-
Panasonic M157594J - page 1
M157594J Installation, Operation, a nd Maintenance Manua l HOT WATER PRESSURE WAS HER : C leans d irty surfaces with high pressure hot water. To the Owner: Thank you fo r purchasing a NorthStar hot w ater pressure w asher. Your machine is designed f or long lif e, dependability, and th e top performance you dem and ! Take time now to read through t ...
-
Panasonic M157594J - page 2
2 Table of Contents Important Saf ety Instruction s 2 Maintenance Instructions 10 Specifications 3 Long Term /Winter Storage 12 Machine Com ponent Identification 4 T roubleshooting 13 Installation Instructi ons 5-6 Parts Breakdowns 14-16 Operation Instr uctions 7-9 Electrical Schem atic 17 Safety F eatures 9 Trailer A ssem bly Instructio ns (157595 ...
-
Panasonic M157594J - page 3
Specifications 3 Pressure Rating 4000 psi Flow Output 4 gpm Pump Type Cat 66DX W ater Supply Standard tap water @ 20 -75 psi or water feed ta nk Engine Horsepower 18 hp BTU Output 353,700 BTU Maximum Temperature 210 F Approved Fuels #1 or #2 Diesel, Ker osene, Fuel Oil Fuel Capacity 4 Gal Gasoline Capacity 4 Gal Discharge Hose 3/8” Dimensions ...
-
Panasonic M157594J - page 4
Machine Component Id entification 4 Ref # Description Ref # Description Ref # Description 1 Unloader 9 Ball Valve (feed tank ) 16 W ater Outlet 2 Lifting E ye 10 Ball Valve (c ity tap water) 17 Engine Ke y Switch 3 Engine (see e ngine manua l) 11 W ater Filter 18 Circuit Break er 4 Inlet Plum bing 12 W ater Inlet (city tap water) 19 Heat Switch 5 D ...
-
Panasonic M157594J - page 5
Installation Instructions 5 Installing a Batter y Warning: Sulfuric acid is a corrosive poiso n. Avoid contact w ith skin, e yes or clothing. Alwa ys wear safet y glasses. A lways wear s afety glass es when wo rking on or near the battery. The engine will not run a nd the burner wi ll not f ire without first inst alling a batt ery. The batter y box ...
-
Panasonic M157594J - page 6
Installation Instructions 6 Venting DANGER: Do not run machine indo ors or in an enclosed area w ithout adequate vent ilation, or in areas where flammab le vapors, (gasoline, solv ents, etc.) may be present. Do not v ent exhaust gases into a wall, a ceiling , or a con cealed place. CAUTION: All venting must be in accordance w ith applicable state a ...
-
Panasonic M157594J - page 7
Operating Instructions 7 Read and understand the entire manual before operating the pressure washer. Follow these instructions ev ery time you use the pressure washer. I.) Pre-Operation Read entire m anual, especially the important safet y instructions. 1.) Check hoses, fittings, wand, trigger gun a nd fuel connections for sig ns of wear, crack s a ...
-
Panasonic M157594J - page 8
Operating Instructions 8 V.) Turn Water Supply ON (city water tap only) Make sure the hose i s not “k inked”. A k inked hose will provide insuff icient water supply to the pump and will reduce its life. Make sure the h ose remains unk inked after moving th e pressure washer. VI.) Attach Nozzle Color of Noz zle: Spra y A ngle Used For: Red 0 Hig ...
-
Panasonic M157594J - page 9
Operating Instructions 9 X.) For Hot Water If HOT water is des ired, m ake sure there is f uel in the fuel tank, turn the heat switch ON, and adjust the thermos tat to the desired temperature. T he burner will fire when the trigger is squeeze d. You m ay need to initially adjust your burner f or peak perform ance. See the “Oil Burner” section u ...
-
Panasonic M157594J - page 10
Maintenance Instructions 10 WARNING: Unauthorized machi ne modification or use of non-approved re placement parts may cause pers onal injury and/or property damage and will void the ma nufacturer warranty . See Engine manual for engine maintenance . Maintenance Mode Before perform ing any maint enance on the press ure washer, it m ust be placed in ...
-
Panasonic M157594J - page 11
Maintenance Instructions 11 Coil Descaling In hard water areas, scale build-u p within the heating coil will occur. Scale deposits will decrease the wat er temperature ris e and m ay eventuall y clog the heat ing coil. 1. Mix c oil cleaner in a 5 g allon buck et and elevate t he bucket s o it is higher than t he unloader. 2. Attach th e high-pressu ...
-
Panasonic M157594J - page 12
Long Term / Winter Storage 12 During cold w eather, stor e the pressur e washer in doors and mov e it outdoors bef ore startin g the eng ine. Long T erm Storage and Freeze Protection 1.) Attach a feed ta nk or buc ket to the water i nlet (feed t ank). See Installation s ection for Attach ing a W ater Feed Tank instructions. 2.) Fill feed tank with ...
-
Panasonic M157594J - page 13
Troubleshooting Guide 13 Engine Will Not Start Causes Solutions Low Oil Shutdown Fill engine with the adequate a mount of oil. Cold Engine Choke engine to start. No Fuel Add gas t o engine, make sure fuel sh utoff valve is open. Dead Battery Recharge/Replace battery. Spark plug wire n ot attached Attach spark plu g wire to spark plug. Pressure Wash ...
-
Panasonic M157594J - page 14
Parts Breakdown 157594J 14 ...
-
Panasonic M157594J - page 15
Component List – 157594J 15 REF PA RT # DESCRIPTION Model QTY REF PART # DESCRIPTION Model QTY 777222 Honda engine 1 8hp All 1 55 777486 Heat shield, battery All 1 1 32842 Honda muffler kit All 1 56 777 485 Tank clamp All 1 2 3 0511 1/2npt plug All 1 57 777 666 Decal, gasoline All 1 3 777837 3/8npt plug A ll 1 58 7 77721 Decal, side panel All 2 4 ...
-
Panasonic M157594J - page 16
Parts Breakdown – 157595J 16 REF P ART # DESCRIPTION QTY REF PART # DESCRIPTION QTY 1 779257 Hose Reel 2 19 5318 Nipple ¾ NPT x ¾ Hose Barb 1 3 777903 Frame, Sk id 1 20 5370 Bulkhead ¾” N PT Fem ale 3 4 3019 8 200 Gal T ank 1 21 50NB R12 ½ Hose Barb x ¾ NPT Elbow 1 5 777707 Tank Strap 2 22 17141 Hose Clam p ¾ 1 6 8208 0 Eye Bolt, ¼” 4 ...
-
Panasonic M157594J - page 17
Wiring Diagram – Rev J 17 ...
-
Panasonic M157594J - page 18
Trailer Assembly Instructions (157595 only) 18 1.) Remove the top and four s ides of the ste el crate. 2.) Remove a-f rame f rom trailer fram e. (k eep fasteners f or step 7) 3.) Slide a-fram e into holders under trailer f rame (built into the f ront posts) . 4.) Install jack onto a-fram e with 3/8x1” bolts , Class G lock nuts, and washers pr ovi ...
-
Panasonic M157594J - page 19
19 This page has intentionally been left blank. ...
-
Panasonic M157594J - page 20
20 Manufactured by Northern Tool + Equipment Co., 2800 SouthCross Drive West P.O. Box 1499 Burnsville, MN 55337-0499 TM ...
¿Tienes una pregunta acerca de Panasonic M157594J?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Panasonic M157594J, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Panasonic M157594J probablemente compartirá una forma de solucionarlo.