Español dropdown-ico

Manual de instrucciones Carrier ASPASICCA012

24 de páginas 2.15 mb
Descargar

Pasar a la página of 24

Summary
  • Carrier ASPASICCA012 - page 1

    ® Owner's Manual US Air-cooled, Prepackaged Automatic Standby Generators Models: ASPASICCA007 (6 kW NG, 7 kW LP) ASPASICCA012 (12 kW NG, 12 kW LP) ASPASICCA015 (13 kW NG, 15 kW LP) © Not intended for use as Primary Power in place of utility or in life-support applications. DEADLY EXHAUST FUMES. OUTDOOR INSTALLATION ONLY!! ...

  • Carrier ASPASICCA012 - page 2

    INTRODUCTION Thank you for purchasing this model of the Carrier product line. This model is a compact, high performance, air-cooled, engine-driven generator designed to automatically supply electrical power to operate critical loads during a utility power failure. This unit is factory installed in an all-weather, metal enclosure that is intended ex ...

  • Carrier ASPASICCA012 - page 3

    Table of Contents Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators Introduction ........................ Inside Front Cover Read This Manual Thoroughly .............................. iFC Contents ................................................................ iFC Operation and Maintenance .................................. iFC How to Obtain Ser ...

  • Carrier ASPASICCA012 - page 4

    SAFETY RULES IMPORTANT SAFETY INSTRUCTIONS Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators SAVE THESE INSTRUCTIONS - The manufacturer suggests that these rules for safe operation be copied and posted near the unit's installation site. Safety should be stressed to all operators and potential operators of this equipment. GENERAL HAZARDS Stud ...

  • Carrier ASPASICCA012 - page 5

    IMPORTANT SAFETY INSTRUCTIONS Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators SAFETY RULES /A ELECTRICAL HAZARDS • All generators covered by this manual produce dangerous electrical voltages and can cause fatal electrical shock. Utility power delivers extremely high and dangerous voltages to the transfer switch as does the standby generator w ...

  • Carrier ASPASICCA012 - page 6

    o • o GENERAL NFORMATON Section 1 -- General Information Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators _Only qualified electricians or contractors should attempt such installations, which must comply strictly with applicable codes, standards and regulations. 1.1 UNPACKING/INSPECTION After unpacking, carefully inspect the contents for damage ...

  • Carrier ASPASICCA012 - page 7

    Section 1 -- General Information Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators GENERAL INFORMATION 1.4 THE GENERATOR Figure 1.1 - 7 kW, Single Cylinder GH-410 Engine Exhaust Enclosure Oil Data Dipsiick ', Decal , , ', , Conirol _0 /' C / GFCI ........ Outlet Fuel -" Fuel ..... " Inlel Oil Filler " Batte ...

  • Carrier ASPASICCA012 - page 8

    o • o GENERAL NFORMAT ON Section 1 -- General Information Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators 1.5 SPECIFICATIONS 1.5.1 GENERATOR Model Rated Max. Continuous Power Capacity (Watts*) Rated Voltage Rated Max. Continuous Load Current (Amps) 120 Volts** 240 Volts Main Line Circuit Breaker Phase Number of Rotor Poles Rated AC Frequency ...

  • Carrier ASPASICCA012 - page 9

    Section 1 -- General Information Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators GENERAL INFORMATION Should the primary fuel need to be changed to LP gas, the fuel system needs to be reconfigured. See Section 1.9 for instructions on reconfiguration of the fuel system. Recommended fuels should have a Btu content of at least 1,000 Btus per cubic ...

  • Carrier ASPASICCA012 - page 10

    GENERAL INFORMATION Section 1 -- General Information Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators 1.10 BATTERY INSTALLATION Fill the battery with the proper electrolyte fluid if necessary and have the battery fully charged before installing it. Before installing and connecting the battery, complete the following steps: 1. Set the generator&a ...

  • Carrier ASPASICCA012 - page 11

    Section 2 -- Operation Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators OPERATION Servicing of the battery is to be performed or supervised by personnel knowledgeable of batteries and the required precautions. Keep unauthorized personnel away from batteries. When replacing the battery, use the following type of battery: Group 26 12-volt DC, nega ...

  • Carrier ASPASICCA012 - page 12

    OPERATION Section 2 -- Operation Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators 2.3 AUTOMATIC TRANSFER OPERATION To select automatic operation, do the following: 1. Make sure the transfer switch main contacts are set to their UTILITY position, i.e., loads connected to the utility power source (Figure 2.2). 2. Be sure that normal UTILITY power ...

  • Carrier ASPASICCA012 - page 13

    Section 2 -- Operation Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators OPERATION 2.5 MANUAL TRANSFER OPERATION 2.5.1 TRANSFER TO GENERATOR POWER SOURCE To start the generator and activate the transfer switch manually, proceed as follows: 1. Set the generator's AUTO/OFF/MANUAL switch to OFF. 2. Set the generator's main circuit breaker ...

  • Carrier ASPASICCA012 - page 14

    OPERATION Section 2 -- Operation Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators NOTE: The exerciser will only work in the AUTO mode and will not work unless this procedure is performed. The exerciser will need to be reset every time the 12-volt battery is disconnected and then reconnected. ;_ CAUTION _The exerciser WILL NOT work if dip switch ...

  • Carrier ASPASICCA012 - page 15

    Section 3 -- Maintenance Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators POS__ iNSTALLATiON STAR.UP ADJUSTMENTS Figure 3.1 - Generator Control Panel ' EX EEHNAL I 0UTLET FUSE z _ GFCI 75A ...... _ C_RGU_T AUTO OFF MAN BREAKER 12 VDC SYST O i i • i i SET EXERCISE ACCESSORY TIME OUTLET 75A MAX 3.2 CHECKING THE ENGINE OIL LEVEL For oil capa ...

  • Carrier ASPASICCA012 - page 16

    MAINTENENANCE Section 3 -- Maintenance Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators Figure 3.4 - Oil Drain Hose and Filter Low OH Switch HighT_ _Switch ¢ OH FHter 3.4 CHANGING THE OIL FILTER Change the engine oil filter as follows: 1. With the oil drained, remove the old oil filter by turning it counterclockwise. 2. Apply a light coating of ...

  • Carrier ASPASICCA012 - page 17

    Section 3 -- Maintenance Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators MAINTENENANCE Figure 3.7 - Setting the Spark Plug Gap SET PLUG GAP AT 0.76 mm (.030 inch) - 7 kW 0.508 mm (.020 inch) - 12 kW & 15 kW 3.7 BATTERY MAINTENANCE The battery should be inspected per the "Service Schedule," Section 4.1. The following procedure shou ...

  • Carrier ASPASICCA012 - page 18

    MAINTENENANCE Section 3 -- Maintenance Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators Figure 3.8 - Coofing Vent Locations [] D t °_ WARNING /dR INTAKF _The exhaust from this product gets extremely hot and remains hot after shutdown. High grass, weeds, brush, leaves, etc. must remain clear of the exhaust. Such materials may ignite and burn fro ...

  • Carrier ASPASICCA012 - page 19

    Section 4 -- Service Schedule Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators SERVICE 4.1 SERVICE SCHEDULE ATTENTION: It is recommended that all service work be performed by the nearest Carrier Dealer. SYSTEM/COMPONENT PROCEDURE FREQUENCY X = Action Inspect Change Clean W = Weekly R = Replace as Necessary M = Monthly * = Notify Dealer Y = Yearl ...

  • Carrier ASPASICCA012 - page 20

    TROUBLESHOOTING Section 5 - Troubleshooting Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators 5.1 TROUBLESHOOTING GUIDE PROBLEM CAUSE CORRECTION The engine will not crank. 1. Fuse blown. 1. 2. 2. 3. 3. 4. 4. * 5. 5. Loose, corroded or defective battery cables. Defective starter contactor. (7 kW) Defective starter motor. Dead Battery. Replace 15A ...

  • Carrier ASPASICCA012 - page 21

    Section 6 -- Warranty Carrier Air-cooled 7 EW, 12 EW and 15 EW Generators CARRIER "TWO YEAR" LIMITED WARRANTY FOR "PREPACKAGED EMERGENCY AUTOMATIC STANDBY GENERATORS" For a period of two years from the date of original sale, warrants that its generator will be free from defects in material and workmanship for the items and perio ...

  • Carrier ASPASICCA012 - page 22

    Section 6 - Warranty Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board (CARB) and Generac Power Systems, Inc. (Generac) are pleased to explain the Emission Control System Warranty on your new engine.* In California, new utility, ...

  • Carrier ASPASICCA012 - page 23

    Section 6 - Warranty Carrier Air-cooled 7 EW, 12 EW and 15 EW Generators EMISSION CONTROL SYSTEM WARRANTY Emission Control System Warranty (ECS Warranty) for 1995 and later model year engines: (a) Applicability: This warranty shall apply to 1995 and later model year engines. The ECS Warranty Period shall begin on the date the new engine or equipmen ...

  • Carrier ASPASICCA012 - page 24

    ® PART NO. 0F6902 CATALOG NO. OMASPAS07-2 REV. * (6/01/05) PRINTED IN U.S.A. ...

Fabricante Carrier Categoría Portable Generator

Los documentos del dispositivo Carrier ASPASICCA012 que obtenemos del fabricante se pueden dividir en varios grupos. Entre ellos están::
- dibujos técnicos Carrier
- manuales de instrucciones ASPASICCA012
- hojas de producto Carrier
- folletos informativos
- o etiquetas energéticas Carrier ASPASICCA012
Todos son importantes, pero lo más importante desde el punto de vista del usuario de un dispositivo lo encontraremos en el manual de instrucciones Carrier ASPASICCA012.

Un conjunto de documentos determinado como manual de instrucciones se divide también en tipos más detallados, tales como: instrucciones de montaje Carrier ASPASICCA012, instrucciones de servicio, instrucciones cortas o instrucciones de usuario Carrier ASPASICCA012. Dependiendo de la situación debes buscar el documento que necesitas. En nuestra página puedes consultar el manual de instrucciones más popular del producto Carrier ASPASICCA012.

Manuales de instrucciones parecidos

El manual de instrucciones del dispositivo Carrier ASPASICCA012, ¿cómo debería ser?
El manual de instrucciones, también determinado como el manual de usuario o simplemente instrucciones, es un documento técnico que tiene como objetivo ayudar a los usuarios a utilizar Carrier ASPASICCA012. Las instrucciones normalmente las realiza un escritor técnico pero en un lenguaje comprensible para todos los usuarios de Carrier ASPASICCA012.

El manual de instrucciones completo de Carrier debe contener unos elementos básicos. Una parte de ellos es menos importante, como por ejemplo: la portada / la página principal o las páginas de autor. Sin embargo, lo demás debe facilitarnos la información más importante desde el punto de vista del usuario.

1. Introducción y pistas sobre cómo orientarse con el manual Carrier ASPASICCA012 - Al principio de cada manual se deben encontrar las indicaciones acerca de la manera de usar un manual de instrucciones. Debe contener información sobre dónde encontrar el índice Carrier ASPASICCA012, preguntas frecuentes o problemas más comunes – son los apartados más buscados por los usuarios de cada manual de instrucciones.
2. Índice - listados de todos los consejos acerca de Carrier ASPASICCA012 que encontraremos en el documento
3. Consejos de uso de las funciones básicas del dispositivo Carrier ASPASICCA012 - que deben facilitarnos los primeros pasos durante el uso de Carrier ASPASICCA012
4. Troubleshooting - una secuencia sistematizada de acciones que nos ayudará a diagnosticar los problemas más importantes con Carrier ASPASICCA012
5. FAQ - las preguntas frecuentes
6. Datos de contacto Información acerca de cómo encontrar los datos de contacto del fabricante / servicio de Carrier ASPASICCA012 en cada país si no somos capaces de solucionar el problema por nuestra cuenta.

¿Tienes una pregunta acerca de Carrier ASPASICCA012?

Utiliza el formulario que se encuentra abajo

Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Carrier ASPASICCA012, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Carrier ASPASICCA012 probablemente compartirá una forma de solucionarlo.

Copia el texto de la imagen

Captcha
Nueva imagen

Comentarios (0)