-
Cal Flame BBQ11955P - page 1
...
-
Cal Flame BBQ11955P - page 2
Copyright 2011 LMS, Inc. All rights re- served. Duplication without writ ten consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice. L TR50001100, Rev . A 4/26/11 250-403 CONTACT INFORMATION For customer ...
-
Cal Flame BBQ11955P - page 3
Safety Instructions 1 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Placement and Location The Cal Flame Power Burner is designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structure, or in any type of enclosed area such as a ga- rage, shed, or breez eway . K eep clea ...
-
Cal Flame BBQ11955P - page 4
2 Safety Instructions Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Operation Do not use the Power Burner f or oth • er than its intended use. Never use the Power Burner if the drip pan is not in place. The drip • pan should be pushed all the w ay in under the P ower Burner . Fire or explosion can result from an improp ...
-
Cal Flame BBQ11955P - page 5
Safety Instructions 3 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m garments while using your Power Burner . F abric may ignite and result in personal injury . When using the P ower Burner , do not touch the grate or immediate • surroundings as these areas become extremely hot and can cause burns. Only use dry pot holder ...
-
Cal Flame BBQ11955P - page 6
4 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Most cities and counties require permits for exterior construction. In addition, some communities have codes requiring residential barriers such as fencing and/or self -closing gates on pr operty to prev ent unsu- pervised access to the pr operty by c ...
-
Cal Flame BBQ11955P - page 7
Installation / Assembl y 5 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Cabinet Cut-out Dimensions Y our Cal Flame P ower Burner is designed for easy installation into a non-combustible enclosure. The supporting deck or counter must be at and level. Width Depth Height 18” 20” 9 ¼” WIDTH DEPTH HEIGHT ...
-
Cal Flame BBQ11955P - page 8
6 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m LP Gas Tank Requirements For plumbed-in LP installation, use a convertible regulator and set it for LP gas. Maximum line pressure for plumbed-in propane is 14” WC (3.5 kP a). Minimum line pressure for pr opane is 11” WC. The Power B urner must be ...
-
Cal Flame BBQ11955P - page 9
Installation / Assembl y 7 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m The maximum fuel capacity is 20 lbs. of propane, or 5 gallons. Full cyl- inder weight should be approximately 38 lbs. (43.7 lbs. nominal water capacity . ) Never ll the cylinder beyond 80% full. Place the dust cap on the cylinder valve outlet whene ...
-
Cal Flame BBQ11955P - page 10
8 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Natural Gas Requirements Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the P ower Burner is manufactured f or . IMPOR T ANT : Never connect the P ower Burner to an unregulated gas supply . The installa ...
-
Cal Flame BBQ11955P - page 11
Installation / Assembl y 9 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any part of the gas system is disconnected ...
-
Cal Flame BBQ11955P - page 12
10 Installation / Assembl y Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Placing the Power Burner in a Built-in Enclosure You may need a second person to help you to avoid damag- ing the Power Burner or your enclosure. Before installing the P ower Burner in an enclosure, make sure that the opening is not bigger than the o ...
-
Cal Flame BBQ11955P - page 13
Using Y our Grill 11 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Read all instructions before you operate your Power Burner. W e recommend you w ash the Power Burner thoroughly with soap and water prior to lighting it for the rst time. Oils are used during the manufacturing process and some residual oil may still be o ...
-
Cal Flame BBQ11955P - page 14
12 Using Y our Grill Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Basic Operation Before lighting, make sure all burner controls are off . Do not at- tempt to light the burners if the smell of gas is present. Check the connection with a soap and w ater solution after attaching the hose. For LP units, make sure there is ga ...
-
Cal Flame BBQ11955P - page 15
Using Y our Grill 13 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Lighting the Power Burner Electronic Ignition Lift the cover . 1. K eep your face as f ar awa y from the burners as possible. 2. T urn the burner knob counter clockwise past the light position 3. to HIGH. Y ou will hear a loud click as the electronic lighte ...
-
Cal Flame BBQ11955P - page 16
14 Using Y our Grill Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Power Burner Lid W e strongly recommend you remove the lid for your P ower Burner before each use. The P ower Burner lid is attached to the unit by two hinges on each side. Each hinge has a detachable spring-loaded hinge pin that re- moves easily when pulle ...
-
Cal Flame BBQ11955P - page 17
Using Y our Grill 15 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Using the Wok Ring If you have a wok, you can use it wi th the P ower B urner . Remove the grate and set it aside. Inside the burner ar ea, surrounding the brass burners, is a stainless steel ring that will securely hold your wok in place while you cook wit ...
-
Cal Flame BBQ11955P - page 18
16 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Cleaning and Maintenance Removing and Replacing Burners The burner has three pieces plus a wok ring. If y ou remo ve the burner for cleaning, make sure to clean each piece and replace them in proper order . Removal Disconnect or shut of f the gas lin ...
-
Cal Flame BBQ11955P - page 19
Cleaning and Maintenance 17 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Replacement Set the burner body in place, 1. making sure the stud in prop- erly seated and the burner body is at and level. Set the burner ring on the 2. burner body , making sure the pin on the burner ring is seat- ed in the notch on the burner b ...
-
Cal Flame BBQ11955P - page 20
18 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m T o ensure safe and proper maintenance, we recommend you follow these directions caref ully . Clean internal parts of the Power Burner regularly as determined by the amount of use and foods cooked. The entire Power Burner should be cleaned at least o ...
-
Cal Flame BBQ11955P - page 21
Cleaning and Maintenance 19 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Caution Do not use WD-40 or Sheila Shine near food or on food preparation surfaces as it is a health hazard. This includes the interior of the Power Burner and the gr ate. Cleaning Products and Materials Avoid using these common cleaning products and ...
-
Cal Flame BBQ11955P - page 22
20 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Clean 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or F or- mula 409 to remove hea vier soil. Rinse 2. Thoroughly rinse all surfaces and dry them completely with a clean ...
-
Cal Flame BBQ11955P - page 23
Cleaning and Maintenance 21 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less ), but it is not stain-proof . If not properly protected and maintained, it can corrode, pit ...
-
Cal Flame BBQ11955P - page 24
22 Cleaning and Maintenance Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m from the P ower Burner by carefully lifting each burner up and away from the gas v alve orice. Use a wire brush to clean the outer surface of each burner to remove food residue and dirt. Clean any clogged ports with a stiff wire such as an opened ...
-
Cal Flame BBQ11955P - page 25
Appendix 23 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Troubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure on page 9. Problem: Burner does not ignite Solution: Use the following procedure with the gure below . Check the po ...
-
Cal Flame BBQ11955P - page 26
24 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Problem: Plugged orice Solution: Unplug the orice as follows: Remov e grate and gr ease tray . • Remov e the burner ring and the outer burner . • Carefully lift the center burner up and away from • the gas orice. Remov e the orice from the control ...
-
Cal Flame BBQ11955P - page 27
Appendix 25 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Problem: Misalignment of Igniter on Burner Solution: Check for proper position of the electrode tip , which • should be pointing forward towar ds the front of the burner and free of grease to allow proper sparking. The ignition wire should be connected rmly to ...
-
Cal Flame BBQ11955P - page 28
26 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m All Cal Flame gas appliances are manufactur ed to operate with standard liquid propane (LP and can be converted to burn natural gas (NG). There are two steps required to con vert from LP to NG. You must perform both steps. Step 1: Switching the regulator behind the ...
-
Cal Flame BBQ11955P - page 29
Appendix 27 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Step 1: Switching the regulator The regulator in the image below has been removed to illustrate this pro- cedure. Remov e the LP gas line. 1. Remov e the cap tting from the 2. end of the NG gas regulator . Place the cap tting over the LP 3. gas inlet. Insert a ...
-
Cal Flame BBQ11955P - page 30
28 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Step 2: Changing the burner orices Remov e the grate, burner ring, 1. and burner from the Power Burn- er . Locate the gas orices. They will 2. be directly behind the gas v alves. Using a 6mm socket or nut driver , 3. remove the orice. Y ou will need: 6 mm s ...
-
Cal Flame BBQ11955P - page 31
Appendix 29 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Apply a small amount of pipe compound to the orice threads. 4. Screw in the orice until it is nger tight. 5. Tighten the orice with the 6mm wrench. 6. Repeat the abo ve steps for the remaining burners. 7 . Replace the burners and the gr ate. 8. Mark the ...
-
Cal Flame BBQ11955P - page 32
30 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Limited Warranty LMS w arrants the P ower Burner and associated hardwar e fr om defects in material and workmanship f or a period of one year from the original date of purchase. This includes deterior ation and corrosion of burners, mountings, and lid and body . Ext ...
-
Cal Flame BBQ11955P - page 33
Appendix 31 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m This warranty is void if the barbecue gril l has been subject to negligence, alteration, misuse, repairs, dings, dents, scratches, or incorrect and / or prohibited applications, as specied in the owner’s manual. Gas lines must be installed by a licensed plumber ...
-
Cal Flame BBQ11955P - page 34
32 Appendix Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m Legal Remedies This limited warranty gives you specic legal rights. Y ou may have other rights, which may v ary from state to state. Customer Service For customer service, contact the authorized selling dealer immediately . If you need additional information or a ...
-
Cal Flame BBQ11955P - page 35
Appendix 33 Power Burner L TR50001100, Rev . A w ww . c a l a m e b b q . c o m ...
-
Cal Flame BBQ11955P - page 36
L TR50001100, Rev . A 4/26/11 California Proposition 65 Warning: Chemicals known to the State of California to cause cancer , birth defects or other reproductive harm are found in and/or created by the combustion of natural gas, propane, butane and other fuels. Always operate this unit as described in the owner’s manual and in well ventilated are ...
¿Tienes una pregunta acerca de Cal Flame BBQ11955P?
Utiliza el formulario que se encuentra abajo
Si con la ayuda del manual de instrucciones encontrado no has podido solucionar tu problema con Cal Flame BBQ11955P, haz una pregunta utilizando el formulario que se encuentra abajo. Si alguno de los usuarios ha tenido un problema parecido con Cal Flame BBQ11955P probablemente compartirá una forma de solucionarlo.