-
Vermont Casting LHEC20 - page 1
10005360 6/03 Rev. 0 • Installation and service must be performed by a qualified installer, service agency or your gas supplier. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPOURS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. FOR YOUR SAFETY What to Do if You Smell Gas: • Do not try to light any appliance. • ...
-
Vermont Casting LHEC20 - page 2
2 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert T able of Contents PLEASE READ THE INSTALLATION & OPERATING INSTRUCTIONS BEFORE USING THIS APPLIANCE. Thank you and congratulations on your purchase of a Vermont Castings fireplace insert. IMPORTANT - Read all instructions and warnings carefully before starting installation. ...
-
Vermont Casting LHEC20 - page 3
3 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert This gas appliance should be installed by a qualified installer in accordance with local building codes and with current CSA- B149.1 Installation codes for Gas Burning Appliances and Equipment. FOR U.S. Installations follow local codes and/or the current National Fuel Gas Code A ...
-
Vermont Casting LHEC20 - page 4
4 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert N O P E M F U S R Q V T Q - Fireplace opening height R - Fireplace opening width S - Depth of insert T - Firebox width at insert depth(S) LHEC20 LHER20 LHEC30 A-1 20 ⁷⁄₈ " (530mm) 20 ⁷⁄₈ " (530mm) 26 ³⁄₄ " (680mm) B-1 30 ³⁄₄ " (781mm) 30 ...
-
Vermont Casting LHEC20 - page 5
5 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert When the unit is installed into a woodburning fireplace, the minimum distance the mantel can be placed above the fireplace is governed by local building codes applicable to woodburning fireplaces. Consult local authorities having jurisdiction for these clearances. For applicatio ...
-
Vermont Casting LHEC20 - page 6
6 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Natural LP Minimum Inlet Pressure 5.5" W . C .1 1.0" W . C . Maximum Inlet Pressure 14.0" W . C . 14.0" W . C . Manifold Pressure 3.5" W . C . 10.0" W . C . Gas Inlet & Manifold Pressures Do not use this appliance if any part of it has been unde ...
-
Vermont Casting LHEC20 - page 7
7 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Gas Supply Pressures This heater must be isolated from the gas supply piping system by closing its individual manual shut-off valve during any pressure equal to or less than 1/2 psig (3.45kPa). The heater and its individual shut-off valve must be disconnected from the gas supply ...
-
Vermont Casting LHEC20 - page 8
8 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Installer must attach red warning plate with screws supplied with the gas fire- place insert to the inside of the firebox of the fireplace into which the gas fireplace insert is installed. Cutting any sheet metal parts of the fireplace, in which the gas fireplace insert is to be ...
-
Vermont Casting LHEC20 - page 9
9 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Zero clearance kit minimum clearance to combustibles materials is 1" (25mm) for B Vent (use of single wall vent is not allowed.) As with any natural drafted appliances, the vent cap must always extend a minimum of 2' (610mm) above any structure within a 10' (3m) h ...
-
Vermont Casting LHEC20 - page 10
10 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Ceramic Refractory Installation 1. Remove front glass. 2. Remove logs from unit. 3. Remove refractory from package. Refractory are fragile and must be han- dled with care. Where at all possible, two hands should be used when handling. 4. Take center refractory and tilt so botto ...
-
Vermont Casting LHEC20 - page 11
11 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Operating Instructions General Glass Information Only ceramic glass approved by Vermont Castings, Majestic Products may be used for replacement on this unit. 1. The use of substitute glass will void all product warranties. 2. Care must be taken to avoid breakage of the glass. 3 ...
-
Vermont Casting LHEC20 - page 12
12 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert LG287 Fig. 23 Correct burner flame appearance for LHEC20 and LHER20. 3/8" - 1/2" SIT Pilot PSE Pilot F584-703 Fig. 22 Correct pilot flame appearance. Flame Adjustment (RN/RP Models) For fireplaces equipped with HI/LO valves, flame adjustment is accomplished by rotatin ...
-
Vermont Casting LHEC20 - page 13
13 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert First Firing Upon completing the gas line connection, a small amount of air will be in the lines. When first lighting unit with pilot light, it will take a few minutes to purge them- selves of this air. Once the purging is complete, the pilot and burner will light and operate a ...
-
Vermont Casting LHEC20 - page 14
14 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert 3. Open control access panel. 4. Push in gas control knob slightly and turn clockwise to " OFF ". Do not force. 5. Close control access panel. 1. STOP! Read the safety information above. 2. Turn off all electrical power to the fireplace. 3. For MN/MP/TN/TP appliances ...
-
Vermont Casting LHEC20 - page 15
15 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert W ARNING: Before doing any gas control service work, remove glass front. SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION 1. Spark ignitor will not light A. Defective or misaligned Using a match, light pilot. If pilot lights, turn off electrode at pilot. pilot and push the red button ...
-
Vermont Casting LHEC20 - page 16
16 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Gas Supply On Supply Line Hooked Up Shutoff Valve Open NO NO NO NO Lockout Has Engaged. Wait 60 Seconds And Try Again. For Spark At Electrode While Depressing Piezo 1/8" Gap To Pilot Hood Needed. All Wiring Connections Replace Piezo Ignitor For Air In The Lines Thermopile ...
-
Vermont Casting LHEC20 - page 17
17 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Instructions for RF Comfort Control V alve The Comfort Control V alve allows remote control of temperature, fan and flame appearance. NOTE: The antenna should hang in free air away from grounded metal. Operation 1. If the manual switch is in remote position, switch it to LOCAL. ...
-
Vermont Casting LHEC20 - page 18
18 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Delay T imer Mode The shut off delay timer has a maximum of 2 hours and a minimum of zero minutes. T o change the timer level, press the time key followed by an arrow key . Pushing the key once will change the timer by 10 minutes. Auto Mode In the AUTO mode, the room temperatur ...
-
Vermont Casting LHEC20 - page 19
19 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert LED Count Service Action 8 Replace valve 7 Confirm stepper motor connection exists 5 Confirm fan connection exists and works 4 Confirm gas type; jumper in place 3 Replace thermopiles 2T urn fan ON NOTE: Some keys are not active. 2. Slide the Remote/Local switch to REMOTE and te ...
-
Vermont Casting LHEC20 - page 20
20 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Light pilot burner Set manual switch to local or remote Release pilotstat knob T urn pilotstat knob from PILOT to ON If manual switch is set to LOCAL, did main burner light? T ransmitter controls fan T urn pilotstat knob to PILOT to turn off main burner T urn pilotstat knob to ...
-
Vermont Casting LHEC20 - page 21
21 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Maintenance Burner and Burner Compartment It is important to keep the burner and the burner compartment clean. At least once per year the logs and lava rock/ember material should be removed and the burner compartment vacuumed and wiped out. Remove and replace the logs as per th ...
-
Vermont Casting LHEC20 - page 22
22 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert LHER20/LHEC20 1a 1d 1b 1e LHEC30 1a 1d 1c 1e 1b 3 2 4 5 6a/b 7a/b 9 a/b 8a/b 19 14 16 18 10a/b 18 17 1 1a/b 12a/b 13a/b 15 20 L O H I PILOT ADJ PILOT ON OFF 23 a/b 21 22a/b LOCAL REMOTE O N ¥ P IL O T OFF ¥ LED 24a/b 25 26 27 28/29 30 31 32 33 35 34 36 41 40 42 43 44 45 46 47 ...
-
Vermont Casting LHEC20 - page 23
23 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert LHE Series (continued) Ref. Description LHER20 LHEC20 LHEC30 1. Log Set Complete 10005332 10005332 10004866 1a. Log Rear Left JR7 JR7 KR22 1b. Log Rear Right JR8 JR8 KR23 1c. Log Rear Center - - KR24 1d. Log Front Left JR9 JR9 KR25 1e. Log Front Right JR10 JR10 KR26 2. Lava Roc ...
-
Vermont Casting LHEC20 - page 24
24 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Ref. Description LHER20 LHEC20 LHEC30 LHE Series (continued) 34. Glass with Gasket 10005526 10005525 10004989 35. Gaskeet Glass 57317 57317 57317 36. Frame Window 10005295 10005067 10004873 37. Remote Switch (for RN or RP Units) 53606 53606 53606 38. Remote Wire Harness w/Termi ...
-
Vermont Casting LHEC20 - page 25
25 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert Optional Accessories Remote Controls Optional remote control units are available to control different functions of the appliance. Model Function(s) Controlled MRC1 ON/OFF MRC2 ON/OFF and T emperature MRC3 ON/OFF and T emperature control with a digital and a programmable 24 hour ...
-
Vermont Casting LHEC20 - page 26
26 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert BASIC WARRANTY The Vermont Castings , Majestic Products Company (hereinafter referred to collectively as the Company) warrants that your new Vermont Castings or Majestic Gas Fireplace/Stove is free from manufacturing and material defects for a period of one year from the date o ...
-
Vermont Casting LHEC20 - page 27
27 10005360 Vermont Castings, Majestic Products LHE Natural Vent Insert ...
-
Vermont Casting LHEC20 - page 28
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www .majesticproducts.com • www .vermontcastings.com Ve r mont Castings, Majestic Products Efficiency Ratings Model EnerGuide Ratings Steady State (%) D.O.E. Fireplace Efficiency (%) Fan-OFF Fan-ON (AFUE%) LHEC20RN 51.2 71 75 60 LHEC20RP 51.2 72 76 60 LHEC20RFN 51.2 71 75 ...
¿Tienes una pregunta acerca de Vermont Casting LHEC20?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Vermont Casting LHEC20, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Vermont Casting LHEC20 probablemente compartirá una forma de solucionarlo.