日本語 dropdown-ico

Henny Penny BFR/BCR-350の取扱説明書

39ページ 0.63 mb
ダウンロード

ページに移動 of 39

Summary
  • Henny Penny BFR/BCR-350 - page 1

    ...

  • Henny Penny BFR/BCR-350 - page 2

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 Henny Penny Blast Chiller/Fr eezer BFR/BCR-350 BCC/BCR-175 BCC/BCR-140 ...

  • Henny Penny BFR/BCR-350 - page 3

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 LIMITED W ARRANTY FOR HENNY PENNY APPLIANCES Subject to the following conditions, Henny Penny Corporation makes the following limited warranties to the original purchaser only for Henny Penny appliances and replacement parts: NEW EQUIPMENT : Any part of a new appliance, except lamps and fuses, ...

  • Henny Penny BFR/BCR-350 - page 4

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 T ABLE OF CONTENTS Section Page Section 1. INTRODUCTION ................................................................................................................... 1- 1 1-1. Henny Penny Blast Chiller ...................................................................................... ...

  • Henny Penny BFR/BCR-350 - page 5

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 201 1-1 SECTION 1. INTRODUCTION 1-1. BLAST CHILLER/ The Henny Penny Blast Chiller are designed to carry out fast refrigeration of food products. The units are electronically con- trolled for easy use and for consistent operation. The BCC/BCR-140, will chill up to 140 lbs (65 kg) of product, th ...

  • Henny Penny BFR/BCR-350 - page 6

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 1-5. SAFETY The Henny Penny Blast Chiller has may safety features incorpo- rated. However , the only way to ensure a safe operation is to fully understand the proper installation, operation, and maintenance procedures. The instructions in this manual have been prepared to aid you in learning t ...

  • Henny Penny BFR/BCR-350 - page 7

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 SECTION 2. INST ALLA TION 2-1. INTRODUCTION This section provides the installation for the Henny Penny Blast Chiller . NOTE Installation of this unit should be performed only by a qualified service technician. Do not puncture the skin of the Blast Chiller with drills or screws, as component da ...

  • Henny Penny BFR/BCR-350 - page 8

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 (Continued) 2-2 201 2-2. UNP ACKING 4. Open door and remove packing from the inside of the unit. 5. Peel off any protective covering from the exterior of the cabinet. 6. Y our Blast Chiller is now ready for operation. If the blast chiller has been laid on its side, the unit must be sitting upr ...

  • Henny Penny BFR/BCR-350 - page 9

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 201 2-3 2-3. ELECTRICAL Refer to the table below for electrical ratings for both models. (Continued) Model No. V olts W atts Amps Freq. Phase BCC-140 200 4700 18 50/60 3 208-240 4700 18 60 3 230 4700 20 50 1 BCC-175 200 5800 20 50/60 3 208-240 5800 20 60 3 400 5800 9 50 3 N BCR-140 208-240 240 ...

  • Henny Penny BFR/BCR-350 - page 10

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 2-5. REFRIGERANT INFORMA TION Design Pressure Refrigerant T ype Amount of Refrig. High Low BCC-140 R404A 6 lbs. (2.7 kg) 406 psig 102psig (28 bar) (7 bar) BCC-175 R404A 5.5 lbs. (2.4 kg) 406 psig 102 psig (28 bar) (7 bar) 2-6. REFRIGERA TION BCC/BCR-140 CAP ACITIES -4 o F (-20 o C) at 6,800 BT ...

  • Henny Penny BFR/BCR-350 - page 11

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 SECTION 3. OPERA TION 3-1. INTRODUCTION This section provides operating procedures for the Blast Chiller . Sections 1, 2, and 3 should be read, and all instructions should be followed before operating the cabinet. This section contains an explanation of all controls and compo- nents and inform ...

  • Henny Penny BFR/BCR-350 - page 12

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-2. OPERA TING CONTROLS (Continued) Fig. Item Description Function No. No. 3 - 1 7 Select Button The Select button is used to choose between a timing cycle or a cycle using the food probe. 3 - 1 8 Fan LED The Fan LED is a green light which illuminates when the fan is running. 3 - 1 9 Compress ...

  • Henny Penny BFR/BCR-350 - page 13

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-3 100 ...

  • Henny Penny BFR/BCR-350 - page 14

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-3. BASIC OPERA TION The Henny Penny Blast Chillers can chill food products with a core temperature of 149ºF (65ºC), down to 40ºF (4ºC) within 4 hours (room ambiant temperature may impact time it takes to reach the desired temperature). But, for the above statements to be accurate, the fo ...

  • Henny Penny BFR/BCR-350 - page 15

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-3. BASIC OPERA TION 5. Press the Select button to choose the food probe mode or the timing mode. With the Frigiprobe mode selected, the digital display will alternately show the core temperature of the product, and the elapsed time of the cycle. If the timing mode is selected, the digital di ...

  • Henny Penny BFR/BCR-350 - page 16

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-3. BASIC OPERA TION A temperature conversion chart is provided for your (Continued) convenience: 200 3-6 ...

  • Henny Penny BFR/BCR-350 - page 17

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-4. DE-ICING Henny Penny recommends to perform the de-icing process after every 3 cycles, and at the end of each day . This will eliminate any ice that may have formed around the evaporator during the chilling cycle. Failure the follow this procedure will increase the time it takes to cool th ...

  • Henny Penny BFR/BCR-350 - page 18

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-5. CLEANING Daily: 1 . Remove all electrical power supplied to the unit by turning off the wall circuit breaker . 2 . Remove all product from the unit. 3. Remove the racks and pans from the unit and clean with soap and water at a sink. 4. Clean all surfaces with a soft cloth, soap and water ...

  • Henny Penny BFR/BCR-350 - page 19

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-5. CLEANING (Continued) 3. Use a vacuum cleaner , or soft brush to remove the dust, or other obstructions from the condenser . 4 . Finish cleaning with compressed air if possible. DO NOT use a wire brush to clean the condenser , or damage to the condenser could result. 5. Replace the front p ...

  • Henny Penny BFR/BCR-350 - page 20

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-7. PROGRAMMING Information about the operation settings can be accessed by pressing the Alarm button. These settings can also be changed while in the different steps. The following information can be accessed: NOTE After pressing the Alarm button, a delay will occur before the desired number ...

  • Henny Penny BFR/BCR-350 - page 21

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-7. PROGRAMMING The holding temperature can be changed at this time by (Continued) using the Up and Down buttons. Factory setting for air temperature is 37ºF (3ºC). The minimum temperature setting is 32ºF (0ºC), and the maximum temperature is 50ºF (10ºC). 06 7. Maximum duration of de-ic ...

  • Henny Penny BFR/BCR-350 - page 22

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-7. PROGRAMMING 1 1. The duration of time the temperatures, (in 9 and 10 (Continued) above), must remain at before the alarms will sound. Press the Alarm button 1 1 times and the digital display will 10 show the time at which the high and low temperatures (no. 9 and 10 above) must remain at, ...

  • Henny Penny BFR/BCR-350 - page 23

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-7. PROGRAMMING 14. Blast chilling, low side air temperature limit, when using the Frigiprobe, in step 12 of this section. Press the Alarm button 14 times and the low side air temperature, at which 20 the compressor cycles on and off, will show in the display . This temperature is used in pre ...

  • Henny Penny BFR/BCR-350 - page 24

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 3-7. PROGRAMMING 17. Frigiprobe temperature for when the buzzer sounds at (Continued) the start of a cycle. Press the Alarm button 17 times, and the temperature that the buzzer will sound when the product 23 has reached the “danger zone” temperature, and must be cooled to a “safe” temp ...

  • Henny Penny BFR/BCR-350 - page 25

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 SECTION 4. TROUBLESHOOTING 4 - 1. INTRODUCTIO N This section provides troubleshooting information in the form of an easy to read table. If a problem occurs during the first operation of a new cabinet, recheck the installation per section 2 of this manual. Before troubleshooting always recheck ...

  • Henny Penny BFR/BCR-350 - page 26

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 4-2. TROUBLESHOOTING (Continued) Display Cause Correction AL-5 T emperature too low in the hold mode. Faulty control board - replace control board. Faulty contactor - replace contactor . AL-6 T emperature too high in the hold mode. Faulty control board - Replace board. Door opened too much - M ...

  • Henny Penny BFR/BCR-350 - page 27

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 4-2. TROUBLESHOOTING (Continued) Problem Cause C or re c ti o n Slow to decrease Condenser obstructed by dirt. Clean the Condenser . in temperature (decline in performance) Evaporator iced up. Perform a de-icing cycle. Refrigerating problem Check refrigeration circuit and components. Display t ...

  • Henny Penny BFR/BCR-350 - page 28

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 4-2. TROUBLESHOOTING (Continued) Problem Cause C or re c ti o n Green compressor indicator V oltage across terminals 10-1 1 light off and compressor of control board: i s wo rk in g . - Control board relay bad Replace control board. No voltage across terminals 10-1 1 of control board: - Faulty ...

  • Henny Penny BFR/BCR-350 - page 29

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 4-5 100 ...

  • Henny Penny BFR/BCR-350 - page 30

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 201 5-1 ...

  • Henny Penny BFR/BCR-350 - page 31

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 5-2 201 ...

  • Henny Penny BFR/BCR-350 - page 32

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 201 5-3 ...

  • Henny Penny BFR/BCR-350 - page 33

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 Quantity BFR/ Item BCC BC R BCC B C R B C R No . Part No. Description 14 0 14 0 17 5 1 75 3 50 1 9504.0205 Control PC Boar d 11111 2 9503.3692 Display PC Board 11111 3 9503.3700 Auxiliary Display Board 11111 4 9503.375 9 Connecting Cabl e 11111 5 9503.7719 Communication Board 11111 6 9503.8436 ...

  • Henny Penny BFR/BCR-350 - page 34

    Henny Penny Model BCC/BCR-140, BCC/BCR-175, BFR/BCR-350 Quantity BFR/ Item Part BC C B C R B C C B C R B C R N o . No . Description 14 0 14 0 17 5 17 5 35 0 31 9500.8967 Nozzle-Expansion V alve BFR-350 ---- 2 32 9500.7993 W ater Pressure V alve - BCC-175 - - 1 - - 33 9503.6182 High Pressure Switch - BCC-140 1 ---- 34 9502.5045 Liquid Receiver - BCC ...

  • Henny Penny BFR/BCR-350 - page 35

    ...

  • Henny Penny BFR/BCR-350 - page 36

    1. General Services 100 Hicks Ave. Medford, MA 02155 (800) 233-1033 2. Art Cole Associates Golden Street Industrial Park Meriden, CT 06450 (203) 237-7177 3. Globe-Monte Metro, Inc. 47-02 Metropolitan Avenue Ridgewood, NY 1 1385 (718) 786-5760 4. Guertin Dist. Inc. 5 T echnology Drive East Syracuse, NY 13057-9713 (315) 437-4928 (800) 468-6336 5. Kre ...

  • Henny Penny BFR/BCR-350 - page 37

    ...

  • Henny Penny BFR/BCR-350 - page 38

    U.S. Headquarters Henny Penny Corporation 1219 U.S. Route 35 West Eaton, OH 45320 USA T elephone: 937-456-8417 Fax: 937-456-1860 Representative Office 1 . Henny Penny Corporation Representative Office Parc dEntreprises de IEsplanade 2bis Rue Paul Henri Speak Saint Thibault des Vignes 77462 Lagny sur Mame Cedex, France T elephone: 33 (1) 60075 ...

  • Henny Penny BFR/BCR-350 - page 39

    Lebanon 40. Pro Kitchen Cahlfoun Building Kaslik - Main Road PO Box 1066 Jounieh Lebanon T elephone: 961-9-635-077 Fax: 961-9-635-059 Lithuania 41. Master Group Baltic Master Dariaus Ir Girena 175 2038 Vilnius, Lithuania T elephone: 3702-306-528/529 Fax: 3702-306-533 Malaysia 42. SCC Corp. Sdn. Bhd. 19-21 Jalan Hujan T aman Overseas Union 58200 Kua ...

メーカー Henny Penny カテゴリー Freezer

Henny Penny BFR/BCR-350のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- BFR/BCR-350の取扱説明書
- Henny Pennyの製品カード
- パンフレット
- またはHenny Penny BFR/BCR-350の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Henny Penny BFR/BCR-350の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Henny Penny BFR/BCR-350の取り付け説明書、サービスマニュアル、簡易説明書、またはHenny Penny BFR/BCR-350のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Henny Penny BFR/BCR-350の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Henny Penny BFR/BCR-350デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがHenny Penny BFR/BCR-350を使用するのを助ける技術的文書のことです。説明書は通常、全てのHenny Penny BFR/BCR-350ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Henny Pennyの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Henny Penny BFR/BCR-350の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははHenny Penny BFR/BCR-350の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Henny Penny BFR/BCR-350に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Henny Penny BFR/BCR-350デバイスの基本機能を使うにあたってのヒント。 Henny Penny BFR/BCR-350のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Henny Penny BFR/BCR-350に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるHenny Penny BFR/BCR-350のメーカー/サービスへの連絡先に関する情報。

Henny Penny BFR/BCR-350についてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもHenny Penny BFR/BCR-350の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがHenny Penny BFR/BCR-350で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)