-
RedMax HBZ2500 - page 1
The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. WARNING OWNER / OPERA T OR MANUAL HANDHELD BLOWER T4022-96110 (111) HBZ2500 Thank you for purchasing a RedMax product. Before using our blower, please read this manual carefully to understand the pr ...
-
RedMax HBZ2500 - page 2
Read this manual carefully to understand all safety precautions, controls, proper operation and maintenance of your RedMax blower . Failure to do so could result in serious injury . Instructions labeled as shown at left concern critical steps or procedures which must be followed in order to prevent accidents which could lead to serious bodily injur ...
-
RedMax HBZ2500 - page 3
CONTENTS SAFETY PRECAUTIONS ················································································ 4 OPERATOR USE OF BLOWER WORKING CONDITION AVOID NOISE PROBLEM AVOID CHANCES OF DAMAGE SYMBOLS ON THE MACHINE ·························? ...
-
RedMax HBZ2500 - page 4
• Read this Blower Owner/Operator Manual carefully. Be sure you understand how to operate this unit properly before you use it. Failure to do so could result in serious injury. • Be sure to keep this manual handy so that you may refer to it later whenever any questions arise. Also note that you are requested to contact the dealer from whom you ...
-
RedMax HBZ2500 - page 5
• Never use the blower without the screen at the air intake of the blower. Before each use, check that the screen is attached in place and is free from any damage. • Never remove debris from the intake screen while the engine is running. Contact with rotating blower fan may result in a serious personal injury. • Do not allow children to use b ...
-
RedMax HBZ2500 - page 6
❲ 6 ❳ • Keep operation area clear of all persons, particularly small children and pets. Injury may result from flying debris. • Avoid using the blower where stable footing and balance are not assured. • Never touch the spark plug or plug cord while the engine is in operation. Doing so may result in being subjected to an electrical shock. ...
-
RedMax HBZ2500 - page 7
❲ 7 ❳ Symbols on the machine For safe operation and maintenance, symbols are carved in relief on the machine. According to these indications, please be careful not to take a mistake. (a) The port to refuel the "MIX GASOLINE" Position: FUEL TANK CAP (b) The direction to close the choke Position: AIR CLEANER BODY (c) The direction to op ...
-
RedMax HBZ2500 - page 8
Parts Location & Specifications Assembly ■ BLOWER PIPE • Align groove in blower pipe with projection on blower housing (or another blower pipe) and slide the pipe onto the blower housing (or another blower pipe). Rotate the pipe clockwise to lock it into place. MODEL HBZ2500 Dimensions ( L x W x H ) mm ( in ) 327 x 273 x 360 (12.9 x 10.7 x ...
-
RedMax HBZ2500 - page 9
❲ 9 ❳ • Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 3m(10ft) away from the fueling point before starting the engine. • The RedMax engines are lubricated by oil specially ...
-
RedMax HBZ2500 - page 10
❲ 10 ❳ ■ RESTARTING ENGINE WHILE ENGINE IS HOT 1. When restarting the engine immediately after stopping it, leave the choke open. 2 . If the engine won't start after several attempts, close the choke and repeat pulling the rope or remove the spark plug and dry it. ■ STOPPING ENGINE Move the throttle lever to the idling position and pre ...
-
RedMax HBZ2500 - page 11
■ FUEL FILTER • A clogged fuel filter may cause poor acceleration of the engine. Check periodically to see if the filter is clogged with dirt. The filter can be taken out of the fueling port using a small wire hook. Disconnect the filter assembly from the fuel pipe and unhook the retainer to disassemble it. Clean the components with gasoline. ? ...
-
RedMax HBZ2500 - page 12
❲ 12 ❳ ■ MUFFLER • Inspect periodically the muffler for loose fasteners, any damage or corrosion. If any sign of exhaust leakage is found, do not use the blower and have it repaired immediately. • Note that failing to do so may result in the engine catching on fire. • Before starting operation, always make sure to check if the muffler i ...
-
RedMax HBZ2500 - page 13
■ HOW TO INSTALL THE AIR INLET SCREEN TO THE VOLUTE COVER • Put the mark ▲ ▲ of the air inlet screen to the mark ● ● of the volute cover in line. • Turn the air inlet screen clockwise (arrow direction) and make sure it is firmly installed. • Install the screw through the stopper to insure that the air inlet screen does not move Stor ...
-
RedMax HBZ2500 - page 14
❲ 14 ❳ T roubleshooting guide Case 1. Starting failure CHECK PROBABLE CAUSES ACTION fuel tank ➞ incorrect fuel ➞ drain it and with correct fuel fuel filter ➞ fuel filter is clogged ➞ clean carburetor adjustment screw ➞ out of normal range ➞ adjust to normal range sparking (no spark) ➞ spark plug is fouled/wet ➞ clean/dry ➞ plu ...
-
RedMax HBZ2500 - page 15
Parts List NOTE : 1. Use KOMATSU ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. KOMATSU ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company. 3. When placing parts orders for repair and/or replacement, check if the model name and the se ...
-
RedMax HBZ2500 - page 16
Fig.1 ENGINE GROUP HBZ2500 ❲ 16 ❳ Parts List ...
-
RedMax HBZ2500 - page 17
Fig.1 ENGINE GROUP HBZ2500 Key# Part Number Description Q'ty 1 4810-12111 CYLINDER 1 2 4810-12210 GASKET 1 3 4820-12130 BOLT TORX, M5x22 2 4 4810-13162 INSULATOR 1 5 T1512-13120 GASKET, INSU 1 6 4810-13130 GASKET, CARB 1 7 4820-13180 BOLT TORX, M5x20 2 8 4810-16100 REEDVALVE-A(S) 1 9 4810-16110 • VALVECASE(S) 1 10 4810-16120 • REEDVALVE 1 ...
-
RedMax HBZ2500 - page 18
Fig.2 BLOWER GROUP HBZ2500 ❲ 18 ❳ Parts List ...
-
RedMax HBZ2500 - page 19
Key# Part Number Description Q'ty 1 6811-11110 VOLUTE CASE 1 2 T4022-11300 VOLUTE COVER-A 1 3 1600-33130 SCREW 3 4 T4970-52001 SCREW TORX 12 5 6811-11130 GURG NET 1 6 6811-11160 STOPPER 1 7 T4970-51410 SCREW TORX 1 8 6811-11150 LEVER 1 9 6811-72200 SWITCH 1 10 T4022-11210 ENGINE COVER 1 11 4820-85510 SCREW TORX 2 12 T4960-53510 SCREW TORX 4 13 ...
-
RedMax HBZ2500 - page 20
THE CALIFORNIA AIR RESOURCES BOARD AND KOMATSU ZENOAH Co. ARE PLEASED TO EXPLAIN THE EMISSION CONTROL SYSTEM WARRANTY ON YOUR 1995 AND LATER LAWN AND GARDEN EQUIPMENT ENGINE. IN CALIFORNIA, NEW UTILITY AND LAWN AND GARDEN EQUIPMENT ENGINES MUST BE DESIGNED, BUILT AND EQUIPPED TO MEET THE STATE'S STRINGENT ANTI-SMOG STANDARDS. KOMATSU ZENOAH Co ...
-
RedMax HBZ2500 - page 21
EMISSION-RELATED PARTS; FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE MODEL HBZ2500 UNIT, KOMATSU ZENOAH AMERICA INC. (THE COMPANY), THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART OR PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP. EMISSION-RELATED ...
-
RedMax HBZ2500 - page 22
Pièces en rapport avec les émissions de gaz d'échappement : KOMATSU ZENOAH AMERICA INC., par l'intermédiaire de n'importe quel revendeur RedMax, réparera gratuitement ou remplacera gratuitement pour l'acheteur initial et chaque acheteur successif toute(s) pièce(s) se révélant de constitution et/ou de montage défectueux ...
¿Tienes una pregunta acerca de RedMax HBZ2500?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con RedMax HBZ2500, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con RedMax HBZ2500 probablemente compartirá una forma de solucionarlo.