-
Poulan FN620L - page 1
• Assembly • Operation • Maintenance • Service and Adjustments • Storage • Troubleshooting • Repair Parts OWNER'S MANUAL 189783 Re v . 1 02.26.04 TR PRINTED IN U .S .A. MODEL NO . FN620L 3.75 HP 17 Inc h Tiller For P arts and Ser vice, contact our authorized distributor: call 1-800-849-1297 For T echnical Assistance: call 1-800-8 ...
-
Poulan FN620L - page 2
2 • Ne v er operate the tiller without proper guards, plates , or other saf ety protective de vices in place. • K eep children and pets a wa y . • Do not ov erload the machine capacity by attempting to till too deep at too f ast a rate . • Ne v er operate the machine at high speeds on slippery surf aces. Look behind and use care when backin ...
-
Poulan FN620L - page 3
3 CONGRA TULA TIONS on your purchase of a new tiller . It has been designed, en gi neered and manu f ac tured to giv e you the best pos sible de penda bil ity and per fo r m ance. Should you e xperience any prob lems y ou can not easily remedy , please contact your nearest authorized service center . W e ha ve com pe tent, well-trained tech ni cian ...
-
Poulan FN620L - page 4
4 ASSEMBL Y OPERA T OR’S POSITION (See Fig. 1) When right or left hand is mentioned in this manual, it means when you are in the oper ating position (standing behind tiller handles). Y our new tiller has been assembled at the f actory with exception of those parts left unassembled f or shipping pur poses. T o ensure saf e and proper operation of ...
-
Poulan FN620L - page 5
5 ASSEMBL Y han dle s _ 96 TILLER HANDLES CABLE HANDLE P ANEL BOL TS 02051 FIG. 2 HAN DLE P ANEL HEX BOL T 5/16-18X3/4" TILLER HANDLE HEX BOL T 5/16-18X1" FLA T W ASHER LOCK W ASH ER NUT depth_stake_5 DEPTH ST AKE SUPPORT BOL T HEX BOL TS, LOCK W ASH ERS, AND HEX NUTS DEPTH ST AKE SUPPORT NUT “A” ENGINE BRA CK ET HAL VES FIG. 3 ST AKE ...
-
Poulan FN620L - page 6
6 KNO W Y OUR TILLER READ THIS O WNER'S MANU AL AND SAFETY R ULES BEFORE OPERA TING Y OUR TILLER. Compare the illustrations with y our tiller to f amiliarize yourself with the location of v arious controls and adjustments. Sav e this manual f or future ref erence. RECOIL ST ARTER HANDLE DEPTH ST AKE TINE SHIELD CHOKE CONTROL FOR W ARD TINE CON ...
-
Poulan FN620L - page 7
7 OPERA TION The operation of any tiller can result in f oreign objects thr own into the e yes, whic h can result in severe e ye damage. Alwa ys wear safety glasses or e ye shields bef ore starting y our tiller and while tilling. W e recommend a wide vision safety mask o ver spectac les or standard saf ety glasses. TRANSPORTING Y OUR TILLER CA UTIO ...
-
Poulan FN620L - page 8
8 OPERA TION FIG. 7 engine_a rt_ 4 OIL FILLER PLUG OIL LEVEL T O ST AR T ENGINE (See Fig. 8) CA UTION: Keep drive control bar in “DISENGA GED” position when star t- ing en gine. When star ting engine for the fi rst time or if engine has run out of fuel, it will take e xtr a pulls of the recoil star ter to mov e fuel from the tank to the engine ...
-
Poulan FN620L - page 9
9 OPERA TION • Y ou will fi nd tilling much easier if you lea ve a ro w un- tilled between passes . Then go bac k between tilled rows . (See Fig. 9) There are two reasons for doing this. First, wide tur ns are much easier to negotiate than about-f aces. Sec ond, the tiller won’t be pulling itself, and you, to ward the ro w ne xt to it. • Set ...
-
Poulan FN620L - page 10
10 GENERAL RECOMMEND A TIONS The warranty on this tiller does not co v er items that hav e been subjected to operator ab use or negligence. T o receive full value from the w arranty , operator m ust main tain tiller as instructed in this manual. Some adjustments will need to be made periodically to properly maintain your tiller . All adjustments in ...
-
Poulan FN620L - page 11
11 MAINTENANCE FIG. 12 AIR CLEANER (See Fig. 13) Ser vice air cleaner car tr idge e v er y twenty-fi ve hours, more often if engine is used in very dusty conditions. • Loosen air cleaner screws , one on each side of cov er . • Remo ve air cleaner co v er . • Carefully remove air cleaner cartr idge. Be care ful. Do not allow dir t or de bris ...
-
Poulan FN620L - page 12
12 MUFFLER Do not operate tiller without muffl er . Do not tamper with e xhaust system. Damaged muffl ers or spark arresters could create a fi re hazard. Inspect pe ri odi cally and re place if nec es sar y . If y our engine is equipped with a spark arrester screen assembly , re move e v ery 50 hours for cleaning and inspection. Re place if dam ...
-
Poulan FN620L - page 13
13 TILLER T O ADJUST HANDLE HEIGHT (See Fig. 15) F actory assembly has provided lo west handle height. Se lect handle height best suited f or your tilling conditions . Handle height will be diff erent when tiller digs into soil. • If a higher handle height is desired, loosen the four nuts securing handle panel to engine brack ets . • Slide hand ...
-
Poulan FN620L - page 14
14 SER VICE AND ADJUSTMENTS TINE OPERA TION CHECK (See Fig. 21) Be sure tines do not rotate when engine is running and tine control is in the “OFF” position. W ARNING: Disconnect spark plug wire from spark plug to pre vent starting while chec king tine operation. FINAL CHECK “OFF” POSITION • With tine control “OFF” (up), push do wn on ...
-
Poulan FN620L - page 15
15 SER VICE AND ADJUSTMENTS V -BEL T IDLER PUL LEY TRANS MIS SION PUL LEY BEL T GUIDE ENGINE PULLEY BEL T GUIDE T O REPLA CE V -BEL T (See Fig. 23) Replace V -belt if it has stretched considerably or if it has crac ks or fra y ed edges. Belt guard must be remo ved to service belt. See “T O RE- MO VE BEL T GU ARD” in this section of man ual. BEL ...
-
Poulan FN620L - page 16
16 ST ORA GE ENGINE OIL Drain oil (with engine warm) and replace with clean oil. (See “ENGINE” in the Maintenance section of this man ual). CYLINDER(S) • Remo ve spark plug. • P our 1 ounce (29 ml) of oil through spark plug hole into cylinder . • Pull star ter handle slowly sev er al times to distribute oil. • Replace with ne w spark pl ...
-
Poulan FN620L - page 17
17 Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “T O ST AR T ENGINE” in the Operation section. 3. Engine fl ooded. 3. Wait se v eral minutes bef ore attempting to start. 4. Dir ty air cleaner. 4. Clean or replace air cleaner car tridge. 5. Water in fuel. 5. Empty fuel tank and carburetor , and ...
-
Poulan FN620L - page 18
18 REP AIR P ARTS TILLER - - MODEL NUMBER FN620L HANDLE ASSEMBL Y 1 2 3 15 19 23 5 5 6 4 7 8 9 12 18 34 28 3 16 14 13 11 10 handle_assy_99_26 1 137176X505 Brac ket, Handle 2 72140512 Bolt, Carr iage 5/16-18 unc x 1-1¦2 3 9266R Gr ip , Handle 4 151473 Handle, L.H. 5 73680500 Locknut, Cro wn 5/16-18 6 19111116 W asher 11/32 x 11/16 x 16 Ga. 7 191214 ...
-
Poulan FN620L - page 19
19 REP AIR P ARTS TILLER - - MODEL NUMBER FN620L BEL T GU ARD AND PULLEY ASSEMBL Y belt_guard_9 3 8 6 7 12 14 13 9 7 7 10 1 2 16 5 17 18 19 20 21 25 4 KEY P ART NO . NO . DESCRIPTION 16 12000036 Ring, Klip 17 73350600 Nut, Hex, J am 3/8-16 18 161806 Pulley , Idler 19 175377 Ar m, Idler 20 74760620 Bolt, Hex 3/8-16 x 1-1/4 21 106968X Shaft, Idler Ar ...
-
Poulan FN620L - page 20
20 REP AIR P ARTS TILLER - - MODEL NUMBER FN620L WHEEL AND DEPTH ST AKE ASSEMBL Y 22 7 8 13 9 10 23 22 15 3 24 5 4 7 4 5 17 16 18 18 21 17 16 2 2 1 3 4 5 19 19 20 20 wheel_d.stake_4 1 9194R Pin, Clevis 2 74760520 Bolt, Hex 5/16-18 x 1-1/4 3 74760512 Bolt, Hex 5/16-18 x 3/4 4 73220500 Nut, Hex 5/16-18 5 10040500 W asher , Loc k 5/16 7 4921H Clip, Ha ...
-
Poulan FN620L - page 21
21 KEY P ART NO . NO . DESCRIPTION 1 165774 Tine, Outer , R.H. 2 4921H Retainer , Spring 3 165772 Tine, Inner , R.H. 4 165771 Tine, Inner , L.H. 5 165773 Tine, Outer , L.H. 6 9194R Pin, Clevis KEY P ART NO . NO . DESCRIPTION 3 1 6 4 5 6 2 2 tine_ipb_4 REP AIR P ARTS TILLER - - MODEL NUMBER FN620L TINE ASSEMBL Y ...
-
Poulan FN620L - page 22
22 REP AIR P ARTS TILLER - - MODEL NUMBER FN620L TRANSMISSION KEY P ART NO . NO . DESCRIPTION 18 10040400 W asher , Loc k 1/4 19 74610412 Bolt, Hex 1/4-28 x 3/4 Gr . 5 20 - - - - - - - Engine, Briggs Model 94202 (Order par ts from engine Manuf ac- turer) 2 3 5 6 8 11 16 17 11 10 7 19 14 10 12 18 10 14 1 20 transmission_12 KEY P ART NO . NO . DESCRI ...
-
Poulan FN620L - page 23
23 KEY P ART NO . NO . DESCRIPTION 1 132629 Decal, Logo 2 163989 Decal, Logo 4 127185X Decal, Description 5 110613X Decal, Tine Control 6 110614X Decal, Hand Placement 8 120076X Decal, W arning, Rotating Tines 9 171803 Decal, Br iggs & Stratton 11 162384 Decal, W arning 12 165327 Decal, Speed Control - - 189783 Manual, Owner’ s (English) - - ...
-
Poulan FN620L - page 24
LIMITED W ARRANTY The Manuf acturer w arrants to the original consumer purchaser that this product as manuf actured is free from de- f ects in materials and work man ship . F or a period of two (2) years from date of purchase b y the original consumer purchaser , w e will repair or replace, at our option, without charge f or parts or labor incurred ...
Avez-vous une question à propos de Poulan FN620L?
Utiliser le formulaire ci-dessous
Si vous n’avez pas résolu votre problème avec Poulan FN620L, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Poulan FN620L il est probable qu’il a envie de partager la façon de le résoudre.