Friedrich CP05C10の取扱説明書

24ページ 0.92 mb
ダウンロード

ページに移動 of 24

Summary
  • Friedrich CP05C10 - page 1

    Room Air Conditioner Ser vice and P ar ts Man ual C P05 .Svc (0 5 /0 6 ) CP05C10 ...

  • Friedrich CP05C10 - page 2

    —2— CONTENTS 1. PREF A CE ...................................................................................................................................................3 1.1 FEA TURES.....................................................................................................................................................3 1.2 SPE ...

  • Friedrich CP05C10 - page 3

    1. PREF A CE This ser vice manual provides v ar ious ser vice inf or mation, including the mechanical and electrical par ts, etc. This room air conditioner was manuf actured and assembled under a strict quality control system. The refrigerant is charged at the factory . Be sure to read the safety precautions prior to ser vicing the unit. 1.1 FEA TU ...

  • Friedrich CP05C10 - page 4

    —4— 1.3 LOCA TIONS OF CONTR OLS 1 2 3 4 6 5 MONEY SAVER 2 The fan stops when the compressor stops cooling. • Approximately every 3 minutes the fan will turn on and sample the room air to determine if more cooling is needed. TEMPERATURE SETTING 1 • These buttons control the temperature of the room. The temperature can be set within a range o ...

  • Friedrich CP05C10 - page 5

    — 5 — 2. DISASSEMBL Y INSTR UCTIONS 2.1 MECHANICAL P AR TS 2.1.1 FRONT GRILLE 1. Pull the inlet grille forw ard. 2. Remov e the screw securing the F ront Gr ille. (Fig. 3) 3. Push the grille up from the bottom and pull the top of the grille aw ay from the case to lift the top tabs out of their slots. (Fig. 4) 4. Carefully position the grille, b ...

  • Friedrich CP05C10 - page 6

    — 6 — 2.2 AIR HANDLING P AR TS 2.2.1 AIR GUIDE UPPER 1. Disconnect the unit from the pow er source . 2. Remov e the front grille. (Ref er to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Rem o v e the control panel. (Ref er to Section 2.1.3) 5. Rem o v e 2 scr e ws that secure the upper air guide to air guide low er . (See ...

  • Friedrich CP05C10 - page 7

    — 7 — 2.2.3 MO T OR 1. Disconnect the unit from the pow er source . 2. Remov e the front grille. (Ref er to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Rem o v e the control panel. (Ref er to Section 2.1.3) 5. Rem o v e the uppe r air guide . (Ref er to Section 2.2.1) 6. Remov e the compressor , turbo fan, f an and shroud ...

  • Friedrich CP05C10 - page 8

    — 8 — 2.3.2 COMPRESSOR 1. Remov e the front grille and cabinet. (Ref er to Section 2.1) 2. Discharge the refrigerant by using a refrigerant recov er y system. 3. Remov e the ov erload protector . (Ref er to Section 2.3.1) 4. After discharging the unit completely , unbrace the suction and discharge pipes at the compressor connections. 5. Remov e ...

  • Friedrich CP05C10 - page 9

    — 9 — 2.3.6 PO WER CORD 1. Disconnect the unit from source of power . 2. Remov e the front grille. (Ref er to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Rem o v e a scr e w that secures control panel to base pan. (Ref er to Section 2.1.3) 5. Pulls the control board tow ard you. 6. Disconnect the 2 receptacles and remov e ...

  • Friedrich CP05C10 - page 10

    2.4.2 EV APORA T OR 1. Remov e the cabinet. 2. Discharge the refrigerant by using a refrigerant recov er y system. 3. Rem o v e the uppe r air guide . (Re f er to Section 2.2.1) 4. After discharging the refrigerant completely , unbraze the interconnecting tube at the condenser connections. 5. Remov e the ev aporator . 6. Re-install by ref erring to ...

  • Friedrich CP05C10 - page 11

    — 11 — Equipment needed: V acuum pump , charging cylinder , manifold gauge , brazing equipment, pinch-off tool capable of making a vapor proof seal, leak detector , tubing cutter , hand tools to remov e components and ser vice valv e. B A B A B A COMPOUND GAUGE SEE INSETS BELOW CAPILLARY TUBE EVAPORATOR (LOW PRESSURE SIDE) COMPRESSOR CONDENSER ...

  • Friedrich CP05C10 - page 12

    — 12 — 2 . 4.4 ELECTRICAL D AT A USE OF EXTENSION CORDS Because of potential saf ety hazards, w e strongly discourage the use of an e xtension cord. Howe ver , if you wish to use an e xtension cord, use a CSA cer tified/UL-listed 3-wire (grounding) e xtension cord, rated 15A, 125V . Do not under any circumstances cut or remove the grounding pro ...

  • Friedrich CP05C10 - page 13

    — 13 — 3 .2 PIPING SYSTEM F ollowing is a brief descr iption of the impor tant components and their function in what is called the refr igeration system. Ref erence should be made to Figure 32 to follow the refrigerating cycle and the flo w of the refr igerant in the cooling cycle. COOLED AIR HOT DISCHARGED AIR MOTOR COMPRESSOR ROOM AIR HEAT LO ...

  • Friedrich CP05C10 - page 14

    — 14 — 3 .3 T R OUBLESHO O TING GUIDE In general, possib le trouble is classified in two kinds. The one is called Starting Failure which is caused b y an electrical defect. The other is Ineffective Air Con- ditioning caused by a def ect in the refrigeration circuit and improper application. Unit is running but cooling is ineff ective . Ineffect ...

  • Friedrich CP05C10 - page 15

    — 15 — Fails to Start Improper ther mostat setting Loose terminal connection Improper wiring Che c k voltage power source. Drop of power v oltage. Capacitor check. Replacement. Che c k control s witch setting. Compressor f ails to star t. De f ect of compressor or capacitor . Replacement of compressor (Motor damaged). Irregular motor insulation ...

  • Friedrich CP05C10 - page 16

    COMPLAINT CA USE REMED Y F an motor will not run. No power Check v oltage at outlet. Correct if none. P o w er supply cord Che c k v oltage to electronic control board. If non e , check p o w er supply cord. Replace cord if circuit is open. Wire disconnected or Connect wire. Ref er to wiring diagram for connection loose terminal identification. Rep ...

  • Friedrich CP05C10 - page 17

    — 17 — COMPLAINT CA USE REMED Y F an motor noise. F an blade If crac ked, out of balance , or par tially missing, replace it. Bl o w er wheel If c r a c k ed, out of balanc e , or pa r tially missing, replace it. Loose set screw Tighten it. W o r n bea r ings If kno c king sounds cont i n ue when r unning replace the moto r . If the motor hums ...

  • Friedrich CP05C10 - page 18

    — 18 — COMPLAINT CA USE REMED Y Compressor cycles on F an motor If not r unning, deter mine the cause. Replace if ov er load. required. Condenser air flow Remov e the cabinet, inspect the inter ior surf ace restriction of the condenser . If restricted, clean carefully with a vacuum cleaner (do not damage fins) or brush. Clean the inter ior base ...

  • Friedrich CP05C10 - page 19

    — 19 — 4 . CIRCUIT DI A GRAM WH(BL) POWER INPUT BK(BR) (Ribbed) (Plain) GN/YL (GN) GN/YL(GN) THERMIST OR BK BK BL RD BL RD CN-TH1 YL YL OR(BR) OR(BR) OR SYNC M OTOR R Y -LO R Y -HI CN-WORK CN-SYNC CN-DISP DISPLA Y P .W.B ASM R Y -SYNC 250V/T2A (115V/T2A) TRANS FORMER ZNR 43 R Y -COMP MAIN P .W.B ASM BK BK WH BK RD BL BL OLP RD MO TOR CAP ACIT O ...

  • Friedrich CP05C10 - page 20

    — 20 — 5 . EXPLODED VIEW 352390 130410 359012 W48602 354210 349480 352390-1 149980 559011 346811 554030 W48602 130910 550140 554160 567502 352115 552102 352111 352113 35211A 135313 135303 152302 135312 132111-2 132111-1 147582-1 147581 159900-1 269310 238310 W0CZZ 249950 268714 263230 137215 268712 267110 749740 ...

  • Friedrich CP05C10 - page 21

    LocNo FRIEDRICH DESCRIPTION 130410 67302921 Base Assy Single 130910 67303709 Cabinet Assy Single 135312 67306003 Grille Assy Front 135313 67304200 Grille Assy Inlet 14758 1 67304600 Link 147582- 1 67304501 Louver Vertical 2 ea. 149980 67303115 Shroud 152302 67304300 Filter (Mech) 238310 67500115 Escutcheon 269310 67300020 Power Cord Assy 349480 673 ...

  • Friedrich CP05C10 - page 22

    — 22 — MEMO ...

  • Friedrich CP05C10 - page 23

    — 23 — MEMO ...

  • Friedrich CP05C10 - page 24

    Post Office Box 1540 • 4200 N. Pan Am Expressway • San Antonio, Texas 78295-1540 • (210) 357-4400 • FAX (210) 357-4490 FRIEDRICH AIR CONDITIONING CO. Visit our web site at www.friedrich.com CP05.Svc (05/06) Use F actor y Cer tified P ar ts... ...

メーカー Friedrich カテゴリー Air Conditioner

Friedrich CP05C10のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- CP05C10の取扱説明書
- Friedrichの製品カード
- パンフレット
- またはFriedrich CP05C10の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Friedrich CP05C10の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Friedrich CP05C10の取り付け説明書、サービスマニュアル、簡易説明書、またはFriedrich CP05C10のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Friedrich CP05C10の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Friedrich CP05C10デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがFriedrich CP05C10を使用するのを助ける技術的文書のことです。説明書は通常、全てのFriedrich CP05C10ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Friedrichの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Friedrich CP05C10の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははFriedrich CP05C10の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Friedrich CP05C10に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Friedrich CP05C10デバイスの基本機能を使うにあたってのヒント。 Friedrich CP05C10のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Friedrich CP05C10に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるFriedrich CP05C10のメーカー/サービスへの連絡先に関する情報。

Friedrich CP05C10についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもFriedrich CP05C10の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがFriedrich CP05C10で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)