Weil-McLain 88の取扱説明書

40ページ 1.76 mb
ダウンロード

ページに移動 of 40

Summary
  • Weil-McLain 88 - page 1

    P art No . 550-100-068/0308 fo r use w i th Ga s, Li gh t O il, & Ga s / Lig h t Oi l – Fir ed Bu rn er s This man ual must only be used by a qualified heating installer/ser vice technician. Read all instructions before installing. Follo w al l in- structions in proper orde r . Fail ure to comply could result in se ver e p ersonal injur y , ...

  • Weil-McLain 88 - page 2

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 2 P art No . 550-100-068/0308 Hazard Definitions The following defined terms are used throughout this manual to bring attention to the pr esence of hazards of various risk levels, o r to important information c oncern- ing the life of t ...

  • Weil-McLain 88 - page 3

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 3 P art No . 550-100-068/0308                        4 ? ...

  • Weil-McLain 88 - page 4

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 4 P art No . 550-100-068/0308 Installation must comply with — State, pr ovincial and lo cal plumbing, heating and electr ical 1 . codes. Regulations of ser vicing utilities. 2. ASME Section IV , L ow Pr essure Boiler and P ressur e V es ...

  • Weil-McLain 88 - page 5

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 5 P art No . 550-100-068/0308 Before installing boiler (continued) Combustion and ventilation air openings A dequate combustion and ventilation air must be pro vided to assure pr oper c ombustion and p revent possibility of ue gas leakage and carbon mono xide emissions, causi ...

  • Weil-McLain 88 - page 6

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 6 P art No . 550-100-068/0308 freely co mmunicate with the outdoors, as follows: W here directly co mmunicating with the outdoors or where • communicating to the outdoors through vertical ducts, ea ch opening shall hav e a minimum fr ...

  • Weil-McLain 88 - page 7

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 7 P art No . 550-100-068/0308 Set boiler in place Section assemb ly lifting weights         (pounds) ? ...

  • Weil-McLain 88 - page 8

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 8 P art No . 550-100-068/0308 Assembling the block Sections are top heavy . U nbolted sect ions may fall if not suppor ted, resulting in se ver e personal injur y or death. Prepar e and position back section Apply 1. 1 / 8 " contin u ...

  • Weil-McLain 88 - page 9

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 9 P art No . 550-100-068/0308 Sections are top heavy . U nbolted sect ions may fall if not suppor ted, resulting in se ver e personal injur y or death. Install intermediate sections Re move and discar d 1. 3 / 8 " diameter shipping tie rods. Re move grit from port machined ...

  • Weil-McLain 88 - page 10

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 10 P art No . 550-100-068/0308 Assembling the block (continued) Section arr angement    W = water S = steam     ...

  • Weil-McLain 88 - page 11

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 11 P art No . 550-100-068/0308 P erform hydrostatic pressure test Prepar e boiler and test: See 1. Figure 10 and Figure 11 f or tapping locations. Install: Boiler drain (not furnished). a. W ater pressure g auge — for test only . Be sure gauge can handle b. test press ure — ...

  • Weil-McLain 88 - page 12

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 12 P art No . 550-100-068/0308 Inser t HXT -bars through cleanout openings as shown below (omit the bottom, b lue-tipped, HXT -bar in the opening  between the front section and the first intermediate section) C ...

  • Weil-McLain 88 - page 13

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 13 P art No . 550-100-068/0308 Cleanout plate assembly  Complete block assembly (continued) Th e b oi le r co nt ai ns cer a mi c fi be r a nd fiberglass materials. U se care when han- dling these mat erials per instructions on page 34 of this manual ...

  • Weil-McLain 88 - page 14

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 14 P art No . 550-100-068/0308 Connect water boiler piping General water piping information Syst em water supply and return piping should b e installe d and 1. piping connecti ons attached to boiler before erecting jacket or installing co ...

  • Weil-McLain 88 - page 15

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 15 P art No . 550-100-068/0308 Connect water boiler piping (continued) Recommended minimum pipe sizes when flo w rate is  not known (see Figure 14, page page 14) (note 1)    ...

  • Weil-McLain 88 - page 16

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 16 P art No . 550-100-068/0308 Connect steam boiler piping General steam piping information: Hartford loop piping arrangement and wet return ar e requir ed for 1. steam boilers. Use the Hartford loop for both pumped-return and gravit y-re ...

  • Weil-McLain 88 - page 17

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 17 P art No . 550-100-068/0308 Connect steam boiler piping (continued) Model 488 through 688 steam (1 riser)  Model 788 through 1188 steam (2 risers required)  Imp rop e rl y pi pe d s ys tem s or u nd er si ze d pi p in g c ...

  • Weil-McLain 88 - page 18

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 18 P art No . 550-100-068/0308 Connect steam boiler piping (continued) Model 1288 through 1888 steam (3 or 4 risers required)  Drawing legend & notes (Figure 23 through Figure 26) Riser pipes (one for each s ...

  • Weil-McLain 88 - page 19

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 19 P art No . 550-100-068/0308 Multiple Steam Boiler Piping Gra vity Condensate Retur n  Connect steam boiler piping (continued) Pipe as shown for gravit y r eturn systems, connect- A ing point A to the wet gravity return. Fo r pumpe d-re turn sys tem ...

  • Weil-McLain 88 - page 20

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 20 P art No . 550-100-068/0308 Install jack et Before installing jacket The boiler contains ceramic fiber and fiberglass materials. U se care when hand ling these materials per instructions on page 34 of this manual. Fail ure to co mply ...

  • Weil-McLain 88 - page 21

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 21 P art No . 550-100-068/0308 Installing jack et suppor t brack ets, support channels and cor ners  (piping and other components omitted for clarity) Install jack et (continued) ...

  • Weil-McLain 88 - page 22

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 22 P art No . 550-100-068/0308 Installing (removing) jac ket front, rear  and side panels Press jack et trim down ov er jack et front,  rear and side panels Install jack et (continued) ...

  • Weil-McLain 88 - page 23

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 23 P art No . 550-100-068/0308 Jac ket side panel placement  Install jack et (continued) ...

  • Weil-McLain 88 - page 24

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 24 P art No . 550-100-068/0308 Jac ket top panel placement  Install jack et (continued) ...

  • Weil-McLain 88 - page 25

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 25 P art No . 550-100-068/0308  Cons umer Pr oduct Saf ety Comm issio n and som e states recommend domestic hot water tempera- ture of 130°F or less. When installing an automatic mixing valve, se- lection and installat ...

  • Weil-McLain 88 - page 26

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 26 P art No . 550-100-068/0308 Install water boiler controls Install controls: Install furnished controls per 1. Figure 36 and Figure 37. Failur e to properly install, pipe and wire boiler controls can result in severe damage to boiler , ...

  • Weil-McLain 88 - page 27

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 27 P art No . 550-100-068/0308 Install steam boiler controls Install controls: Install contr ols where shown in 1. Figure 38 and Figure 39. Failur e to properly install, pipe and wire boile r contr ols can result in severe damage to boiler , building and per- sonnel; and is not ...

  • Weil-McLain 88 - page 28

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 28 P art No . 550-100-068/0308 Install steam boiler controls (continued) Steam control siphon and fittings  Float-type water le v el control locations  ? ...

  • Weil-McLain 88 - page 29

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 29 P art No . 550-100-068/0308 Connect breeching and venting systems General venting information M odel 88 boilers operate w ith positive overfire pressure. Adj ust 1. damper assembly (see Figure 49, page 33) during burner start-up to achieve 0.1" W .C. positiv e pressur e ...

  • Weil-McLain 88 - page 30

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 30 P art No . 550-100-068/0308 Connect breeching and venting systems Stub vent – f orced draft — single boiler  Conv entional chimney – balanced dr aft  with barometr ic draft co ...

  • Weil-McLain 88 - page 31

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 31 P art No . 550-100-068/0308 Install burner & wiring and fill system T o install bur ner U npack burner . 1. Place gasket around air tube and against burner mounting ange. 2. If sealing rope is used, apply 1 / 8 " co ntinuous bead of rope adhesive around burner mo ...

  • Weil-McLain 88 - page 32

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 32 P art No . 550-100-068/0308 Install fuel piping Gas piping In sizing the gas piping , the following fac tors should be consid- 1. ered: Diameter and length of the gas supply piping . a. N umber of fittings. b. Maximum gas consumption ...

  • Weil-McLain 88 - page 33

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 33 P art No . 550-100-068/0308 Mak e final adjustments Flue collar/damper assembly  Adjust burner and damper assembly: Lock ue damper OPEN ( 1. Figure 49). Mak e final burner adjustments using combustion test equipme nt to assure pr oper operation ...

  • Weil-McLain 88 - page 34

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 34 P art No . 550-100-068/0308 Handling ceramic fiber and fiberglass materials REMOV AL OF FRONT PLA TE OR CLEANOUT PLA TE MA TERIALS The burner fr ont plate and cleanou t plate gask ets contain ceramic fiber mate rials. Ceramic fiber ...

  • Weil-McLain 88 - page 35

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 35 P art No . 550-100-068/0308 Ratings Boiler model number I=B=R burner capacity Gross I=B=R output Net I=B=R ratings Boiler H.P . Combustion efficiency Thermal efficiency Net firebox volume Flue gas volume P ositive pressure in firebox Flue outlet diameter Boiler water cont ...

  • Weil-McLain 88 - page 36

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 36 P art No . 550-100-068/0308 Dimensions Dimensions (inches) Model A B C D E L W H 488 23 — — 10 54 ¾ 34 ¾ 30 23 C, 588 31 — — 10 54 ¾ 42 ¾ 38 31 C, 688 39 — — 10 54 ¾ 50 ¾ 46 39 C, 788 47 — — 12 53 ¾ 58 ¾ 54 4 ...

  • Weil-McLain 88 - page 37

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 37 P art No . 550-100-068/0308 Dimensions (continued) Dimensions (see lettered dimensions on opposite page)  ...

  • Weil-McLain 88 - page 38

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 38 P art No . 550-100-068/0308 P arts Item Description Part number 1 F ront sections (8823) 316-301-210 2 Regular intermediate section (8825) 316-301-212 3 T ankless intermediate section (8826) 316-301-214 4 Back section (8828) 316-301-21 ...

  • Weil-McLain 88 - page 39

    Boiler manual: • Installation • Start-Up • Maintenance • Parts 39 P art No . 550-100-068/0308 P arts (continued) P ar ts  ...

  • Weil-McLain 88 - page 40

    W eil-McLain 88 W ater and steam boilers — Series 2 — for Gas, Light Oil, & Gas/Light Oil-Fired Burners 40 P art No . 550-100-068/0308 W arranty R esi d e nt i a l & Co mme rcia l C a st Ir on B o il er s  R e sid e ntial W a te r W a rran ty — Lim ite d L i fe tim e  R e sid e nt ia l S t e am W a rr ant y — Li m ite d 10 Y e ...

メーカー Weil-McLain カテゴリー Boiler

Weil-McLain 88のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 88の取扱説明書
- Weil-McLainの製品カード
- パンフレット
- またはWeil-McLain 88の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Weil-McLain 88の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Weil-McLain 88の取り付け説明書、サービスマニュアル、簡易説明書、またはWeil-McLain 88のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Weil-McLain 88の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Weil-McLain 88デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWeil-McLain 88を使用するのを助ける技術的文書のことです。説明書は通常、全てのWeil-McLain 88ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Weil-McLainの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Weil-McLain 88の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWeil-McLain 88の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Weil-McLain 88に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Weil-McLain 88デバイスの基本機能を使うにあたってのヒント。 Weil-McLain 88のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Weil-McLain 88に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWeil-McLain 88のメーカー/サービスへの連絡先に関する情報。

Weil-McLain 88についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもWeil-McLain 88の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWeil-McLain 88で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)