-
Carson SC-1002 - page 1
TB0362A Page 1 of 14 05/28/10 Carson Manufacturing Co., Inc. 5451 North Rural Street Indianapolis, IN 46220 Phone: (888) 577-6877 Fax: (317) 254-2667 www.c ar so ns ir en s. co m TECHNICAL BULLETIN INSTALLATION AND OPERATING MANUAL SC-1002 / 1012 / 1022-10 14V (Old Version) Different DIP Switch Options Carson is a trademark of Carson Manufacturing ...
-
Carson SC-1002 - page 2
TB0362A Page 2 of 14 05/28/10 SC-1000 / 1012 / 1022-10 SPECIFICATIONS AMPLIFIER INPUT POWER: 9-16 Volts DC, 8 Amps DC SIREN MODE OUTPUT POWER: 105 Watts RMS (15 VDC input, 100W speaker) SIREN FREQUENCY: 700Hz - 1500Hz Nominal CYCLE RATES: MECHANICAL - 5 cycles/min WAIL - 13 cycles/min YELP - 190 cycles/min PHASER - 15 cycles/sec TWO-TONE - 1 cycle/ ...
-
Carson SC-1002 - page 3
TB0362A Page 3 of 14 05/28/10 INSTALLATION Proper installation of the unit is essential for years of safe, reliable operation. Please read all instruction before installing the unit. Failure to follow these instructions can cause serious damage to the unit or vehicle and may void warranties. SAFETY PRECAUTIONS For the safety of the installer, v ehi ...
-
Carson SC-1002 - page 4
TB0362A Page 4 of 14 05/28/10 INSTALLER-SELECTABLE OPTIONS An internal 8-position DIP switch on the circ uit board may be changed to select various options. Accessing Option Sw itches - the DIP switch is located just behind the fr ont panel of the amplifier. Use a 7/64” allen wrench to remove the 4 corner screws then remove front panel. Adjusting ...
-
Carson SC-1002 - page 5
TB0362A Page 5 of 14 05/28/10 ELECTRICAL CONNECTIONS Disconnect vehicle battery before making any electrical connections. Electrical connections to the unit are made using a removable terminal block plug and screw terminals located on the amplifier. A label on the unit identifies each terminal func tion. Install the plug on the unit before wiring. ...
-
Carson SC-1002 - page 6
TB0362A Page 6 of 14 05/28/10 BAT + - Plug installed this orientation 6-P Terminal Block Plug (CP4956-06) RED #16G BLK #18G BRN #22G WHT 15A Automotive Type Fuse 25A Automotive Type Fuse Load 1 Load 2 Back of Unit Gau g e see table Gauge see table On SC-1002 / 1012 Enable Input must be connected unless option SW-2 is set. See INSTALLER SELECTABLE O ...
-
Carson SC-1002 - page 7
TB0362A Page 7 of 14 05/28/10 ELECTRICAL CONNECTIONS CONTINUED (SC-1012 only) Plug installed this orientation 10-P Terminal Block Plug (CP4688-10) Front of Unit LT1 and LT2 Lighted Rocker Switch Circuit LAMP A UTO MAN YELP MECH PHSR HORN LT1 LT2 NEG REMOTE PANEL Plug into unit first for terminal identification MAN A UTO S T B Y W A I L Y ELP MECH P ...
-
Carson SC-1002 - page 8
TB0362A Page 8 of 14 05/28/10 ELECTRICAL CONNECTIONS CONTINUED (SC-1022 only) Front of Unit HAND CONTROL Plug hand control into unit SC-1022 MAN LT1 MECH YELP HORN LT2 WAIL PHSR Note: Cable may be extended with ED1753 Hand Control Cable Extension Kit. Do not extend with other cables which may cause unreliable operation or damage. ...
-
Carson SC-1002 - page 9
TB0362A Page 9 of 14 05/28/10 OPERATION SC-1002 and SC-1012 Models Sound Hazard - Sound level from siren speaker (>120d BA @ 10 feet) may cause hearing damage. Do not operate siren without adequate hearing protec tion for you and anyone in immediate vicinity. (Ref. OSHA 1910.95 for occupational noise exposure guidelines) POWER ON/OFF Power to th ...
-
Carson SC-1002 - page 10
TB0362A Page 10 of 14 05/28/10 OPERATION SC-1022 Model Sound Hazard - Sound level from siren speaker (>120d BA @ 10 feet) may cause hearing damage. Do not operate siren without adequate hearing protec tion for you and anyone in immediate vicinity. (Ref. OSHA 1910.95 for occupational noise exposure guidelines) POWER ON/OFF The unit is normally tu ...
-
Carson SC-1002 - page 11
TB0362A Page 11 of 14 05/28/10 SERVICE This unit is designed to provide years of reliable servic e under even the worst conditions. Many times there may appear to be a problem with the unit when the true problem is in the speaker, cont rolled devices, or improper installation. The following chart show s typical symptoms and possible causes. A blown ...
-
Carson SC-1002 - page 12
TB0362A Page 12 of 14 05/28/10 SC-1002 PARTS Item Part # Description 1 CP4837 Button, Switch Cap Red 2 CP4989-02 Connector, 2-P terminal block 3 CP4957-06 Connector, 6-P header CP4739 Cover, extruded (does not incl ude Front Panel or slide out Chassis) 4 CP4990-150 Fuse, 15 Amp Mini Automotive (Siren) 5 CP4990-250 Fuse, 25 Amp Mini Automotive (Lite ...
-
Carson SC-1002 - page 13
TB0362A Page 13 of 14 05/28/10 SC-1012 PARTS Item Part # Description 1 CP4989-02 Connector, 2-P terminal block 2 CP4957-06 Connector, 6-P header 3 CP4687-10 Connector, 10-P header CP4739 Cover, extruded (does not incl ude Front Panel or slide out Chassis) 4 CP4990-150 Fuse, 15 Amp Mini Automotive (Siren) 5 CP4990-250 Fuse, 25 Amp Mini Automotive (L ...
-
Carson SC-1002 - page 14
TB0362A Page 14 of 14 05/28/10 SC-1022 PARTS Item Part # Description 1 CP4989-02 Connector, 2-P terminal block 2 CP4957-06 Connector, 6-P header 3 520242-3 Connector, 6-P modular receptacle CP4739 Cover, extruded (does not incl ude Front Panel or slide out Chassis) 4 CP4990-150 Fuse, 15 Amp Mini Automotive (Siren) 5 CP4990-250 Fuse, 25 Amp Mini Aut ...
¿Tienes una pregunta acerca de Carson SC-1002?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Carson SC-1002, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Carson SC-1002 probablemente compartirá una forma de solucionarlo.