April 2009 Ending Manufacturing Date: Active 1 5 2 3 6 7 12 9 8 4 10 11 13 14 15 16 21 17 18 19 20 22 23 24 25 26 33 35 37 38 39 40 31 29 28 27 30 36 32 ...
-
Quadra-Fire CB1200M-MBK - page 40
Page40 7014-179D December 16, 201 1 R CB 1200 Pellet Stove Figure 40.1 B. Service Parts & Accessories Service Parts 12/1 1 R IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an author ...
-
Quadra-Fire CB1200M-MBK - page 41
R December 16, 201 1 7014-179D Page41 CB 1200 Pellet Stove Service Parts 12/1 1 R IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM DESCRIPTION ...
-
Quadra-Fire CB1200M-MBK - page 42
Page42 7014-179D December 16, 201 1 R CB 1200 Pellet Stove Service Parts 12/1 1 R IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM DESCRIPTION ...
-
Quadra-Fire CB1200M-MBK - page 43
R December 16, 201 1 7014-179D Page43 CB 1200 Pellet Stove Service Parts 12/1 1 R IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM DESCRIPTION ...
-
Quadra-Fire CB1200M-MBK - page 44
Page44 7014-179D December 16, 201 1 R CB 1200 Pellet Stove Service Parts 12/1 1 R IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in this manual may be ordered from an authorized dealer . Stocked at Depot ITEM DESCRIPTION ...
-
Quadra-Fire CB1200M-MBK - page 45
R December 16, 201 1 7014-179D Page45 CB 1200 Pellet Stove Service Parts 12/1 1 R CB1200M-MBK Beginning Manufacturing Date: April 2009 Ending Manufacturing Date: Active IMPORT ANT : THIS IS DA TED INFORMA TION. When requesting service or replacement parts for your appliance please provide model number and serial number . All parts listed in t ...
-
Quadra-Fire CB1200M-MBK - page 46
Page46 7014-179D December 16, 201 1 R CB 1200 Pellet Stove E. W arranty Policy ...
-
Quadra-Fire CB1200M-MBK - page 47
R December 16, 201 1 7014-179D Page47 CB 1200 Pellet Stove ...
-
Quadra-Fire CB1200M-MBK - page 48
R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI INDUSTRIES www .quadrare.com 7014-179D December 16, 201 1 Page48 CONT ACT INFORMA TION : This product may be covered by one or more of the following patents: (United States) 4593510, 4686807, 4766876, 4793322, 481 1534, 5000162, 5016609, 5076254, 51 1 ...
¿Tienes una pregunta acerca de Quadra-Fire CB1200M-MBK?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Quadra-Fire CB1200M-MBK, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Quadra-Fire CB1200M-MBK probablemente compartirá una forma de solucionarlo.