Siemens 500の取扱説明書

35ページ 0.52 mb
ダウンロード

ページに移動 of 35

Summary
  • Siemens 500 - page 1

    ANIM-03522-0612 (New Issue) ©2012 Siemens Industr y, Inc. All rights reserved. Installation Operation Maintenance Horizontal – Medallion  500, 580, 880, SH400, SH450, SH560 Frames TEFC Enclosures Type CZ, NCZ, CGZ, 1LA4 Induction Motors/ Generators ...

  • Siemens 500 - page 2

    - 1 - Table of Contents Page Page TABLE OF CONTENTS 1 OPERATION 11 SAFETY PROCEDURES 2 Initial Start 11 INTRODUCTION 3 Oil Circulating Systems 11 Warranty 3 Normal Operation 11 Receiving 3 Voltage/Frequency Variation 11 Handling 4 Trouble Shooting 12 Temporary Storage 4 MAINTENANC E 14 Type Designations 4 Preventive Maintenance 14 INSTALLATION 5 In ...

  • Siemens 500 - page 3

    - 2 - Safety Procedures This equipment contains haza rdous voltages. Death, serious perso nal injury or property damage can resu lt if safety instructions are not followed. The successful and safe ope ration of motors and generators is depend ent upon proper handling, installation, operation and mainte nance, as well as upon proper design and manuf ...

  • Siemens 500 - page 4

    - 3 - Introduction DANGER Hazardous voltage. Will cause death, serious injur y, electrocution or propert y damage. Disconnect all power before working on this equipment. These instructions present general recommendations for installation, operation and m aintenance of induction motors built at the Norwo od plant. If additional information i s requi ...

  • Siemens 500 - page 5

    - 4 - Introduction WARNING Heavy equipment. Improper handling may cause death, seri ous injury or property damage. Check lifting devices before lifting. Use proper slings, chains and spreaders. Note any warning plates on motor and foll ow instructions on each plate. Handling Lifting devices are provided for handling only. An experienced rigger shou ...

  • Siemens 500 - page 6

    - 5 - Installation Motor Dimensions For motors built in the frame si zes covered by this manual, the letter dim ensions have the same definitions as established NEMA standards. Established dimensions for these frames may be found on catalog sheets or ce rtified dra wings. CAUTION Damp Location. Can cause propert y damage if equipment is oper ated i ...

  • Siemens 500 - page 7

    - 6 - Installation External Wiring DANGER Hazardous voltage. Will cause death, serious injur y, electrocution or propert y damage. Disconnect all power before working on this equipment. NOTE Before runnin g motor, see Initial Start. Starting and overload control devi ces must be matched to motor rating. For safety or convenience they may need to be ...

  • Siemens 500 - page 8

    - 7 - Installation Angular Alignment Hold each shaft at maximu m end float. Rotate both shafts together, and measure b etween matching points at the outside diameter of the coupli ng faces for the top, bottom and both sides. Use two indicat ors because of possible axial shaft movement. Read difference of variation between them. Align shafts so that ...

  • Siemens 500 - page 9

    - 8 - Installation Hot Alignment It is possible for the motor shaft height to change relative to the driven equipment and this should be compensated for during the alignme nt procedure. Heat from driven equipme nt can al so cause horizontal misalignment. WARNING Rotating parts. Can cause serious injury. Disconnect and lock out power before working ...

  • Siemens 500 - page 10

    - 9 - Installation Doweling Doweling the moto r (and driven unit) accomplis h es the following: 1. Restrict s movement. 2. Eases realignment if motor is removed from base. 3. Temporarily restrains the motor, shoul d mounting bolts loosen. Inserting Dowel Pins The following procedure is recomme nde d: a. Check the alignment after the unit has been i ...

  • Siemens 500 - page 11

    - 10 - Installation Typical Motor Control Settings Alarm Trip (Shutdown) Timer Trip Setting (1) Winding Temperature  Class B Insulation  Class F Insulation 130°C 155°C 155°C 170°C Motor Bearing Temperature (Thermocouple or RTD’s)  Sleeve Bearing 100°C 105°C  Antifriction Bearing 100°C 105°C Ground Fault 4 Amps (2) Primary Circ ...

  • Siemens 500 - page 12

    - 11 - Operation Initial Start CAUTION Do not exceed nu mb er o f Siemens specified hot and cold starts per hour. Will cause overheating. Allow time between starts to permit stator windings and rotor cage to cool. After installation is completed, but before motor is pu t in regular service, make an initial start as follows: 1. Check that motor, sta ...

  • Siemens 500 - page 13

    - 12 - Operation Trouble Shooting Between regular maintenance inspe ctions, be alert for signs of motor trouble. Comm on symptoms are listed in the following table. Correct any trouble immediately an d AVOID COSTLY REPAIR AND SHUT DOWN. TROUBLE POSSIBLE CAUSES CORRECTION Usually line trouble. Singl e phasing at starter. Check power source. DO NOT c ...

  • Siemens 500 - page 14

    - 13 - Operation Trouble Shooting TROUBLE POSSIBLE CAUSES CORRECTION Open stator windings. Disconnect motor from load. Check idle amps for balance in all three phases. Check stator resistance in all three phases for bala nce. Air Recirculation. Check air intake and exhaust for obstructions. Check air inlet temperature. Over voltage/under voltage. C ...

  • Siemens 500 - page 15

    - 14 - Maintenance Preventive Maintenance Motors are designed to give many years of reliable service with a minimum of attention. Trouble-free operation cannot be expected if p roper maintenance is postponed or negl ecte d. Provide proper maintenance on the equipm ent. Follow carefully the instructions containe d herein. Be certain personnel review ...

  • Siemens 500 - page 16

    - 15 - Maintenance Hazardous Location WARNING Explosion or fire. Can cause death, serious injur y or pr opert y damage. Do not modify or change any motor accessories, which are not suitable for the area classification. Any part replacements are accurate duplicates of the original to maintain the hazardous area classificati on. Consult manufacturer ...

  • Siemens 500 - page 17

    - 16 - Maintenance Temperature Electrical apparatus operatin g under normal conditions becomes quit e warm. Although som e places may feel hot to the tou ch, the unit may be within limits. If checking total temperature by winding resistance or imbedd ed detector (RTD), the total temperature should not exceed the follo wing: When operating at full l ...

  • Siemens 500 - page 18

    - 17 - Maintenance Rotor Cleaning Remove rotor. Inspect and clean. Stator Cleaning Micalastic™ form wound VPI (vacuum pressu re impregnated) insulated coils may be cleane d with solvent using lint free clot hs or steam cleaned with low-pressure steam, then the e ntire stator oven baked at 170 °F for 6 hou rs and then 245°F for 12 hours. The sta ...

  • Siemens 500 - page 19

    - 18 - Maintenance Electric Strip Heater Drying 1. Remove bearing housing s. 2. Remove rotor. 3. Direct a fan on stator to carry away the moisture. 4. Attach temperature i ndicators to winding and apply heat as specified in the Insulation Drying Temperature table and follo w procedures described for drying insulation. 5. Radiant type heaters are no ...

  • Siemens 500 - page 20

    - 19 - Maintenance Insulated Bearings One or both bearings m ay be insulated to prevent shaft currents from pitting bearing surfaces. The insulation is located at the joint between the bearing housing or bracket a nd the bearing. Insulat ed bearings are designated by an instruction plate on the bearing housing. Check periodically to be sure the ins ...

  • Siemens 500 - page 21

    - 20 - Maintenance At the first sign of oil discoloration or contamination, replace with new oil. Rapi d discoloration is caused by bearing wear, often from vibration or thrust. Chang e oil as required to keep cle an. When assembling the bea ring, it is possible to foul the rings so that they will not turn freely. Check ring operation by rotating s ...

  • Siemens 500 - page 22

    - 21 - Maintenance Sealing Parts Even though joints may seem to match perfectly, minute clearances exist through which oil may leak. Sealant should be ap plied to the mating surfaces of parts where oil is present to prevent seepage of oil. Sealant should be applied as follo ws: 1. Surfaces shall be clean of dirt, grease, and oil sealant. Use a non- ...

  • Siemens 500 - page 23

    - 22 - Maintenance Sleeve Bearings CAUTION Maintain proper oil lev el. Failure to do so may cause improper lubric ation of motor resulting in damage to the equipm ent. Follow lubrication instructions carefully. Avoid adding oil while unit is running. Motors with sleeve bearings are shipped without oil. A rust-inhibiting film is applied at the facto ...

  • Siemens 500 - page 24

    - 23 - Maintenance To Replace Antifriction Bearings 1. Remove bolts holding end caps to housi ngs. 2. Remove bolts holding bearing housin gs t o yoke. 3. Remove bearing housing s. 4. Remove the bearing with a puller. See Figure 6. 5. Check shaft and housing diameter for prop er size with micrometer. 6. Heat the new bearing in an oven (200°F). Whil ...

  • Siemens 500 - page 25

    - 24 - Maintenance Protect the shaft end with a cap. If bearing is reusable, make certain the puller applies pressure a ga inst the bearing inner race only. If puller will not hook the bearing inner race, fabricate a split bushing an d install it between the bearing and the puller h ooks. Figure 6. Removing Bearing with a Puller Sleeve Bearing When ...

  • Siemens 500 - page 26

    - 25 - Maintenance 11. Lubricate. Turn moto r by hand to be su re of proper fit and oil ring operation. 12. Start motor without load and check oil ring operation. Figure 8. Sleeve bearing construction with labyrinth-type oil seals-580 Frame. 880, SH400, SH450, and SH56 0 Frames (See Figure 9) 1. Chec k replacement bearings fo r nicks or shipping da ...

  • Siemens 500 - page 27

    - 26 - Spare Parts Identification All units have an identification nam eplate affixed to the frame (Figure 10 & 11). Al l the necessary information pertaining to the motor can be found on this plate including; 1. Serial Number 2. Type and Frame Size 3. Horsepower and Speed 4. Bearing Designations It is important when orderin g spare parts or di ...

  • Siemens 500 - page 28

    - 27 - Spare Parts Figure 11. Identification Plate – Hazardous L ocation Figure 12. Type CZ, 509 / 5011 / 5013 Frames Item Description Item Description Item Description 1 Stator Core 7 Ball Bearing 14 Inboard Seal 2 Stator Yoke 8 Shaft Seal 15 Oil Seal 3 Stator Coils 10 Grid Cover 16 Bearing Capsule 4 Bearing Housing 11 Rotor Core 17 Sleeve Beari ...

  • Siemens 500 - page 29

    - 28 - Spare Parts Item Description Item De scription 1 Stator Core 8 Shaft Seal 2 Stator Yoke 10 Grid Cover 3 Stator Coils 11 Rotor Core 4 Bearing Housing 12 External Fan (4 Pole or Slower) 5 Rotor Shaft 13 Fan Housi ng 6 Inner End Cap 14 Internal Fan 7 Ball Bearing 15 Rotor Air Duct Figure 15. Type CZ, 588 / 5810 / 5812 Frames Item Description 16 ...

  • Siemens 500 - page 30

    - 29 - Spare Parts Figure 16 . Sleeve Bearing Arrangement for Type CGZ 880, SH400, SH450, Type 1LA4 SH560 Frames Item Description 18 Oil Seal 19 Bearing Cap. Housing 20 Sleeve Bearing Bushing 21 Shims 22 Machine Seal 23 Oil Ring Item Description Item De scription 1 Stator Core 8 Shaft seal 2 Stator Yoke 10 Grid Cover 3 Stator Coils 11 Rotor Core 4 ...

  • Siemens 500 - page 31

    - 30 - Spare Parts Item Description Item Description 1 Stator Core 9 Outer End Cap 2 Stator Yoke 10 Grid Cover 3 Stator Coils 11 Rotor Core 4 Bearing Housing 5 Rotor Shaft 12 External Fan (Directional) 6 Inner End Cap 13 Fan Housing 7 Ball Bearing 14 Internal Fan 8 Shaft seal 15 Roller Bearing Figure. 20 . Type 1LA4, SH560 Frame ...

  • Siemens 500 - page 32

    - 31 - Motor Service Record Serial No ______________________ Horsepower ______________ Type ___________ Speed ________ Volts _____________ Amperes _____________ Hertz _______ Insulation Class _______ Temperature Rise _______  C Frame Size ____________ Owner Order No _________________ Item No _____ Date Of Manufacture _________ MACHINE TYPE BEARI ...

  • Siemens 500 - page 33

    - 32 - Vibration Analysis Sheet Pick-Up Filter-Out Coupled Filter-In Couple d Disp. Freq* Vel. Freq.* Vel. Freq . Vel. Freq. Vel. Freq. Vel. Freq. Point Pos ition Mils CPM In/Sec CPM Mils CPM Mils CPM Mils CPM Mils CPM Horizontal Vertical Axi al Horizontal Vertical Axi al Horizontal Vertical Axi al Horizontal Vertical Axi al Horizontal Vertical Axi ...

  • Siemens 500 - page 34

    - 33 - Notes ___________________ ______________ ___________________ __________________ __________________ __ ___________________ ______________ ___________________ __________________ __________________ __ ___________________ ______________ ___________________ __________________ __________________ __ ___________________ ______________ ______________ ...

  • Siemens 500 - page 35

    ANIM-03522-0612 (New Issue) ©2012 Siemens Industr y, Inc. All rights reserved. Siemens Industry Drive Technologies Divisio n Norwood Motor Plant 4620 Forest Avenue Norwood, OH 45212-3396 (513) 841-31 00 ...

メーカー Siemens カテゴリー Portable Generator

Siemens 500のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 500の取扱説明書
- Siemensの製品カード
- パンフレット
- またはSiemens 500の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Siemens 500の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Siemens 500の取り付け説明書、サービスマニュアル、簡易説明書、またはSiemens 500のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Siemens 500の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Siemens 500デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがSiemens 500を使用するのを助ける技術的文書のことです。説明書は通常、全てのSiemens 500ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Siemensの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Siemens 500の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははSiemens 500の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Siemens 500に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Siemens 500デバイスの基本機能を使うにあたってのヒント。 Siemens 500のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Siemens 500に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるSiemens 500のメーカー/サービスへの連絡先に関する情報。

Siemens 500についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもSiemens 500の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがSiemens 500で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)