Français dropdown-ico

Manuel d’utilisation Kohler 12RES

36 pages 1.01 mb
Télécharger

Aller à la page of 36

Summary
  • Kohler 12RES - page 1

    Residential/Commercial Generator Sets Models: 8.5RES 12RES Controller: Advanced Digital Control (ADC 2100) TP-6331 5/04 Operation ...

  • Kohler 12RES - page 2

    Engine exhaust from this product contains chemicals known to the State of California to cause cancer , birth defects, or other reproductive harm. W ARNING California Proposition 65 Product Identification Information Product identification numbers determine service parts. Record the product identification numbers in the spaces below immediately afte ...

  • Kohler 12RES - page 3

    T able of Contents TP-6331 5/04 T able of Contents Product Identification Information Inside front cover ............................................ Safety Precautions and Instructions I ........................................................ Introduction i ............................................................................... Service As ...

  • Kohler 12RES - page 4

    T able of Contents, continued TP-6331 5/04 T able of Contents Section 4 T roubleshooting 19 ................................................................. 4.1 Introduction 19 .......................................................... 4.2 Generator Set T roubleshooting 19 .......................................... 4.3 Fault Codes 20 ............. ...

  • Kohler 12RES - page 5

    TP-6331 5/04 I Safety Precautions and Instructions Safety Precautions and Instructions IMPORT ANT SAFETY INSTRUCTIONS. Electromechanical equipment, including generator sets, transfer switches, switchgear , and accessories, can cause bodily harm and pose life-threatening danger when improperly installed, operated, or maintained. T o prevent accident ...

  • Kohler 12RES - page 6

    TPTPS-6331 5/04 II Safety Precautions and Instructions Battery gases. Explosion can cause severe injury or death. Battery gases can cause an explosion. Do not smoke or permit flames or sparks to occur near a battery at any time, particularly when it is charging. Do not dispose of a battery in a fire. T o prevent burns and sparks that could cause an ...

  • Kohler 12RES - page 7

    TP-6331 5/04 III Safety Precautions and Instructions Fuel System Explosive fuel vapors. Can cause severe injury or death. Use extreme care when handling, storing, and using fuels. W ARNING The fuel system. Explosive fuel vapors can cause severe injury or death. V aporized fuels are highly explosive. Use extreme care when handling and storing fuels. ...

  • Kohler 12RES - page 8

    TPTPS-6331 5/04 IV Safety Precautions and Instructions Welding on the generator set. Can cause severe electrical equipment damage. Before welding on the generator set perform the following steps: (1) Remove the battery cables, negative ( - - ) lead first. (2) Disconnect all engine electronic control module (ECM) connectors. (3) Disconnect all gener ...

  • Kohler 12RES - page 9

    TP-6331 5/04 V Safety Precautions and Instructions Servicing the generator set when it is operating. Exposed moving parts can cause severe injury or death. Keep hands, feet, hair , clothing, and test leads away from the belts and pulleys when the generator set is running. Replace guards, screens, and covers before operating the generator set. Notic ...

  • Kohler 12RES - page 10

    TPTPS-6331 5/04 VI Safety Precautions and Instructions Notes ...

  • Kohler 12RES - page 11

    TP-6331 5/04 i Introduction Introduction This manual provides operation and maintenance instructions for model 8.5RES and 12RES generator sets equipped with the Kohler r Advanced Digital Control (ADC 2100). This generator set is approved for use in stationary applications in locations served by a reliable utility power source. Have the generator se ...

  • Kohler 12RES - page 12

    TP-6331 5/04 ii Service Assistance tp6195 Figure 3 Air Index Label, 8.5/12RES This engine/generator is certified to operate using natural gas or propane fuel. The Emission Compliance Period referred to on the Emission Control or Air Index label indicates the number of operating hours for which the engine has been shown to meet CARB emission require ...

  • Kohler 12RES - page 13

    TP-6331 5/04 1 Section 1 Features Section 1 Features 1.1 Specifications The generator set specification sheets provide specific generator and engine information. Refer to the spec sheet for data not supplied in this manual. Consult the generator set service manual, engine operation manual, and engine service manual for additional specifications. Ob ...

  • Kohler 12RES - page 14

    TP-6331 5/04 2 Section 1 Features 1.5 Generator Set Components 12 3 6 57 1 9 13 14 4 11 21 16 18 12 9 20 ADV- 6823 -A 1. Enclosure 2. Muffler 3. Oil check 4. Oil fill 5. Air cleaner 6. Spark plug locations (both sides) 7. ADC 2100 8. Generator set master switch (RUNOFF/RESETAUTO) 9. Nameplate 10. Line circuit breaker 1 1. Engine starting battery ...

  • Kohler 12RES - page 15

    TP-6331 5/04 3 Section 2 Operation Section 2 Operation 2.1 Prestart Checklist T o ensure continued satisfactory operation, perform the following checks or inspections before or at each startup, as designated, and at the intervals specified in the service schedule. In addition, some checks require verification after the unit starts. Air Cleaner . Ch ...

  • Kohler 12RES - page 16

    TP-6331 5/04 4 Section 2 Operation 2.3.1 Controls and Indicators Figure 2-2 describes the controls and indicators located on the ADC 2100. The LED display indicates generator set status as shown in Figure 2-2. With the factory-installed continuous power mode jumper in place, the LED display is activated when the generator set master switch is moved ...

  • Kohler 12RES - page 17

    TP-6331 5/04 5 Section 2 Operation 2.4 Fault Shutdowns The generator set shuts down automatically under the fault conditions listed in Figure 2-3 and the controller displays a fault code. The generator set cannot be restarted until the fault condition is corrected and the controller is reset. See Section 2.4.1 to reset the controller after a fault ...

  • Kohler 12RES - page 18

    TP-6331 5/04 6 Section 2 Operation Code Fault Description Check HB High battery voltage warning Fault code is displayed if the engine starting battery voltage rises above 16 VDC for a 12 VDC system or above 30 VDC for a 24 VDC system for more than 10 seconds when the engine is not running. This fault condition does not inhibit engine starting. The ...

  • Kohler 12RES - page 19

    TP-6331 5/04 7 Section 2 Operation 2.6 Battery Charger The generator set is equipped with a 6-amp float/equalize battery charger to maintain the engine starting battery . The charger ’s power cord must be connected to a 120 V AC power source. Figure 2-5 illustrates the battery charger . The battery charger uses an AGS 10 inline fuse. The fuse is ...

  • Kohler 12RES - page 20

    TP-6331 5/04 8 Section 2 Operation Notes ...

  • Kohler 12RES - page 21

    TP-6331 5/04 9 Section 3 Scheduled Maintenance Section 3 Scheduled Maintenance Accidental starting. Can cause severe injury or death. Disconnect the battery cables before working on the generator set. Remove the negative ( - - ) lead first when disconnecting the battery . Reconnect the negative ( - - ) lead last when reconnecting the battery . W AR ...

  • Kohler 12RES - page 22

    TP-6331 5/04 10 Section 3 Scheduled Maintenance 3.2 Service Schedule Procedure System Component or Procedure See Section Visually Inspect Check Change Clean T est Frequency Fuel Flexible lines and connections X R Quarterly Main tank supply level X Weekly Fuel piping X Y early Lubrication 3.3 Oil level X X 8 hours or before use Crankcase breather ho ...

  • Kohler 12RES - page 23

    TP-6331 5/04 11 Section 3 Scheduled Maintenance 3.3 Lubrication System See Section 3.2, Service Schedule, for oil change and oil filter replacement intervals. See Section 1.5, Service Views, for the oil drain, oil check, oil fill, and oil filter locations. For extended operation, check the oil level every 8 hours. Maintain the oil level at or near ...

  • Kohler 12RES - page 24

    TP-6331 5/04 12 Section 3 Scheduled Maintenance b. Clean the gasket sealing surface of the oil filter adapter . c. Apply a light coat of clean oil to the rubber seal of the new oil filter . d. Install the new oil filter following the instructions provided with the filter . Note: Dispose of all waste materials (engine oil, fuel, filter , etc.) in an ...

  • Kohler 12RES - page 25

    TP-6331 5/04 13 Section 3 Scheduled Maintenance traces of detergent are eliminated. Squeeze out excess water (do not wring). Allow the precleaner to air dry . 5. Saturate the precleaner with new engine oil. Squeeze out all of the excess oil. 6. Reinstall the precleaner over the paper element. 7. Reinstall the air cleaner cover . Secure the cover wi ...

  • Kohler 12RES - page 26

    TP-6331 5/04 14 Section 3 Scheduled Maintenance 3.6 Cooling System The engine fan draws cooling air through the openings in the sides and end near the battery . The alternator fan draws cooling air through openings on the side walls of the enclosure. The cooling air mixes with the engine exhaust and is discharged at the exhaust outlet. See Figure 3 ...

  • Kohler 12RES - page 27

    TP-6331 5/04 15 Section 3 Scheduled Maintenance Battery short circuits. Explosion can cause severe injury or death. Short circuits can cause bodily injury and/or equipment damage. Disconnect the battery before generator set installation or maintenance. Remove all jewelry before servicing the equipment. Use tools with insulated handles. Remove the n ...

  • Kohler 12RES - page 28

    TP-6331 5/04 16 Section 3 Scheduled Maintenance 3.10 Circuit Protection If the generator set circuit breaker trips or the fuses blow repeatedly , see Section 4, Troubleshooting, for possible causes. 3.10.1 Line Circuit Breaker A line circuit breaker interrupts the generator output in the event of a fault in the wiring between the generator and the ...

  • Kohler 12RES - page 29

    TP-6331 5/04 17 Section 3 Scheduled Maintenance 3.1 1.3 Cylinder Lubrication 1. Remove the spark plugs. 2. Pour one tablespoon of engine oil into each spark plug hole. Install the spark plugs and ground the spark plug leads. Do not connect the leads to the plugs. 3. T oggle the generator set master switch to crank the engine two or three revolution ...

  • Kohler 12RES - page 30

    TP-6331 5/04 18 Section 3 Scheduled Maintenance Notes ...

  • Kohler 12RES - page 31

    TP-6331 5/04 19 Section 4 Troubleshooting Section 4 T roubleshooting 4.1 Introduction Use the following charts to diagnose and correct common problems. First check for simple causes such as a dead engine starting battery , loose connections, or an open circuit breaker . The charts include a list of common problems, possible causes of the problem, a ...

  • Kohler 12RES - page 32

    TP-6331 5/04 20 Section 4 Troubleshooting 4.3 Fault Codes The Advanced Digital Control displays fault codes to aid in troubleshooting. Fault codes, descriptions, and recommended actions are listed in Figure 2-3. Identify and correct the cause of the fault condition. Then reset the controller after a fault shutdown. See Section 2.4.1. 4.4 T roublesh ...

  • Kohler 12RES - page 33

    TP-6331 5/04 Appendix A-1 Appendix A Abbreviations The following list contains abbreviations that may appear in this publication. A, amp ampere ABDC after bottom dead center AC alternating current A/D analog to digital ADC analog to digital converter adj. adjust, adjustment ADV advertising dimensional drawing AHWT anticipatory high water temperatur ...

  • Kohler 12RES - page 34

    TP-6331 5/04 A-2 Appendix ISO International Organization for Standardization J joule JIS Japanese Industry Standard k kilo (1000) K kelvin kA kiloampere KB kilobyte (2 10 bytes) kg kilogram kg/cm 2 kilograms per square centimeter kgm kilogram-meter kg/m 3 kilograms per cubic meter kHz kilohertz kJ kilojoule km kilometer kOhm, k Ω kilo-ohm kPa kil ...

  • Kohler 12RES - page 35

    ...

  • Kohler 12RES - page 36

    E 2004 by Kohler Co. All rights reserved. TP-6331 5/04 KOHLER CO. Kohler , Wisconsin 53044 Phone 920-565-3381, Fax 920-459-1646 For the nearest sales/service outlet in the US and Canada, phone 1-800-544-2444 KohlerPowerSystems.com Kohler Power Systems Asia Pacific Headquarters 7 Jurong Pier Road Singapore 619159 Phone (65)264-6422, Fax (65)264-6455 ...

Fabricant Kohler Catégorie Portable Generator

Les documents que nous recevons du fabricant de l'appareilKohler 12RES peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Kohler
- manuels d’utilisations 12RES
- fiches produit Kohler
- dépliants
- ou étiquettes-énergie Kohler 12RES
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Kohler 12RES.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Kohler 12RES, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Kohler 12RES. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Kohler 12RES.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Kohler 12RES, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Kohler 12RES par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Kohler 12RES.

Le manuel d’utilisation complet Kohler, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Kohler 12RES - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Kohler 12RES, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lKohler 12RES qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Kohler 12RES - qui devraient nous aider dans les premières étapes lors de l'utilisation Kohler 12RES
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Kohler 12RES
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Kohler 12RES dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Kohler 12RES?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Kohler 12RES, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Kohler 12RES il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)