日本語 dropdown-ico

Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の取扱説明書

39ページ 3.1 mb
ダウンロード

ページに移動 of 39

Summary
  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 1

    Owner’ s Manual • SAFETY • ASSEMBLY • OPERATION • TROUBLESHOOTING • ELECTRICAL DATA • PARTS • WARRANTY 1-800-333-1322 UL TRA SOURCE Portable Generator COMMERCIAL • INDUSTRIAL • RESIDENTIAL MODELS: 004451 (12,500 W A TT) 004582 (15,000 W A TT) AUTHORIZED DEALER SUPPORT: ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 2

    Table of Contents Commercial-Industrial-Residential Portable Generator System Safety Rules ..............................................1-3 Section 1 – General Information ................4 1.1 Unpacking ....................................................................4 1.1.1 Accessory Box ..................................................4 1 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 3

    INTRODUCTION Thank you for purchasing this model of the GUARDIAN ® product line by Generac Power Systems, Inc. This model is a compact, high performance, air-cooled, engine driven generator designed to supply electrical power to operate electrical loads where no utility power is available. READ THIS MANUAL THOROUGHLY If you do not understand any p ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 4

    2 • Never start or stop the unit with electrical loads connected to receptacles AND with connected devices turned ON. Start the engine and let it stabilize before connecting electrical loads. Disconnect all electrical loads before shutting down the generator. • Do not insert objects through unit's cooling slots. • Never operate generator ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 5

    3  ELECTRICAL HAZARDS  • All generators covered by this manual produce dangerous electrical voltages and can cause fatal electrical shock. Utility power delivers extremely high and dangerous voltages as does the generator when it is in operation. Avoid contact with bare wires, terminals, connections, etc., while the unit is running. Ensure ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 6

    1.1 UNPACKING • Set the palleted carton on a rigid flat surface. • Remove staples along bottom of carton that fasten carton to pallet. Open carton from top. • Remove all packaging material. • Remove separate accessory box. • Lift carton off the generator. • Remove generator from shipping pallet by removing bolts through the shipping bra ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 7

    5 1.2.3 BATTERY CONNECTION • The battery shipped with the generator has been provided fully charged. Caution must be taken when connecting the battery. • Cut the tie wrap cable holding the RED and BLACK battery cables to the stator. • Connect the RED battery cable to the battery Positive terminal (+). After making sure that the connection is ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 8

    6 Section 2 – Operation Commercial-Industrial-Residential Portable Generator System OPERATION 2.1 KNOW THE GENERATOR Read the Owner’s Manual and Safety Rules before operating this generator. Compare the generator to this illustration to become familiarized with the locations of various controls and adjustments. Save this manual for future refer ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 9

    14) Start/Run/Stop Switch – Controls the operation of the generator. 15) Oil Fill – Use this point to add oil to engine. 16) Fuse - 10 Amp (Located at rear of panel) – Protects the DC control circuit from overload. If this fuse element has melted open the engine will not be able to crank and start. 2.2 CORD SETS AND CONNECTION PLUGS 2.2.1 AC, ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 10

    Figure 9 - 120 VAC, 30 Amp Receptacle Use this receptacle to operate 120 Volt AC, 60 Hz, single phase loads requiring up to 3600 watts (3.6 kW) of power at 30 Amps. The outlet is protected by a 30 Amp push-to-reset circuit breaker. 2.2.4 120/240V AC, 30 AMP RECEPTACLE Use a NEMA L14-30 plug with this receptacle. Connect a suitable 4-wire grounded c ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 11

    2.3 HOW TO USE THE GENERATOR If you have any problems operating your generator, please call the generator helpline at 1-800-333-1322. 2.3.1 GROUNDING THE GENERATOR The National Electrical Code requires that the frame and external electrically conductive parts of this generator be properly connected to an approved earth ground . Local electrical cod ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 12

    10 2.5 WATTAGE REFERENCE GUIDE Device . . . . . . . . . . . . . . . . . . . . . . .Running Watts *Air Conditioner (12,000 Btu) . . . . . . . . . . . . . . . . .1700 *Air Conditioner (24,000 Btu) . . . . . . . . . . . . . . . . .3800 *Air Conditioner (40,000 Btu) . . . . . . . . . . . . . . . . .6000 Battery Charger (20 Amp) . . . . . . . . . . . . ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 13

    11 2.6.2 ADDING GASOLINE  WARNING: Never fill fuel tank indoors. Never fill fuel tank when engine is running or hot. DO NOT light a cigarette or smoke when filling the fuel tank.  Caution: Do not overfill the fuel tank. Always leave room for fuel expansion. • Use regular UNLEADED gasoline with the generator engine. Do not use premium gasoli ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 14

    12 • Move engine CHOKE knob to “Full Choke” position. Figure 17 - Full Choke Position • To start engine, press and hold the Start/Run/Stop switch in the “Start” position. The engine will crank and attempt to start. When the engine starts, release the switch to the run position. • When the engine starts, move choke knob to “1/2 Choke ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 15

    2.12 CHARGING A BATTERY  DANGER! Storage batteries give off explosive hydrogen gas while recharging. An explosive mixture will remain around the battery for a long time after it has been charged. The slightest spark can ignite the hydrogen and cause an explosion. Such an explosion can shatter the battery and cause blindness or other serious inju ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 16

    3.2.1 GENERATOR SPECIFICATIONS MODEL GPS 12500 GPS 15000 Model # 004451-1 004582-1 Rated Max. Power 12.5 kW 15.0 kW Surge Power 18.75 kW 22.5 kW Rated AC Voltage 120/240 120/240 Rated Max AC Load Current @ 240V 52.0 Amps 62.5 Amps Current @ 120V 104.0 Amps 125.0 Amps Rated Frequency 60 Hz @ 3600 RPM Phase Single Phase Rated DC Voltage 12 Volts Rate ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 17

    15 3.3 GENERAL RECOMMENDATIONS The warranty of the generator does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, the operator must maintain the generator as instructed in this manual. Some adjustments will need to be made periodically to properly maintain the generator. All adjustm ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 18

    16 3.3.6 REPLACING THE SPARK PLUG Use Champion RC14YC spark plug or equivalent. The correct air gap is 0.76 mm (0.030 in.). Replace the plug once each year . This will help your engine start easier and run better. 1. Stop the engine and pull the spark plug wire off of the spark plug. 2. Clean the area around the spark plug and remove it from the cy ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 19

    Figure 21 - Spark Arrestor 3.6 ADJUSTING VALVE CLEARANCE After the first 50 hours of operation, you should adjust the valve clearance in the engine. Important: If you feel uncomfortable about doing this procedure or you don't have the proper tools, please take your generator in to the nearest service center to have the valve clearance adjusted ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 20

    18 Section 3 — Maintenance Commercial-Industrial-Residential Portable Generator System 3.7 GENERAL The generator should be started at least once every seven days and be allowed to run at least 30 minutes. If this cannot be done and you must store the unit for more than 30 days, use the following information as a guide to prepare it for storage. ? ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 21

    19 4.1 TROUBLESHOOTING Engine is running, but no AC 1. Circuit breaker is open. 1. Reset circuit breaker. output is available. 2. Poor connection or defective cord set. 2. Check and repair. 3. Connected device is bad. 3. Connect another device that is in good condition. 4. Fault in generator. 4. Contact Authorized Service Facility. Engine runs good ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 22

    20 Section 5 — Notes Commercial-Industrial-Residential Portable Generator System ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 23

    21 Section 5 - Notes Commercial-Industrial-Residential Portable Generator System ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 24

    22 Section 6 — Electrical Data Commercial-Industrial-Residential Portable Generator System Wiring Diagram – Drawing No. 0E0228 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 25

    23 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 26

    24 Section 7 — Exploded Views and Parts Lists Commercial-Industrial-Residential Portable Generator System GT-990 & GT-760 Engine (Page 1) – Drawing No. 0E8589-J ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 27

    25 ITEM PART NO. QTY. DESCRIPTION 1 0C5729 1 ASSEMBLY, CRANKCASE HOUSING WITH SLEEVE 2 0E9843 1 SEAL, 38 I.D. CRANKSHAFT 3 090388 3 SCREW, TAPTITE M6-1.0 X 12 BP 4 0C5372 1 ASSEMBLY, BREATHER 5 0C3005 1 GASKET, BREATHER COVER 6 0E3372B 1 SEPARATOR, OIL BREATHER 7 0D8067A 1 ASSEMBLY, HEAD #1 8 071983 4 RETAINER, PISTON PIN 20 9 0D5269 1 ROCKER, COVE ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 28

    26 Section 7 — Exploded Views and Parts Lists Commercial-Industrial-Residential Portable Generator System GT-990 & GT-760 Engine (Page 2) – Drawing No. 0E8589-J ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 29

    ITEM PART # QTY. DESCRIPTION 66 0D6592 1 WINGNUT, AIRBOX 67 0D4511 1 PRECLEANER, AIR 68 0D9723 1 ELEMENT, AIR CLEANER 69 0E5302 1 STUD M6-1.0 X 73 70 0D4183 1 ADAPTOR, SPIT BACK 71 0D6327 1 GASKET, SPITBACK 72 0D2774B 1 BASE, AIRBOX 73 0D5125 1 SPRING, WINTER/SUMMER VALVE 74 0D2930 1 VALVE, SUMMER / WINTER 75 0D4612A 1 SNORKEL, AIR INTAKE 76 0D6143 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 30

    28 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 31

    29 ITEM PART NO. QTY. DESCRIPTION 1 0C6934 1 ADAPTOR, ENGINE 2 0D2123 1 STATOR 12.5KW 0D2134 STATOR 15KW 0D2136 STATOR 18KW 3 0D21320SRV 1 ASSEMBLY, ROTOR WITH FAN 12.5KW 0D21330SRV ASSEMBLY, ROTOR WITH FAN 15KW 0D2135 ROTOR 18KW 4 0C6043B 1 CARRIER, REAR BEARING 5 0D2492 1 EXHAUST MANIFOLD 6 0D2726 1 MUFFLER 7 0C4138 2 GASKET, EXHAUST 8 0D3547 1 C ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 32

    30 Section 7 — Exploded Views and Parts Lists Commercial-Industrial-Residential Portable Generator System Control Panel – Drawing No. 0E0227-C ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 33

    ITEM PART NO. QTY. DESCRIPTION 1 087968 1 SWITCH, ROCKER -/0 2 090418 1 OUTLET, 12VDC SNAP 3 0D6640 1 COVER, GOVERNOR CONTROL 4 090987 6 SCREW PPHM M3-0.5 X 12 5 0D8740 1 PANEL, SHEET METAL 6 068868 2 OUTLET 30A 120V RECEPT 7 022985 2 WASHER FLAT #6 8 043182 10 WASHER LOCK M3 9 051714 6 NUT HEX M3-0.5 G8 10 075207A 4 CIRCUIT BREAKER 30A 11 075207 2 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 34

    32 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 35

    33 ITEM PART NO. QTY. DESCRIPTION 1 057058 4 SCREW HHC M6-1.0 X 55 2 0D5315 4 RUBBER TANK MOUNT 3 0D4570 1 CAP, FUEL WITH GAUGE & VENT 4 0D22850SRV 1 KIT, FUEL TANK 5 045771 4 NUT HEX M8-1.25 6 022129 10 WASHER LOCK M8-5/16 7 022145 14 WASHER FLAT 5/16 8 0D4565 1 BRACKET BATTERY 9 0D3545 2 BOLT,BATTERY J-BOLT 10 022287 2 SCREW HHC 1/4-20 X 3/4 ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 36

    34 CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board (CARB) and Generac Power Systems, Inc. (Generac) are pleased to explain the Emission Control System warranty on your new engine. In California, new off-road Large Spark-Ignition (LSI) engines must be designed, built and equipped ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 37

    35 EMISSION CONTROL SYSTEM WARRANTY Emission Control System Warranty (ECS warranty) for 2001 and later model year LSI engines: (a) Applicability: This warranty shall apply to 1995 and later model year engines. The ECS Warranty period shall begin on the date the new engine or equipment is purchased by/delivered to its original, end-use purchaser/own ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 38

    GENERAC POWER SYSTEMS “TWO YEAR” LIMITED WARRANTY FOR GUARDIAN ® “12,500 WATT AND 15,000 WATT PORTABLE GENERATORS” For a period of two years from the date of original sale, Generac Power Systems, Inc. (Generac) warrants its Guardian generator will be free from defects in materials and workmanship for the items and period set forth below. G ...

  • Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT) - page 39

    GENERAC POWER SYSTEMS, INC. P.O. Box 297 • Whitewater, WI 53190 Part No. 0E0226 Rev. G 5.04, 10.04, 5.05 Printed in USA ...

メーカー Guardian Technologies カテゴリー Portable Generator

Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 004451 (12,500 WATT), 004582 (15,000 WATT)の取扱説明書
- Guardian Technologiesの製品カード
- パンフレット
- またはGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の取り付け説明書、サービスマニュアル、簡易説明書、またはGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)を使用するのを助ける技術的文書のことです。説明書は通常、全てのGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Guardian Technologiesの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)デバイスの基本機能を使うにあたってのヒント。 Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)のメーカー/サービスへの連絡先に関する情報。

Guardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)についてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがGuardian Technologies 004451 (12,500 WATT), 004582 (15,000 WATT)で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)