Frymaster MPF50S Seriesの取扱説明書

30ページ 1.48 mb
ダウンロード

ページに移動 of 30

Summary
  • Frymaster MPF50S Series - page 1

    Frymaster, a member of the Co mmercial Food Eq uipment Service Ass ociation, recomm ends using CFESA Certified Tec hnicians. 24-Hour Service Hotline 1-800-551-8633 MAR 2008 *8196301* MPF50S Series Portable Filtration System Operating, Service & Parts Manual ...

  • Frymaster MPF50S Series - page 2

    Please read all sections of this manual and retain for future reference. Installation, maintenance, and repairs shoul d be performed by your Frymaster Dean Factory Authorized Service Agency. WARNING Safe and satisfactory operation of y our equipment depends on its proper installation. Installation MUST conform to local codes, or in th e absence of ...

  • Frymaster MPF50S Series - page 3

    NOTICE: If this filter unit is cleaned with water, disconnect the unit from power source before cleaning and thoroughly dry the filter unit before reconnecting to electrical power source. DANGER The crumb tray (if equipped) in portable filter sy stems must be emptied into a fireproof container at the end of frying operati ons each day. Some food pa ...

  • Frymaster MPF50S Series - page 4

    MPF50S Series Portable Filtration Systems Operation, Service & Parts Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 2. IMPORTANT INFORMATION 2-1 3. FILTER PREPARATION 3-1 4. OPERATING/FILTER INSTRUCTIONS 4-1 5. CLEANING AND MAINTENANCE 5-1 6. TROUBLESHOOTING/SERVI CE PROCEDURES 6-1 7. PARTS LIST 7-1 ...

  • Frymaster MPF50S Series - page 5

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-1 1.1 Parts Ordering Place parts orders directly with your local Frym as ter/Dean Factory Authorized Service Center. A list of FASCs was included with th e filter when shipped from the factory. If you do not have access to this list, please contact the Frymaster/Dean service depart ...

  • Frymaster MPF50S Series - page 6

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-2 1.3 After Purchase In order to improve service, fill out the followi ng chart with the nearest Frymaster Authorized Service Technician and FASC in your area. Authorized Service Technician/FASC Address Telephone/Fax Filter Model Number Filter Serial Number 1.4 Safety Information B ...

  • Frymaster MPF50S Series - page 7

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 1: INTRODUCTION 1-3 1.5 Service Personnel 1.5.1 Definitions A. Qualified and/or Authorized Operating Pers onnel 1. Qualified/authorized operating pe rsonnel are those who have car efully read the information in this manual and have familiarized them selves with the equipment f unctions, or have had ...

  • Frymaster MPF50S Series - page 8

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 General MPF50S portable filters can be used with a va riety of Frymaster fryers, as well as other manufacturers’ equipment. Oil capacity is appr oximately 50 pounds. Unit specifications are listed below. Model Unit Height (inches) Unit Width (inches) Unit Length (i ...

  • Frymaster MPF50S Series - page 9

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-2 2.1 General (cont.) Oil or shortening is gravity-draine d from the fryer into the filter ("S" Models), or pumped from the frypot into the filter pan, and then filtered through filter p aper. Filter powder, which enhances the filtering process, is distributed ov ...

  • Frymaster MPF50S Series - page 10

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 2: IMPORTANT INFORMATION 2-3 2.3 Pre-Installation NOTE: Failure to use qualified service personnel will void the Fry master warranty. A. Standards : Use of this filter unit mu st be in accordance with all app licable state and local codes. DANGER This portable filter is equipped with a three-prong ( ...

  • Frymaster MPF50S Series - page 11

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 3: FILTER PREPARATION 3-1 3.1 Assembling The Filter System On initial installation and before each use, rem ove all loose parts from the filter, wash all access ories in hot, soapy water and dry thoroughly. DO NOT WASH INTERIOR OF FILTER PAN WITH DETERGENT OR WATER! Wipe debris and residue from th e ...

  • Frymaster MPF50S Series - page 12

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 3: FILTER PREPARATION 3-2 3.1 Assembling The Filter System 1. Ensure the filter pan is clean a nd free of all food and breading pa rticles that could prevent the filter paper from sealing against the bottom of the pan. 2. Place the filter paper support sc reen between the raised dimp les in th e bot ...

  • Frymaster MPF50S Series - page 13

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4-1 4.1 Filter Operation WARNING Use care when draining and filtering oil to avoid the possibility of a serious burn. 1. Sprinkle 8 ounces (1 cup) of filter po wder over the filter paper, distr ibuting the powder as evenly as possible. If filtering a second frypot ...

  • Frymaster MPF50S Series - page 14

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 4: OPERATING/FILTERING INSTRUCTIONS 4-2 4.1 Filter Operation (cont.) 5. Ensure the oil is at operating temper ature, 350°F. Turn the fryer off. WARNING The filter pan maximum capacity is 50 lb s. DO NOT OVERFI LL THE FILTER PAN. 6. Place filter pan directly under fryer drain valve an d drain oil in ...

  • Frymaster MPF50S Series - page 15

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5-1 5.1 General Cleaning operations fall into three general categories : • Wiping unit clean after e ach filter session; • Cleaning, changing filter paper and prepari ng the unit for the next day’s business. • Weekly cleaning to remove oil deposits and other parti ...

  • Frymaster MPF50S Series - page 16

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 5: CLEANING AND MAINTENANCE 5-2 5.3 Daily— Close Of Business At the close of a working day, filter the oil in all f r yers. When the last f ryer is filtered, follow these steps: 1. Ensure the flexible hose and pump lines ar e clear by running the f ilter pump for an additional 15–30 seconds afte ...

  • Frymaster MPF50S Series - page 17

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-1 6.1 Operating Problems Plugged lines and plugged filter paper account for ove r 90 percent of filtrati on system m alfunctions. A general troubleshooting chart, included in this chapter, provides instructions in diagnosing common malfunctions. Contact a fa c ...

  • Frymaster MPF50S Series - page 18

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-2 6.2 General Troubleshooting (cont.) ...

  • Frymaster MPF50S Series - page 19

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-3 6.3 Wiring Diagrams 6.3.1 MPF50SS 115 2P 17P HEATER 1P 12P 11P 14P 15P 16P 4P 3P SWITCH FILTER LIGHT HEATER LIGHT FILTE R CONTROL SW ITCH PUMP M OTOR MOTOR PUMP GREEN WH I T E BLACK CORDSET GREEN WH I T E BLACK EXTERNAL CORD 115V OPTION 230V OPTION 6.3.2 MPF ...

  • Frymaster MPF50S Series - page 20

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-4 6.4 Service Procedures 6.4.1 Replace Lights/Switches WARNING Disconnect power cord from elect rical power before servicing. 1. Disconnect power cord from power supply. 2. Remove four screws securing the switch panel to the control panel. 3. Lift the panel ou ...

  • Frymaster MPF50S Series - page 21

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-5 6.4.2 Replace Heater Strip 1. Disconnect power cord from power supply. 2. Perform Step 2, Section 6.4.3.1, Replace Motor. 3. Remove screws securing outer panels and cord-holding bracket. Remove bracket and the panels. 4. Turn the unit on its side and remove ...

  • Frymaster MPF50S Series - page 22

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-6 6.4.2 Replace Heater Strip (cont.) 7. 115VAC Filters: Disconnect the black wire from the heater indica tor light on the switch panel (left, black arrow), and the white wire from the receptacle (white, white arrow). 230VAC Filters: Disconnect the red wire con ...

  • Frymaster MPF50S Series - page 23

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-7 6.4.3 Replace Motor/Pump 1. Disconnect power cord from power supply. 2. Perform Step 2, Section 6.4.1. Remove two screws securing the handle brackets to the control panel (arrows). Do not remove the remaining handle-bracket screws. Remove remaining screws se ...

  • Frymaster MPF50S Series - page 24

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-8 6.4.3.1 Replace Motor 4. Remove four bolts securing the pump to the motor. Leave the plumbing connected to the pump. Use care not to damage the flex supply lines connected to the pump. Remove the pump gasket for reassembly. 5. Remove six screws securing the ...

  • Frymaster MPF50S Series - page 25

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-9 6.4.3.2 Replace Pump 1. Disconnect power cord from power supply. 2. Perform Steps 2 and 3, Section 6.4.3.1, Replace Motor. 3. Remove foil insulation tape and heater strip from pump and flex lines. Remove the heater strip from the pump and disconnect flexline ...

  • Frymaster MPF50S Series - page 26

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 6: TROUBLESHOOTING/SERVICE PROCEDURES 6-10 6.4.3.3 Replace Wand Hose 1. Disconnect power cord from power supply. 2. Remove cord-holder bracket and outer panels (see Step 3, Section 6.4.2 for reference). 3. Unscrew the hose fitting with an open-end wrench from the elbow on the pump. 4. Install the ne ...

  • Frymaster MPF50S Series - page 27

    MPF50S SERIES PORTABLE FILTRATION SYSTEMS CHAPTER 7: PARTS LIST 7-1 7.1 MPF50S Parts List ...

  • Frymaster MPF50S Series - page 28

    MPF50S SERIES PORTABLE FILTRATION SYST EMS CHAPTER 7: PARTS LIST 7-2 Item Part # Description 1 823-6231 Pan, Filter 2 806- 5223SP Base Assembly (Includes items 3 & 4) 900-9542 Bracket, Motor-Mount – All MPF50S 900-1748 Brace, End- Filter Base 900-8585 Brace, Rear Cross- Filter Base 3 810-2805 Caster, 2"- Swivel (Without Brake ) 4 810-280 ...

  • Frymaster MPF50S Series - page 29

    MPF50S SERIES PORTABLE FILTRATION SYST EMS CHAPTER 7: PARTS LIST 7-3 24 912-2616 Bracket, Handle- Right 25 911-2616 Bracket, Handle- Left * 826-1380 Screw, ¼-20 x ½" Slotted Head (For Handle Bra cket) (Qty. of 5) 26 910-9169 Handle, Portable Filter * 826-1389 Bolt, ¼-20 x ¾" Hex Head (Qty. of 10) * 810-0219 Spacer, Handle Bolt * 809-0 ...

  • Frymaster MPF50S Series - page 30

    Frymaster, L.L.C., 8700 Line Av enue, PO Box 51 000, Shreveport, Louisiana 71135-1000 Shipping Address: 8700 Line Av enue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318- 219-71 40 FAX (Tech Support) 1-318-219-7135 PRINTED IN THE UNITED STATES SERVICE HOTLINE 1-800-551-8633 819-6301 MA R 2 00 8 ...

メーカー Frymaster カテゴリー Water Dispenser

Frymaster MPF50S Seriesのメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- MPF50S Seriesの取扱説明書
- Frymasterの製品カード
- パンフレット
- またはFrymaster MPF50S Seriesの消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Frymaster MPF50S Seriesの取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Frymaster MPF50S Seriesの取り付け説明書、サービスマニュアル、簡易説明書、またはFrymaster MPF50S Seriesのユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Frymaster MPF50S Seriesの製品を使用するにあたって最も人気のある説明書を閲覧できます。

Frymaster MPF50S Seriesデバイスの取扱説明書はどのようなものですか?
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがFrymaster MPF50S Seriesを使用するのを助ける技術的文書のことです。説明書は通常、全てのFrymaster MPF50S Seriesユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Frymasterの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Frymaster MPF50S Seriesの説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははFrymaster MPF50S Seriesの目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Frymaster MPF50S Seriesに関してこのドキュメントで見つけることができる全てのヒントの目次
3. Frymaster MPF50S Seriesデバイスの基本機能を使うにあたってのヒント。 Frymaster MPF50S Seriesのユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Frymaster MPF50S Seriesに関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるFrymaster MPF50S Seriesのメーカー/サービスへの連絡先に関する情報。

Frymaster MPF50S Seriesについてご質問がありますか?

次のフォームを使用してください

見つけた説明書を読んでもFrymaster MPF50S Seriesの問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがFrymaster MPF50S Seriesで同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

コメント (0)