Français dropdown-ico

Manuel d’utilisation Kohler CH18-26

19 pages 2.17 mb
Télécharger

Aller à la page of 19

Summary
  • Kohler CH18-26 - page 1

    C OMMAND S ERIES CH18-26, CH730-745 O WNER ' S M ANUAL H ORIZONT AL C RANKSHAFT ...

  • Kohler CH18-26 - page 2

    2 Explosive Fuel can cause fires and severe burns. S top engine before filling fuel tank. W ARNING Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ignited. Store gasoline only in approved containers, in well ventilated, unoccupied buildings, away from sparks or flames. Do not fill the fuel tank while the engine is hot ...

  • Kohler CH18-26 - page 3

    3 Safety Precautions (Cont.) Accidental S t arts can cause severe injury or death. Disconnect and ground spark plug leads before servicing. W ARNING Carbon Monoxide can cause severe nausea, fainting or death. Do not operate engine in closed or confined area. W ARNING W ARNING Explosive Gas can cause fires and severe acid burns. Charge battery only ...

  • Kohler CH18-26 - page 4

    4 Figure 1. T ypical Command Horizontal Shaf t Carbureted Engine. Figure 2. T ypical Command Horizontal Shaf t EFI Engine. Air Cleaner Oil Fill Rectifier-Regulator Throttle Body Intake Manifold Ignition Coil Fuel Injectors Ignition Coil Oil Filter Oil Cooler Oil Filter Rectifier-Regulator Fuel Pump Electric S tarter Oil Cooler Dip stick Side Oil Dr ...

  • Kohler CH18-26 - page 5

    5 Refer to “Maintenance Instructions” beginning on p age 8 for detailed oil check, oil change, and oil filter change procedures. Fuel Recommendations W ARNING: Explosive Fuel! Gasoline is extremely flammable and its vapors can explode if ignited. Store gasoline only in approved containers, in well ventilated, unoccupied buildings, away from spa ...

  • Kohler CH18-26 - page 6

    6 Engine Identification Numbers When ordering parts, or in any communication involving an engine, always give the Model, Specification, and Serial Numbers of the engine. The engine identification numbers appear on a decal affixed to the engine shrouding. Include letter suf fixes, if there are any . Record your engine identification numbers on the i ...

  • Kohler CH18-26 - page 7

    7 flywheel is rotating, the starter pinion and flywheel ring gear may clash resulting in damage to the st arter . If the starter does not turn the engine over , shut off starter immediately . Do not make further attempts to start the engine until the condition is corrected. Do not jump start using another battery (refer to “Battery” on this pag ...

  • Kohler CH18-26 - page 8

    8 Refer to the operating instructions of the equipment this engine powers. Because of equipment design or application, there may be more stringent restrictions regarding the angle of operation. NOTE: D o n o t operate this engine continuously at angles exceeding 25° in any direction. Engine damage could result from insufficient lubrication. Coolin ...

  • Kohler CH18-26 - page 9

    9 Change Oil and Filter , Service Oil Cooler Change Oil Change oil after every 100 hours of operation (more frequently under severe conditions). Refill with service class SG , SH, SJ or higher oil as specified in the ‘‘V iscosity Grades’’ table (Figure 3) on p age 5. Change the oil while the engine is still warm. The oil will flow more free ...

  • Kohler CH18-26 - page 10

    10 Service Oil Cooler Some engines are equipped with an oil cooler . One style of oil cooler mounts on the engine crankcase and has the oil filter on it (See Figure 8). The other style of oil cooler is mounted on the blower housing (See Figure 9), separate from the oil filter . Inspect and clean the oil cooler every 100 hours of operation (more fre ...

  • Kohler CH18-26 - page 11

    11 4. Do not wash the paper element or use pressurized air , as this will damage the element. Replace a dirty , bent, or damaged element with a genuine Kohler element. Handle new elements carefully; do not use if the sealing surfaces are bent or damaged. 5. When servicing the air cleaner , check the air cleaner base. Make sure it is secured and not ...

  • Kohler CH18-26 - page 12

    12 Clean Air Intake/Cooling Areas T o ensure proper cooling, make sure the grass screen, cooling fins, and other external surfaces of the engine are kept clean at all times . Every 100 hours of operation (more often under extremely dusty , dirty conditions), remove the blower housing* and other cooling shrouds. Clean the cooling fins and external s ...

  • Kohler CH18-26 - page 13

    13 Fuel Filter Carbureted Engines: Most engines are equipped with an in-line fuel filter . Periodically inspect the filter and replace with a genuine Kohler filter every 200 operating hours . EFI Engines: A special, high volume, high pressure filter with greater filtration capabilities and internal surface area is used. See Figure 15. Figure 14. Se ...

  • Kohler CH18-26 - page 14

    14 Figure 16. Carburetor (CH18-25,CH730,740). T roubleshooting If engine troubles are experienced that appear to be fuel system related, check the following areas before adjusting the carburetor . • Make sure the fuel tank is filled with clean, fresh gasoline. • Make sure the fuel tank cap vent is not blocked and that it is operating properly . ...

  • Kohler CH18-26 - page 15

    15 T roubleshooting When troubles occur , be sure to check the simple causes which, at first, may seem too obvious to be considered. For example, a starting problem could be caused by an empty fuel t ank. Some common causes of engine troubles are listed in the following table. Do not attempt to service or replace major engine components, or any ite ...

  • Kohler CH18-26 - page 16

    16 Storage If the engine will be out of service for two months or more, use the following storage procedure: 1. Clean the exterior surfaces of the engine. On EFI engines, avoid spraying water at the wiring harness or any of the electrical components. 2. Change the oil and filter while the engine is still warm from operation. See “Change Oil and O ...

  • Kohler CH18-26 - page 17

    17 KOHLER CO. FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMS LIMITED W ARRANTY SMALL OFF-ROAD ENGINES The U.S. Environmental Protection Agency (EP A), the California Air Resources Board (CARB), and Kohler Co. are pleased to explai n the Federal and California Emission Control Systems W arranty on your small off-road equipment engine. For Californi ...

  • Kohler CH18-26 - page 18

    18 (c) For warranty repairs, the engine must be presented to a Kohler Co. service center as soon as a problem exists. Call 1-800-54 4-2444 or access our website at: www .kohlerengines.com, for the names of the nearest service centers. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have any que ...

  • Kohler CH18-26 - page 19

    ENGINE DIVISION, KOHLER CO., KOHLER, WISCONSIN 53044 FOR SALES AND SERVICE INFORMA TION IN U.S. AND CANADA, CALL 1-800-544-2444 LITHO IN U.S.A. FORM NO.: 2 4 590 01 ISSUED: 1 1/04 REVISED: 1/05 MAILED: ...

Fabricant Kohler Catégorie Automobile Parts

Les documents que nous recevons du fabricant de l'appareilKohler CH18-26 peuvent être divisés en plusieurs groupes. Ceux-ci sont, entre autres:
- dessins techniques Kohler
- manuels d’utilisations CH18-26
- fiches produit Kohler
- dépliants
- ou étiquettes-énergie Kohler CH18-26
Tous sont importants, mais les informations les plus importantes du point de vue de l'utilisation de l'appareil se trouvent dans le manuel d’utilisation Kohler CH18-26.

Un groupe de documents appelé manuels d’utilisation est également divisé en types plus spécifiques, tels que: Manuels d’installation Kohler CH18-26, manuels d’entretien, brefs manuels ou manuels de l’utilisateur Kohler CH18-26. Selon vos besoins, vous devriez chercher le document dont vous avez besoin. Sur notre site, vous pouvez voir le manuel le plus populaire d’utilisation du produit Kohler CH18-26.

Manuels d’utilsiation similaires

Manuel d’utilisation complet de l’appareil Kohler CH18-26, quelle devrait-elle être?
Le manuel d’utilisation, également appelé le mode d’emploi, ou tout simplement le manuel, est un document technique destiné à aider à utiliser Kohler CH18-26 par les utilisateurs. Des manuels sont généralement écrits par un rédacteur technique, mais dans un langage accessible à tous les utilisateurs Kohler CH18-26.

Le manuel d’utilisation complet Kohler, devrait inclure plusieurs éléments de base. Certains d'entre eux sont moins importants, tels que: la couverture / page de titre ou pages d'auteur. Cependant, la partie restante, devrait nous fournir des informations importantes du point de vue de l'utilisateur.

1. Introduction et des conseils sur la façon d'utiliser le manuel Kohler CH18-26 - Au début de chaque manuel, nous devrions trouver des indices sur la façon d'utiliser le document. Il doit contenir des informations sur l'emplacement de la table des matières Kohler CH18-26, FAQ ou des problèmes les plus fréquents - les points qui sont les plus souvent recherchés par les utilisateurs de chaque manuel
2. Table des matières - index de tous les conseils pour lKohler CH18-26 qui peuvent être trouvés dans le document courant
3. Conseils sur la façon d'utiliser les fonctions de base de l’appareil Kohler CH18-26 - qui devraient nous aider dans les premières étapes lors de l'utilisation Kohler CH18-26
4. Troubleshooting - séquence systématique des activités qui nous aideront à diagnostiquer et ensuite résoudre les principaux problèmes de Kohler CH18-26
5. FAQ - questions fréquemment posées
6. Détails du contact Informations sur l'endroit où chercher le contact avec le fabricant / service Kohler CH18-26 dans un pays donné, si le problème ne peut être résolu par nous-mêmes.

Avez-vous une question à propos de Kohler CH18-26?

Utiliser le formulaire ci-dessous

Si vous n’avez pas résolu votre problème avec Kohler CH18-26, avec l'aide du manuel que vous avez trouvé, posez une question en utilisant le formulaire ci-dessous. Si un utilisateur a eu un problème similaire avec Kohler CH18-26 il est probable qu’il a envie de partager la façon de le résoudre.

Réécrire le texte de l'image

Captcha
Nouvelle image

Commentaires (0)