Swisher ZT17542の取扱説明書

24ページ 0.73 mb
ダウンロード

ページに移動 of 24

Summary
  • Swisher ZT17542 - page 1

    ZERO TURN HYDROS TATIC D RIVE ZERO TURN HYDROS TATIC D RIVE ZERO TURN HYDROS TATIC D RIVE ZERO TURN HYDROS TATIC D RIVE OWNER’S MANU AL 1602 CORPORATE DRIVE, P.O. BOX 67, WARRENSB URG, MISSOURI 64093 PHONE 660-747-81 83 FAX 660-747-8650 MODEL N O. ZT17542 Manufa cturing quality law n care e quipmen t sinc e 19 45 Assembly Operati on Service and A ...

  • Swisher ZT17542 - page 2

    1) Engine W arrant y All en gines utiliz ed on our product s have a se parate wa rrant y extended to them b y the individu al engin e manufa cturer. An y engine servic e difficult y is the respon sibilit y of the en gine manufa cturer and in no wa y is Swisher Mower Co., Inc. or its agents respons ible for the en gine warrant y. The Briggs & S ...

  • Swisher ZT17542 - page 3

    TABLE OF CONTENTS 3 WARRANTY……… ………....….2 INTRODUCTION………………..3 SAFETY………………………… 4-7 OPERATION………………… …8-10 MAINTENANCE…………………… .11-12 SERVICE / ADJUSTMENT……… .…13-16 PARTS BREAKDOWN……………...17-21 TROUBLESHOOTING…………… …..22 Thank you for choo ...

  • Swisher ZT17542 - page 4

    SAFETY P RECAU TIONS & DEC ALS This Safety Alert Sy mbol indicates i mportant messages in thi s manual. When you see this sy mbol, carefully read th e message that follows and be alert to t he possibili ty of personal injury. Read this manual completely. T his machine ca n amputate hands, feet, and throw objects. Failu re to observe the f ollow ...

  • Swisher ZT17542 - page 5

    • Turn off the bl ades when not mowin g. Befo re leavin g the ma chine, t urn off the blad es and stop th e engine. • Watch for tr affic when op eratin g near or cross ing roadways. • Do not operate th e mower if it has be en dropped or dam aged in any manner or if the mowe r vibrat es excessivel y. Exc essive vibration is an indi cation of d ...

  • Swisher ZT17542 - page 6

    WARN I NG: Hydraulic f luid can cause sever e burns and pen etrate skin causing severe injur y or death . • Do not step on mower deck when oper ating, di smounting or mount in g the mower. • Never push or pull un it with anot her vehi cle. Transmission d amage will occur. • When transpo rting be sure to secure mow er fra me to transport v ehi ...

  • Swisher ZT17542 - page 7

    SAFETY P RECAU TIONS & DEC ALS Danger/Wa rning Decal – OD99155 Ignition/PTO/ Throttle D ecal – OD99154 Parking Brake D ecal – OD9915 2 Flying Debris De cal – OD53 Triangl e Danger Dec al – OD55 7 ...

  • Swisher ZT17542 - page 8

    OPERATING YOUR NEW ZTR M OWER The operation of an y cutter can encount er forei gn objects to b e thrown into the eyes, resultin g in sever e e ye damage. Alwa ys wear certi fied safet y glasses or wide-vision safet y goggl es for over spect acles be fore starin g an y cutting machi ne and while ope ratin g such a machi ne. The operation of an y cu ...

  • Swisher ZT17542 - page 9

    OPERATING YOUR NEW ZTR M OWER (cont.) CONTROLS ● OPERATOR P RESENCE SYSTEM : This mower is equipp ed with an operator’s pr esence system. Any attempt to leave the seated posit ion while the engine ru nning, without first disengaging the PTO switch and p lacing the steering levers in the neutral position will cause th e engine to shut off. ● W ...

  • Swisher ZT17542 - page 10

    OPERATING YOUR NEW ZTR M OWER (cont.) MOWI NG • WARNING: Do not operate mo wer at too fast of a rat e. Sudden mov emen ts forward and backward at fast speeds c an cause accidents resultin g in personal inj ury • Start out slowl y moving s teering l evers SLOWLY forward and b ackward until you learn to op erate th e unit. NOTE: This mow er has b ...

  • Swisher ZT17542 - page 11

    MAIN TENANCE SCHED ULE INSPECT BEFO RE EACH USE - Loose fasteners : Be sure all f asteners ar e at proper torque. Espe ciall y guards and blades. - Parking brake : If brake does not keep uni t from rolling, brak e must be adjusted or repaired. - Tires : Always check a nd maintain proper tir e pressure (See tire sidew all for recomm endation). Ch ec ...

  • Swisher ZT17542 - page 12

    INSPECT EVERY 25 HOURS -Lubrication: Gre ase all pi vot points with a high temp grease - Battery, check a nd clean : Keep batter y terminals cl ean and tight. Per iodic charging will extend it s life. Cl ean t erminals with a wire brush and coat wi th a petroleum j ell y. -Change engine oil and filter : Use onl y qualit y detergent oil . See engine ...

  • Swisher ZT17542 - page 13

    SERVIC E / ADJUS TMENTS TRACKING Adjustments to the unit may need to be made if the unit does not track in a straight line. The primary reason for t he unit not tracking straight is incorrect or unbalanced tire pressure. Before making any adjust m ents first check and adjust the tire pressure. DO NOT EXCEED MAXIMUM RECOM MENDED TIRE PRESSURE. ADJUS ...

  • Swisher ZT17542 - page 14

    SERVIC E / ADJUS TMENTS REMOVING THE MOWER DECK 1. Turn off engin e and en gage parkin g brake. 2. Rotate cut ting hei ght lev er counterclo ckwise to low est cuttin g position. 3. Remove bolt from picku p point loc ated at the front of th e deck. 4. Remove cott er pins on rear hanger poin ts and slide out st abiliz er bars. Disconn ect tension spr ...

  • Swisher ZT17542 - page 15

    LEVELING THE MOW ER DECK 1. Position un it on a smooth lev el surface. 2. For side to side lev elin g, measure th e distan ce from th e floor to th e bottom edge at the rear of the d eck. The m easurem ent should be equal within 1/16 inch si de t o side. Adjustment c an be mad e b y loosening lockin g nut on rear eyebolt h angers and adjus ting up ...

  • Swisher ZT17542 - page 16

    SERVIC E / ADJUS TMENTS BELTS Clutch drive belt replac ement 1. Disconne ct tension idle r fr om tensio n brack et. 2. Remove be lt fro m mower p ulley and electri c clutc h. 3. Install ne w belt onto electr ic clutc h and mower pull ey and c hec k for prope r routing a nd clea ranc e. 4. Reconne ct idler te nsion b olt to tension brack et. Mower d ...

  • Swisher ZT17542 - page 17

    SEAT DETAIL STEERING DETAIL ENGINE DETA IL FRAME DETAIL TRANSMISSION IDLER DETA IL DECK LIFT DETAIL MOWING DECK DETA IL 1 2 129 3 4 5 6 7 IT E M # D ESCR I PT ION PAR T # 1 ST EE R ING CO V E R 3644 2 NEU T RA L SWIT CH B RA CK ET 3704T K NEU T RA L SWIT CH 3695 3 Z T R C A ST E R S E R V I CE A SSE M. 3725 4 H YD RO R E L E A SE 3678 5 T RA N SMI ...

  • Swisher ZT17542 - page 18

    TRANSMIS SION I DLER 26 25 24 23 22 21 20 8 9 10 11 12 13 14 15 16 18 19 17 BLADE DRIVE R ENGINE SET-UP I T E M # D E SC R IPT IO N PAR T # 8 3/ 4 NUT N B 175 9 B E LL E V I L L E WA SHE R A S 155 10 B E LL E V I L L E WA SHE R A S 155 11 WA S H E R N B 184 12 B L AD E PU L L E Y B104 13 WA S H E R N B 184 14 PUL L E Y SPACE R 6114CS 15 B L A DE PU ...

  • Swisher ZT17542 - page 19

    STEERING (LEFT) SEAT BASE ASS EMBLY SEE DETAIL THIS PAGE 49 50 57 51 52 56 55 53 54 CONTROL CAR D 58 59 60 61 62 63 64 65 66 67 I T E M # DE S C RI P T I ON P AR T # 4 9 HANDL E G R I P 3 6 7 3 5 0 DI RECT I ON AL H ANDL E 3 6 8 5 T K 5 1 C O NT R OL CAR D LE FT 36 2 0 T K C O NT R OL CAR D RIG HT 3 6 2 1 T K 5 2 UNI V ERS AL P I V OT P LAT E 3 6 9 ...

  • Swisher ZT17542 - page 20

    FRAME 69 68 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 93 89 90 91 92 IT E M # DE S CR I P T I ON P A R T # 6 8 HE IG HT I NDI CAT OR 3 7 2 8 6 9 KI CK P L AT E 3 7 2 9 7 0 AC CES S P L AT E HI NG E 3 6 7 5 T K 7 1 ACC E S S P L AT E 36 3 1 T K 7 2 S E AT BAS E 3 7 3 0 7 3 UP P ER M OT OR BAS E 3 6 1 1 T K 7 4 R E AR COV E R 3 7 1 1 T ...

  • Swisher ZT17542 - page 21

    MOWING DECK SEE DETAIL THIS PAGE SEE DETAIL THIS PAGE 94 95 96 97 98 99 100 101 102 BLADE DRIVER 103 104 106 107 108 109 110 111 112 105 114 113 BLADE BELT IDLER (3714) IT E M # D E SCRI P T IO N PAR T # 94 G R ASS CHU T E 3732 95 T O R S ION SPRI N G 9100 96 C HU T E MOUNT 6030T K 97 B EL T /PU L L E Y CO V E R 3656T K 98 3/ 8 E YE B O L T N B 204 ...

  • Swisher ZT17542 - page 22

    CORRECTION CAUSE SYMPTOM 1. CHECK ANDADJUS T TIRE PRESSURE 2. SEE TRACKING ADJUSTMENT IN SERVICE SE CTION 1. IMPR OPER AIR PRESSURE 2. TRACKING ADJUSTMEN TS OUT OF ADJUSTMENT UNIT DOES NOT TRACK STRAIGHT 1. MOV E LEVERS INTO POSITION. 2. P USH PTO SWITCH IN. 3. SEE START UP IN OPERATION SECTION. 4. WAIT SEV ERAL MINUTES BEFORE STARTING 5. REPLACE W ...

  • Swisher ZT17542 - page 23

    ...

  • Swisher ZT17542 - page 24

    OWNER’S MANU AL MODEL N O. ZT17542 Each mower h as its own mo del nu mber. Ea ch e ngine has its own model n umber. The model number for t he mo wer will be found unde r the s eat. T he mod el number for the engine will be found on th e top o f the blowe r fa n housing. All mower p arts listed herei n ma y be ord ered d irectly from Swisher Mo we ...

メーカー Swisher カテゴリー Lawn Mower

Swisher ZT17542のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- ZT17542の取扱説明書
- Swisherの製品カード
- パンフレット
- またはSwisher ZT17542の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Swisher ZT17542の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Swisher ZT17542の取り付け説明書、サービスマニュアル、簡易説明書、またはSwisher ZT17542のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Swisher ZT17542の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Swisher ZT17542デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがSwisher ZT17542を使用するのを助ける技術的文書のことです。説明書は通常、全てのSwisher ZT17542ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Swisherの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Swisher ZT17542の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははSwisher ZT17542の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Swisher ZT17542に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Swisher ZT17542デバイスの基本機能を使うにあたってのヒント。 Swisher ZT17542のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Swisher ZT17542に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるSwisher ZT17542のメーカー/サービスへの連絡先に関する情報。

Swisher ZT17542についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもSwisher ZT17542の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがSwisher ZT17542で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)