-
Weil-McLain Boiler - page 1
• Selection data • Installation • Piping • W ater treatment This manual must only be used by a qualified heating installer/service technician. Before installing, read all instructions, including this manual, the Ultra Boiler Manual and all applicable Supplements. Consider all connections to the boilers before selecting a location and layout ...
-
Weil-McLain Boiler - page 2
Part number 550-101-232/0703 2 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Contents Hazard definitions .................................................................................................................................. 3 Selection data Controls ...................................................... ...
-
Weil-McLain Boiler - page 3
Part number 550-101-232/0703 3 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems The following defined terms are used throughout this manual to bring attention to the presence of hazards of various risk levels or to important information concerning the life of the product. Hazard definitions Controls W eil-M cLain offe ...
-
Weil-McLain Boiler - page 4
Part number 550-101-232/0703 4 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Ratings and engineering data Figure 1 Ratings and engineering data (see page 5 for notes) D O E ...
-
Weil-McLain Boiler - page 5
Part number 550-101-232/0703 5 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems For simplicity , the table on page 4 lists only sy stems using m ultiples of the same Ultra b oiler module. Any combination of Ultra boilers can be installed as a multiple boiler system. Figure 1 Ratings and engineering data (continued) No ...
-
Weil-McLain Boiler - page 6
Part number 550-101-232/0703 6 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems 1 . Boiler supply and return tappings are both 1" NPT . Connect to headers with 1” pipe for Ultra-80 and Ultra-105; 1¼" pipe for Ultra-155 and Ultra-230. For wall-hung boilers, water piping and gas pipe can be routed through b ...
-
Weil-McLain Boiler - page 7
Part number 550-101-232/0703 7 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems 06-24-03 CONFIDENTIAL REVIEW & COMMENT ONL Y Placement and mounting information Placement, general 1 . Locate multiple boilers in boiler room according to: • Figure 3 (side-to-side), or • Figure 4 (back-to-back). For wall mounting, ...
-
Weil-McLain Boiler - page 8
Part number 550-101-232/0703 8 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems 06-24-03 CONFIDENTIAL REVIEW & COMMENT ONL Y Easy -Fit ® P iping Figure 6 Single-sided connection — Maximum connected boiler output: 2-inch manifolds — 450 MBH 3-inch manifolds — 1400 MBH 4-inch manifolds — 2900 MBH Figure 7 D ...
-
Weil-McLain Boiler - page 9
Part number 550-101-232/0703 9 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems 06-24-03 CONFIDENTIAL REVIEW & COMMENT ONL Y Figure 8 Piping schematic — Typical piping for multiple Ultra boilers, using Weil-McLain Easy-Fit ® Manifolds 1 Flow/check valve (each boiler) 2 Isolation valves (when used) 3 Cap 4 Easy- ...
-
Weil-McLain Boiler - page 10
Part number 550-101-232/0703 10 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Figure 9 Typical piping for multiple Ultra boilers, using Weil-McLain Easy-Fit ® Manifolds Easy -Fit ® P iping (continued) 1 Flow/check valve (each boiler) 2 Isolation valves (when used) 3 Caps 4 Easy-Fit ® Manifold (supply), sized per ...
-
Weil-McLain Boiler - page 11
Part number 550-101-232/0703 11 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Figure 10 Typical piping for multiple Ultra boilers, Weil-McLain Easy-Fit ® Manifolds, and indirect water heaters 1 Flow/check valve (each boiler) 2 Isolation valves (when used) 3 Caps 4 Easy-Fit ® Manifold (supply), sized per Fig. 1 or ...
-
Weil-McLain Boiler - page 12
Part number 550-101-232/0703 12 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Figure 11 Typical piping for multiple Ultra boilers, using Weil-McLain Easy-Fit ® Manifolds and heat exchanger Use isolation heat exchanger for: 1. Large volume systems with high mineral conte nt in water . 2. Systems exposed to untreate ...
-
Weil-McLain Boiler - page 13
Part number 550-101-232/0703 13 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Figure 12 Manifolding combution air piping Combustion air & vent piping installation Vent piping 1. Each boiler requires an individual vent pipe, in- stalled and terminated per the Ultra Boiler Manual and Ultra Boiler V enting Suppme ...
-
Weil-McLain Boiler - page 14
Part number 550-101-232/0703 14 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Figure 13 Connecting gas supply piping Gas piping Connecting gas supply piping 1 . Remove jacket front panel and refer to Figure 13 to pipe gas to boiler . a. Install ground joint union for servicing, when required. b . Install manual shu ...
-
Weil-McLain Boiler - page 15
Part number 550-101-232/0703 15 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Figure 14 Common gas piping, with manifolded gas header Common gas piping installation 4 . Size gas piping from meter outlet to entrance of gas header in acc ordance with T ables 1 and 2 belo w . Fo r gases w ith other specific gravity or ...
-
Weil-McLain Boiler - page 16
Part number 550-101-232/0703 16 GA S - FIRED WA TER BOILER — Installation Manual — Multiple-boiler S ystems Additional instructions Air for boiler room ventilation 1. Follow instructions in Ultra Boiler Manual to ensure the boiler room provides sufficient air infiltration. Wiring 1. Refer to boiler sequencing control instructions and Ultra Boil ...
Weil-McLain Boilerについてご質問がありますか?
次のフォームを使用してください
見つけた説明書を読んでもWeil-McLain Boilerの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWeil-McLain Boilerで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。