日本語 dropdown-ico

Guardian Technologies 004582-2の取扱説明書

36ページ 2.75 mb
ダウンロード

ページに移動 of 36

Summary
  • Guardian Technologies 004582-2 - page 1

    Owner’ s Man ual • SAFETY • ASSEMBL Y • OPERA TION • TR OUBLESHOO TING • ELECTRICAL D A T A • P AR TS • W ARRANTY 1-800-333-1322 UL TRA SOURCE P or table Generator COMMERCIAL • INDUSTRIAL • RESIDENTIAL MODEL: 004582-2 15,000 W att P or table Generator A UTHORIZED DEALER SUPPORT : ...

  • Guardian Technologies 004582-2 - page 2

    T able of Contents Commercial-Industrial-Residential P or table Generator System Safety Rules .................................................................. 1 Section 1 – General Information ................................. 4 1.1 Unpacking ............................................................................. 4 1.1.1 Accessory Box ... ...

  • Guardian Technologies 004582-2 - page 3

    INTRODUCTION Thank you f or purchasing this model by Generac P ower Systems , Inc. This model is a compact, high performance, air-cooled, engine driven generator designed to supply electrical power to operate electrical loads where no utility power is a vailab le or in place of utility due to a power outage . READ THIS MANU AL THOROUGHL Y If any po ...

  • Guardian Technologies 004582-2 - page 4

    2 Nev er star t or stop the unit with electrical loads connected to receptacles AND with connected devices turned ON. Star t the engine and let it stabilize bef ore connecting electrical loads. Disconnect all electrical loads before shutting down the generator . Do not inser t objects through unit's cooling slots. Never operate generator: indo ...

  • Guardian Technologies 004582-2 - page 5

     ELECTRICAL HAZARDS  All generators cov ered by this manual produce dangerous electrical voltages and can cause f atal electr ical shoc k. Utility power delivers extremely high and dangerous v oltages as does the generator when it is in operation. Av oid contact with bare wires, ter minals , connections, etc., while the unit is running. Ensur ...

  • Guardian Technologies 004582-2 - page 6

    1.1 UNP A CKING Set the palleted car ton on a rigid flat surface . Remov e staples along bottom of car ton that f asten car ton to pallet. Open car ton from top . Remov e all packaging material. Remov e separate accessory box. Lift car ton off the generator . Remov e generator from shipping pallet by remo ving bolts through the shipping brack ets ( ...

  • Guardian Technologies 004582-2 - page 7

    5 1.2.3 B A TTER Y CONNECTION The battery shipped with the generator has been provided fully charged. Caution must be taken when connecting the battery . NO TE: A battery may lose some of it’ s charge when not in use for prolonged periods of time. Cut the tie wrap cable holding the RED and BLA CK batter y cables to the stator . Connect the RED ba ...

  • Guardian Technologies 004582-2 - page 8

    6 Section 2 – Operation Commercial-Industrial-Residential P or table Generator System 2.1 KNO W THE GENERA T OR Read the Owner’ s Manual and Safety Rules before operating this generator . Compare the generator to Figures 4 through 6 to become f amiliarized with the locations of various controls and adjustments. Save this manual f or future refe ...

  • Guardian Technologies 004582-2 - page 9

    2.2 CORD SETS AND CONNECTION PLUGS 2.2.1 120 V A C, 20 AMP , DUPLEX RECEPT A CLE This is a 120 V olt outlet protected against overload by a 20 Amp push-to-reset circuit breaker (Figure 7). Use each sock et to power 120 V olt AC , single phase, 60 Hz electrical loads requiring up to a combined 2400 watts (2.4 kW) or 20 Amps of current. Use only high ...

  • Guardian Technologies 004582-2 - page 10

    Use this receptacle to operate 120 V olt AC , 60 Hz, single phase loads requiring up to 3600 watts (3.6 kW) of power at 30 Amps . The outlet is protected by a 30 Amp push-to-reset circuit break er . 2.2.4 120/240 V A C, 30 AMP RECEPT A CLE Use a NEMA L14-30 plug with this receptacle. Connect a suitable 4- wire grounded cord set to the plug and to t ...

  • Guardian Technologies 004582-2 - page 11

    Proper gr ounding of the generator will help prevent electrical shock in the e vent of a ground f ault condition in the generator or in connected electrical devices. Proper grounding also helps dissipate static electricity , which often builds up in ungrounded de vices. 2.3.2 CONNECTING ELECTRICAL LO ADS DO NO T connect 240 V olt loads to 120 V olt ...

  • Guardian Technologies 004582-2 - page 12

    2.6 BEFORE ST AR TING THE GENERA T OR Prior to operating the generator , engine oil and gasoline will need to be added, as follo ws: 2.6.1 ADDING ENGINE OIL NO TE: When adding oil to the engine crankcase in the future, use only high quality detergent oil rated with API service classification SG, SH or SL SAE 30 weight. Use no special additives. 5W- ...

  • Guardian Technologies 004582-2 - page 13

    2.7 T O ST ART THE ENGINE  Never start or stop engine with electrical devices plug ged into the receptacles AND devices turned on. Unplug all electrical loads from the unit's receptacles before star ting the engine. Make sure the unit is in a le vel position. Open the fuel shut-off valv e (Figure 15). Figure 15 - Fuel Shut-off V alve Locate ...

  • Guardian Technologies 004582-2 - page 14

    2.9 A UT OMA TIC IDLE CONTR OL This feature is designed to g reatly improv e fuel economy . When this switch is turned “ On , ” the engine will only run at its normal fast gov er ned engine speed when electrical load is connected. When the load is remov ed, the engine will run at a reduced speed of 2100 RPM. With the s witch “ Off , ” the e ...

  • Guardian Technologies 004582-2 - page 15

    13 Section 3 — Maintenance Commercial-Industrial-Residential P or table Generator System 3.2.1 GENERA T OR SPECIFICA TIONS MODEL GPS 15,000 Model # 004582-2 Rated Max. Po wer 15.0 kW Surge Po wer 22.5 kW Rated AC V oltage 120/240 Rated Max A C Load Current @ 240V 62.5 Amps Current @ 120V 125.0 Amps Rated F requency 60 Hz @ 3600 RPM Phase Single P ...

  • Guardian Technologies 004582-2 - page 16

    14 Section 3 — Maintenance Commercial-Industrial-Residential P or table Generator System 3.3 GENERAL RECOMMEND A TIONS The warranty of the gener ator does not cover items that ha ve been subjected to operator abuse or negligence . T o receive full v alue from the warranty , the operator must maintain the gener ator as instructed in this manual. S ...

  • Guardian Technologies 004582-2 - page 17

    15 Section 3 — Maintenance Commercial-Industrial-Residential P or table Generator System 3.3.6 REPLA CING THE SP ARK PLUG Use Champion RC14YC spark plug or equivalent. The correct air gap is 1.01 mm (0.040 in.) (Figure 18). Replace the plug once each year . This will help the engine star t easier and run better . 1. Stop the engine and pull the s ...

  • Guardian Technologies 004582-2 - page 18

    3.6 ADJUSTING V AL VE CLEARANCE After the first 50 hours of operation, check the v alve clearance in the engine and adjust if necessary . Important: If feeling uncomf or table about doing this procedure or the proper tools are not av ailable, please tak e the generator to the nearest service center to have the v alve clearance adjusted. This is a v ...

  • Guardian Technologies 004582-2 - page 19

    Section 3 — Maintenance Commercial-Industrial-Residential P or table Generator System 17 3.8 LONG TERM ST ORA GE It is impor tant to pre vent gum deposits from f or ming in essential fuel system par ts such as the carb uretor , fuel hose or tank during storage. Also , experience indicates that alcohol-blended fuels (called gasohol, ethanol or met ...

  • Guardian Technologies 004582-2 - page 20

    Section 4 — T roubleshooting Commercial-Industrial-Residential P or table Generator System 4.1 TROUBLESHOO TING GUIDE PROBLEM CA USE CORRECTION Engine is running, but no A C output is av ailable. 1. Circuit breaker is open. 2. Poor connection or def ective cord set. 3. Connected device is bad. 4. Fault in gener ator . 1. Reset circuit breaker . 2 ...

  • Guardian Technologies 004582-2 - page 21

    19 19 Section 5 — Electrical Data Electrical Schematic – Drawing No. 0G0733 ...

  • Guardian Technologies 004582-2 - page 22

    20 Section 5 — Electrical Data Wiring Diagram – Drawing No. 0G0731 ...

  • Guardian Technologies 004582-2 - page 23

    21 Section 5 — Electrical Data Wiring Diagram – Drawing No. 0G0731 ...

  • Guardian Technologies 004582-2 - page 24

    22 Section 6 — Exploded Views and Parts Lists Handle, Frame & Wheel Kit – Drawing No. 0E0695-B ...

  • Guardian Technologies 004582-2 - page 25

    23 Section 6 — Exploded Views and Parts Lists Handle, Frame & Wheel Kit – Drawing No. 0E0695-B ITEM P AR T NO . QTY . DESCRIPTION 1 057058 4 SCREW HHC M6-1.0 X 55 2 0D5315 4 R UBBER T ANK MOUNT 3 0D4570 1 CAP , FUEL WITH GAUGE & VENT 4 0D22850SR V 1 KIT , FUEL T ANK 5 045771 4 NUT HEX M8-1.25 6 022129 10 W ASHER LOCK M8-5/16 7 022145 14 ...

  • Guardian Technologies 004582-2 - page 26

    24 Section 6 — Exploded Views and Parts Lists Control P anel – Drawing No. 0G0727-B ...

  • Guardian Technologies 004582-2 - page 27

    25 Section 6 — Exploded Views and Parts Lists Control P anel – Drawing No. 0G0727-B ITEM P AR T NO . QTY . DESCRIPTION 1 087968 1 SWITCH, ROCKER -/0 2 090418 1 OUTLET , 12VDC SNAP 3 0D6640 1 CO VER, GOVERNOR CONTR OL 4 090987 6 SCREW PPHM M3-0.5 X 12 5 0D8740 1 P ANEL, SHEET MET AL (15 KW) 0G0309 1 P ANEL, SHEET MET AL (17.5 KW) 6 068868 2 OUTL ...

  • Guardian Technologies 004582-2 - page 28

    26 Section 6 — Exploded Views and Parts Lists Generator – Drawing No. 0G0742-A ...

  • Guardian Technologies 004582-2 - page 29

    27 Section 6 — Exploded Views and Parts Lists Generator – Drawing No. 0G0742-A ITEM P AR T NO . QTY . DESCRIPTION 1 0C6934 1 AD APTOR, ENGINE 2 0G1177 1 ST A T OR 15KW 0D2136 ST A TOR 17.5KW 3 0G11760SRV 1 ASSEMBL Y , ROT OR WITH F AN 15KW 0D21350SR V ASSEMBL Y , ROT OR WITH F AN 17.5KW 4 0C6043B 1 CARRIER, REAR BEARING 5 0D2492 1 EXHA UST MANI ...

  • Guardian Technologies 004582-2 - page 30

    28 Section 6 — Exploded Views and Parts Lists GT -760/990 Engine – Drawing No. 0E8589-W - Part 1 ...

  • Guardian Technologies 004582-2 - page 31

    27 29 Section 6 — Exploded Views and Parts Lists GT -760/990 Engine – Drawing No. 0E8589-W - Part 1 ITEM P AR T NO . QTY . DESCRIPTION 1 0C5729 1 ASSEMBL Y , CRANKCASE HOUSING WITH SLEEVE 2 0E9843 1 SEAL, 38 I.D . CRANKSHAFT 3 090388 3 SCREW , T APTITE M6-1.0 X 12 BP 4 0C5372 1 ASSEMBL Y , BREA THER 5 0C3005 1 GASKET , BREA THER CO VER 6 0E3372 ...

  • Guardian Technologies 004582-2 - page 32

    30 Section 6 — Exploded Views and Parts Lists GT -760/990 Engine – Drawing No. 0E8589-W - Part 2 ...

  • Guardian Technologies 004582-2 - page 33

    31 Section 6 — Exploded Views and Parts Lists GT -760/990 Engine – Drawing No. 0E8589-W - Part 2 ITEM P AR T NO . QTY . DESCRIPTION 66 0D6592 1 WINGNUT , AIRBOX 67 0D4511 1 PRECLEANER, AIR 68 0D9723 1 ELEMENT , AIR CLEANER 69 0E5302 1 STUD M6-1.0 X 73 70 0D4183 1 AD APTOR, SPIT BA CK 71 0D6327 1 GASKET , SPITBACK 72 0D2774B 1 BASE, AIRBOX 73 0D ...

  • Guardian Technologies 004582-2 - page 34

    32 CALIFORNIA EMISSION CONTROL W ARRANTY ST A TEMENT Y OUR W ARRANTY RIGHTS AND OBLIGA TIONS The Calif or nia Air Resources Board (CARB) and Generac P ower Systems, Inc. (Generac) are pleased to e xplain the Emission Control System warr anty on your ne w engine. In California, new off-road Large Spark-Ignition (LSI) engines must be designed, b uilt ...

  • Guardian Technologies 004582-2 - page 35

    33 EMISSION CONTROL SYSTEM W ARRANTY Emission Control System W arranty (ECS warr anty) for 2001 and later model y ear LSI engines: (a) Applicability: This warranty shall apply to 2001 and later model y ear engines. The ECS W arranty period shall begin on the date the new engine or equipment is purchased by/deliv ered to its or iginal, end-use purch ...

  • Guardian Technologies 004582-2 - page 36

    Section 7 – Warranty Commercial-Industrial-Residential P or table Generator System P ar t No . 0G1086 Rev . C Printed in U.S .A. 03/27/07 GENERA C PO WER SYSTEMS “TWO YEAR” LIMITED W ARRANTY FOR GU ARDIAN ® “15,000 W A TT POR T ABLE GENERA T OR” For a period of two y ears from the date of original sale, Generac P ower Systems, Inc. (Gene ...

メーカー Guardian Technologies カテゴリー Portable Generator

Guardian Technologies 004582-2のメーカーから受け取ることができるドキュメントは、いくつかのグループに分けられます。その一部は次の通りです:
- #BRANDの図面#
- 004582-2の取扱説明書
- Guardian Technologiesの製品カード
- パンフレット
- またはGuardian Technologies 004582-2の消費電力シール
それらは全部重要ですが、デバイス使用の観点から最も重要な情報は、Guardian Technologies 004582-2の取扱説明書に含まれています。

取扱説明書と呼ばれる文書のグループは、Guardian Technologies 004582-2の取り付け説明書、サービスマニュアル、簡易説明書、またはGuardian Technologies 004582-2のユーザーマニュアル等、より具体的なカテゴリーに分類されます。ご必要に応じてドキュメントを検索しましょう。私たちのウェブサイトでは、Guardian Technologies 004582-2の製品を使用するにあたって最も人気のある説明書を閲覧できます。

関連する取扱説明書

Guardian Technologies 004582-2デバイスの取扱説明書はどのようなものですか？
取扱説明書は、ユーザーマニュアル又は単に「マニュアル」とも呼ばれ、ユーザーがGuardian Technologies 004582-2を使用するのを助ける技術的文書のことです。説明書は通常、全てのGuardian Technologies 004582-2ユーザーが容易に理解できる文章にて書かれており、その作成者はその分野の専門家です。

Guardian Technologiesの取扱説明書には、基本的な要素が記載されているはずです。その一部は、カバー/タイトルページ、著作権ページ等、比較的重要度の低いものです。ですが、その他の部分には、ユーザーにとって重要な情報が記載されているはずです。

1. Guardian Technologies 004582-2の説明書の概要と使用方法。説明書にはまず、その閲覧方法に関する手引きが書かれているはずです。そこにははGuardian Technologies 004582-2の目次に関する情報やよくある質問、最も一般的な問題に関する情報を見つけられるはずです。つまり、それらはユーザーが取扱説明書に最も期待する情報なのです。
2. 目次。Guardian Technologies 004582-2に関してこのドキュメントで見つけることができる全てのヒントの目次
3. Guardian Technologies 004582-2デバイスの基本機能を使うにあたってのヒント。 Guardian Technologies 004582-2のユーザーが使い始めるのを助けてくれるはずです。
4. トラブルシューティング。Guardian Technologies 004582-2に関する最も重要な問題を診断し、解決するために役立つ体系化された手続き
5. FAQ。よくある質問
6. 連絡先。一人では問題を解決できない場合に、その国におけるGuardian Technologies 004582-2のメーカー/サービスへの連絡先に関する情報。

Guardian Technologies 004582-2についてご質問がありますか？

次のフォームを使用してください

見つけた説明書を読んでもGuardian Technologies 004582-2の問題を解決できない場合、下記のフォームを使用して質問をしましょう。ユーザーのどなたかがGuardian Technologies 004582-2で同様の問題を抱えていた場合、その解決方法を共有したいと考えるかもしれません。

画像のテキストを入力してください

Captcha
新しい画像

コメント (0)