English dropdown-ico

Manual BKI CO1-G

16 pages 0.64 mb
Download

Go to site of 16

Summary
  • BKI CO1-G - page 1

    INST ALLA TION AND OPERA TING INSTRUCTIONS GA S CONVECTION O VEN Model: CO1-G INTENDED FOR OTHER THAN HOUSEHOLD USE RET AIN THIS MANUAL FOR FUTURE REFERENCE OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES IMPORT ANT INSTRUCTIONS After the gas supply has been connected to your unit, it is extremely important to check piping for possible leaks. ...

  • BKI CO1-G - page 2

    I. INST ALLA TION INSTRUCTIONS SECTION ITEM P AGE A Receiving B Set-Up Mounting C Installation with Casters (Optional) D Location and Minimum Clearances E Gas Connection F Electrical Connection G Flue Connections-V entilation H Burner Operation I System Check - Rotary Control II. OPERA TING INSTRUCTIONS 1 General Instructions 2 System Operation Seq ...

  • BKI CO1-G - page 3

    3 observe the clearances detailed in Section D (Location). Provide adequate ventilation and make up air in accordance with local codes. Servicing your oven is done through the front control panel and right side access cover . Assure that these areas are kept unobstructed for easy access. For a single unit: (1) T ilt Oven over onto left hand side, a ...

  • BKI CO1-G - page 4

    E. GAS CONNECTIONS: The ovens should not be installed on the same gas line with space heaters, boilers or other gas equipment with high intermittent demand. The installation of this oven must conform with the latest local codes or Nationa/Fuel Gas Code. ANSI Z223.1, Natural Gas Installation Code. CAN/CGA-BJ49.1. or the Propane Installation Code. CA ...

  • BKI CO1-G - page 5

    installation and thence to an independent earth connection in compliance with EN 60335-1 and/or local codes. The electric motor , all the related switches, interior lights and the timer/buzzer , are all connected through the 6ft (1829 mm) power supply cord located at the rear of the oven. The supply cord must be plugged into a properly grounded thr ...

  • BKI CO1-G - page 6

    II. OPERA TING INSTRUCTIONS 1. GENERAL INSTRUCTIONS: (a) This equipment has an Electronic T emperature Control and Electronic Hot Surface Direct Ignition System. (b) Due to the increased efficiency of this oven, the temperature of standard recipes may be reduced 50°F (30°C). (c) Always load each shelf evenly . Space pans away from each other and ...

  • BKI CO1-G - page 7

    (5) Load the oven with product to be cooked. (6) T urn the timer knob to the desired bake time and timer will start counting down. (7) When timer reaches zero, a buzzer will sound. (8) T urn the T imer knob to '0' position to reset. (9) T urn the thermostat knob to the desired hold temperature. (10) Remove the product from the oven when d ...

  • BKI CO1-G - page 8

    4. SERVICING: NOTE: This appliance must be serviced by an authorized service agent. a) Power supply to the unit must be disconnected before any service is performed. b) Most of the service on the unit can be performed from the front and/or control panel side. c) For proper servicing, access to the Control Panel side of the unit will be required. d) ...

  • BKI CO1-G - page 9

    WHEEL PULLER BOL T 3/8”-HEX BLOWER WHEEL MOTOR SET SCREW (2) ASSEMBL Y OF LEGS (SHOWN WITH OPEN RACK ST AND) 30” CONVECTION OVEN LEGS TOP LEFT ANGLE TOP RIGHT ANGLE 1/2” FLA TW ASHER (4 CORNERS ONL Y) 1/2”-13 x 1” HEX HEAD BOL T (12 REQUIRED) 5/16” FLA TW ASHER (4 REQUIRED) 5/16”-18 HEX NUT (4 REQUIRED) OPEN RACK SHELF RACK SUPPORT 3/ ...

  • BKI CO1-G - page 10

    6. ELECTRICAL SCHEMA TIC (ROT AR Y CONTROL) CO1-G Flame Sensor Ignitor Gas Control therm. ignitor valve ground sensor l1 4 3 2 1 P4 P3 P2 P1 120V AC SSAC X 0 - O 0...60' X 0...60' O 0 - 5 4 2 1 NOTO 3 7 6 COM HI LO GC-20 NO COM L2 L1 NO NC ooox ooxo oxoo oxxo 24V 120V BUZZER TIMER M450 1 2 4 S Fan Rotary Switch (Off, Low , High, Cool Down ...

  • BKI CO1-G - page 11

    timer M450 flame rod combination control VR 8205 4 3 2 1 P4 P3 P2 P1 light switch COM NO L2 L1 NC NO C flame sensor ground valve hot thermostat L1-24vac ignitor 3 4 5 6 2 1 7 steam switch steam timer potentiometer blk yel red blu solenoid valve FF PILOT IN 120v 24v ignitor 120V AC 1 2 3 4 S Rotary Switch Door Switch Pilot Light (Thermostat) Pilot L ...

  • BKI CO1-G - page 12

    12 VALVE WATER SOL EN OI D BLU RED YE L BLK A1 H1 H2 A2 BRN A1 BLU 29 BLU 31 BLU H2 B R N H1 BRN POTENTIOMETER STEAM TIMER STEAM SW I T CH 7 1 2 6 5 4 3 BUTT CON N E CT OR STEAM OPT I O N A B D2 BLU RED Purple T2 BLU BLU NC NO 120 V Light s 120 V 2 Speed Mot or VR8605A Thermost at Igni ter GDN Valve Sensor L1 Ign itor Sensor RAM COM HI LO Door Sw. ...

  • BKI CO1-G - page 13

    CO1-G F ull Size Gas Convection Oven Figure B Burners / V alve / Door Chain / Legs (864) 963-3471 (864) 963-5316 (800) 927-6887 customerser vice@bkideas.com fax US & Canada web address OUT IN IN Safety V alve Legs & Open Rack Stand Door Chain Assy Steam Option (Not Shown) Item Part # Description Item Part # Description Burners 7 8 9 10 11 1 ...

  • BKI CO1-G - page 14

    Figure A Exterior / Interior / Controls / Doors 95 94 1 2 3 4 5 6 8 10 11 12 13 14 15 17 18 19 20 23 24 25 26 27 28 29 30 31 32 34 35 36 37 38 39 40 41 42 43 44 45 47 46 48 49 9 50 51 52 53 54 56 55 57 58 58 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72 74 75 75 75 73 76 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 16 ER BK S A ER BK S A I PE D R I ...

  • BKI CO1-G - page 15

    Exterior / Interior / Controls / Doors I t e m Part # D e s c r i p t i o n I t e m Part # Description Conversion Kit (Natural to LP) Conversion Kit (LP to Natural) 1 E3450X Door Seal, T op or Bottom, each (2) 49 P6007X Elec Line Cord, 250V (UK) 2 E3451K Door Seal, Sides, each (2) 50 N5048P Rear Pipe Connection 3 E3466U Door Closure Strip 51 P1 144 ...

  • BKI CO1-G - page 16

    16 WHA T IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated and maintained in accor dance with National an ...

Manufacturer BKI Category Convection Oven

Documents that we receive from a manufacturer of a BKI CO1-G can be divided into several groups. They are, among others:
- BKI technical drawings
- CO1-G manuals
- BKI product data sheets
- information booklets
- or energy labels BKI CO1-G
All of them are important, but the most important information from the point of view of use of the device are in the user manual BKI CO1-G.

A group of documents referred to as user manuals is also divided into more specific types, such as: Installation manuals BKI CO1-G, service manual, brief instructions and user manuals BKI CO1-G. Depending on your needs, you should look for the document you need. In our website you can view the most popular manual of the product BKI CO1-G.

Similar manuals

A complete manual for the device BKI CO1-G, how should it look like?
A manual, also referred to as a user manual, or simply "instructions" is a technical document designed to assist in the use BKI CO1-G by users. Manuals are usually written by a technical writer, but in a language understandable to all users of BKI CO1-G.

A complete BKI manual, should contain several basic components. Some of them are less important, such as: cover / title page or copyright page. However, the remaining part should provide us with information that is important from the point of view of the user.

1. Preface and tips on how to use the manual BKI CO1-G - At the beginning of each manual we should find clues about how to use the guidelines. It should include information about the location of the Contents of the BKI CO1-G, FAQ or common problems, i.e. places that are most often searched by users in each manual
2. Contents - index of all tips concerning the BKI CO1-G, that we can find in the current document
3. Tips how to use the basic functions of the device BKI CO1-G - which should help us in our first steps of using BKI CO1-G
4. Troubleshooting - systematic sequence of activities that will help us diagnose and subsequently solve the most important problems with BKI CO1-G
5. FAQ - Frequently Asked Questions
6. Contact detailsInformation about where to look for contact to the manufacturer/service of BKI CO1-G in a specific country, if it was not possible to solve the problem on our own.

Do you have a question concerning BKI CO1-G?

Use the form below

If you did not solve your problem by using a manual BKI CO1-G, ask a question using the form below. If a user had a similar problem with BKI CO1-G it is likely that he will want to share the way to solve it.

Copy the text from the picture

Captcha
New picture

Comments (0)