-
Ingersoll-Rand SS5N5 - page 1
ingersoll Owner's Manual Installation, Operation and Maintenance Instructions for Models SS3 and SS5 Stationary Air Compressors IMPORTANT INFORMATION! READ AND FOLLOW THESE INSTRUCTIONS. RETAIN FOR REFERENCE. ll_*-]r-1 =1 ul li" DEFINITIONS /k_ WILL cause DEATH, SEVERE INJURY or substantial property damage WARNING CAN cause DEATH, SEVERE ...
-
Ingersoll-Rand SS5N5 - page 2
SELECTING A LOCATION GENERAL° Select a clean, dry, welt-lighted indoor area with plenty of space far proper cooling air flow and accessibility. Locate the unit at least 12 inches (30 cm) from wails, and make sure the main power supply is clearly identified and accessible TEMPERATURE.. Ideal operating temperatures are between 32"F and 100°F ( ...
-
Ingersoll-Rand SS5N5 - page 3
connected to the same circuit, the total electrica! load must be considered in selecting the proper wire size DO NOT USE UNDERSIZE WIRE FUSES., Refer to the National Electric Code to determine the proper fuse or circuit breaker rating required. When selecting fuses, remember the momentary starting current of an electric motor is greater than its fu ...
-
Ingersoll-Rand SS5N5 - page 4
NORMAL START-UP 1 Set the pressure switch lever to "OFF" 2 Close the service valve 3 Attach hose and accessory 4., Move the pressure switch lever Io "ON/AUTO _ The coil will start 5. Allow tank pressure to build The motor will stop when tank pressure reaches cut-out pressure, 6 Open the service valve The unit is now ready for use. NO ...
-
Ingersoll-Rand SS5N5 - page 5
Follow the procedures outlined below to correctfy set and measure belt tension 1. Lay e slraight edge across the top outer surface of the belt drive from pulley to sheave 2. At the cen_.arof the span. perpendicular !o the bait. apply pressure to the outer surface of the bell with a tension gauge Force the belt to the deflection indicated in the tab ...
-
Ingersoll-Rand SS5N5 - page 6
ld :(0] II :| II:l"l_'[*Ia]l d I_ [{glm m ,_ PROBLEM POSSIBLE CAUSE Abnormal piston, ring or 1 Lubricant viscosity too tow cylinder wear 2 Lubricant level too law 3 Detergent type lubricant being used 4 Cylinder(s) or piston(s) scratched, worn or scored 5 Extremely dusty atmosphere 6 Worn cylinder finish Air delivery drops off U_it does n ...
-
Ingersoll-Rand SS5N5 - page 7
PROBLEM Knocking or retlting Lights flicker or dim when running Moisture in crankcase or "milky" appearance in pelroleum lubricant or rusling in cylinders Motor ovedoad trips or draws excessive current Motor will not start Oit in discharge air (oil pumping) Oil leakinc 1 from shaft seal Safety/relief valve "pops" POSSIBLE CAUSE ...
-
Ingersoll-Rand SS5N5 - page 8
WARRANTY Ingersoll-Rand Company warrants that the Equipment manufactured by it and defivered hereunder shall be free of defects in material and workmanship for a period of twelve (I2) months from the date of placing the Equipment in operation or eighteen (18) months from the date of shipment, whichever shall occur first. The foregoing warranty peri ...
-
Ingersoll-Rand SS5N5 - page 9
INGERSOLL-RANDo AIR COMPRESSORS Ingersoll-Rand Company 800-B Beery Street P.O Box 1803 Davidson, NC 28036 1-800 AIR SERV www_atr ingersoU-rand 1corn PARTS LIST FOR MODEL SS5 BARE COMPRESSOR PUMP 45 LISTA DE PIEZAS PARA MODELO SS5 BOMBA COMPRESORA SIN ACCESORIOS LISTE DE PII_CES POUR COMPRESSEUR NU, MODELE SS5 Piston R}ng S_quenc_ Se_encla de a ni_l ...
-
Ingersoll-Rand SS5N5 - page 10
DESCRIPCt0N DESCRIPTION REF NO PART NO QTY N _ DE REF. N _ DE PIEZA DESCRIPTION CANT. N = DE REP. N" DE PIECE QTY. REF, 97334148 PUMP, BARE COMPRESSOR BDMBA COMPRESORA SIN ACCESORIOS COMPRESSEUR NU X 1 20102703 SET, PISTON RING CON JUNTO DE ANILLOS DE PISTON JEU DE SEGMENTS 2 2 NSS e RING, COMPRESSION • ANILLO DE COMPRES{0N • SEGMENT DE CO ...
-
Ingersoll-Rand SS5N5 - page 11
ingersoliRand Parts List for Models SS5L5 & SS5N5 7 ..4 22.24 -- 3 • 26- 10- 23.2.5 - 11- ', -- " " ....... <_-17, ,_ . " 15 21 iTq--_,-', F4"-,_ i 13 REF NO PART NO DESCRIPTION OTY 84G03724 CAPSCREW 4 2 95750394 WASHER, SPRING LOCK 4 3 9733.148 PUMP. BARE COMPRESSOR I 4 ASSEMBLY, COMPLETE BELTGUARD 1 5 _18851 ...
-
Ingersoll-Rand SS5N5 - page 12
START-UP KIT Each slart_Up kit contI31n._ enough Ingersoll-Rand synthetic compressor _ubricant _nd _Ir ISlet etem_nts tD starbup and mglnfaln your _,8 fo_" lh_ first y_at PART NO DESCRIPTION 20100251 KIT. START*UP INGERSOLL-RAND SYNTHETIC COMPRESSOR LUBRICANT PART NO, DESCRIPTION 3231867,5 LUBRICANT, 1 QUART BOTTLE 32318683 LUBRICAN'E CAS ...
Ingersoll-Rand SS5N5についてご質問がありますか?
次のフォームを使用してください
見つけた説明書を読んでもIngersoll-Rand SS5N5の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがIngersoll-Rand SS5N5で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。