-
Shop-Vac XPO100 - page 1
Service Manual DEALER: Keep this m anual. The procedur es in this m anual MUST be performed by a qualifi ed technician. For mo re inform ation reg arding In va ca re p ro du cts , pa rts, and services, please v isit www.inva care.com XPO 2 ™ Portable Oxygen Concentrator Models XP O100 and XPO100B ...
-
Shop-Vac XPO100 - page 2
XPO 2 ™ 2 Part No 1150748 WARNIN G DO NOT USE THIS PRODUCT OR ANY AVAIL ABLE OPTIONAL EQUIPMENT WITHOUT FIRST COMPLETELY READING AND UNDERSTANDING THESE INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTIONAL MATERIA L SUCH AS OWN ER’S MANUALS , SERVICE MANUALS OR INS TRUCTION SHEETS SUPPLIED WITH THIS PRODUCT OR OPTIONAL EQUIPMENT. IF YOU ARE UNA BL ...
-
Shop-Vac XPO100 - page 3
TABL E OF CON TENT S Part No 1150748 3 XPO 2 ™ TABLE OF CONTENT S SPE CI AL NOT ES ..... ...... ...... ...... ....... ...... ...... ...... ....... ...... ...... ...... ...... . 4 TYP ICA L P RO DUC T P ARAM ET ERS ...... ...... ...... ...... ....... ...... ...... ...... ... 5 Regulatory Listing ........................................... ........ ...
-
Shop-Vac XPO100 - page 4
SPECIAL NOTES XPO 2 ™ 4 Part No 1150748 SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could result in personal injury or property damage. Refer to the following table for definiti ons of the signal words. NOTICE The information contai ned in this document is subject to change without notice. ...
-
Shop-Vac XPO100 - page 5
TYPICAL PRODUCT PARAMETERS Part No 1150748 5 XPO 2 ™ TYPICAL PRODUCT PARAMETERS Direct Current Ty pe B F e qui pmen t Attention - Consider Accompanying D ocuments DO NOT smoke Class II, Double Insulation Power On/Off DO NOT di spose of in household waste Recycle DO NOT use oil or g rease Keep dry IPX1 Protected against dripping water Ele ctr ic a ...
-
Shop-Vac XPO100 - page 6
TYPICAL PRODUCT PARAMETERS XPO 2 ™ 6 Part No 1150748 Regul atory Lis ting Battery Duration (times are approximate): Setting 1 = 3.5 hours Setting 2 = 2.5 hours Setting 3 = 2.0 hours Setting 4 = 1.5 hours Setting 5 = 1.0 hours Battery Recharge Ti me: NOTE: Recharge time increases if battery is charging while unit is running. 4 hours Humidity Opera ...
-
Shop-Vac XPO100 - page 7
SECTION 1—IMPORTANT SAFEGUARDS Part No 1150748 7 XPO 2 ™ SECTION 1—IMPORTANT SAFEGUARDS In order to ensure the safe in stallation, assembly and operation of the XPO 2 P ortable Concentrator these ins tructions MUST be follow ed. WARNING SECTION 1 - IMPORT ANT SAFEGUARDS contains i mportant information for the safe operation and use of thi ...
-
Shop-Vac XPO100 - page 8
SECTION 1—IMPORTANT SAFEGUARDS XPO 2 ™ 8 Part No 1150748 Radio F requency Interference This equi pment has been tested and found to comply with EMC limi ts specifi ed by IEC/ EN 60601-1-2. These limi ts are designed to provide a reasonable protection against electromagnetic interference in a typical medi cal in stallation. Other devices may exp ...
-
Shop-Vac XPO100 - page 9
SECTION 2—COMPONENT REPLACEMENT Part No 1150748 9 XPO 2 ™ SECTION 2—COMPONENT REPLACEMEN T CAUTION Ensure not to damage ribbon cable when removing or installing front cove r . DO NOT use Methyl Ethyl Ket one (MEK). This wi ll damage the plastic. Replacin g the Gross P article F ilter or Filter Cover NOTE: For this pr ocedure, r efer to FIGURE ...
-
Shop-Vac XPO100 - page 10
SECTION 2—COMPONENT REPLACEMENT XPO 2 ™ 10 Part No 1150748 1. Remov e label from the top of the XPO 2 (FIGURE 2.2). NOTE: This label adheres to the f ront and rear sections of the XPO 2 . This la bel MUST be rem oved to separate the two sections. FIGURE 2.2 Remove/Install label 2. P ositi on the XPO 2 so that the back panel label is facin g up ...
-
Shop-Vac XPO100 - page 11
SECTION 2—COMPONENT REPLACEMENT Part No 1150748 11 XPO 2 ™ 4. While holding the unit tog ether rotate the XPO 2 and position it so that the back panel label is faci ng down. NOTE: The ribbon cable i s connected to the front cov er and the pc board. Only open the XPO 2 as shown in Details “B” and “C”. 5. Slowly , o pen the front cov er e ...
-
Shop-Vac XPO100 - page 12
SECTION 2—COMPONENT REPLACEMENT XPO 2 ™ 12 Part No 1150748 4. T ransfer the 5 / 8 -inch tubing to the intake of the new filter . NOTE: The flow arrow points away from the intake. 5. Connect the 11½- i nch tubi ng to the outlet of the i nlet fi lter (Detail “ A” of FIGURE 2.4). 6. P ositi on and orient the new fi lter in the holder (Detail ...
-
Shop-Vac XPO100 - page 13
SECTION 2—COMPONENT REPLACEMENT Part No 1150748 13 XPO 2 ™ NOTE: When installing new battery , ensure the battery is label side up. 5. P ositi on new battery on thermal pad as shown. 6. Connect the battery wirin g harness to the PC board. 7. Install inlet filter with tubi ng into holder . 8. Re-assemble the XPO 2 . Refer to Re-assembling the XP ...
-
Shop-Vac XPO100 - page 14
SECTION 3—CHECKING O 2 PURITY XPO 2 ™ 14 Part No 1150748 SECTION 3—CHECKING O 2 PURITY NOTE: Although the XPO 2 offers pu lse dose only , the oxygen purity can be checked with a hand held oxygen analyzer . NOTE: Oxygen purity should be checked every 4,320 hou rs. 1. T urn the unit On. 2. Press the “+” button to increase the flow to settin ...
-
Shop-Vac XPO100 - page 15
SECTION 4—ERROR CODES Part No 1150748 15 XPO 2 ™ SECTION 4 —ERROR CODES The XPO 2 has dozens of alarms that are being monitored on a continuous basi s. The alarms are grouped into four main categories: • Common Alarms: These are alarms for whi ch the patient, or the provider , can take action to eliminate the is sue. These alarms, and the c ...
-
Shop-Vac XPO100 - page 16
SECTION 4—ERROR CODES XPO 2 ™ 16 Part No 1150748 (*) Wi thin the System Alarms there are a few alarms that may co rrect themselves simply by cha nging the in ter nal batte ry . Compressor Alarms Code: 6000 4, 5 None Code: 6001 4, 5 1 Code: 6002 4, 5 2 Code: 6003 4, 5 1 ,2 ERROR/ ERROR CO DE ALARM (Illuminated flow LEDs) SUB-ALARM (Illuminated f ...
-
Shop-Vac XPO100 - page 17
NOTES Part No 1150748 17 XPO 2 ™ NOT ES ...
-
Shop-Vac XPO100 - page 18
NOTES XPO 2 ™ 18 Part No 1150748 NOT ES ...
-
Shop-Vac XPO100 - page 19
LIMITED WARRANTY Part No 1150748 19 XPO 2 ™ LIMITED WARRANTY For warranty informati on, please refer to th e origina l owner's manual which came with this produ ct, or contact Invacare f or more info rmation. ...
-
Shop-Vac XPO100 - page 20
Invacare Corporation www.i nvacare. com USA One Invaca re Way Elyr ia, Oh io USA 44036-2125 800-333-6900 Canada 570 Matheso n Blvd E Unit 8 Missi ssauga Ont ario L4Z 4G4 Ca nada 800-668-5324 All rights re served. Trade marks are identi fied by ™ and ®. All tradem arks are owned by or li censed to Invaca re Corpora tion unl ess ot herwise noted. ...
Shop-Vac XPO100についてご質問がありますか？
次のフォームを使用してください
見つけた説明書を読んでもShop-Vac XPO100の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがShop-Vac XPO100で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。