LG Electronics 25kWの取扱説明書

60ページ 4.54 mb
ダウンロード

ページに移動 of 60

Summary
  • LG Electronics 25kW - page 1

    ST ANDBY GENERA T OR O WNER'S MANU AL This manual should remain with the unit. A ne w standar d of reliability Serial Number 1.6L 20/25/30 kW Models   N ot i nt ended for us e i n c r i t i c al l i f e s uppor t appl i c at i ons.  ONL Y QU ALIFIED ELECTRICIANS OR CONTRA CT ORS SHOULD A TTEMPT INST ALLA TION! DEADL Y EXHA UST FUMES. ...

  • LG Electronics 25kW - page 2

    Standby Generator Sets T able of Contents SECTION P AGE SAFETY RULES ................................................ 1-1 INTRODUCTION ..................................................... 1-3 Read this Manual Thoroughly ................................... 1-3 Operation and Maintenance ...................................... 1-3 How to Obtain Servic ...

  • LG Electronics 25kW - page 3

    Study these SAFETY RULES carefully before install- ing, operating or servicing this equipment. Become familiar with this Owner’s Manual and with the unit. The generator can operate safely , efficiently and reli- ably only if it is properly installed, operated and maintained. Many accidents are caused by failing to follow simple and fundamental ru ...

  • LG Electronics 25kW - page 4

    • Before performing any maintenance on the gen- erator , disconnect its battery cables to prevent accidental start -up. Disconnect the cable from the battery post indicated by a NEGA TIVE, NEG or (–) first. Reconnect that cable last. • Never use the generator or any of its parts as a step. Stepping on the unit can stress and break parts, and ...

  • LG Electronics 25kW - page 5

    1-3 I NTRODUCTION Thank you for purchasing this model of the standby generator set product line. Every effort was expended to make sure that the information and instructions in this manual were both accurate and current at the time the manual was written. However , the manufacturer reserves the right to change, alter or otherwise improve this produ ...

  • LG Electronics 25kW - page 6

    I DENTI F ICA TION REC ORD D A T A LA BE L Every generator set has a DA T A LABEL that contains important information pertinent to the generator . The data label, which can be found attached to the gen- erator’s lower connection box, lists the unit ’s serial number and its rated voltage, amps, wattage capacity , phase, frequency , rpm, power fa ...

  • LG Electronics 25kW - page 7

    E QUIPM ENT DE SCRI PTION This equipment is a revolving field, alternating cur - rent generator set. It is powered by a gaseous fueled engine operating at 1800 rpm for 4-pole direct drive units, 3600 rpm for 2-pole direct drive units and 2300 - 3000 rpm for quiet drive gear units. See the Specifications section for exact numbers. The unit comes com ...

  • LG Electronics 25kW - page 8

    ENGI N E P RO TECTIVE DEVICE S The standby generator may be required to operate for long periods of time without an operator on hand to monitor such engine conditions as coolant tempera- ture, oil pressure or rpm. F or that reason, the engine has several devices designed to protect it against potentially damaging conditions by automatically shuttin ...

  • LG Electronics 25kW - page 9

    F U E L SYST E M FUE L RE QUIRE MEN T S The standby generator may be equipped with one of the following fuel systems: • Natural gas fuel system • Propane vapor (PV) fuel system The Manual Drawing Listing that is affixed to the unit includes the “Identification Code,” which may be used to identify the type of fuel system installed on the uni ...

  • LG Electronics 25kW - page 10

    SP E CI F ICA TIONS GEN ERA T OR T ype ............................................................................. Synchronous Rotor Insulation .................................................................... Class F Stator Insulation ................................................................... Class F T otal Har monic Distor tion .... ...

  • LG Electronics 25kW - page 11

    COLD WEA THER KIT F or cold climates, optional cold weather kit (part number 0F6148) is recommended. The kit includes: • Battery W armer • 4” Junction Box with hardware • 6 qt. pack 5W -30 synthetic oil (engine) R E C ON FIGU R I NG TH E FU EL SY S TEM NOTE: All models are configured to run on natural gas from the factory . T o reconfigure ...

  • LG Electronics 25kW - page 12

    GEN ER A T OR AC LEAD C ONN ECTIONS See “V oltage Codes”. This generator may be rated at any one of three voltages, either single -phase or three -phase. The electrical wires in the unit ’s AC con- nection (lower) panel should be installed according to the number of leads and the voltage/phase required for the application. If there are any qu ...

  • LG Electronics 25kW - page 13

    I NS T ALLA TION Refer to the separate “Installation Guide” supplied with the unit. P R EP AR A TION B EFOR E ST ART -UP The instructions in this section assume that the standby generator has been properly installed, ser - viced, tested, adjusted and otherwise prepared for use by a competent, qualified installation contractor . Be sure to read ...

  • LG Electronics 25kW - page 14

    • Battery charger connection to 120 V AC. • Communication wires connected between transfer switch and generator (HTS only). • Unit secured to pad. S T ART -U P CH E CKLIS T  Before working on the generator , ensure the fol- lowing: • The AUTO/OFF/MANU AL switch is in the OFF position. • The 120V AC supply to the battery charger is swit ...

  • LG Electronics 25kW - page 15

    GEN ER A T OR CONTROL AND OP ER A TION Refer to the appropriate control panel operator’s manual for this unit. OP ER A TING U N IT WITH MAN UAL TR ANSF ER SWIT CH If the generator was installed in conjunction with a transfer switch capable of manual operation only , the following procedure applies. A manually operated transfer switch is one that ...

  • LG Electronics 25kW - page 16

    MAI NTENANCE P ER FOR M ED B Y SERVICE F ACI LITIES  Before working on the generator , ensure the fol- lowing: The AUTO/OFF/MANU AL switch is in the OFF position. The 15A fuse has been removed from the con- trol box. The 120V AC supply to the battery charger is switched OFF . EVER Y TH R EE MONTHS 1. Check battery condition. 2. Inspect and test ...

  • LG Electronics 25kW - page 17

    Figure 10.1 - Oil Dipstick and Oil Fill Cap ...

  • LG Electronics 25kW - page 18

    CHANGI NG ENGIN E OI L Refer to maintenance performed by service facilities for engine oil and filter change frequencies. Drain the oil while the engine is still warm from run- ning . This means warm up the engine, shut it down and drain immediately as follows: 1. Remove OIL DRAIN HOSE from its retaining clip. 2. Loosen and remove OIL DRAIN HOSE CA ...

  • LG Electronics 25kW - page 19

    M IS CELL AN E OUS MAI NTENANCE CLEAN ING TH E GEN ER A T OR Keep the generator as clean and as dry as possible. Dirt and moisture that accumulates on internal gen- erator windings have an adverse effect on insulation resistance. P eriodically clean generator exterior surfaces. A soft brush may be used to loosen caked on dirt. Use a vacuum system o ...

  • LG Electronics 25kW - page 20

    SERVICE S CH EDU LE The following is a recommended maintenance schedule for small standby and residential generator sets. The established intervals in the schedule are the maximum recommended when the unit is used in an average service application. They will need to be decreased (performed more frequently) if the unit is used in a severe applica- t ...

  • LG Electronics 25kW - page 21

    Maintenance Level 1 Level 2 Level 3 Level 4 T asks Recom- T ask Required T ask Required T ask T ask mended Comp . to be done Comp . to be done Comp . Required Comp . to be done (Date- 3 months/ (Date- Semi- (Date- to be done (Date- monthly Initials) Break-in Initials) annually Initials) Annually Initials) 10 Hrs. 30 Hrs. 50 Hrs. 100 Hrs. 1. Disable ...

  • LG Electronics 25kW - page 22

    Maintenance Level 1 Level 2 Level 3 Level 4 T asks Recom- T ask Required T ask Required T ask T ask mended Comp . to be done Comp . to be done Comp . Required Comp . to be done (Date- 3 months/ (Date- Semi- (Date- to be done (Date- monthly In itials) Break-in Initials) annually Initials) Annually Initials) 10 Hrs. 30 Hrs. 50 Hrs. 100 Hrs. 13. Initi ...

  • LG Electronics 25kW - page 23

    TROU B LE SHOO TI NG GU I DE P ROB LEM CAUSE C OR R E CTION Engine won’t crank. 1. 15 amp fuse blown. 1. Replace fuse. 2. Loose or corroded or defectiv e 2. Tighten, clean or replace battery cables. batter y cables as necessary . 3. Defectiv e star ter contactor . 3. Replace contactor.* 4. Defectiv e star ter motor . 4. Replace star ter motor.* 5 ...

  • LG Electronics 25kW - page 24

    ...

  • LG Electronics 25kW - page 25

    1 0G4827 1 ASSY RTR 104 KD1 HI EFF ( 18KW) 0 G2927 1 RTR-102-20.0AD1 CPL (2006) (20KW) 0 G2827 1 ASSY RTR 25KW 2P (2006) (25KW) 0G34 51C 1 RTR 102 30KD2 (20 06) CPL CHI ( 30KW) 2 0G0820A 1 HO USING BLOWE R LG PILOT 3 0G4452 1 BLOWER HOUSING SCREE N 4 020746 4 SCREW PPHM M5-0. 8 X 8 ZINC 5 049226 4 WASHER LOCK M5 6 051713 4 WASHER FLAT M5 7 022129 4 ...

  • LG Electronics 25kW - page 26

    ...

  • LG Electronics 25kW - page 27

    ...

  • LG Electronics 25kW - page 28

    ...

  • LG Electronics 25kW - page 29

    ...

  • LG Electronics 25kW - page 30

    ...

  • LG Electronics 25kW - page 31

    ...

  • LG Electronics 25kW - page 32

    ...

  • LG Electronics 25kW - page 33

    1 0G33 43 1 M OUNTING BASE 1 .6L 2007 C1 2 02748 2 2 WASHER S HAKEPROO F EXT 5/1 6 STL 3 07093 6 2 DAMPENE R VIBRATIO N 4 07093 6C 2 VIB. ISO. 7 0-75 DURO 5 03925 3 8 SCREW HH C M8-1.2 5 X 20 G8.8 6 02214 5 1 2 WASHER FL AT 5/16 ZINC 7 02212 9 1 2 WASHER LO CK M8-5/ 16 8 04577 1 4 NUT HEX M 8-1.25 G 8 YEL CHR 9 07195 6 4 WASHER FL AT M8 10 0517 30 ...

  • LG Electronics 25kW - page 34

    ...

  • LG Electronics 25kW - page 35

    1 0F3 408C 1 BATTERY T RAY, C1 & C2 2 0F3411 1 STRAP BATTERY RETAI NMENT 3 025507 1 WASHE R SHAKEPROOF EX T 7/16 STL 4 059980 1 SCREW HHC M10-1.5 X 25 G10.9 5 046526 1 WASHE R LOCK M10 6 077483 REF BATTERY 12VDC 75-AH 26 7 050331A REF BA TTERY POST COVER RED + 8 050331 REF BATTERY POST COVER BLK - 9 0 38805J 1 CA BLE BATTERY BLAC K #1 X 30.00 1 ...

  • LG Electronics 25kW - page 36

    ...

  • LG Electronics 25kW - page 37

    1 0G0207 R EF ENGINE GENERAC 1 .6L NG 2 0G0834 1 ENGINE PL ATE 1.6L 3 0G0820 R EF HOUSING BLOWER M ACHINED 1. 6L 4 0E 9747 1 S TARTER 12 VOLT 5 0G0839 2 ENGINE M OUNTING FOO T STAMPING 6 0G0781 1 EX HAUST MANIFOLD 1. 6L MACHINED 7 0G0722 1 INT AKE MANIFOLD MA CHINED 1.6L 8 0G4059 1 SHIELD 1 .6L EXHAUST HEAT 9 0G4604 1 DC ALTE RNATOR ADA PTER MACHI ...

  • LG Electronics 25kW - page 38

    ...

  • LG Electronics 25kW - page 39

    ...

  • LG Electronics 25kW - page 40

    ...

  • LG Electronics 25kW - page 41

    1 026812 2 ELBOW 90D 3/4 NPT 2 075580 1 FL ANGE FUEL I NLET 3 0G1397A 1 FU EL REG. REWO RK 1.6L 3600 '0 7 (3600RPM) 0 G1397B 1 FU EL REG. REWORK 1.6L 1800 '07 (1800RPM ) 4 039253 2 S CREW HHC M 8-1.25 X 20 G8.8 ...

  • LG Electronics 25kW - page 42

    ...

  • LG Electronics 25kW - page 43

    (1) 1 0G3337 1 R OOF 1.6L C1 (1) 2 0G3336 1 R EAR INTAKE W RAP 1.6L C1 (2) 3 077992 16 NUT HEX L OCK M6-1.0 SS NY INS (1) 4 0G3341 2 R IGHT SIDE DOO R 1.6L C1 (1) 5 0G3335 1 F RONT DISCHA RGE WRAP 1.6L C1 6 0F4 487A 1 ASSY ACCESS COVER 7 022127 1 NUT HEX 1/4-20 STEEL 8 022097 1 WASHE R LOCK M6-1/ 4 9 022473 1 WASHE R FLAT 1/4-M6 ZI NC 10 0C2454 16 ...

  • LG Electronics 25kW - page 44

    ...

  • LG Electronics 25kW - page 45

    ...

  • LG Electronics 25kW - page 46

    ...

  • LG Electronics 25kW - page 47

    ...

  • LG Electronics 25kW - page 48

    ...

  • LG Electronics 25kW - page 49

    ...

  • LG Electronics 25kW - page 50

    ...

  • LG Electronics 25kW - page 51

    ...

  • LG Electronics 25kW - page 52

    ...

  • LG Electronics 25kW - page 53

    ...

  • LG Electronics 25kW - page 54

    ...

  • LG Electronics 25kW - page 55

    ...

  • LG Electronics 25kW - page 56

    ...

  • LG Electronics 25kW - page 57

    Standby Generator Sets Notes ...

  • LG Electronics 25kW - page 58

    ...

  • LG Electronics 25kW - page 59

    ...

  • LG Electronics 25kW - page 60

    BackPg001 Re v . A 04/07 ...

メーカー LG Electronics カテゴリー Portable Generator

LG Electronics 25kWのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 25kWの取扱説明書
- LG Electronicsの製品カード
- パンフレット
- またはLG Electronics 25kWの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、LG Electronics 25kWの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、LG Electronics 25kWの取り付け説明書、サービスマニュアル、簡易説明書、またはLG Electronics 25kWのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、LG Electronics 25kWの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

LG Electronics 25kWデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがLG Electronics 25kWを使用するのを助ける技術的文書のことです。説明書は通常、全てのLG Electronics 25kWユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

LG Electronicsの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. LG Electronics 25kWの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははLG Electronics 25kWの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。LG Electronics 25kWに関してこのドキュメントで見つけることができる全てのヒントの目次
3. LG Electronics 25kWデバイスの基本機能を使うにあたってのヒント。 LG Electronics 25kWのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。LG Electronics 25kWに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるLG Electronics 25kWのメーカー/サービスへの連絡先に関する情報。

LG Electronics 25kWについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもLG Electronics 25kWの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがLG Electronics 25kWで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)