Français dropdown-ico

Manuel d’utilisation Yeoman DEVON 50

39 pages 1.95 mb
Télécharger

Aller à la page of 39

Summary
  • Yeoman DEVON 50 - page 1

    PM302 Issue 4 (October 2010) High Output Boiler Stoves M ODELS : YEOMAN DEVON 50/COUNTY 60/COUNTY 80 Instructions for Use, Installation and Servicing For use in GB & IE (Great Britain and Republic of Ireland). IMPORTANT This appliance will become hot whilst in operation, it is therefore recommended that a suitable guard should be used for the p ...

  • Yeoman DEVON 50 - page 2

    COVERING THE FOLLOWING MODELS: YEOMAN DEVON/COUNTY 60/COUNTY 80 2 APPLIANCE COMMISSIONING CHECKLIST 3 USER INSTRUCTIONS 4 General Points 4 Heating Controls 5 Using the Appliance for the first time 6 Condensation 6 Recommended Fuels 6 Lighting the appliance 7 Running the appliance 7 Burning Tips 9 Ash Removal 10 Wood Burning Tray 10 Extended burning ...

  • Yeoman DEVON 50 - page 3

    3 APPLIANCE COMMISSIONING CHECKLIST To assist us in any guarantee claim please complete the following information. In the unlikely event of a problem, contact your installer or retailer for assistance: Retailer appliance was purchased from Name: ........................................................................................................ ...

  • Yeoman DEVON 50 - page 4

    4 USER INSTRUCTIONS 1. GENERAL POINTS 1.1 Before use of this appliance please read these instructions fully. The appliance must be fitted by a registered installer * or approved by your local building control officer. 1.2 All local regulations, including those referring to national and European Standards need to be complied with when installing the ...

  • Yeoman DEVON 50 - page 5

    5 USER INSTRUCTIONS AIRWASH & PRIMARY AIR CONTROLS 1.14 Use a gloved hand to operate air controls. Primary Air Control PR7519 Airwash Control Airwash Control Open Close Primary Control Open Close Open DOOR HANDLE 1.15 Use a protected gloved hand to operate. DO NOT OPEN THE DOOR WITH BARE HANDS To Open and Close Drop door tool over knob to fit. ...

  • Yeoman DEVON 50 - page 6

    6 USER INSTRUCTIONS WARNING Properly installed, operated and maintained this appliance will not emit fumes into the room. Occasional fumes from de-ashing and refuelling may occur. Persistent fume emission is potentially dangerous and must not be tolerated. If fume emission does persist: — Open doors and windows to ventilate the room. — Allow fi ...

  • Yeoman DEVON 50 - page 7

    7 USER INSTRUCTIONS 4 — Leave the door slightly open as the fire establishes and the glass warms to avoid the build-up of condensation. — Add larger pieces of solid fuel once the fire is established Do not add too much fuel initially as this may smother the fire. Do not load fuel above the log guard (see Diagram 5). PR8872 5 Log guard Base of b ...

  • Yeoman DEVON 50 - page 8

    8 USER INSTRUCTIONS 6 PR8855 7 PR7519 Primary Air: Fully Open Airwash: Fully Open — Wood burns best on a bed of ash (approx. 25mm (1") deep). — Rake the embers evenly over the firebed and open the Airwash control fully for a few minutes before re-fuelling. Do not refuel when a large amount of flames are present in the firebox as this could ...

  • Yeoman DEVON 50 - page 9

    9 THERMOSTAT OPERATION 5.17 This appliance can be fitted with a thermostat kit to control the temperature of the boiler. See the instructions included in the kit for operation details. 6. BURNING TIPS 6.1 Fuel Quality (Wood) Use wood with a moisture content of less than 20%. Seasoned logs have the bark beginning to lift and peel away and cracks rad ...

  • Yeoman DEVON 50 - page 10

    9 PR8881 PR8880 Front plate Ashpan — Using gloves, carefully remove ashpan (see Diagram 9). — Place the ash into a Stovax Ash Caddy (Stovax Part No. 4227) or other suitable container. — Check and remove ash as often as required when burning solid fuel. — De-ash at least once a week. — Do not place hot ash in a container made from plastic ...

  • Yeoman DEVON 50 - page 11

    9. EXTENDED BURNING 9.1 It is possible to get the appliance to burn for extended periods. In order to do this: — De-ash prior to final refuelling. — Set air controls to low combustion settings. This will blacken the glass over night but it will clear when operated at high output for a short period. — Use smokeless fuel or small, thick logs de ...

  • Yeoman DEVON 50 - page 12

    13. CLEANING GLASS 13.1 Kee p th e gl as s cle an wit h co rr ec t use of th e Ai rw ash sys te m and goo d qu al it y fue l. Som et im es ad di ti on al clea ni ng may be req ui re d. This can be done as follows: — Allow appliance to cool fully. Do not clean hot glass. — Use a soft cloth and Stovax Glass Cleaner. 13.2 Before re-lighting the ap ...

  • Yeoman DEVON 50 - page 13

    16. SEASONAL USE 16.1 Clean and service the appliance if it is not used during the warmer periods of the year as detailed in the Maintenance and Servicing section. 16.2 Set the air controls 50% open to keep the appliance ventilated and stop the build-up of any moisture inside. 16.3 Before re-lighting the appliance: — Remove the baffle. — Clear ...

  • Yeoman DEVON 50 - page 14

    TECHNICAL SPECIFICATION YEOMAN 14 Model Yeoman Devon 50 Yeoman County 60 Yeoman County 80 Yeoman Devon 50 Yeoman County 60 Yeoman County 80 Nominal Heat Output to Room Solid Fuel kW 5.0 7.0 9.0 Nominal Heat Output to Water kW 8.0 11.0 14.0 Flue Draught at Nominal Heat Output All Fuels mm Wg 1.25 1.25 1.25 inch Wg 0.05 0.05 0.05 Flue Outlet Size (To ...

  • Yeoman DEVON 50 - page 15

    2. PACKING LIST • User Instructions • Installer Instructions • Guarantee card • Pair leather gloves • Door handle tool • Fire bricks • Ashpan (MF Only) • Riddling tool (MF Only) TECHNICAL SPECIFICATION 1. STANDARD FEATURES • Primary air (under grate air for full multi fuel use) • Airwash (for wood burning / clean glass) • Ridd ...

  • Yeoman DEVON 50 - page 16

    TECHNICAL SPECIFICATION YEOMAN DIMENSIONS Description Model A B C D E F G H I J K (dia) Devon 50 590 659 389 118 469 430 120 400 241 315 153 County 60 632 772 446 125 507 508 126 530 246 343 153 County 80 691 857 508 125 566 572 138 608 258 397 153 16 PR8249 B C D G F E J I H K A ...

  • Yeoman DEVON 50 - page 17

    1. FLUE OR CHIMNEY 1.1 The flue or chimney system must be in good condition. It must be inspected by a competent person and passed for use with the appliance before installation. Products of combustion entering the room can cause serious health risks. 1.2 The following must be checked: — The construction of the masonry chimneys, flue block chimne ...

  • Yeoman DEVON 50 - page 18

    2.1 The appliance must stand on a constructional hearth which is at least 125mm thick with the minimum dimensions as shown in the diagram opposite. 2.2 The building must have a suitable load-bearing capacity for the hearth and appliance. — Consult a structural engineer for advice before proceeding. Caution: These appliances are heavy. 2.3 When fi ...

  • Yeoman DEVON 50 - page 19

    SITE REQUIREMENTS WALLS NEXT TO A HEARTH Solid, non-combustible material e.g. masonry or concrete Thickness W C 150mm minimum 150mm minimum C H PR7204 Position of Appliance & Hearth in relation to walls Requirement for the walls Distance of hearth from wall 'C' Distance of Appliance to wall Min thickness of Wall 'W' Min heig ...

  • Yeoman DEVON 50 - page 20

    PRE-INSTALLATION CHECKS 1. FLUES 20 Model Yeoman Devon 50 Yeoman County 60 Yeoman County 80 Yeoman Devon 50 Yeoman County 60 Yeoman County 80 Flue / Chimney Size Without Liner System (round) Diameter mm 150 150 150 inch 6 6 6 Without Liner System (square) Minimum Dimension mm 135 135 135 inch 5½ 5½ 5½ With Liner or Factory Made System (diameter) ...

  • Yeoman DEVON 50 - page 21

    2.6 Extractor fans or cooker hoods must not be placed in the same room or space as this can cause the appliance to emit fumes into the room. 2.7 Increase air supply provisions where a room contains multiple appliances. 2.8 The need for additional ventilation may also be identified during the commissioning procedure and should be provided if needed. ...

  • Yeoman DEVON 50 - page 22

    LEGAL REQUIREMENTS Before installation and/or use of this appliance please read these instructions carefully to ensure that all requirements are fully understood. The appliance must be fitted by a registered installer * , or approved by your local building control officer. It is very important to understand the requirements of the national Building ...

  • Yeoman DEVON 50 - page 23

    INSTALLATION INSTRUCTIONS — Connect tee to the chimney using flue pipe. — Secure with self tapping screw. — Seal the connecting joints. Do not use a 90˚ elbow to make this connection. The Flue must be installed in accordance with manufacturers instructions. PR7218 Seal Collar with Fire Cement Self Tapping Screw Tee Size Stovax Part No. 6&quo ...

  • Yeoman DEVON 50 - page 24

    24 INSTALLATION INSTRUCTIONS 2. REMOVAL OF THE LOG GUARD 2.1 To remove the Log guard: — Lift Log Guard clear of the supporting brackets. — Rotate to clear the sides of the door opening. Do not use appliance without the log guard in position. 3. FITTING AND REMOVAL OF THE BAFFLE No tools are required. 3.1 To maintain efficient combustion the app ...

  • Yeoman DEVON 50 - page 25

    INSTALLATION INSTRUCTIONS 9 PR8896 5mm Hex Key Riddling Boss Fixing Bolt Spring Washer — Unscrew the boss. — Remove Riddling Cam Bar (see Diagram 10). 10 PR8889 To remove Multi-fuel frames: — Lift frames from the front. — Remove right hand side first through the front of the stove. — Repeat for the left hand side. 11 PR8898 — Replace in ...

  • Yeoman DEVON 50 - page 26

    3. Hot Water Cylinder 3.1 The domestic hot water cylinder must be an indirect vented double feed type to meet national standards** and should have a minimum capacity of 117 litres. Houses with more than one bathroom or a separate shower will need a bigger tank. Fully insulate the tank. The water draw off pipes to the taps should be in a dead leg co ...

  • Yeoman DEVON 50 - page 27

    INSTALLATION INSTRUCTIONS 27 6. Pump 6.1 Where a pump is fitted into the circuit it should be adjustable so that the flow can match the system requirements. Fit isolation valves to enable removal for servicing. The pump must have at least 1.5 meters of static head. 7. Electrical Supply 7.1 Electrical connections must meet the requirements of nation ...

  • Yeoman DEVON 50 - page 28

    INSTALLATION INSTRUCTIONS 28 See below typical layout of a fully pumped central heating and hot water circuit. Feed and Expansion Cistern Cold Water Storage Cistern Double Feed indirect cylinder Circulator and isolating valves Two channel programmer Two port normally open motorized valve controlled by room thermostat and programmer Yeoman High Outp ...

  • Yeoman DEVON 50 - page 29

    HEATING SYSTEM CONTROLS CONTROLS GENERAL 1.1 The controls fitted to the system will provide two functions: — To control the comfort level in the house. — To maintain safety in the event of misuse or mechanical failure. COMFORT CONTROLS 1.2 This primarily consists of a time clock wired into the pump. The pump is switched on when heat is required ...

  • Yeoman DEVON 50 - page 30

    COMMISSIONING 1.1 To commission: — Replace the log retainer. — Check the door alignment and catch operation, adjust if required, see Installation Instructions, Section 6, Adjusting Door Hinges. — Check the soundness of door seals, castings and joints. — Check the operation of the air controls. — Ensure the system has been filled with wate ...

  • Yeoman DEVON 50 - page 31

    31 MAINTENANCE and SERVICING For a complete list of spare parts and accessories contact your Yeoman retailer or call 01392 474011 1. ANNUAL SERVICE 1.1 Before the start of the heating season strip, inspect and clean the appliance as detailed: — Allow appliance to cool. — Remove all internal parts; baffle, log guard and, for multi-fuel versions, ...

  • Yeoman DEVON 50 - page 32

    5.4 Clean, and re-paint, the rear of the door if required. Clean the screws with light oil and coat with high temperature anti-seize grease, this will aid future removal. 5.5 Fit a new sealing rope between the new glass and the door, and place the glass into position in the door. Place the glass fixing clips into position and re-fix with the clean ...

  • Yeoman DEVON 50 - page 33

    6.6 Using the stove with a damaged door seal could cause dangerous fumes to enter the room, or the stove to over- fire, resulting in damage. 6.7 If you require help, your local Yeoman retailer will be able to carry out all of your service and maintenance requirements for a reasonable cost. 7. ADJUSTING DOOR CATCH 7.1 To adjust the fit of the door c ...

  • Yeoman DEVON 50 - page 34

    SPARE PARTS DEVON 50 Re f. No. Product Code Drawing No . (if different) Description 1 ST8-MEC8158 MEC8158 RIDDLING T OOL ASSEMBL Y 2 YF00106 HINGE PIN 3 - YM-Y A2DDEVWD DEVON TWIN DOOR ASSEMBL Y 4 RVPX-CA7588 CA7588 MULTI-FUEL RIDDLING SOCKET 5 ST8-CA7584 C A7584 RIDDLING BAR 6 ST8-CA7500 C A7500 BACK RIDDLING BAR 7 YM-YM10057 YM10057 MUL TI-FUEL R ...

  • Yeoman DEVON 50 - page 35

    SPARE PARTS COUNTY 60 Re f. No. Product Code Drawing No . (if different) Description 1 ST8-MEC8158 MEC8158 RIDDLING T OOL ASSEMBLY 2 YF00106 HINGE PIN 3 - YM-Y A2DCOUWD 2 DOOR ASSEMBL Y 4 RVPX-CA7588 CA7588 MUL TI-FUEL RIDDLING SOCKET 5 ST11-CA7585 C A7585 RIDDLING BAR 6 ST11-CA7503 C A7503 BACK RIDDLING BAR 7 YM-YM95057 YM95057 MULTI-FUEL RIDDLING ...

  • Yeoman DEVON 50 - page 36

    SPARE PARTS COUNTY 80 Re f. No. Product Code Drawing No . (if different) Description 1 ST8-MEC8158 MEC8158 RIDDLING T OOL ASSEMBLY 2 - YM-Y A2DC14WD DOOR ASSEMBL Y 3 YF00106 HINGE PIN 4 RVPX-CA7588 CA7588 MUL TI-FUEL RIDDLING SOCKET 5 ST11-CA7586 C A7586 RIDDLING BAR 6 ST11-CA7504 C A7504 BACK RIDDLING BAR 7 YM-YM99057 YM99057 MULTI-FUEL RIDDLING G ...

  • Yeoman DEVON 50 - page 37

    SPARE PARTS DOOR ASSEMBLY (ALL MODELS) Re f. No. Product Code Drawing No . (if different) Description 1 SM29 M0508PHS M5 X 8 PAN HEAD SCREW 2 4670H Ø14 ROPE SEAL (BLACK) 3 YC00353 ST ANDARD GLASS CLIP 4 GL0253 GL0253 TWIN DOOR GLASS 5 YM-YM05001 YM05001 RIGHT HAND DOOR CROSS 6 YB00030 M18 DOOR CAM 7 YM-F00004 YF00004 SPIROL PIN Ø3 X 18 LG 8 YM-A9 ...

  • Yeoman DEVON 50 - page 38

    SERVICE RECORDS 38 1ST SERVICE Date of Service:........................................................................... Next Service Due:....................................................................... Signed:........................................................................................ Retailer's Stamp/HETAS Registration N ...

  • Yeoman DEVON 50 - page 39

    Stovax Ltd, Falcon Road, Sowton Industrial Estate, Exeter, Devon, England EX2 7LF Tel: (01392) 474011 Fax: (01392) 219932 E-mail: info@stovax.com www.stovax.com A division of Stovax ...

Fabricant Yeoman Catégorie Stove

Les documents que nous recevons du fabricant de l'appareilYeoman DEVON 50 peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Yeoman
- manuels d’utilisations DEVON 50
- fiches produit Yeoman
- dépliants
- ou étiquettes-énergie Yeoman DEVON 50
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Yeoman DEVON 50.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Yeoman DEVON 50, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Yeoman DEVON 50. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Yeoman DEVON 50.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Yeoman DEVON 50, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Yeoman DEVON 50 par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Yeoman DEVON 50.

Le manuel d’utilisation complet Yeoman, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Yeoman DEVON 50 - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Yeoman DEVON 50, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lYeoman DEVON 50 qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Yeoman DEVON 50 - qui devraient nous aider dans les premières étapes lors de l'utilisation Yeoman DEVON 50
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Yeoman DEVON 50
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Yeoman DEVON 50 dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Yeoman DEVON 50?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Yeoman DEVON 50, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Yeoman DEVON 50 il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)