Friedrich CP05N10Aの取扱説明書

22ページ 0.81 mb
ダウンロード

ページに移動 of 22

Summary
  • Friedrich CP05N10A - page 1

    Room Air Conditioner Ser vice and P ar ts Man ual CP05 Svc Parts 2010 (05/ 10 ) CP05N10A 1 15 V olts ...

  • Friedrich CP05N10A - page 2

    —2— CONTENTS 1. PREF A CE ............................................................................................................................... ....................2 1.1 FEA TURES .............................................................. ..................................................... ..................................2 1.2 ...

  • Friedrich CP05N10A - page 3

    1. PREF A CE This ser vice man ual provides v ar ious service information, including the mechanical and electrical par ts, etc. This room air conditioner was manuf actured and assembled under a strict quality control system. The refrigerant is charged at the factory . Be sure to read the saf ety precautions pr ior to servicing the unit. 1.1 FEA TUR ...

  • Friedrich CP05N10A - page 4

    —3— 1.3 LOCA TIONS OF CONTR OLS MONEY SAVER 2 The fan stops when the compressor stops cooling. • Approximately every 3 minutes the fan will turn on and sample the room air to determine if more cooling is needed. TEMPERATURE SETTING 1 • These buttons control the temperature of the room. The temperature can be set within a range of 60 ° F to ...

  • Friedrich CP05N10A - page 5

    —4— 2. DISASSEMBL Y INSTR UCTIONS 2.1 MECHANICAL P AR TS 2.1.1 FRONT GRILLE 1. Pull the inlet grille forw ard. 2. Remov e the screw securing the F ront Grille. (Fig. 3) 3. Push the grille up from the bottom and pull the top of the grille aw a y from the case to lift the top tabs out of their slots. (Fig. 4) 4. Carefully position the grille, bot ...

  • Friedrich CP05N10A - page 6

    —5— 2.2 AIR HANDLING P AR TS 2.2.1 AIR GUIDE UPPER 1. Disconnect the unit from the pow er source . 2. Remov e the front grille. (Refer to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Remov e the control panel. (Ref er to Section 2.1.3) 5. Remov e 2 screws that secure the upper air guide to air guide low er . (See Figure 6) ...

  • Friedrich CP05N10A - page 7

    —6— 2.2.3 MO T OR 1. Disconnect the unit from the pow er source . 2. Remov e the front grille. (Refer to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Remov e the control panel. (Ref er to Section 2.1.3) 5. Remov e the upper air guide. (Ref er to Section 2.2.1) 6. Remov e the compressor , turbo f an, fan and shroud. (Ref er ...

  • Friedrich CP05N10A - page 8

    —7— 2.3.2 COMPRESSOR 1. Remov e the front grille and cabinet. (Ref er to Section 2.1) 2. Discharge the refrigerant by using a refrigerant recov er y system. 3. Remov e the overload protector . (Ref er to Section 2.3.1) 4. After discharging the unit completely , unbrace the suction and discharge pipes at the compressor connections. 5. Remov e 3 ...

  • Friedrich CP05N10A - page 9

    —8— 2.3.6 PO WER CORD 1. Disconnect the unit from source of power . 2. Remov e the front grille. (Refer to Section 2.1.1) 3. Remov e the cabinet. (Refer to Section 2.1.2) 4. Remov e a screw that secures control panel to base pan. (Ref er to Section 2.1.3) 5. Pulls the control board tow ard you. 6. Disconnect the 2 receptacles and remov e the gr ...

  • Friedrich CP05N10A - page 10

    2.4.2 EV APORA T OR 1. Remov e the cabinet. 2. Discharge the refrigerant by using a refrigerant recov er y system. 3. Remov e the upper air guide . (Refer to Section 2.2.1) 4. After discharging the refrigerant completely , unbraze the interconnecting tube at the condenser connections. 5. Remov e the ev aporator . 6. Re-install by ref err ing to the ...

  • Friedrich CP05N10A - page 11

    —10— Equipment needed: V acuum pump, charging cylinder , manifold gauge, br azing equipment, pinch-off tool capable of making a vapor proof seal, leak detector , tubing cutter , hand tools to remove components and service valv e. B A B A B A COMPOUND GAUGE SEE INSETS BELOW CAPILLARY TUBE EVAPORATOR (LOW PRESSURE SIDE) COMPRESSOR CONDENSER (HIGH ...

  • Friedrich CP05N10A - page 12

    —11— 2.4.4 ELECTRICAL D A T A USE OF EXTENSION CORDS Because of potential saf ety hazards, w e strongly discourage the use of an e xtension cord. Howe ver , if you wish to use an e xtension cord, use a CSA cer tified/UL-listed 3-wire (grounding) extension cord, r ated 15A, 125V . Do not under any circumstances cut or remove the grounding prong ...

  • Friedrich CP05N10A - page 13

    —12— 3.2 PIPING SYSTEM F ollowing is a brief description of the impor tant components and their function in what is called the refr igeration system. Re f erence should be made to Figure 21 to f oll o w the ref r ige r ating cycle and the fl o w of the ref r ige r ant in the cooling cycle. COOLED AIR HOT DISCHARGED AIR MOTOR COMPRESSOR ROOM AIR ...

  • Friedrich CP05N10A - page 14

    —13— 3.3 TR OUBLESHOO TING GUIDE In general, possib le trouble is classified in tw o kinds. The one is called Starting Failure which is caused by an electrical def ect. The other is Ineffective Air Con- ditioning caused by a def ect in the refrigeration circuit and improper application. Unit is running but cooling is ineff ective . Ineffective ...

  • Friedrich CP05N10A - page 15

    —14— Fails to Start Improper ther mostat setting Loose ter minal connection Improper wiring Check voltage power source. Drop of power v oltage. Capacitor check. Replacement. Check control s witch setting. Compressor f ails to star t. Def ect of compressor or capacitor . Replacement of compressor (Motor damaged). Irregular motor insulation ( Ω ...

  • Friedrich CP05N10A - page 16

    COMPLAINT CA USE REMED Y F an motor will not run. No power Check v oltage at outlet. Correct if none. P ower supply cord Check v oltage to electronic control board. If none, check power supply cord. Replace cord if circuit is open. Wire disconnected or Connect wire. Ref er to wir ing diagram f or connection loose ter minal identification. Repair or ...

  • Friedrich CP05N10A - page 17

    —16— &203/$,17 &$ 86( 5(0(' < ) DQPRWRUQRLVH ) DQEODGH ,IFUDF NHGRXWRIEDODQFH RUSDU WLD OOPLVVLQJ UHSODFHLW %ORZHU wheel ,IFUDF NHGRXWRIEDODQFH RUSDU WLDOOPLVVLQJ UHSODFHLW /RRVHVHWVFUHZ 7LJKWHQLW : RUQ ...

  • Friedrich CP05N10A - page 18

    —17— COMPLAINT CA USE REMED Y Compressor cycles on F an motor If not running, deter mine the cause. Replace if ov er load. required. Condenser air flow Remov e the cabinet, inspect the inter ior surface restriction of the condenser . If restricted, clean carefully with a vacuum cleaner (do not damage fins) or brush. Clean the inter ior base bef ...

  • Friedrich CP05N10A - page 19

    —18— 4. CIRCUIT DIA GRAM (SMPS) 250V/T2A (250V/T3.15A) MEZ62420702 WH (BL) LOCATI ON PART NO Q'TY NO. CP05N10A PER SET 1 POW ER CORD ASSY 67300020 1 2F A N M O T O R 67400116 1 3 COMPRESSOR -1 4C A P A C I T O R -1 5 OVERLOAD PROT ECT OR 67301425 1 DESCRIPTION ...

  • Friedrich CP05N10A - page 20

    ² 19 ² (;3/2'('9,(: 352390-2   :      :    $  0    ...

  • Friedrich CP05N10A - page 21

    —2 0 — LocNo DESCRIPT ION CP05N10A 130410 Base Ass em bly,W eld 67302931 130910 Cabinet 67303719 135312 Grille As sem bly,Front 67306008 135303 Grille,Inlet 67306107 145200 Link 67304600 149980 Shroud 67305531 152302 Filter,Air 67400167 237200 Panel,Control 67305507 238310 Escutc heon 67500149 249950 Case Ass em bly ,Control 67305532 264110 Pow ...

  • Friedrich CP05N10A - page 22

    Post Office Box 1540 • 4200 N. Pan Am Expressway • San Antonio, Texas 78295-1540 • (210) 357-4400 • FAX (210) 357-4490 FRIEDRICH AIR CONDITIONING CO. Visit our web site at www.friedrich.com CP05 Svc Parts 2010 (05/ 10 ) Use F actor y Cer tified P ar ts... P/NO:MFL38735502 ...

メーカー Friedrich カテゴリー Air Conditioner

Friedrich CP05N10Aのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- CP05N10Aの取扱説明書
- Friedrichの製品カード
- パンフレット
- またはFriedrich CP05N10Aの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Friedrich CP05N10Aの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Friedrich CP05N10Aの取り付け説明書、サービスマニュアル、簡易説明書、またはFriedrich CP05N10Aのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Friedrich CP05N10Aの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Friedrich CP05N10Aデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがFriedrich CP05N10Aを使用するのを助ける技術的文書のことです。説明書は通常、全てのFriedrich CP05N10Aユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Friedrichの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Friedrich CP05N10Aの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははFriedrich CP05N10Aの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Friedrich CP05N10Aに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Friedrich CP05N10Aデバイスの基本機能を使うにあたってのヒント。 Friedrich CP05N10Aのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Friedrich CP05N10Aに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるFriedrich CP05N10Aのメーカー/サービスへの連絡先に関する情報。

Friedrich CP05N10Aについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもFriedrich CP05N10Aの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがFriedrich CP05N10Aで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)