Weil-McLain EG-30 THRU -75の取扱説明書

24ページ 4.12 mb
ダウンロード

ページに移動 of 24

Summary
  • Weil-McLain EG-30 THRU -75 - page 1

    For additional information, refer to . . . EG • PEG • EGH Boiler manual for Natural or Propane gas (tankless heater application optional) PEG-30 thru -65 EG-30 thru -75 Gas-Fir ed Boilers – Series 4 Contr ol supplement – Standing pilot This supplement must only be used by a qualified heat ing installe r/ser v ice technic ian. Before instal ...

  • Weil-McLain EG-30 THRU -75 - page 2

    2 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 Please read this page first! Hazard definitions The following defined terms are used throughout these instruc tions to bring attention to the presenc e of hazards of various risk le vels or to important information ...

  • Weil-McLain EG-30 THRU -75 - page 3

    3 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement T able of contents Hazard definitions and Note to the installer .................................................................................... 2 Control installation — EG-30 thru -75 water boilers without tankless heaters ........................ 4-5 Control inst ...

  • Weil-McLain EG-30 THRU -75 - page 4

    4 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 ...

  • Weil-McLain EG-30 THRU -75 - page 5

    5 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement Figure 2 EG-75 water boilers without tankless heaters Figure 1 1. Mount and wire contr ols per wiring diagram, pag e 4, and Figure 1. a. A ttach junctio n bo x insid e left jack et pane l with #8-3 2 x ½” machine screws pro v ided. b. Install transformer with plug-in r ...

  • Weil-McLain EG-30 THRU -75 - page 6

    6 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 ...

  • Weil-McLain EG-30 THRU -75 - page 7

    7 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement Note: T ankless heater not available on EG-75 standing pilot boilers. EG-30 thru -65 water boilers with tankless heaters Control installation continued 1. Mount and wire contr ols per wiring diagram, pag e 6, and Figure 3. a. Install c ombination limit co ntrol and r elay ...

  • Weil-McLain EG-30 THRU -75 - page 8

    8 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 ...

  • Weil-McLain EG-30 THRU -75 - page 9

    9 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement 1. Mount and wire contr ols per wiring diagram, pag e 8, and Figure 5. a. Att ach j un ct i on box in si de le ft j a cke t p an e l w i t h #8-32 x ½” machine screws and green g round nuts pro v ided. b. Install transfor mer with plug-in relay receptacle. In Canada, u ...

  • Weil-McLain EG-30 THRU -75 - page 10

    10 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 ...

  • Weil-McLain EG-30 THRU -75 - page 11

    11 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement 1. Mount and wire contr ols per wiring diagram, pag e 10, and Figure 7. a. Att ach j un ct i on box in si de le ft j a cke t p an e l w i t h #8-32 x ½” machine screws and green g round nuts pro v ided. b. Install transfor mer with plug-in relay receptacle. In Canada, ...

  • Weil-McLain EG-30 THRU -75 - page 12

    12 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 Figure 8 V ent damper assemblies The following boiler models must have damper installed: • EG-30 thru EG-65, natural or propane gas. • PEG-30 thru PEG-65, steam, natural gas. The following boiler models may have damper installed: • EG-75, natural or propane gas ...

  • Weil-McLain EG-30 THRU -75 - page 13

    13 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement Damper installation continued 4. Re ad an d a pp ly th e ha r ne s s pl ug wa r ni ng la b el (shown above) so that it is v isible after installa- tion. 5. Plug dam per har ness re ce ptac le int o dampe r harne ss plug. Bypassing (jumpering) vent damper will cause flue ...

  • Weil-McLain EG-30 THRU -75 - page 14

    14 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 Check out procedure Room thermostat anticipator settings W ater without tankless heater — 0.40 amps W ater with tankless heater — 0.20 amps Steam — Select based on gas valve and damper . See table below . 1. See pages 15-18 for “Lig hting Instructions” . 2. ...

  • Weil-McLain EG-30 THRU -75 - page 15

    15 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement Lighting instructions — Robertshaw 7200 ...

  • Weil-McLain EG-30 THRU -75 - page 16

    16 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 Lighting instructions — Honeywell VR8200/VR8300 Natural gas boilers only ...

  • Weil-McLain EG-30 THRU -75 - page 17

    17 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement Lighting instructions — Honeywell VR8200/VR8300 P ropane boilers only ...

  • Weil-McLain EG-30 THRU -75 - page 18

    18 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 Lighting instructions — Robertshaw 7000ERHC ...

  • Weil-McLain EG-30 THRU -75 - page 19

    19 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement Figure 9 Manually opening v ent damper In event of vent damper failure: Effikal vent damper If troubleshooting chart r ecommends replacing actuator and actuator is not immediately available, damper blade can be fix ed in an open position to allow boiler operation. Manu ...

  • Weil-McLain EG-30 THRU -75 - page 20

    20 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 Figure 11 1. Checking thermocouple or thermopile open system (Figur e 10): a. U se an electroni c multimete r , w ith leads fitted with alligator clips. Set meter scale to DC Milliv olts. b. U nscrew thermocouple or thermopile fitting fr om gas valve. c. Attach one ...

  • Weil-McLain EG-30 THRU -75 - page 21

    21 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement T roubleshooting continued ...

  • Weil-McLain EG-30 THRU -75 - page 22

    22 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 T roubleshooting continued ...

  • Weil-McLain EG-30 THRU -75 - page 23

    23 Part Number 550-110-032/0607 Standing Pilot Boilers — Contr ol Supplement T roubleshooting continued ...

  • Weil-McLain EG-30 THRU -75 - page 24

    24 Part Number 550-110-032/0607 EG-30 thru 75 Series 4 and PEG-30 thru 65 Series 4 Only dampers listed below are approv ed for use on EG-30 thr u 75 Series 4, and PEG-30 thr u 55 S eries 4, standing pilot ignition system boilers. A ny other damper installed can cause sever e personal injur y or death. Replacement parts Description Manufacturer / Mf ...

メーカー Weil-McLain カテゴリー Boiler

Weil-McLain EG-30 THRU -75のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- EG-30 THRU -75の取扱説明書
- Weil-McLainの製品カード
- パンフレット
- またはWeil-McLain EG-30 THRU -75の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Weil-McLain EG-30 THRU -75の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Weil-McLain EG-30 THRU -75の取り付け説明書、サービスマニュアル、簡易説明書、またはWeil-McLain EG-30 THRU -75のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Weil-McLain EG-30 THRU -75の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Weil-McLain EG-30 THRU -75デバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがWeil-McLain EG-30 THRU -75を使用するのを助ける技術的文書のことです。説明書は通常、全てのWeil-McLain EG-30 THRU -75ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Weil-McLainの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Weil-McLain EG-30 THRU -75の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははWeil-McLain EG-30 THRU -75の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Weil-McLain EG-30 THRU -75に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Weil-McLain EG-30 THRU -75デバイスの基本機能を使うにあたってのヒント。 Weil-McLain EG-30 THRU -75のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Weil-McLain EG-30 THRU -75に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるWeil-McLain EG-30 THRU -75のメーカー/サービスへの連絡先に関する情報。

Weil-McLain EG-30 THRU -75についてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもWeil-McLain EG-30 THRU -75の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがWeil-McLain EG-30 THRU -75で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)