-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 1
- 1 - INSTRUCTION MANUAL AND SAFETY INSTRUCTIONS FOR AIR COMPRESSOR MODEL EC 25E / AC1-PH55-08H TECHNICAL W ARNING Improper and unsafe use of this compressor can result in death or serious bodily injury! Compressor manual (this manual) and engine manual contains important information about product safety. Please read carefully and fully understand ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 2
- 2 - Page IMPORTANT INFORMATION ............................................ 3 MEANINGS OF SIGNAL WORDS ..................................... 3 SAFETY IMPORTANT SAFETY INSTRUCTIONS FOR USE OF THE COMPRESSOR ................................. 4 REPLACEMENT PARTS ................................................... 6 Page OPERATION AND MAINTENANCE NAM ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 3
- 3 - IMPORT ANT INFORMA TION Read and understand all of the operating instructions, safety precautions and warnings in the Instruction Manual before operating or maintaining this compressor. Most accidents that result from compressor operation and maintenance are caused by the failure to observe basic safety precautions. An accident can be avoided ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 4
- 4 - English SAFETY IMPORT ANT SAFETY INSTRUCTIONS FOR USE OF THE COMPRESSOR WARNING: Death or serious bodily injury could result from improper or unsafe use of this compressor. To avoid these risks, follow these basic safety instructions: READ ALL INSTRUCTIONS 1. NEVER TOUCH MOVING PARTS. Never place your hands, fingers or other body parts near t ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 5
- 5 - English 12 . CHECK DAMAGED PARTS AND AIR LEAK. Before further use of this compressor, guard or other parts should be carefully checked to see that it will operate properly and perform its intended function. Check alignment of moving parts, binding of moving parts, breakage of parts, mounting, air leak, and any other conditions that may affect ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 6
- 6 - English 26 . BE CAREFUL NOT TO TRIP OVER OR DROP THE COMPRESSOR DURING TRANSPORT. Exercise utmost caution when you carry this compressor. If you trip over something and drop it, there is a fear that unexpected injury may result. If you drop this compressor or bump it against any objects, air tank or any component parts can cause serious defor ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 7
- 7 - English OPERA TION AND MAINTENANCE NOTE: The information contained in the Compressor Instruction Manual (this Instruction Manual) and Engine Instruction Manual are designed to assist you in the safe operation and maintenance of this compressor. Some illustrations in the Compressor Instruction Manual (this Instruction Manual) and Engine Instru ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 8
- 8 - English SPECIFICA TIONS Compressor Model Engine M anufacturer And Model Displacement Max. Output Fuel Tank Capacity Tank Capacity Maximum Pressure Free Air Delivery EC25E Honda GX160 9.9 cu in (163 mL) 5.4bhp (4.0kW, 5.5PS)/3600min -1 0.95 US gal. (3.6 L) 8.0 gal. (30.3L) 125 PSI (8.6 bar) at 40 PSI (2.8 bar) at 90 PSI (6.2 bar) at 100 PSI (6 ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 9
- 9 - B) Remove any moisture in this compressor air tank. Gradually open the drain cock and discharge the drain. Close tightly when drained. C) Make sure the engine switch is in the “OFF” position. D) Make sure the safety relief valve is working correctly. (Fig. 3) The safety relief valve is designed to prevent system failures by relieving pres ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 10
- 10 - English C) Start the engine. (Refer to the Engine Manual accompanying this unit.) D ) When the engine has run for 1-2 minutes, flip toggle back to the original position. The operation of this compressor is automatic and is controlled by the pilot valve which idles it when the pressure in the air-tank reaches the maximum level and restart it ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 11
- 11 - All quality compressors will eventually require servicing or replacement of parts because of wear and tear from normal use. To assure that only genuine replacement parts will be used, all service and repairs must be performed by a HITACHI AUTHORIZED SERVICE CENTER, only. NOTE: Specifications are subject to change without any obligation on th ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 12
- 12 - EC 25E ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 13
- 13 - AC1 - PH55-08M&H- 0 62102- D LG T ANK ASSEMBL Y FO R EC 2 5E / A C1-PH55-08H (A FTER S ERI AL # 20005 563) REF # DESCRI PTIO N P ART # P ART # QTY REF # DESCRIPTI ON PA RT # P ART # QTY 1 W ash er 724001 28-0008 8 43 Pum p 724046 3-0215 1 2 Wh eel * *CF 14-0080 1 44 Spacer 724047 33-0358 2 3 A x l e 724003 20-0420 1 45 Ai r Sh r oud 7240 ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 14
- 14 - EC 25E ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 15
- 15 - 3- 0215 M & Hit ach i - 081301- BAR SING LE ST AG E COM PRES SO R (724046 / 3- 0215) REF # DESCRI PTI ON P A RT # P ART # QT Y REF # DESCRI PT IO N P A RT # P A RT # Q TY 1 Screw 724101 27 -0071 2 22 Bear Ball 72 4122 48-001 6 2 2 Sc rew 724040 27 -0068 4 23 Cran ksh af t 724123 46 -0955 1 3 Cy lin der Head 724103 46-095 1 1 24 Flan ge G ...
-
Hitachi EC 25E / AC1-PH55-08H TECHNICAL - page 16
- 16 - Issued by Hitachi Koki Co., Ltd. Sinagawa Intercity Tower A, 15-1, Konan 2-chome, Minato-Ku, Tokyo 108-6020, Japan Distributed by Hitachi Koki U.S.A., Ltd. 3950 Steve Reynolds Blvd. Norcross, GA 30093 Hitachi Koki Canada Co. 6395 Kestrel Road Mississauga ON L5T 1Z5 108 Code No. C99109061 Printed in U.S.A. ...
¿Tienes una pregunta acerca de Hitachi EC 25E / AC1-PH55-08H TECHNICAL?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Hitachi EC 25E / AC1-PH55-08H TECHNICAL, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Hitachi EC 25E / AC1-PH55-08H TECHNICAL probablemente compartirá una forma de solucionarlo.