Fisher 655Rの取扱説明書

16ページ 0.18 mb
ダウンロード

ページに移動 of 16

Summary
  • Fisher 655R - page 1

    www.Fisher.com D100305X012 Type 6 55 a nd 6 55R A ctuators for S elf-Operated C ontrol Contents Introduction 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Scope of Manual 1 . . . . . . . . . . . . . . . . . . . . . . . . . Description 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Specifications 2 . . . . . . . . . ...

  • Fisher 655R - page 2

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 2 Table 1. Specifications Actuator Sizes and Maximum Casing Pressures ACTUATOR MAXIMUM CASING PRESSURE ACTUATOR SIZE Bar Psig 3A, 4A 17.2 250 3B, 4B 12.1 175 32, 42 6.9 100 33, 43 4.5 65 34, 44 3.1 45 35, 45 2.1 30 36, 46 1.0 15 Actuator Pressure Setting Ranges See table 2 Actuator Yoke ...

  • Fisher 655R - page 3

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 3 CAUTION To avoid premature wear of the diaphragm due to debris in the pressure line to the diaphragm, install a strainer in the pipeline ahead of the regulator or relief valve. Before installing the actuator, inspect it for any damage. Also, keep any adjacent piping clean and free of p ...

  • Fisher 655R - page 4

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 4 T able 2. Actuator Pressure-Setting Ranges (1) ACTUA- TOR SPRING PART PRESSURE REDUCTION PRESSURE RELIEF ACTUA- TOR SPRING PART PRESSURE REDUCTION PRESSURE RELIEF TOR SIZE SPRING PART NUMBER Minimum Maximum Minimum Maximum TOR SIZE SPRING PART NUMBER Minimum Maximum Minimum Maximum SIZ ...

  • Fisher 655R - page 5

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 5 T able 3. Effective Diaphragm Area (1) ACTUA- TRAVEL DOWN FROM UPPER CASING STOP, mm (IN.) ACTUA - TOR 0 3 (0.125) 5 (0.1875) 6 (0.25) 10 (0.375) 11 (0.4375) 13 (0.5) 14 (0.5625) 19 (0.75) 22 (0.875) TOR SIZE Cm 2 In. 2 Cm 2 In. 2 Cm 2 In. 2 Cm 2 In. 2 Cm 2 In. 2 Cm 2 In. 2 Cm 2 In. 2 ...

  • Fisher 655R - page 6

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 6 f. Stroke the actuator, and measure the stem movement to check travel. If the movement is more than full travel, turn the valve stem out of the actuator stem the amount of over-travel. If movement is less than full travel, turn the valve stem into the actuator stem the amount of under- ...

  • Fisher 655R - page 7

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 7 4. Slowly open the upstream shutoff valve. Startup For Pressure-Relief Service 1. Open the needle valve in the control line. 2. Open the downstream shutoff valve. 3. Slowly open the upstream shutoff valve. 4. Close the valve in the bypass line. Adjustment For Pressure-Reducing or Press ...

  • Fisher 655R - page 8

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 8 pressurized, even when the valve has been removed from the pipeline. Process fluids may spray out under pressure when removing the packing hardware or packing rings, or when loosening the packing box pipe plug. D Check with your process or safety engineer for any additional measures th ...

  • Fisher 655R - page 9

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 9 diaphragm casing (key 5). Some Type 655R actuators will have travel stops (key 13, not shown) in place of three of these six cap screws. 9. If a top-mounted handwheel assembly is used, refer to steps 4 through 8 of the Disassembly portion of the Top-Mounted Handwheel section. Assembly ...

  • Fisher 655R - page 10

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 10 16. To start up and adjust the actuator, follow the procedures outlined in the Startup section of this instruction manual. Top-Mounted Handwheel Top-mounted handwheel assemblies (figures 5, 6 and 7) are normally used as adjustable travel stops to limit full upward travel of the actuat ...

  • Fisher 655R - page 11

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 11 tightened to the proper load to prevent leakage, but not crush the material. Perform the following tightening sequence with a manual torque wrench. CAUTION Over-tightening the diaphragm cap screws (key 19) can damage the diaphragm. Do not exceed 27 N S m (20 lbf S ft) torque. Note Do ...

  • Fisher 655R - page 12

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 12 Parts Ordering When corresponding with your Emerson Process Management sales office about this equipment, refer to the serial number found on the actuator nameplate (key 17, figure 4). Also, specify the complete 11-character part number from the following parts list when ordering repl ...

  • Fisher 655R - page 13

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 13 Figure 4. Type 655 Actuator 30A8341-A/DOC 30A8342-A/DOC SIZE 3A AND 4A ACTUA TOR DIAPHRAGM CASINGS A APPL Y MOL Y-GREASE LUBRICANT TO ADJUSTING SCREW Key Description Part Number 9 Lower Spring Seat 10 Adjusting Screw 11 Travel Indicator Disk 12 Hex Nut 13 Travel Stop 14 Screw 15 Trave ...

  • Fisher 655R - page 14

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 14 Figure 6. Size 3B and 4B Top-Mounted Handwheel Assembly 38A1217-B/DOC APPL Y LUB P ARTS NOT SHOWN : 30 & 31 Key 6 Spring, steel COLOR CODE SPRING RATE SAFE LOAD COLOR CODE N/mm Lb/in. N Lb Aluminum & red 22 123 1290 290 Aluminum & dark green 43 246 2420 545 Dark green 64 3 ...

  • Fisher 655R - page 15

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 15 ...

  • Fisher 655R - page 16

    655 and 655R Actuators Instruction Manual Form 1292 July 2007 16 Emerson Process Management Marshalltown, Iowa 50158 USA Cernay 68700 France Sao Paulo 05424 Brazil Singapore 128461 www.Fisher.com The contents of this publication are presented for informational purposes only, and while every effort has been made to ensure their accuracy, they are no ...

メーカー Fisher カテゴリー Automobile Parts

Fisher 655Rのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 655Rの取扱説明書
- Fisherの製品カード
- パンフレット
- またはFisher 655Rの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Fisher 655Rの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Fisher 655Rの取り付け説明書、サービスマニュアル、簡易説明書、またはFisher 655Rのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Fisher 655Rの製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Fisher 655Rデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがFisher 655Rを使用するのを助ける技術的文書のことです。説明書は通常、全てのFisher 655Rユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Fisherの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Fisher 655Rの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははFisher 655Rの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Fisher 655Rに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Fisher 655Rデバイスの基本機能を使うにあたってのヒント。 Fisher 655Rのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Fisher 655Rに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるFisher 655Rのメーカー/サービスへの連絡先に関する情報。

Fisher 655Rについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもFisher 655Rの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがFisher 655Rで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)