-
Multiquip LT6D - page 1
Opera tiOn Manual THIS MANU AL MUST A CCOMP ANY THE EQ UIPMENT A T ALL TIMES. T o find the latest re vision of this publication, visit our website at: www .m ultiquip.com MODel l t6D liGHt tOWer/Genera tOr (KOHler KDW 1003 DieSel enGine) Re vision #0 (07/16/13) pn 34639 ...
-
Multiquip LT6D - page 2
proposition 65 w arning Diesel engine exhaust and some of ...
-
Multiquip LT6D - page 3
If you believe that your vehicle has a defect that could cause a crash or could cause injury or death, you should immediately inform the Nation ...
-
Multiquip LT6D - page 4
p a ge 4 — L T6D LIgHT TO WeR • OpeRa TIOn manu aL — Rev . #0 (07/16/13) T ABLE OF CONTENTS L T6D Light T ower Proposition 65 W ar ning ........................................... 2 Repor ting Saf ety Def ects ......................................... 3 T ab le Of Contents .................................................... 4 Saf ety Inf orm ...
-
Multiquip LT6D - page 5
safety informa tion Do not operate or service the equipment before reading the entire manual. Safety precautions should be f ollow ed at all ti ...
-
Multiquip LT6D - page 6
safety informa tion operate this equipment without ...
-
Multiquip LT6D - page 7
safety informa tion LIGHT T O WER SAFETY operate the equipment in an e xplosiv e atmosphere or ne ...
-
Multiquip LT6D - page 8
safety informa tion The engine fuel e xhaust gases contain poisonous carb ...
-
Multiquip LT6D - page 9
safety informa tion star t the engine near spilled fuel ...
-
Multiquip LT6D - page 10
safety informa tion Bef ore lifting, make sure th ...
-
Multiquip LT6D - page 11
safety informa tion The electrical voltage required to ope ...
-
Multiquip LT6D - page 12
safety informa tion drop the batter y . Ther ...
-
Multiquip LT6D - page 13
safety informa tion NO TICE The diesel engine used in this equipment has be ...
-
Multiquip LT6D - page 14
lamp footcanDle plot Figure 1. Lamp Footcandle Plot ...
-
Multiquip LT6D - page 15
specifica tions L T6D Specifications Light T ower Model L T6D W eight (Dr y) 1,575 lbs. (714 kg.) Suppor t P ...
-
Multiquip LT6D - page 16
specifica tions Engine Specifications K ohler KD W 1003 Diesel Engine Engine T ype 3-Cylinder , Diesel Engine ...
-
Multiquip LT6D - page 17
Dimensions Figure 2. Dimensions Dimensions Reference Letter Description Dimension A Length (Mast Stowed P osit ...
-
Multiquip LT6D - page 18
general informa tion The Multiquip L T6D Series Light T ower is a dedicated general purpose light tower engineered to provide dependable lig ...
-
Multiquip LT6D - page 19
notes ...
-
Multiquip LT6D - page 20
components Figure 3. Major Components 1 (Control P anel Side) 120/240 VAC ENGINE HOURS OFF OFF OFF OFF OFF 1/10 LIGHTING 120 VAC 10 2 4 4 3 ...
-
Multiquip LT6D - page 21
components Figure 4. Major Components 2 (Control P anel Side) 120/240 VAC ENGINE HOURS OFF OFF OFF OFF OFF 1/10 LIGHTING 120 VAC 15 14 13 17 ...
-
Multiquip LT6D - page 22
components Figure 5. Major Components (Front/ Rear) REAR VIEW FRONT VIEW 25 29 30 24 28 33 32 29 26 34 27 31 31 24. Rear Reflector s — Th ...
-
Multiquip LT6D - page 23
notes ...
-
Multiquip LT6D - page 24
control p anel Figure 6. Control P anel/Ignition Switch 120/240 V AC ENGINE HOURS OFF OFF OFF OFF OFF 1/10 LIGHTING 120 V AC = NOT USED 3 1 ...
-
Multiquip LT6D - page 25
control p anel Figure 6 shows the location of the controls and indicators on the L T6D control panel. Below is a breif description of each c ...
-
Multiquip LT6D - page 26
Figure 7. Kohler Engine Components 1 2 3 1 5 4 7 6 19 18 11 12 10 9 8 14 16 17 15 13 1 . ? ...
-
Multiquip LT6D - page 27
inspection The diesel engine (Figure 7) must be chec ked f or proper lubrication and fill ...
-
Multiquip LT6D - page 28
1 . T o check the engine fuel le vel, make sure the light tower is placed on secure le vel ground with the en ...
-
Multiquip LT6D - page 29
inspection It is recommended that antifreeze/summer coolant be used with the engine. This can be purchased pre-dilu ...
-
Multiquip LT6D - page 30
Exhaust gases from diesel engines are e xtremely poisonous. Whene ver an engine ...
-
Multiquip LT6D - page 31
setup If additional grounding (ground rod) of the light to wer is require ...
-
Multiquip LT6D - page 32
setup Figure 22. Mast Operation MAST ROT A TION LOCKING KNOB MAST EXTENSION HANDLE FORKLIFT POCKET USED AS A M ...
-
Multiquip LT6D - page 33
setup 1 . T o release t ...
-
Multiquip LT6D - page 34
opera tion 1 . Place the main circuit breaker , CB1 (Figure 18) on the cont ...
-
Multiquip LT6D - page 35
opera tion This light tower is equipped with tw o auxiliar y o ...
-
Multiquip LT6D - page 36
Frequency 10 hrs Daily 200 hrs 500 hrs 1000 ...
-
Multiquip LT6D - page 37
When perf orming any maintenance on the light tower or engine, f ollow all safety messages and rules f or saf e operation stated at the begi ...
-
Multiquip LT6D - page 38
Replacing Fuel Filter 1 . Set a container under the fuel filter car tridge (Figure 25) to catch spilled fuel. Figure 25. Fuel Filter 2 . Us ...
-
Multiquip LT6D - page 39
maintenance Figure 28. V -Belt Inspection Lamp Replacement 1 . Place all circuit breakers in the OFF position. 2 . Remov e protectiv e lens ...
-
Multiquip LT6D - page 40
maintenance 1 . Stop the engine and allow it to cool. Tighten v alv e of the corrosion resistor (if equipped). 2 . T ur n w ater filler cap ...
-
Multiquip LT6D - page 41
maintenance 5 . Rethread the cable through the pulle y and reattach the cable to the ball soc k et pin. 6 . Raise and low er the mast se v e ...
-
Multiquip LT6D - page 42
maintenance — trailers The f ollowing trailer maintenan ce guidelines are intend ...
-
Multiquip LT6D - page 43
maintenance — trailers Wheel Hub Adjustment Every time the wheel hub is remov ed and the bearings are reassembled, f ollow the steps below ...
-
Multiquip LT6D - page 44
The f ollowing guidelines are intended to assist the operator in the operation and handling of a trailer . Saf ety precautions should be f o ...
-
Multiquip LT6D - page 45
When towing a trailer , you will hav e decreased acceleration, increased stopping dis ...
-
Multiquip LT6D - page 46
Be sure that the brak es and a ...
-
Multiquip LT6D - page 47
Figure B. VIN T ag Location The trailer VIN T ag contains the f ollowing critical safety inf ormation for the use of y our trailer . GA WR : ...
-
Multiquip LT6D - page 48
If the coupler connection comes loose, the saf ety chains can keep the tr ailer attached to the tow ...
-
Multiquip LT6D - page 49
Rock the ball to mak e sure it is tightened to the hitch, and visually check that the hitch ball n ut is solid against the lock washer a ...
-
Multiquip LT6D - page 50
Visually inspect the saf ety chains and hooks f or wear or damage. Replac ...
-
Multiquip LT6D - page 51
A pintle ey e coupler (Figure F) connects to a pintle-hook hitch that is located on or under the ...
-
Multiquip LT6D - page 52
Raise the bottom surf ace of the coupler to be abov e the top of the pintle hitch hook. Use the tongue jackstand to suppor t the trailer ...
-
Multiquip LT6D - page 53
Lug nuts are also prone to loosen after first being assembled. When driving a ne w trailer (or after wheels hav e been remounted), check to ...
-
Multiquip LT6D - page 54
Deter mine the weight of the equipment being loaded on the tow v ehicle. That weight ma y not safely e xceed the av ai ...
-
Multiquip LT6D - page 55
: This tw o-digit number is the wheel or rim diameter in inches. If you change your wheel siz e, y ou wil ...
-
Multiquip LT6D - page 56
Tires f or light trucks ha ve other markings besides those f ound on the sidew alls of passenger tires. LT : The “L T” indicates the tir ...
-
Multiquip LT6D - page 57
Wheel Rims If the trailer has been struck, or impacted, on or near the wheels, or if the trailer has struck a curb , inspect the rims for da ...
-
Multiquip LT6D - page 58
troublesHooting (genera tor) Practically all breakdowns can be pre vented b y proper handling and maintenance inspections, b ut in the ev en ...
-
Multiquip LT6D - page 59
troublesHooting (engine) Engine T roubleshooting Symptom Soluti ...
-
Multiquip LT6D - page 60
troublesHooting (engine) ? ...
-
Multiquip LT6D - page 61
troublesHooting (lamps) Lamp T roubleshooting Symptom Solution ...
-
Multiquip LT6D - page 62
troublesHooting (lamps) ? ...
-
Multiquip LT6D - page 63
troublesHooting Use the f ollowing procedure and wiring dia ...
-
Multiquip LT6D - page 64
p anel ligHt/Hour meter wiring Diagram 120/240 VAC ENGINE HOURS OFF OFF OFF OFF OFF 1/10 LIGHTING 120 VAC REAR VIEW HOUR METER HOUR METER FR ...
-
Multiquip LT6D - page 65
electronic components loca tor 120/240 VAC ENGINE HOURS OFF OFF OFF OFF OFF 1/10 LIGHTING 120 VAC 120/240 VAC ENGINE HOURS OFF OFF OFF OFF O ...
-
Multiquip LT6D - page 66
wiring Diagram (genera tor/ligHts) A B D H J TB1 L TB2 M LINE (L1) X Y 240/120 VA C AUX RECPT . W G BLK (LINE 1) RED RED C5 25µF@425V EXCIT ...
-
Multiquip LT6D - page 67
NEU. BALLAST #1 (LAMP 1) 4 LAMP BALLAST ASSEMBL Y P/N 34050 24µF@480V CAP ACITOR OUTPUT 120V IN NEU. BALLAST #2 24µF@480V CAP ACITOR OUTPU ...
-
Multiquip LT6D - page 68
REAR VIEW LEFT SIDE VIEW RIGHT SIDE VIEW C E H D F A B G ligHts loca tor Diagram ...
-
Multiquip LT6D - page 69
ligHts wiring Diagram P2 BK W J2 BK W P3 BK W P4 BK W P5 J5 BK W R BK W R P6 J6 BK LICENSE PLA TE LAMP RIGHT SIDE AMBER REFLECTOR SPLICE:TYP ...
-
Multiquip LT6D - page 70
Opera tiOn and p ar ts Manual Y our Local Dealer is: HERE’S HOW TO GET HELP PLEASE HA VE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING United St a teS Multiquip Corporate Office MQ P arts Depar tment 18910 Wilmington A ve. Carson, CA 90746 Contact: mq@multiquip .com T el. (800) 421-1244 F ax (310) 537-3927 800-427-1244 310-537-3700 F ax: 800- ...
Hai una domanda su Multiquip LT6D?
Utilizza il modulo sottostante
Se non hai risolto il problema con Multiquip LT6D con l'aiuto del manuale che hai trovato, fai una domanda utilizzando il modulo sottostante. Se un utente ha avuto un problema simile con Multiquip LT6D è probabile che voglia condividere il modo di risolverlo.