Español dropdown-ico

Manual de instrucciones Powerex SBS1517

20 de páginas 0.52 mb
Descargar

Pasar a la página of 20

Summary
  • Powerex SBS1517 - page 1

    Please read and save these instructions. Read carefully before attempting to assemble, install, operate or maintain the product described. Protect yourself and others by observing all safety information. Failure to comply with instructions could result in personal injury and/or prop- erty damage! Retain instructions for future reference. Powerex ? ...

  • Powerex SBS1517 - page 2

    2 Scroll Air Compr essors T ankmount/Basemount Installation RECEIVING THE UNIT Immediately upon receipt of the scroll compressor, the unit should be inspect- ed for any damage which may have occurred in shipment. Any shipping damage must be immediately filed with the freight carrier. The compressor nameplate should be checked to see if the unit is ...

  • Powerex SBS1517 - page 3

    3 Scroll Air Compr essors T ankmount/Basemount RESET RESET Figure 1 - SBS Scroll Basemount Simplex Figure 2 - STS Scroll Tankmount Figure 3 - STD Scroll Tankmount Duplex Aftercooler Scroll Air End Pressure Switch Starter ASME Receiver 30/60 Gallon Auto Drain (optional) ASME Receiver 30/60 Gallon Beltguard Pulley Belt 3/4” NPT Outlet Aftercooler S ...

  • Powerex SBS1517 - page 4

    RESET 4 Scroll Air Compr essors T ankmount/Basemount SCFM Full Load Gallon Dimension Ship Model HP Phase @100 PSIG Voltage Amperage Tank LxWxH Weight (Lbs.) SBS0307 3 3 8.6 208/230/460 8.7/8.0/4.0 Basemount 29x19x19 160 SBS1307 3 1 8.6 230 17 Basemount 29x19x19 175 SBS0507 5 3 14.7 208/230/460 13.7/13.2/6.6 Basemount 29x19x19 180 SBS1517 5 1 14.7 2 ...

  • Powerex SBS1517 - page 5

    5 Maintenance Schedule Operating Hours Item Action needed 500 2500 5000 10,000 15,000 20,000 Remarks Tank Drain moisture Daily Inlet air filter Replace  (Every 2,500 hrs or less) Part #91348550 Blower fan Clean  Fan Duct Clean  Compressor Fins Clean  (Every 2,500 hrs or less) Bearings Grease  Service Center On ...

  • Powerex SBS1517 - page 6

    6 Scroll Air Compr essors T ankmount/Basemount Electrical Wiring Diagram - Simplex Figure 4 - 3-5 HP Basemount/Simplex Single-Phase 208/230 Volts Field furnished power supply  Disconnect Red Black Motor Red Red Pressure electric switch L1 L2 T1 T2 Open Red Black Red Red Red Red Black Red Blank  Main disconnect and branch circuit protection to ...

  • Powerex SBS1517 - page 7

    7 Scroll Air Compr essors T ankmount/Basemount Electrical Wiring Diagram - Simplex Figure 5 - 3-5 HP Basemount/Simplex Three-Phase 208-230/460 Volts Disconnect Black Motor Red Pressure electric switch L1 L2 T1 T2 L3 T3 Blue Red Red Red Black Blue Field furnished power supply   Main disconnect and branch circuit protection to be installed by a ...

  • Powerex SBS1517 - page 8

    8 Scroll Air Compr essors T ankmount/Basemount PANEL DATA - 3 PHASE, 60 Hz OVERLOAD SETTINGS TOTAL PANEL F.L.A. F.L.A. TOTAL UNIT 208 230 460 PANEL 208 230 460 HP VOLT VOLT VOLT HP VOLT VOLT VOLT 3 10.29 9.2 4.6 6 21.1 18.9 9.7 5 15.56 14.0 7.0 10 31.6 28.5 14.5 Figure 6 - 3-5 HP Duplex Three-Phase 208-230/460 Volts ...

  • Powerex SBS1517 - page 9

    9 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for SBS Models RESET RESET RESET Ref. SBS Model No. Description Part Number Qty. 1 Motor 3 HP 3 Phase MC022374AV 1 Motor 3 HP 1 Phase MC301519AV 1 Motor 5HP 3 Phase MC022307AV 1 Motor 5HP 1 Phase MC301520AV 1 2 Base BA000301AV 1 3 Angle bracket ST185500AV 4 4 Beltguard back BG303 ...

  • Powerex SBS1517 - page 10

    10 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for STS Models Ref. STS Model No. Description Part Number Quantity 1 Motor: 3 HP 3 Phase MC022374AV 1 3 HP 1 Phase MC301519AV 1 5 HP 3 Phase MC022307AV 1 5 HP 1 Phase MC301520AV 1 2 Starter: 3 HP 230V 1 Phase JP001045AV 1 5 HP 230V 1 Phase JP001046AV 1 3 HP 230V 3 Phase JP001047 ...

  • Powerex SBS1517 - page 11

    11 Scroll Air Compr essors T ankmount/Basemount Replacement Parts List for STD Models Ref. STD Model No. Description Part Number Quantity 1 Motor: 3 HP 3 Phase MC022374AV 1 3 HP 1 Phase MC301519AV 1 5 HP 3 Phase MC022307AV 1 5 HP 1 Phase MC301520AV 1 2 Starter alternator panel: 3 HP 230V 1 Phase ZZ000435AJ 1 5 HP 230V 1 Phase ZZ000436AJ 1 3 HP 230V ...

  • Powerex SBS1517 - page 12

    Scroll Air Compr essors T ankmount/Basemount Powerex • 150 Production Drive • Harrison, OH 45030 • USA Powerex Limited W arranty Powerex 3 Year / 10,000 Hour Extended Parts Limited Warranty - Powerex warrants each Compressor Pump or Scroll Air-End against defects in material or workmanship from the date of purchase for a period of Three years ...

  • Powerex SBS1517 - page 13

    The Powerex Oilless Rotary Scroll Air Compressor has advanced scroll com- pressor technology through the devel- opment of a completely oilless unit. The Powerex Scroll Compressor offers a dynamically balanced air end which insures vibration-free operation. The rotary design permits a continuous 100% duty cycle. No oil separation, oil filtration, or ...

  • Powerex SBS1517 - page 14

    2 Scroll Air Compr essors GREASE DELIVERY SLAE03 SLAE05 Bearing 1st Time 2nd Time 1st Time 2nd Time Orbit Scroll Bearing 5 Times 3 Times 6 Times 4 Times Pin Crank Bearing Orbit Scroll Side 5 Times 3 Times 6 Times 4 Times Pin Crank Bearing Housing Side 5 Times 3 Times 6 Times 4 Times NOTE: Each pump of the grease gun equals 0.65 grams of grease. Fig ...

  • Powerex SBS1517 - page 15

    3 Scroll Air Compr essors Figure 4 Figure 5 Extension Adaptor Needle Adaptor Orbit Scroll Bearings Grease Fitting Housing Side Bearings Maintenance Schedule Operating Hours Item Action needed 500 2500 5000 10,000 15,000 20,000 Remarks Tank Drain moisture Daily Inlet air filter Replace  (Every 2,500 hrs or less) Part #IP032901AV Blower fan Cle ...

  • Powerex SBS1517 - page 16

    expensive filtration. The tip seal should be replaced every 10,000 hours of oper- ation. 1. Confirm if the tip seal you pur- chased is correct for the air end you are repairing (See Parts Listing below). 2. Confirm if the following parts are included (See Figure 6). 1. Remove six nuts with T-type wrench and then FS set from air end (See Figure 7). ...

  • Powerex SBS1517 - page 17

    5 Scroll Air Compr essors Figure 9 Lip Direction Lip Surface (Inside) Enter Side Lip Side (Grooved Bottom) Machined To Avoid Movement During Installation Figure 10 Dust Seal 3 o’clock Position 6 o’clock Position Back-up Tube Figure 8 Figure 11 NOTE: Tips seals for Fixed Scroll and Orbit Scroll have opposing seal cut angels (See NOTE and explana ...

  • Powerex SBS1517 - page 18

    6 Scroll Air Compr essors Figure 12 - Compressor Parts 19 1 2 4 3 6 5 8 7 10 9 12 11 14 15 16 17 18 15 17 A A B B 13 ...

  • Powerex SBS1517 - page 19

    7 Scroll Air Compr essors Ref. Part No. For Models No. Description SLAE03 SLAE05 SLAE03HP SLAE05HP Quantity 1 Airend Pulley 92805020 IP600400AV 92805020 IP600400AV 1 2 Key IP600600AV IP600600AV IP600600AV IP600600AV 1 3 Centrifugal Fan IP601300AV IP601300AV IP601300AV IP601300AV 1 4 Fan Duct (1) IP601400AV IP601400AV IP601400AV IP601400AV 1 5 Fan D ...

  • Powerex SBS1517 - page 20

    Scroll Air Compr essors Powerex • 150 Production Drive • Harrison, OH 45030 • USA Powerex Limited W arranty POWEREX 3 YEAR / 10,000 HOUR EXTENDED PARTS LIMITED WARRANTY - Powerex warrants each Compressor Pump or Scroll Air-End against defects in material or workmanship from the date of purchase for a period of Three years or 10,000 hours , wh ...

Fabricante Powerex Categoría Air Compressor

Los documentos del dispositivo Powerex SBS1517 que obtenemos del fabricante se pueden dividir en varios grupos. Entre ellos están::
- dibujos técnicos Powerex
- manuales de instrucciones SBS1517
- hojas de producto Powerex
- folletos informativos
- o etiquetas energéticas Powerex SBS1517
Todos son importantes, pero lo más importante desde el punto de vista del usuario de un dispositivo lo encontraremos en el manual de instrucciones Powerex SBS1517.

Un conjunto de documentos determinado como manual de instrucciones se divide también en tipos más detallados, tales como: instrucciones de montaje Powerex SBS1517, instrucciones de servicio, instrucciones cortas o instrucciones de usuario Powerex SBS1517. Dependiendo de la situación debes buscar el documento que necesitas. En nuestra página puedes consultar el manual de instrucciones más popular del producto Powerex SBS1517.

Manuales de instrucciones parecidos

El manual de instrucciones del dispositivo Powerex SBS1517, ¿cómo debería ser?
El manual de instrucciones, también determinado como el manual de usuario o simplemente instrucciones, es un documento técnico que tiene como objetivo ayudar a los usuarios a utilizar Powerex SBS1517. Las instrucciones normalmente las realiza un escritor técnico pero en un lenguaje comprensible para todos los usuarios de Powerex SBS1517.

El manual de instrucciones completo de Powerex debe contener unos elementos básicos. Una parte de ellos es menos importante, como por ejemplo: la portada / la página principal o las páginas de autor. Sin embargo, lo demás debe facilitarnos la información más importante desde el punto de vista del usuario.

1. Introducción y pistas sobre cómo orientarse con el manual Powerex SBS1517 - Al principio de cada manual se deben encontrar las indicaciones acerca de la manera de usar un manual de instrucciones. Debe contener información sobre dónde encontrar el índice Powerex SBS1517, preguntas frecuentes o problemas más comunes – son los apartados más buscados por los usuarios de cada manual de instrucciones.
2. Índice - listados de todos los consejos acerca de Powerex SBS1517 que encontraremos en el documento
3. Consejos de uso de las funciones básicas del dispositivo Powerex SBS1517 - que deben facilitarnos los primeros pasos durante el uso de Powerex SBS1517
4. Troubleshooting - una secuencia sistematizada de acciones que nos ayudará a diagnosticar los problemas más importantes con Powerex SBS1517
5. FAQ - las preguntas frecuentes
6. Datos de contacto Información acerca de cómo encontrar los datos de contacto del fabricante / servicio de Powerex SBS1517 en cada país si no somos capaces de solucionar el problema por nuestra cuenta.

¿Tienes una pregunta acerca de Powerex SBS1517?

Utiliza el formulario que se encuentra abajo

Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Powerex SBS1517, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Powerex SBS1517 probablemente compartirá una forma de solucionarlo.

Copia el texto de la imagen

Captcha
Nueva imagen

Comentarios (0)